2016 FORD F250 open hood

Engine oil filler cap
D.
Engine oil dipstick
E.
Power steering fluid reservoir
F.
Brake fluid reservoir
G.
Engine coolant reservoir
H.
Air filter assembly
I.
Power distribution box
J.
ENGINE OIL DIPSTICK MINA
MAX
B
ENGINE OIL CHECK
Note: For diesel engine information, refer
to the diesel supplement.
1. Make sure that your vehicle is on level ground.
2. Turn the engine off and wait 15 minutes
for the oil to drain into the oil pan.
3. Set the parking brake and ensure the gearshift is in P.
4. Open the hood. Protect yourself from engine heat. 5.
Locate and carefully remove the engine
oil level dipstick. See the Under Hood
Overview in this chapter for location of
dipstick.
6. Wipe the dipstick clean. Insert the dipstick fully, then remove it again.
•If the oil level is between the lower
and upper holes, the oil level is
acceptable. DO NOT ADD OIL.
• If the oil level is below the lower
hole, add enough oil to raise the
level within the lower and upper
holes.
• Oil levels above the upper hole may
cause engine damage. Some oil
must be removed from the engine
by an authorized dealer.
7. Put the oil level dipstick back into the oil dipstick tube and ensure it is fully
seated.
Adding Engine Oil
Note: Do not remove the filler cap when
the engine is running.
Note: Do not remove the engine oil level
dipstick when the engine is runnin
Note: Do not add oil further than the MAX
mark. Oil levels above the MAX mark may
cause engine damage.
235
Super Duty (TFA) Canada/United States of America, enUSA, First Printing MaintenanceE161560
AB

Headlamp Aiming Target
8 feet (2.4 meters)
A
Center height of lamp to ground
B
25 feet (7.6 meters)
C
Horizontal reference line
D
Vertical Aim Adjustment Procedure
1. Park the vehicle directly in front of a wall or screen on a level surface,
approximately 25 feet (7.6 meters)
away.
2. Measure the height of the headlamp bulb center from the ground and mark
an 8 foot (2.4 meter) horizontal
reference line on the vertical wall or
screen at this height.
Note: To see a clearer light pattern for
adjusting, you may want to block the light
from one headlamp while adjusting the
other.
3. Turn on the low beam headlamps to illuminate the wall or screen and open
the hood. 4. On the wall or screen you will observe
a flat zone of high intensity light
located at the top of the right hand
portion of the beam pattern. If the top
edge of the high intensity light zone is
not at the horizontal reference line, the
headlamp will need to be adjusted. 5. Locate the vertical adjuster on each
headlamp. Using a Phillips #2
screwdriver, turn the adjuster either
clockwise or counterclockwise in order
to adjust the vertical aim of the
headlamp.
6. Repeat steps 3 thru 5 to adjust the other headlamp.
7. Close the hood and turn off the lamps.
Horizontal Aim Adjustment
Horizontal aim is not required for this
vehicle and is not adjustable.
248
Super Duty (TFA) Canada/United States of America, enUSA, First Printing MaintenanceE142592 E142465 E163806

REMOVING A HEADLAMP
WARNING
Handle a halogen headlamp bulb
carefully and keep out of children
’s
reach. Grasp the bulb only by its
plastic base and do not touch the glass.
The oil from your hand could cause the
bulb to break the next time the headlamps
are operated. Note:
If the bulb is accidentally touched, it
should be cleaned with rubbing alcohol
before being used.
Note: This procedure is for replacing the
headlamps, park lamps or turn lamps.
1. Make sure the headlamp control is in the off position and open the hood. 2.
Using masking tape or a marker, make
an alignment mark between one of the
grille brackets and the vehicle radiator
support to ensure correct grille
alignment during the installation
procedure. Do not scratch the black
coating from the radiator support.
3. Remove the two grille to headlamp assembly push pins and the four bolts
attaching the top of the grille to the
radiator support.
4. Pull the top of the grille forward to gain
access to the lower grille spring clips. 5. Depress the spring clips through the
lower inner grille access openings using
a flat head screwdriver.
6. Pull the grill straight out to remove. 7. Remove the four bolts from the
headlamp assembly.
8. Pull the assembly straight out disengaging one snap clip from the
fender.
9. Disconnect the electrical connector by
squeezing the release tab and pushing
the connector forward, then pulling it
rearward.
CHANGING A BULB WARNINGS
Switch all of the lamps and the
ignition off. Failure to follow this
warning could result in serious
personal injury. Bulbs become hot when in use. Let
them cool down before you remove
them.
Use the correct specification bulb. See
Bulb Specification Chart (page 252).
Install in the reverse order unless otherwise
stated.
249
Super Duty (TFA) Canada/United States of America, enUSA, First Printing MaintenanceE163821 E163822

