2016 FORD POLICE INTERCEPTOR SEDAN steering

Multi-Point inspection
Hazard warning system operation
Accessory drive belt(s)
Horn operation
Battery performance
Radiator, cooler, heater and air conditioninghoses
Engine air filter
Suspension components for leaks ordamage
Exhaust system
Steering and linkage
Exterior lamps operation
Tires (including spare) for wear and properpressure**
Fluid levels *
; fill if necessary
Windshield for cracks, chips or pits
For oil and fluid leaks
Washer spray and wiper operation
Half-shaft dust boots
* Brake, coolant recovery reservoir, automatic transmission and window washer
** If your vehicle is equipped with a temporary mobility kit, check the tire sealant expiration
Use By date on the canister. Replace as needed.
Be sure to ask your dealership service
advisor or technician about the multi-point
vehicle inspection. It is a comprehensive
way to perform a thorough inspection of
your vehicle. Your checklist gives you
immediate feedback on the overall
condition of your vehicle.
NORMAL SCHEDULED
MAINTENANCE
Intelligent Oil-Life Monitor™
Your vehicle is equipped with an Intelligent
Oil-Life Monitor that determines when you
should change the engine oil based on how
your vehicle is used. By using several
important factors in its calculations, the
monitor helps reduce the cost of owning
your vehicle and reduces environmental
waste at the same time. This means you do not have to remember
to change the oil on a mileage-based
schedule. Your vehicle lets you know when
an oil change is due by displaying a
message in the information display.
The following table provides examples of
vehicle use and its impact on oil change
intervals. It is a guideline only. Actual oil
change intervals depend on several factors
and generally decrease with severity of
use.
313
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Scheduled Maintenance

When to expect the OIL CHANGE REQUIRED message
Vehicle use and example
Interval
Normal
7500-10000 miles
(12000-16000 km) Normal commuting with highway driving
No, or moderate, load or towing
Flat to moderately hilly roads
No extended idling
Severe
5000-7499 miles
(8000-11999 km) Moderate to heavy load or towing
Mountainous or off-road conditions
Extended idling
Extended hot or cold operation
Extreme
3000-4999 miles
(4800-7999 km) Maximum load or towing
Extreme hot or cold operation
Normal Maintenance Intervals At every oil change interval as indicated by the information display
*
Change engine oil and filter. **
Rotate the tires.
Perform a multi-point inspection (recommended).
Inspect the automatic transmission fluid level. Consult your dealer for requirements.
Inspect the brake pads, rotors, hoses and parking brake.
Inspect the engine cooling system strength and hoses.
Inspect the exhaust system and heat shields.
Inspect the rear axle and U-joints (AWD only).
Inspect the half-shaft boots.
Inspect the steering linkage, ball joints, suspension, tire-rod ends, driveshaft and U-
joints.
314
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Scheduled Maintenance

Police vehicles equipped with an engine idle hour meter
Replace cabin air filter.
Inspect frequently, service
as required
Inspect the brake system
Every 5000 miles (8000
km)
Lubricate control arm and steering ball joints (if equipped
with grease fittings).
Rotate tires, inspect tires for wear and measure tread
depth.
Change engine oil and filter.*
Every 5000 miles (8000
km) or six months or as
indicated by time/milage
calculation (see description
below) Perform multi-point inspection.
Change automatic transmission fluid.
Every 30000 miles (48000
km)
Replace spark plugs.
Every 60000 miles (96000
km)
* Reset your Intelligent Oil-Life Monitor after engine oil and filter changes. See Engine
Oil Check (page 175).
Engine Idle Hour Meter
Your vehicle may been fitted with an idle
meter to indicate how much time the
vehicle has been sitting in park (P) or
neutral (N). The meter is incorporated with
the vehicle odometer. Depressing the
odometer-reset button once displays the
trip odometer (miles [kilometers]
following by a "T" for trip odometer);
depressing the odometer-reset button a
second time displays the idle meter (hours
following by an "H" for hours). The idle
meter only accumulates time when the
vehicle is in park (P) or neutral (N). Displayed time is cumulative for the vehicle
and cannot be reset to zero. Police vehicles
often experience long periods of idling,
during which engine oil continues to break
down but distance is not accumulated on
the odometer.
Engine idle hour meter calculation:
Idle hours x 33 = miles (kilometers)
equivalency
Miles (kilometers) driven + miles
(kilometers) equivalency = oil change
interval
318
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Scheduled Maintenance

