2016 AUDI A8 fuel

Fuel and Refueling
nearest authorized Audi dealer or author­
ized Audi Service Facility for assistance.
These fuels contain substances that can se­
verely damage the fuel system and the en­
gine if the engine is started.
Refueling
Fuel filler neck
The fuel filler neck is located on the right rear
side panel behind the fuel filler flap.
If the power locking system should fail, you can
still open the flap manual ly -for detailed instruc­
tions see
c;> page 216.
You can find the fuel tank capac ity of your vehicle
In .
The label on the inside of the fuel filler flap tells
you the correct fuel for your vehicle. For more in­
formation about fue l specifications, see
c;> page 212.
Your vehicle fuel tank has an onboard refuelling
vapor recovery system. This feature helps to pre­
vent fuel vapors from escaping from the tank and
pollut ing the environment while you refuel your
veh icle. In order to fill the tank properly while
protecting the environment, please follow this
refueling procedure carefully.
_& WARNING
Under normal operating conditions, never car­
ry additional fuel containers in your car. Gas
canisters and other containers used to trans­
port fuel can be dangerous. Such containers,
full or empty, may leak and could cause a fire
in a collision. If you must transport fuel to
use for you r lawn mower, snow blower, etc.,
be very careful and always observe local and
state laws regarding the use, transportation
and storage of such fuel containers. Make cer­
tain the container meets industry standards
(ANSI/ASTM F852 -86).
(D Note
Never drive your vehicle until the fuel tank is
completely empty. The ir regular supply of
fuel can cause m isfiring. Gasoline could enter
214
the exhaust system and damage the catalytic
converter.
Refuelling
Fig. 188 Right rear vehicle side: Opening the fuel filler flap
Fig. 189 Fuel fille r flap with attached fuel cap
When activating the central locking, the fue l fill­
er flap is automatically unlocked or locked. Re­
fuel the vehicle with the ignition switched
off.
Taking the fuel cap off
.,. Press the left side of the fuel fil ler flap to open
it
c;>fig. 188- arrow- .
.,. Unscrew f uel filler cap counter-clockwise and
hang it on the fuel filler flap¢
fig. 189.
.,. Check the label on the inside of the fuel filler
flap to determine if the vehicle must be fueled
with gasoline or diesel fuel.
Refuelling procedure
.,. Insert the fuel nozz le from the gasoline pump
into the fue l filler neck as far as it will go.
.,. Select a medium refuelling rate so that the
nozzle switches off automatically when the
tank is full.

Putting the fuel c ap back on
"' After filling your tank , tw ist the f uel fi ller cap
clockwise as far as it wi ll go .
"' Close the fuel filler flap.
To avoid fuel spill ing o r evaporating from the f uel
tank always close fuel filler cap properly and
comp let ely. An improperly closed fue l filler cap
may a lso caus e the MIL lamp ¢
page 28 to come
on (only vehicles with gasoline engine).
A WARNING
Improper refueling or handling of fuel can
cause fire, explosion and severe burns .
- Fuel is highly f lammable and can cause se­
vere burns and other injur ies.
-
- Failure to shut the engine off wh ile refuel ­
ing and/or to insert the pump no zzle fully
into the fuel filler neck could cause fuel to
spray out of filler neck or to overflow . Fuel
spray and overflowing fue l can cause a fire .
- Never use a cellular telephone wh ile refuel­
ing . The electromagnetic radiation can
cause spa rks that can ignite fuel vapors and
cause a fire.
- Never get back into your vehicle while refu­
eling .
If in except io na l circumstances you
must get back in you r vehicle while refue l­
ing, make certain tha t you close the door
and touch meta l to discharge static electric­
ity before touchi ng the filler nozz le again.
Static electricity can ca use spa rks that can
ignite fuel vapors released during refueling .
- Never smoke o r have an open flame any­
where in or near your vehicle when refueling or filling a portable f uel container.
