2016 DODGE CHARGER engine overheat

HAZARD WARNING FLASHERS
The Hazard Warning flasher switch is located on the
instrument panel, below the radio.Push the switch to turn on the Hazard Warning
flasher. When the switch is activated, all direc-
tional turn signals will flash on and off to warn oncoming
traffic of an emergency. Push the switch a second time to
turn off the Hazard Warning flashers.
This is an emergency warning system and it should not
be used when the vehicle is in motion. Use it when your
vehicle is disabled and it is creating a safety hazard for
other motorists.
When you must leave the vehicle to seek assistance, the
Hazard Warning flashers will continue to operate even
though the ignition is placed in the OFF position.
NOTE: With extended use the Hazard Warning flashers
may wear down your battery.
IF YOUR ENGINE OVERHEATS
In any of the following situations, you can reduce the
potential for overheating by taking the appropriate action.
• On the highways — slow down.
•
In city traffic — while stopped, place the transmission in
NEUTRAL, but do not increase the engine idle speed.
NOTE: There are steps that you can take to slow down
an impending overheat condition:
• If your air conditioner (A/C) is on, turn it off. The A/C
system adds heat to the engine cooling system and
turning the A/C off can help remove this heat.
• You can also turn the temperature control to maximum
heat, the mode control to floor and the blower control
to high. This allows the heater core to act as a
supplement to the radiator and aids in removing heat
from the engine cooling system.
6
WHAT TO DO IN EMERGENCIES 513

least amount of accelerator pedal pressure that will
maintain the rocking motion, without spinning the
wheels or racing the engine.
NOTE:Shifts between DRIVE and REVERSE can only be
achieved at wheel speeds of 5 mph (8 km/h) or less.
Whenever the transmission remains in NEUTRAL for
more than 2 seconds, you must press the brake pedal to
engage DRIVE or REVERSE.
CAUTION!
Racing the engine or spinning the wheels may lead to
transmission overheating and failure. Allow the en-
gine to idle with the transmission in NEUTRAL for at
least one minute after every five rocking-motion
cycles. This will minimize overheating and reduce
the risk of transmission failure during prolonged
efforts to free a stuck vehicle. NOTE:
Push the ESC Off switch, to place the Electronic
Stability Control (ESC) system in Partial Offmode,
before rocking the vehicle. Refer to “Electronic Brake
Control” in “Starting And Operating” in your Owner’s
Manual on the DVD for further information. Once the
vehicle has been freed, push the ESC Offswitch again to
restore ESC On mode.
CAUTION!
•When “rocking” a stuck vehicle by shifting be-
tween DRIVE and REVERSE, do not spin the
wheels faster than 15 mph (24 km/h), or drivetrain
damage may result.
• Revving the engine or spinning the wheels too fast
may lead to transmission overheating and failure.
It can also damage the tires. Do not spin the wheels
above 30 mph (48 km/h) while in gear (no trans-
mission shifting occurring).
540 WHAT TO DO IN EMERGENCIES

CAUTION!(Continued)
performance, have your vehicle serviced promptly.
Continued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and
vehicle.
Under normal operating conditions, the catalytic con-
verter will not require maintenance. However, it is im-
portant to keep the engine properly tuned to assure
proper catalyst operation and prevent possible catalyst
damage.
NOTE: Intentional tampering with emissions control
systems can result in civil penalties being assessed
against you.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop the vehicle, turn off the engine and allow it to cool.
Service, including a tune-up to manufacturer’s specifica-
tions, should be obtained immediately.
To minimize the possibility of catalytic converter dam-
age:
•
Do not shut off the engine or interrupt the ignition,
when the transmission is in gear and the vehicle is in
motion.
• Do not try to start the engine by pushing or towing the
vehicle.
• Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough
idle or malfunctioning operating conditions.
572 MAINTAINING YOUR VEHICLE

•Use only high purity water such as distilled or deion-
ized water when mixing the water/engine coolant
(antifreeze) solution. The use of lower quality water
will reduce the amount of corrosion protection in the
engine cooling system.
NOTE:
• It is the owner’s responsibility to maintain the proper
level of protection against freezing according to the
temperatures occurring in the area where the vehicle is
operated.
• Some vehicles require special tools to add coolant
properly. Failure to fill these systems properly could
lead to severe internal engine damage. If any coolant is
needed to be added to the system, please contact your
local authorized dealer.
• Mixing engine coolant (antifreeze) types is not recom-
mended and can result in cooling system damage. If HOAT and OAT coolant are mixed in an emergency,
have a authorized dealer drain, flush, and refill with
OAT coolant (conforming to MS.90032) as soon as
possible.
Cooling System Pressure Cap
The cap must be fully tightened to prevent loss of engine
coolant (antifreeze), and to ensure that engine coolant
(antifreeze) will return to the radiator from the coolant
recovery tank.
The cap should be inspected and cleaned if there is any
accumulation of foreign material on the sealing surfaces.
WARNING!
•
Do not open hot engine cooling system. Never add
engine coolant (antifreeze) when the engine is
overheated. Do not loosen or remove the cap to cool
(Continued)
576 MAINTAINING YOUR VEHICLE

