2016 MAZDA MODEL 6 maintenance

Black plate (494,1)
qJack
To remove the jack
1. Lift the trunk mat.
Trunk mat
2. Remove the pocket.
3. Turn the wing bolt and jack screw
counterclockwise.
Wing bolt
Jack screw
To secure the jack
1. Insert the wing bolt into the jack with
the jack screw pointing to the front and
turn the wing bolt clockwise to
temporarily tighten it.
2. Turn the jack screw in the direction
shown in the figure.
Wing bolt
Jack screw
3. Turn the wing bolt completely to
secure the jack.
NOTE
If the jack is not completely secured, it could
rattle while driving. Make sure the jack screw
is sufficiently tightened.
Maintenance
lAlways keep the jack clean.lMake sure the moving parts are kept
free from dirt or rust.
lMake sure the screw thread is
adequately lubricated.
7-4
If Trouble Arises
Flat Tire
Mazda6_8EA2-EA-14K_Edition2 Page494
Saturday, January 10 2015 3:27 PM
Form No.8EA2-EA-14K

Black plate (520,1)
CAUTION
If the above message is indicated, or
the push button start indicator light
(amber) flashes, the engine may not
start. If the engine cannot be started,
try starting it using the emergency
operation for starting the engine, and
have the vehicle inspected at an
Authorized Mazda Dealer as soon as
possible.
Refer to Emergency Operation for
Starting the Engine on page 4-8.
“Ignition is on”is displayed
This message is displayed when the
driver's door is opened without switching
the ignition off.
“Key not detected”is displayed
This message is displayed when any of
the following operations is performed
with the key out of the operational range
or placed in areas inside the cabin where it
is difficult for the key to be detected.
lThe push button start is pressed with
the ignition switched off
lThe ignition is switched onlAll doors are closed without switching
the ignition off
Type B
If any malfunction occurs in the keyless
entry system, it illuminates continuously.
CAUTION
If the key warning indicator light
illuminates or the push button start
indicator light (amber) flashes, the
engine may not start. If the engine
cannot be started, try starting it
using the emergency operation for
starting the engine, and have the
vehicle inspected at an Authorized
Mazda Dealer as soon as possible.
Refer to Emergency Operation for
Starting the Engine on page 4-8.
qIf the high beam control system
(HBC) warning light (amber)
illuminates
í
This light turns on if there is a
malfunction in the high beam control
system (HBC). Have your vehicle
inspected by an Authorized Mazda
Dealer.
qIf the wrench indication/indicator
light is indicated
Type A
Perform maintenance in accordance with
the message.
7-30
If Trouble Arises
íSome models.
Warning/Indicator Lights and Warning Sounds
Mazda6_8EA2-EA-14K_Edition2 Page520
Saturday, January 10 2015 3:27 PM
Form No.8EA2-EA-14K

Black plate (531,1)
8
Customer Information and Reporting
Safety Defects
Important consumer information including warranties and add-on equipment.
Customer Assistance ............................... 8-2
Customer Assistance (U.S.A.) ............ 8-2
Customer Assistance (Canada) ........... 8-7
Customer Assistance (Puerto Rico) ... 8-10
Customer Assistance (Mexico) ......... 8-11
Mazda Importer/Distributors ............... 8-13
Importer/Distributor .......................... 8-13
Reporting Safety Defects ....................... 8-14
Reporting Safety Defects (U.S.A.) .... 8-14
Reporting Safety Defects (Canada) ... 8-15
Warranty ................................................ 8-16
Warranties for Your Mazda ............... 8-16
Outside the United States/Canada ..... 8-17
Registering Your Vehicle in A Foreign
Country (Except United States and
Canada) ............................................. 8-18
Add-On Non-Genuine Parts and
Accessories ....................................... 8-19
Cell Phones ............................................. 8-20
Cell Phones Warning ......................... 8-20
Event Data Recorder ............................. 8-21
Event Data Recorder (U.S.A. and
Canada) ............................................. 8-21
Recording of Vehicle Data .................... 8-22
Recording of Vehicle Data ................ 8-22
Uniform Tire Quality Grading System
(UTQGS) ................................................ 8-23
Uniform Tire Quality Grading System
(UTQGS) .......................................... 8-23Tire Information (U.S.A.) ..................... 8-25
Tire Labeling ..................................... 8-25
Location of the Tire Label
(Placard) ............................................ 8-31
Tire Maintenance .............................. 8-34
Vehicle Loading ................................ 8-37
Steps for Determining the Correct Load
Limit ................................................. 8-43
Declaration of Conformity .................... 8-44
Declaration of Conformity ................ 8-44
Service Publications .............................. 8-54
Service Publications .......................... 8-54
8-1
Mazda6_8EA2-EA-14K_Edition2 Page531
Saturday, January 10 2015 3:27 PM
Form No.8EA2-EA-14K