- For yo ur safety , we strongly recommend
that you do not travel with a portable fue l
conta iner in your vehicle. The conta iner, full
or empty may leak and could cause a fire,
especially in a crash .
-If, under exceptional c ircumstances, you
must transport a portable fuel container,
please observe the follow ing :
- Neve r fi ll a portable fuel containe r wh ile i t
is anywhere in or on the vehicle (for exam ­
p le, in the luggage compartment, or on
the trunk) . Static e lectr icity can build up
Fuel and R efueling
whi le filling and can ignite fuel vapors
caus ing a fire .
- Always place a portab le fue l container on
the ground before f illing.
- Always keep the fi ller nozzle comp lete ly
inside the po rtable container before and
during f illing.
- If filling a portable container made of
metal, the filler nozz le m ust always be in
contact with the container. This will he lp
prevent stat ic electricity from discharging
and cause a fire .
- Never spill fue l inside the vehicle or lug­
gage compartment. F uel vapors are highly
flammable .
- Always observe local and state/prov incial
laws regarding the use, storage and trans ­
po rtation of fuel co nta iners.
- Make ce rtain t he f uel container meets in­
dust ry standards (ANSI/ ASTM F852-86) .
(0 Note
If any fuel has sp illed onto the car, it should
be removed immed iately to p revent damage
to the pa int.
@ For the sake of the environment
As soon as the correctly operated noz zle
switches off automatically for the first time,
the tank is fu ll. Do not try to add more fuel
because f uel may sp ill out . In add it ion, the
expans ion space in the fuel tank will be fi lled -
causing the fue l to overflow when it becomes
warm and po llute the environment.
(D Tips
- Runn ing your engine while refuelling may
cause vapors to escape or even ca use fue l to
spill out of the tank. This wo uld then shut
off the f uel no zzle befo re t he t ank is f ull.
- Do not ref ue l your veh icle with the ignition
switched on . The fuel gauge m ay o therwise
no t indicate the co rrect fuel leve l after refu­
elling.
- Diesel vehicles* are equ ipped wi th a die sel
m isf ueli ng pro tector . It a llows the vehi cle
to be fuele d only with a d iesel fue l pump .,.
215

Fuel and Refueling
nozzle. A worn or damaged nozzle or a noz ­
zle that is too small may not be ab le to open
the diesel m isfueling protector. If th is is the
case, try turning the nozzle before inserting
i t in the fuel f iller neck, use a different fuel
pump or see your authorized Audi dealer or
authorized repair facility for ass istance.
- The fuel filler flap of your vehicle is not
locked when you lock the veh icle from the
i nside .
Fuel filler flap emergency release
You can open the fuel filler flap by hand if the
power locking system should fail.
F ig . 190 Vehicles w ith se lect ive cata lytic reductio n: Right
side tr im pane l
Fig. 191 Right side trim panel in the lu ggage compart ·
ment: e mergency release mechan is m
...,
"' 9 ::i: ... (D
The emergency release mechanism is located be­
hind the right side trim panel in the luggage
compartment. In vehicles with selective catalytic
reduction*, remove the vent grille first :
.. Press both tabs@¢
fig. 190 and tilt the vent
gri lle downward. You can then remove the
grille upward.
.. Loosen the loop¢
fig. 191 from the retainer
and then pull on the loop carefully ¢(D.
216
.. Press on the left side of the fuel filler door to
open
¢ page 214, fig. 188.
(D Note
Only pull on the loop until you feel resistance .
You wi ll not hea r it re lease . Otherwise you
could damage the emergency release mecha­ nism.
Selective catalytic reduction (Ad Blue)
General information
Applies to: vehicles with selective catalytic reduction (SCR)
In vehicles with selective catalytic reduction, a
urea solution (AdBlue) is injected into the ex­
haust system before a nitrogen oxide catalytic
converter to reduce nitrogen emissions .
The Ad Blue is carried in a separate tank in the ve­
hicle. The AdBlue usage accounts for approxi­
mately 0.5% to 1.2% of the diesel fuel that is
used.