A
A/C
See: Climate Control........................................... 79
About This Manual...........................................7
ABS See: Brakes............................................................. 112
ABS driving hints See: Hints on Driving With Anti-Lock
Brakes.................................................................. 112
Accessories See: Replacement Parts
Recommendation............................................. 11
Adjusting the Headlamps..........................187 Horizontal Aim Adjustment........................... 188
Vertical Aim Adjustment.................................. 187
Adjusting the Pedals
.....................................55
Adjusting the Steering Wheel....................53
Airbag Disposal...............................................45
Air Conditioning See: Climate Control........................................... 79
Air Filter See: Changing the Engine Air Filter..............192
Alarm See: Anti-Theft Alarm........................................ 52
All-Wheel Drive
.............................................105
Anti-Theft Alarm............................................52
Alarm System........................................................ 52
Arming the Alarm................................................. 52
Disarming the Alarm........................................... 52
Triggering the Alarm............................................ 52
Appendices....................................................330
Audible Warnings and Indicators.............69 Headlamps On Warning Chime..................... 69
Key in Ignition Warning Chime........................ 69
Parking Brake On Warning Chime.................69
Audio Control
...................................................53
Audio Input Jack...........................................259
Audio System
................................................254
General Information......................................... 254
Audio Unit - Vehicles With: AM/FM/CD/ SYNC/Satellite Radio.............................255
Menu Structure................................................... 257Automatic Transmission
...........................102
Automatic Transmission Adaptive
Learning............................................................ 104
Brake-Shift Interlock......................................... 102
If Your Vehicle Gets Stuck In Mud or Snow.................................................................. 104
Understanding the Positions of Your Automatic Transmission............................. 102
Automatic Transmission Fluid Check - 2.0L EcoBoost™.......................................180
6F35 Transmission............................................ 180
Automatic Transmission Fluid Check - 3.5L Duratec/3.5L Ecoboost™/
3.7L
.................................................................180
6F50/6F55 Transmission............................... 180
Auxiliary Power Points..................................87 12 Volt DC Power Point....................................... 87
Locations................................................................. 87
AWD See: All-Wheel Drive......................................... 105
B
Battery See: Changing the 12V Battery...................... 185
Blind Spot Information System...............123 Switching the System Off and On................125
System Errors....................................................... 124
Using the System................................................ 123
Bonnet Lock See: Opening and Closing the Hood...........170
Booster Seats
..................................................22
Types of Booster Seats...................................... 23
Brake Fluid Check.........................................184
Brakes.................................................................112 General Information............................................ 112
Breaking-In......................................................144
Bulb Specification Chart...........................190
C
Cabin Air Filter.................................................82
California Proposition 65..............................11
Capacities and Specifications - 2.0L EcoBoost™.................................................238
Specifications..................................................... 238
347
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Index