Black plate (564,1)
Tire Maintenance
Improper or inadequate vehicle maintenance can cause tires to wear abnormally. Here are
some important maintenance points:
qTire Inflation Pressure
Inspect all tire pressure monthly (including the spare) when the tires are cold. Maintain
recommended pressures for the best ride, top handling, and minimum tire wear. Use the
pressures specified on the vehicle tire information placard or tire label for optimum service.
qTire Rotation
To equalize tread wear, rotate the tires every 12,000 km (7,500 miles) or sooner if irregular
wear develops. During rotation, inspect them for correct balance.
Do not include (TEMPORARY USE ONLY)
spare tire in rotation.Forward
Inspect the tires for uneven wear and damage. Abnormal wear is usually caused by one or a
combination of the following:
lIncorrect tire pressurelImproper wheel alignmentlOut-of-balance wheellSevere braking
After rotation, inflate all tire pressures to specification (page 9-7) and inspect the lug nuts
for tightness.
CAUTION
Rotate unidirectional tires and radial tires that have an asymmetrical tread pattern
or studs only from front to rear, not from side to side. Tire performance will be
weakened if rotated from side to side.
8-34
Customer Information and Reporting Safety Defects
Tire Information (U.S.A.)
Mazda6_8EA2-EA-14K_Edition2 Page564
Saturday, January 10 2015 3:27 PM
Form No.8EA2-EA-14K

Black plate (584,1)
Service Publications
Factory-authorized Mazda service publications are available for owners who wish to do
some of their own maintenance and repair.
When requesting any of our publications through an Authorized Mazda Dealer, refer to the
chart below.
If they do not have what you need in stock, they can order it for you.
PUBLICATION ORDER NUMBER PUBLICATION DESCRIPTION
9999-95-063B-16 2016 WORKSHOP MANUAL (English)
9999-MX-063B-16 2016 WORKSHOP MANUAL (Spanish)
9999-95-039G-16 2016 WIRING DIAGRAM (English)
9999-MX-039G-16 2016 WIRING DIAGRAM (Spanish)
9999-95-078C-16 2016 OWNER'S MANUAL (English)
9999-EC-078C-16 2016 OWNER'S MANUAL (French)
9999-PR-078C-16 2016 OWNER'S MANUAL (Spanish)
9999-95-101F-16 2016 SERVICE HIGHLIGHTS
9999-95-050C-16NAV2016 NAVIGATION SYSTEM OWNER'S MANUAL
(English)
9999-EC-050C-16NAV2016 NAVIGATION SYSTEM OWNER'S MANUAL
(English and French)
9999-PR-050C-16NAV2016 NAVIGATION SYSTEM OWNER'S MANUAL
(Spanish)
qWORKSHOP MANUAL:
Covers recommended maintenance and repair procedures of the drive train, body and
chassis.
qWIRING DIAGRAM:
Provides electrical schematics as well as component location for the entire electrical
system.
qOWNER'S MANUAL:
This booklet contains information regarding the proper care and operation of your vehicle.
This is not a technician's manual.
8-54
Customer Information and Reporting Safety Defects
Service Publications
Mazda6_8EA2-EA-14K_Edition2 Page584
Saturday, January 10 2015 3:27 PM
Form No.8EA2-EA-14K