When a message about Ad Blue appears in the in­
strument cluster display, you must refill the
Ad Blue yourself or have it refilled by an author­ ized Audi dealer or author ized Audi Service Facili­
ty
¢ page 217.
@ Tips
-The instrument cluster display indicates the
distance remaining that can be driven
¢page 216. If the AdBlue tank is com­
pletely empty , the eng ine will not start
again after the ign ition is switched off.
- Ad Blue is required by law to operate th is ve­
hicle.
Messages in the instrument cluster display
Applies to: vehicles with selective catalytic reduction (SCR)
The display indicates if the Ad Blue level is Low or
if there is a system malfunction .
AdBlue level low
You will be informed if the AdBlue in the tank
drops below a certain level.

Please refill Ad B lue . Range 1500 mi (2400 km )
This message appears when there is only eno ugh
Ad Blue lef t to d rive the distance indicated in the
d river information system . Fill the AdBlue.
AdBlue ,0 Refill AdBlue! No re start in 600 mi
( 1000 km )! See owner 's manual
This message appea rs when there is only eno ugh
Ad Blue left to drive the distance indicated in the
driver info rmation system . Fill the Ad Blue . Ot he r­
wise the eng ine will not sta rt again if you s top it
once the d ist an ce in dicate d ha s been d riven. You
can also check t he remai ning dis tance in the on­
board com puter.
Refill Ad Blue! No restart! See own-
er's manual
This message appears whe n the AdBlue ta nk is
empty . Fill the AdB lue. Otherwise you will not be
ab le to s tart the engine aga in once yo u stop it.
The AdBlue must be refilled when t he amount in
the tank has reached the minimum level
q page 217, Filling Ad Blue.
Incorrect filling /system malfunction
A message appears if the AdB lue tank was filled
with a fluid other than AdBlue and the system
has detected that the tan k was fi lled incor rect ly,
or if there is a system malfunction .
Ad Blue -I' Ad Blue: System fault! No restart in
600 mi (1000 km ). See owner's manual.
This message appears when it is only poss ible to
drive the d istance ind icated in the dr iver informa­
tion system. Drive to t he nearest authorized Aud i
dealer o r authorized Aud i Serv ice Facility to have
the ma lfunction co rrected. Otherwise the engine
w ill not start agai n if you stop it once the d is­
tance ind icated has been driven .
AdBlue: System fault No restart!
See owner's manual
This message appears if the system has detected
that the tank was filled inco rrectly o r that there
i s a malfunction . Drive immediately to the near­
est authorized Aud i dea le r or authorized Aud i
Service Facility to have the malfunction correct-
Fuel and Refueling
ed. Ot herwise you wi ll not be able to star t the en ­
gine again once yo u stop it .
Filling AdBlue
Applies to : veh icles w ith selec tive catalytic re du ctio n (SCR)
Fig. 192 Right rear s ide of the ve hicle: re m ov ing t he A d Bl­
u e cap
The Ad Blue tank open ing is located near t he d ie­
sel tank opening. Add at least 1.5 gallons (5. 7L)
of Ad B lue . Thi s is the minim um amount requ ired
to ensure the system detects the refi lling and to
sta rt the eng ine. You can add a maxim um of 4
g allo ns ( 16L) .
Requireme nt: Th e reques t to add Ad Blue m ust
appear in the instrum ent clus te r disp lay .
.,. Switch t he ignit ion off.
.,. Open the tank door ¢ page 214 .
.,. Tu rn the cap on t he tank opening to the left to
remove ¢fig . 192.
.,. Fill t he A d Bl ue w ith the bottle ¢ page 218 or
t he ca n iste r ¢p age 218.
WARNING
A d Bl ue can irrita te the s kin, eyes an d re sp ira­
tory system. If there is contact with t he f lui d,
fl ush immed iate ly w ith plenty of water . Con­
sult a phys ician if necessary.
(D Note
- Only use Ad Blue th at con forms to t he
s tandar d ISO 2 22 41-1. Do not m ix any addi­
tives with the Ad Blue and do not dilute it
w ith wate r.