4
4WD
See: Four-Wheel Drive..................................... 158
A
A/C See: Climate Control.......................................... 110
About This Manual...........................................7
ABS See: Brakes........................................................... 169
ABS driving hints See: Hints on Driving With Anti-Lock
Brakes................................................................ 169
Accessories....................................................447 Exterior style........................................................ 447
Interior style......................................................... 447
Lifestyle................................................................. 447
Peace of mind..................................................... 447
Accessories See: Replacement Parts
Recommendation............................................. 11
Adjusting the Headlamps.........................247 Horizontal Aim Adjustment........................... 248
Vertical Aim Adjustment................................. 247
Adjusting the Pedals
....................................69
Adjusting the Steering Wheel...................66
Airbag Disposal
..............................................46
Air Conditioning See: Climate Control.......................................... 110
Alarm See: Anti-Theft Alarm........................................ 65
Anti-Theft Alarm
............................................65
Arming the Alarm................................................. 65
Disarming the Alarm........................................... 65
Appendices.....................................................472
Audible Warnings and Indicators.............87 Headlamps On Warning Chime...................... 87
Key in Ignition Warning Chime......................... 87
Parking Brake On Warning Chime.................88
Audio Control
..................................................66
Media........................................................................\
. 67
Seek, Next or Previous........................................ 67
Audio System.................................................317 General Information........................................... 317
Audio Unit - Vehicles With: AM/FM/CD/ SYNC..............................................................319 Audio Unit - Vehicles With: AM/FM/CD/
Touchscreen Display
................................322
Audio Unit - Vehicles With: AM/FM.......318
Autolamps.........................................................72 Autolamps - Programmable Exit
Delay..................................................................... 72
Automatic Climate Control.........................111
Automatic Transmission.............................151 Brake-Shift Interlock......................................... 155
If Your Vehicle Gets Stuck In Mud or Snow.................................................................. 156
Understanding the Shift Positions of a 6– Speed Automatic Transmission.........152
Understanding the Shift Positions of the 5– Speed Automatic Transmission..........151
Understanding your SelectShift Automatic ™ transmission......................... 154
Automatic Transmission Fluid Check............................................................240
Checking Automatic Transmission Fluid.................................................................... 241
Auxiliary Power Points.................................137 110 Volt AC Power Point.................................... 137
12 Volt DC Power Point...................................... 137
Locations................................................................ 137
Auxiliary Switches.......................................448
B
Bed Extender...................................................62 Grocery mode........................................................ 63
Tailgate mode........................................................ 62
Bonnet Lock See: Opening and Closing the Hood...........232
Booster Seats..................................................24 Types of Booster Seats...................................... 25
Brake Fluid Check........................................244
Brakes...............................................................169 General Information.......................................... 169
Breaking-In.....................................................207
Bulb Specification Chart
...........................252
C
California Proposition 65..............................11
Capacities and Specifications - 6.2L V8...................................................................307
Specifications..................................................... 308
495
Super Duty (TFA) Canada/United States of America, enUSA, First Printing Index