General Maintenance Information........310
Multi-Point Inspection...................................... 312
Owner Checks and Services............................ 311
Protecting Your Investment............................ 310
Why Maintain Your Vehicle?.......................... 310
Why Maintain Your Vehicle at Your Dealership?...................................................... 310
Getting Assistance Outside the U.S. and Canada..........................................................155
Getting the Services You Need
................152
Away From Home............................................... 152
H
Handbrake See: Parking Brake............................................... 113
Hazard Warning Flashers..........................148
Headlamp Adjusting See: Adjusting the Headlamps...................... 187
Head Restraints
..............................................83
Adjusting the Head Restraint.......................... 84
Tilting Head Restraints ..................................... 84
Heated Windows and Mirrors.....................81 Heated Exterior Mirror......................................... 81
Heated Rear Window.......................................... 81
Heating See: Climate Control........................................... 79
Hints on Controlling the Interior Climate...........................................................80
Cooling the Interior Quickly............................. 80
General Hints........................................................ 80
Heating the Interior Quickly............................. 80
Maximum Cooling Performance in Instrument Panel or Instrument Panel
and Footwell Positions.................................. 81
Recommended Settings for Cooling ............81
Recommended Settings for Heating...........80
Side Window Defogging in Cold Weather............................................................... 81
Vehicle Stationary for Extended Periods During Extreme High Ambient
Temperatures.................................................... 81
Hints on Driving With Anti-Lock Brakes..............................................................112
Hood Lock See: Opening and Closing the Hood...........170 I
Ignition Switch
................................................89
In California (U.S. Only)..............................153
Information Display Control.......................54
Information Displays
.....................................70
General Information............................................ 70
Information Messages
..................................73
AdvanceTrac ™...................................................... 73
Alarm........................................................................\
. 73
AWD
........................................................................\
... 74
Battery and Charging System.......................... 74
Blind Spot Information and Cross Traffic Alert System...................................................... 75
Brake System......................................................... 75
Doors and Locks.................................................... 75
Fuel........................................................................\
.... 76
Maintenance.......................................................... 76
Park Aid.................................................................... 76
Power Steering....................................................... 77
Reminder Messages............................................. 77
Seats........................................................................\
.. 77
Tire Pressure Monitoring System................... 78
Traction Control.................................................... 78
Installing Child Restraints
............................16
Child Seats............................................................... 16
Using Lap and Shoulder Belts.......................... 17
Using Lower Anchors and Tethers for CHildren (LATCH)............................................ 19
Using Tether Straps.............................................. 21
Instrument Cluster........................................65
Instrument Lighting Dimmer
.....................58
Interior Lamps.................................................59 Dome Task Lamp................................................. 60
Front Map Lamps................................................. 59
Interior Luggage Compartment Release...........................................................50
Interior Mirror...................................................63 Auto-Dimming Mirror.......................................... 63
Introduction.........................................................7
J
Jump Starting the Vehicle
.........................149
Connecting the Jumper Cables..................... 149
Jump Starting...................................................... 150
Preparing Your Vehicle..................................... 149
Removing the Jumper Cables........................ 150
350
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Index

K
Keys and Remote Controls........................46
L
Lighting Control...............................................57
Headlamp Flasher............................................... 58
High Beams............................................................. 57
Spot Lamp Control.............................................. 58
Lighting
...............................................................57
General Information............................................ 57
Load Carrying.................................................130
Load Limit
.......................................................130
Special Loading Instructions for Owners of
Pick-up Trucks and Utility-type
Vehicles.............................................................. 137
Vehicle Loading - with and without a Trailer................................................................. 130
Locking and Unlocking
................................48
Battery Saver......................................................... 49
Hidden Rear Door Locks.................................... 48
Illuminated Entry.................................................. 49
Illuminated Exit..................................................... 49
Locking and Unlocking the Doors with the Key Blade........................................................... 49
Opening a Rear Door From the Inside..........49
Opening the Luggage Compartment...........50
Power Door Locks................................................ 48
Remote Control.................................................... 48
Locks...................................................................48
Lug Nuts See: Changing a Road Wheel........................ 224
M
Maintenance...................................................170 General Information.......................................... 170
Manual Climate Control..............................79
Manual Seats..................................................85 Lumbar Adjustment........................................... 86
Moving the Seat Backward and Forward............................................................... 85
Recline Adjustment............................................. 85
Media Hub......................................................260
Message Center See: Information Displays................................. 70Mirrors
See: Heated Windows and Mirrors.................81
See: Windows and Mirrors................................. 61
Mobile Communications Equipment.......13
Motorcraft Parts - 2.0L EcoBoost™..................................................231
Motorcraft Parts - 3.5L Duratec.............233
Motorcraft Parts - 3.5L Ecoboost™.................................................234
Motorcraft Parts - 3.7L...............................235
N
Normal Scheduled Maintenance............313 Intelligent Oil-Life Monitor™.......................... 313
Normal Maintenance Intervals...................... 314
O
Oil Change Indicator Reset........................176
Oil Check See: Engine Oil Check........................................ 175
Opening and Closing the Hood...............170 Closing the Hood.................................................. 171
Opening the Hood.............................................. 170
Ordering Additional Owner's Literature......................................................156
Obtaining a French Owner ’s Manual...........157
Overhead Console
.........................................88
P
Parking Aids......................................................117 Principle of Operation........................................ 117
Parking Brake
..................................................113
Pedals.................................................................55
Perchlorate.........................................................11
Personal Safety System ™
..........................33
How Does the Personal Safety System
Work?................................................................... 33
Power Door Locks See: Locking and Unlocking............................. 48
Power Seats.....................................................86
Power Steering Fluid Check.....................184
351
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Index