Black plate (606,1)
A
Accessory Socket ............................ 5-130
Active driving display ....................... 4-20
Adaptive Front Lighting System
(AFS) ................................................ 4-94
Add-On Non-Genuine Parts and
Accessories ....................................... 8-19
Advanced Key
Operational range ....................... 3-10
Advanced Keyless Entry System ........ 3-9
Air Bag Systems ............................... 2-41
Antilock Brake System (ABS) .......... 4-80
Audio Control Switch
Adjusting the Volume ................ 5-51
Seek Switch ................................ 5-51
Audio System
Antenna ...................................... 5-13
Audio Control Switch ................ 5-51
Audio Set (Type A) .................... 5-21
Audio Set (Type B) .................... 5-32
AUX/USB/iPod mode ................ 5-52
Operating Tips for Audio
System ........................................ 5-13
Satellite Radio ............................ 5-42
Automatic Transaxle
Driving tips ................................ 4-56
Shift-lock override ..................... 4-51
Shift-lock system ....................... 4-51
Transaxle ranges ........................ 4-50
B
Battery ............................................... 6-36
Maintenance ............................... 6-37
Replacement ............................... 6-37
Specifications ............................... 9-4
Battery runs out ................................. 7-14
Jump-Starting ............................. 7-14
B
Beep sounds
Power steering warning buzzer ... 7-37
Beep Sounds
Air bag/front seat belt pretensioner
system warning .......................... 7-34
Blind spot monitoring
(BSM) system warning .............. 7-36
Electric parking brake warning ... 7-37
i-ELOOP ..................................... 7-36
Ignition not switched off
(STOP) warning ......................... 7-35
Key left-in-trunk compartment
warning ...................................... 7-36
Key left-in-vehicle warning ....... 7-36
Key removed from vehicle
warning ...................................... 7-35
Lane departure warning ............. 7-36
Lights-on reminder ..................... 7-33
Request switch inoperable
warning ...................................... 7-35
Seat belt warning ........................ 7-34
Tire inflation pressure warning ... 7-36
Blind Spot Monitoring
(BSM) System ................................ 4-104
Bluetooth® ....................................... 5-69
Bluetooth® Audio (Type A) .... 5-108
Bluetooth® Audio (Type B) ..... 5-110
Bluetooth® Hands-Free
(Type A) ..................................... 5-91
Bluetooth® Hands-Free
(Type B) ..................................... 5-98
Troubleshooting ....................... 5-124
Body Lubrication .............................. 6-32
Bottle Holder ................................... 5-132
10-2
Index
Mazda6_8EA2-EA-14K_Edition2 Page606
Saturday, January 10 2015 3:28 PM
Form No.8EA2-EA-14K