Fuel Consumption........................................147
Calculating Fuel Economy.............................. 148
Filling the Tank..................................................... 147
Fuel Filter........................................................244
Fuel Quality.....................................................145 Choosing the Right Fuel................................... 145
Choosing the Right Fuel With a Flex Fuel Vehicle (If Equipped)................................... 145
Diesel Engine........................................................ 145
Octane Recommendations............................ 145
Fuel Shutoff
....................................................213
Fuses.................................................................223
Fuse Specification Chart...........................223 Passenger Compartment Fuse
Panel
.................................................................. 228
Power Distribution Box.................................... 223
G
Garage Door Opener See: Universal Garage Door Opener............129
Gauges...............................................................82 Engine Coolant Temperature Gauge............83
Engine Oil Pressure Gauge............................... 83
Fuel Gauge.............................................................. 83
Information Display............................................. 84
Transmission Fluid Temperature Gauge.................................................................. 83
General Information on Radio Frequencies...................................................47
General Maintenance Information
.......453
Multi-point Inspection..................................... 455
Owner Checks and Services.......................... 454
Protecting Your Investment........................... 453
Why Maintain Your Vehicle?......................... 453
Why Maintain Your Vehicle at Your Dealership?..................................................... 453
Getting Assistance Outside the U.S. and Canada.........................................................220
Getting the Services You Need................217 Away From Home............................................... 217
Global Opening
................................................77
Opening the Windows........................................ 77
H
Handbrake See: Parking Brake.............................................. 170Hazard Warning Flashers
...........................213
HDC See: Using Hill Descent Control..................... 177
Head Restraints..............................................117 Adjusting the Head Restraint.......................... 118
Heated Seats
..................................................124
Rear Heated Seats ............................................ 124
Heated Steering Wheel
...............................68
Heated Windows and Mirrors...................115 Heated Exterior Mirror........................................ 115
Heated Rear Window......................................... 115
Heating See: Climate Control.......................................... 110
Hill Start Assist..............................................170 Switching the System On and Off.................171
Using Hill Start Assist........................................ 170
Hints on Controlling the Interior Climate...........................................................112
Cooling the Interior Quickly.............................. 114
General Hints......................................................... 112
Heating the Interior Quickly............................. 113
Recommended Settings for Cooling ...........114
Recommended Settings for Heating...........114
Side Window Defogging in Cold Weather.............................................................. 115
Hints on Driving With Anti-Lock Brakes
............................................................169
Hood Lock See: Opening and Closing the Hood...........232
I
Ignition Switch...............................................140
In California (U.S. Only)
.............................218
Information Display Control.......................67 Type 1........................................................................\
. 67
Type 2....................................................................... 68
Information Displays
....................................89
General Information........................................... 89
Information.....................................................418 911 Assist............................................................... 425
Alerts...................................................................... 424
Calendar................................................................ 424
Sirius Travel Link................................................. 423
SYNC Services (If Equipped, United States Only)................................................................... 419
Vehicle Health Report (If Equipped, US Only).................................................................. 427
498
Super Duty (TFA) Canada/United States of America, enUSA, First Printing Index

Memory Function.........................................120
Easy Entry and Exit Feature............................ 122
Linking a PreSet Position to your Remote Control or Intelligent Access Key Fob
........................................................................\
........ 121
Recalling a Preset Position............................... 121
Saving a Preset Position.................................... 121
Message Center See: Information Displays................................. 89
Mirrors See: Heated Windows and Mirrors................115
See: Windows and Mirrors................................ 76
Mobile Communications Equipment.......13
Moonroof..........................................................80 Bounce-Back
.......................................................... 81
Opening and Closing the Moonroof.............80
Venting the Moonroof......................................... 81
Motorcraft Parts
..........................................304
MyFord Touch ™...........................................374
General Information.......................................... 374
MyFord Touch ™ Troubleshooting........440
MyKey Troubleshooting...............................55
MyKey ™..............................................................51
Principle of Operation.......................................... 51
N
Navigation.......................................................431 cityseekr................................................................ 433
Destination Mode............................................... 431
Map Mode............................................................. 437
Navigation Map Updates............................... 440
Navigation Voice Commands....................... 440
Point of Interest (POI) Categories...............433
Quick-touch Buttons....................................... 439
Setting Your Navigation Preferences.........434
Normal Scheduled Maintenance..........456 6.2L and 6.8L Gasoline Engines.................. 456
6.7L Diesel Engine.............................................. 457
O
Oil Change Indicator Reset......................236 Resetting the Oil Life Monitoring
System.............................................................. 236
Oil Check See: Engine Oil Check...................................... 235
Opening and Closing the Hood..............232 Ordering Additional Owner's
Literature.......................................................221
Obtaining a French Owner ’s Manual...........221
Overhead Console
........................................139
P
Parking Aid
......................................................179
Rear Parking Aid.................................................. 179
Parking Aids
....................................................179
Parking Brake.................................................170
Passive Anti-Theft System........................64 SecuriLock ™.......................................................... 64
PATS See: Passive Anti-Theft System..................... 64
Pedals................................................................69
Perchlorate.........................................................11
Phone.................................................................411 Making Calls......................................................... 413
Pairing Subsequent Cell Phones.................. 412
Pairing Your Cell Phone for the First Time.................................................................... 412
Phone Menu Options........................................ 414
Phone Settings.................................................... 417
Phone Voice Commands................................. 418
Receiving Calls..................................................... 413
Text Messaging.................................................... 415
Post-Crash Alert System...........................216
Power Door Locks See: Locking and Unlocking............................. 56
Power Seats
...................................................120
Power Lumbar..................................................... 120
Power Recline...................................................... 120
Power Steering Fluid Check
.....................244
Power Take-Off.............................................156
Power Windows..............................................76 Accessory Delay..................................................... 77
Bounce-Back.......................................................... 76
One-Touch Up or Down..................................... 76
Window Lock.......................................................... 77
Protecting the Environment........................14
R
Rear Axle..........................................................167
Rear Seat Armrest........................................128
500
Super Duty (TFA) Canada/United States of America, enUSA, First Printing Index