Speed Control
See: Cruise Control.............................................. 121
Stability Control.............................................115
Principle of Operation........................................ 115
Starter Switch See: Ignition Switch............................................ 89
Starting a Gasoline Engine
.........................89
Cold Weather Starting - Flex Fuel
Vehicles.............................................................. 90
Failure to Start...................................................... 90
Guarding Against Exhaust Fumes.................. 91
Important Ventilating Information.................91
Stopping the Engine When Your Vehicle is Moving.................................................................. 91
Stopping the Engine When Your Vehicle is Stationary........................................................... 91
Starting and Stopping the Engine...........89 General Information........................................... 89
Steering............................................................128 Electric Power Steering.................................... 128
Steering Wheel................................................53
Storage Compartments..............................88
Sun Visors.........................................................64 Slide-on-rod.......................................................... 64
Supplementary Restraints System.........34 Principle of Operation........................................ 34
Symbols Glossary
.............................................7
SYNC™ Applications and Services.......279
911 Assist............................................................... 279
SYNC Services: Traffic, Directions & Information (TDI) (If Equipped, United
States Only).................................................... 283
Vehicle Health Report (If Equipped, United States Only)..................................................... 281
SYNC™ AppLink ™
......................................287
SYNC Mobile Apps............................................ 287
SYNC™.............................................................261 General Information.......................................... 261
SYNC™ Troubleshooting
.........................299
T
Technical Specifications See: Capacities and Specifications............229
The Better Business Bureau (BBB) Auto Line Program (U.S. Only)
........................154 Tire Care
.........................................................206
Glossary of Tire Terminology......................... 207
Information About Uniform Tire Quality Grading............................................................. 206
Information Contained on the Tire Sidewall........................................................... 208
Police Wheels and Tires................................... 219
Temperature A B C............................................ 207
Traction AA A B C............................................... 207
Treadwear............................................................ 206
Tire Inflation When Punctured See: Tire Sealant and Inflator Kit................200
Tire Pressure Monitoring System...........220 Changing Tires With a Tire Pressure
Monitoring System........................................ 221
Understanding Your Tire Pressure Monitoring System ....................................... 222
Tire Repair Kit See: Tire Sealant and Inflator Kit................200
Tire Sealant and Inflator Kit
....................200
First Stage: Reinflating the Tire with Sealing
Compound and Air....................................... 202
General Information.......................................... 201
Second Stage: Checking Tire Pressure........................................................... 203
Tips for Use of the Kit....................................... 201
What to do after the Tire has been Sealed............................................................... 204
What to do when a Tire Is Punctured........202
Tires See: Wheels and Tires..................................... 200
Towing a Trailer.............................................138 Load Placement.................................................. 138
Towing the Vehicle on Four Wheels...........................................................142
Emergency Towing............................................. 142
Recreational Towing.......................................... 143
Towing..............................................................138
Traction Control
.............................................114
Principle of Operation........................................ 114
Transmission Code Designation.............237
Transmission..................................................102
Transmission See: Transmission.............................................. 102
Transporting the Vehicle
............................142
353
Police Interceptor (CPH), enUSA, Edition date: 10/2015, First Printing Index