Black plate (608,1)
E
Engine
Coolant ....................................... 6-29
Engine Compartment
Overview .................................... 6-26
Exhaust gas ................................ 3-26
Hood release .............................. 6-24
Oil .............................................. 6-27
Starting ......................................... 4-3
Essential information .......................... 6-2
Event Data Recorder ......................... 8-21
Exhaust Gas ...................................... 3-26
Exterior Care ..................................... 6-62
Aluminum Wheel
Maintenance ............................... 6-66
Bright-Metal Maintenance ......... 6-65
Maintaining the Finish ............... 6-63
Plastic Part Maintenance ............ 6-67
F
Flasher
Hazard warning .......................... 4-70
Headlights .................................. 4-58
Flat Tire ............................................... 7-3
Mounting the Spare Tire ............ 7-10
Removing a Flat Tire ................... 7-7
Floor Mat .......................................... 3-44
Fluid
Brake/Clutch .............................. 6-31
Washer ........................................ 6-31
Fluids
Classification ................................ 9-4
Fog Lights ......................................... 4-63
Foot Brake ........................................ 4-74
Forward Sensing Camera (FSC) ..... 4-135
Front Seat ............................................ 2-5
F
Fuel
Filler lid and cap ........................ 3-27
Gauge ......................................... 4-13
Requirements ............................. 3-24
Tank capacity ............................... 9-5
Fuel Consumption Display ................ 4-88
Fuel Economy Monitor ..................... 4-87
Control Status Display ............... 4-88
Ending Screen Display ............... 4-89
Fuel Consumption Display ......... 4-88
Fuses ................................................. 6-56
Panel description ........................ 6-58
Replacement ............................... 6-56
G
Gauges .............................................. 4-10
Glove Compartment ........................ 5-134
H
Hazard Warning Flasher .................... 4-70
Hazardous Driving ............................ 3-44
Head Restraint .................................. 2-12
Headlights
Coming Home Light System ..... 4-61
Control ....................................... 4-58
Flashing ...................................... 4-61
High-low beam .......................... 4-61
Leaving Home Light System ..... 4-62
Leveling ..................................... 4-62
High Beam Control System (HBC) ... 4-95
Hill Launch Assist (HLA) ................. 4-78
HomeLink Wireless Control
System .............................................. 4-70
Hood Release .................................... 6-24
Horn .................................................. 4-69
10-4
Index
Mazda6_8EA2-EA-14K_Edition2 Page608
Saturday, January 10 2015 3:28 PM
Form No.8EA2-EA-14K

Black plate (610,1)
I
Interior Care ...................................... 6-67
Cleaning the Lap/Shoulder Belt
Webbing ..................................... 6-69
Cleaning the Upholstery and Interior
Trim ............................................ 6-67
Cleaning the Window Interiors ... 6-70
Dashboard Precautions ............... 6-67
Interior Lights ................................. 5-128
Courtesy Lights ........................ 5-128
Map Lights ............................... 5-128
Overhead Lights ....................... 5-128
J
Jack ..................................................... 7-4
Jump-Starting .................................... 7-14
K
Key Suspend Function ........................ 3-8
Keyless Entry System ......................... 3-4
Keys .................................................... 3-2
Key suspend function ................... 3-8
Transmitter ................................... 3-5
L
Label Information ............................... 9-2
Lane Departure Warning System
(LDWS) ............................................ 4-98
LDWS switch ........................... 4-101
Lane-Change Signals ........................ 4-63
Laser Sensor (Front) ....................... 4-141
Leaving Home Light System ............ 4-62
Light Bulbs
Replacement ............................... 6-46
Specifications ............................... 9-6
Lighting Control ............................... 4-58
L
Lubricant Quality ................................ 9-4
M
Maintenance
Information .................................. 6-2
Scheduled ..................................... 6-4
Maintenance and Care ........................ 6-2
Maintenance Monitor ........................ 4-15
Manual Transaxle Operation ............. 4-47
Recommendations for shifting.... 4-48
Map Lights ...................................... 5-128
Mazda Radar Cruise Control
(MRCC) .......................................... 4-117
Close proximity warning .......... 4-120
Cruise control function ............. 4-124
Display indication .................... 4-120
Setting the system .................... 4-121
Mazda Radar Cruise Control
(MRCC) System Warnings ............... 7-37
Mazda Radar Cruise Control
(MRCC) Warning Light (Amber)/
Indicator Light (Green) ..................... 4-45
Meters and Gauges ........................... 4-10
Mirror Defogger ................................ 4-69
Mirrors
Rearview mirror ......................... 3-31
Moonroof .......................................... 3-36
O
Outside Temperature Display ............ 4-14
Overhead Console ........................... 5-133
Overhead Lights .............................. 5-128
Overheating ....................................... 7-18
Overloading ...................................... 3-47
10-6
Index
Mazda6_8EA2-EA-14K_Edition2 Page610
Saturday, January 10 2015 3:28 PM
Form No.8EA2-EA-14K