Towing Points...............................................204
Towing the Vehicle on Four Wheels.........................................................206
Emergency Towing........................................... 206
Recreational Towing........................................ 206
Towing..............................................................192
Traction Control.............................................172 Principle of Operation........................................ 172
Trailer Sway Control
....................................193
Transfer Case Fluid Check........................243
Transmission Code Designation...........306
Transmission...................................................151
Transmission See: Transmission............................................... 151
Transporting the Vehicle..........................205
U
Under Hood Overview - 6.2L...................233
Under Hood Overview - 6.8L..................234
Universal Garage Door Opener...............129 CAR2U® Home Automation System..........129
HomeLink Wireless Control System............132
USB Port
.........................................................328
Using Cruise Control....................................183
Switching Cruise Control Off......................... 183
Switching Cruise Control On.......................... 183
Using Four-Wheel Drive
.............................158
4WD Indicator Lights........................................ 159
Driving Off-Road With Truck and Utility Vehicles............................................................. 162
Electronic Shift-On-the-Fly (ESOF) 4WD system............................................................... 158
How Your Vehicle Differs From Other Vehicles............................................................. 162
Manual Shift On Stop (MSOS) 4WD system............................................................... 158
Using a Manual Shift On Stop (MSOS) 4WD system.................................................... 159
Using the Electronic Shift on the Fly 4WD system................................................................ 161
Using Hill Descent Control.........................177 Hill descent modes............................................. 177
Using MyKey With Remote Start Systems..........................................................55
Using Snow Chains
.....................................284 Using Stability Control................................174
AdvanceTrac® with Roll Stability Control ™
(RSC®)............................................................... 174
Using SYNC™ With Your Media Player............................................................355
Accessing Your Play Menu............................. 360
Connecting Your Digital Media Player to the USB Port........................................................... 355
Media Menu Features...................................... 358
Media Voice Commands................................. 357
System Settings................................................. 362
What's Playing?................................................. 357
Using SYNC™ With Your Phone............334 Accessing Features Through the Phone
Menu.................................................................. 338
Accessing Your Phone Settings.................... 342
Making a Call....................................................... 337
Pairing a Cell Phone for the First Time................................................................... 334
Pairing Subsequent Cell Phones.................335
Phone Options during an Active Call..........337
Phone Voice Commands................................ 335
Receiving Calls.................................................... 337
System Settings................................................. 343
Text Messaging.................................................. 340
Using Traction Control
................................172
System Indicator Lights and
Messages........................................................... 173
Using Voice Recognition............................331 Initiating a Voice Session................................. 331
System Interaction and Feedback..............332
Utilizing the Mediation/Arbitration Program (Canada Only)
.........................219
V
Vehicle Care...................................................256 General Information......................................... 256
Vehicle Certification Label
......................306
Vehicle Identification Number...............305
503
Super Duty (TFA) Canada/United States of America, enUSA, First Printing Index