WARNING!(Continued)
an overheated engine. Heat causes pressure to
build up in the cooling system. To prevent scalding
or injury, do not remove the pressure cap while the
system is hot or under pressure.
• Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or en-
gine damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine coolant (antifreeze) is
a regulated substance requiring proper disposal. Check
with your local authorities to determine the disposal
rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
engine coolant in open containers or allow it to remain in puddles on the ground. If ingested by a child or pet, seek
emergency assistance immediately. Clean up any ground
spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine OFF and cold, the level of the engine coolant
(antifreeze) in the bottle should be between the ranges
indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator/coolant pressure cap
unless checking for engine coolant (antifreeze) freeze
point or replacing coolant. Advise your service attendant
of this. As long as the engine operating temperature is
satisfactory, the coolant bottle need only be checked once
a month.
7
MAINTAINING YOUR VEHICLE 577

DrivingThrough Flowing, Rising, Or Shallow Standing
Water ............................... .430
E-85 Fuel .............................. .488
Electrical Power Outlets .....................245
Electric Rear Window Defrost .................254
Electric Remote Mirrors .....................121
Electronic Brake Control System ...............437
Anti-Lock Brake System ..................438
Electronic Roll Mitigation .................449
Traction Control System ...................444
Electronic Power Distribution Center (Fuses) ......591
Electronic Speed Control (Cruise Control). .176, 177, 180
Electronic Stability Control (ESC) ..............444
Electronic Throttle Control Warning Light ........275
Emergency Deck Lid Release ..................47
Emergency, In Case Of Freeing Vehicle When Stuck ................539 Jacking
.............................. .516
Jump Starting ..................... .535, 537
Overheating .......................... .513
Towing ............................. .544
Emergency Trunk Release ....................47
Emission Control System Maintenance ..........555
Engine ................................ .553
Air Cleaner .......................... .563
Block Heater ......................... .414
Break-In Recommendations .................99
Checking Oil Level ..................... .559
Compartment ...................... .552, 553
Compartment Identification ................552
Coolant (Antifreeze) ...........573, 613, 614, 615
Cooling ............................. .573
Exhaust Gas Caution .................100, 488
Fails To Start ......................... .413
Flooded, Starting ...................... .413
Fuel Requirements ..................... .483
10
INDEX 641

Jump Starting..................... .535, 537
Oil ....................559, 611, 613, 614, 615
Oil Filler Cap ......................... .561
Oil Filter ............................ .562
Oil Selection ...................... .560, 611
Oil Synthetic ......................... .562
Overheating .......................... .513
Starting ............................. .410
Engine Oil Viscosity ...................... .561
Engine Oil Viscosity Chart ...................561
Enhanced Accident Response Feature ............73
Entry System, Illuminated ....................21
Ethanol ............................ .485, 488
Event Data Recorder ........................76
Exhaust Gas Caution ...................100, 488
Exhaust System ...................... .100, 570
Exterior Folding Mirrors ....................120
Exterior Lighting ......................... .154Exterior Lights
.......................... .103
Filters Air Cleaner .......................... .563
Air Conditioning ....................380, 567
Engine Oil ..................562, 613, 614, 615
Engine Oil Disposal .....................562
Flashers ............................... .513
Hazard Warning ....................... .513
Turn Signal .....................103, 160, 291
Flash-To-Pass ........................... .160
Flexible Fuel Vehicles Cruising Range ........................ .491
Engine Oil ........................... .490
Fuel Requirements ...................488, 489
Maintenance .......................... .491
Replacement Parts ...................... .491
Starting ............................. .490
Flooded Engine Starting ....................413
642 INDEX

Vanity.............................. .122
Modifications/Alterations, Vehicle ...............7
Monitor, Tire Pressure System ................477
MOPAR Parts ........................ .557, 631
MTBE/ETBE ........................... .485
Multi-Function Control Lever .................159
New Vehicle Break-In Period ..................99
Occupant Restraints ........................47
Octane Rating, Gasoline (Fuel) ......483, 613, 614, 615
Oil, Engine .................298, 559, 613, 614, 615
Capacity ..............................611
Change Interval ....................... .560
Checking ............................ .559
Dipstick ............................. .559
Disposal ............................. .562
Filter ..................... .562, 613, 614, 615
Filter Disposal ........................ .562Identification Logo
..................... .560
Materials Added To ..................... .562
Pressure Warning Light ...................274
Recommendation ....................560, 611
Synthetic ............................ .562
Viscosity ......................... .561, 611
Oil Filter, Change ........................ .562
Oil Filter, Selection ....................... .562
Oil Pressure Light ........................ .274
Onboard Diagnostic System ..................554
Operating Precautions ..................... .554
Operator Manual (Owner’s Manual) .............4
Outside Rearview Mirrors ...................119
Overheating, Engine ...................... .513
Owner’s Manual (Operator Manual) ..........4,632
Paint Care ............................. .584
Panic Alarm ..............................24
Parking Brake ........................... .434
648 INDEX