- Ad Blue must not be filled in the diese l ta nk
and diese l fue l must not be filled in the
217

Fuel and Refueling
Ad Blue tank. If the wrong fluid is filled in
the tank, do not start the engine under any
circumstances. If yo u do, you risk damaging
the tank system and the engine. See an au ­
thorized Audi dealer or authorized Audi
Service Fac ility for assistance .
- AdBlue attacks surfaces such as painted ve­
hicle components, plastic and carpet. Re­
move the fluid as quickly as poss ible with a
damp cloth and plenty of cold water. If the
Ad Blue has already crysta llized, use wa rm
water and a sponge. Ad Bl ue residue that is
not removed will crystallize and can damage
the affected surface.
- Do not store refill bott les or canisters per­
manently in the vehicle . If the container
l eaks, the escaping AdBlue could damage
the vehicle interior.
- Do not allow AdBlue to come into contact
with clothing. If there is contact with the
flu id, f lush immed iate ly w ith plenty of wa­
ter.
(D Tips
Follow the Ad Blue manufacturer's instruc ­
tions for use and storage .
Refilling Ad Blue with a bottle
Applies to: veh icles w ith selective catalyt ic reduction (SCR)
"'Remove the cap from the refill bottle c> A in
Filling Ad Blue on page 217,
¢ @) in Filling
AdBlue on page 21 7.
"' Pos ition the bottle on the filler tube and turn
the bottle clockwise until it stops turning .
"'Pr ess lightly against the bottom of the bottle
to empty it. Continue press ing the bottom of
the bottle until it is empty or until fluid stops
flowing into the tank.
"' Remove the bottle and close the filler neck
c> page 219, Completing AdBlue refill .
(D Note
Only use refill bottles that are approved for
your vehicle. Using other systems can cause
Ad Blue to leak.
218
(D Tips
-You can obtain refi ll bott les from an author­
ized Aud i dea ler or authorized Audi Service
Facility.
- A permitted refill bottle contains approxi­
mately 0.5 gallon (1.9 liters) of AdBlue.
· Refilling Ad Blue with a canister
App lies to : vehicles with selective cata lyt ic r educt ion (SCR)
®
+®
Fig. 193 Canis te r w ith attachab le hose
N ::> "' Remove the cover on the refill canister¢ A in
Filling AdBlue on page 217, ¢(Din Filling
AdBlue on page 217.
"' Secure the end of the hose (Don the opening in
the canister @by turn ing the hose to the right.
"' Remove the cap @from the other end of the
hose @.
"' Posit ion the end of the hose @on the filler
neck in the vehicle and turn the hose to the
r ig ht to tighten it.
"' Lift the canister up and then tip it. Continue
holding the canister in a tipped position until it
is empty or until no more fluid flows into the
tank.
"' Remove the canister and close the filler neck
¢ page 219, Completing AdBlue refill.
(D Note
Only use refill canisters that are approved for
your vehicle. Using other systems can cause Ad Blue to leak .
0) Tips
-An authorized Audi dealer or authorized
Audi repair facility can tell you which refill
canisters are approved for your vehicle .

-A permitted refill canister contains approxi ­
mately 1.3 gallons (5 liters) of Ad B lue .
Completing AdBlue refill
Applies to: veh icles with selective catalyt ic reduction (SCR)
Cl os ing the fill er ne ck
~ Turn the Ad Blue cap to the r ight on the fill er
tube unti l the cap clicks into place ¢
A in Fill­
ing Ad Blue on page 217,
¢ CD in Filling Ad Blue
on page 217 .
~ Then press on the left side of the tank door un -
t il you hear it lock.
After filling
T he vehicle must be driven so that the system
recogni zes th at the Ad Blue was refilled. Th is
process can take several minutes.
~ If there was no Ad Blue left in the tank and a
range of
O m i (0 km ) was shown in the display,
switch the ign ition on for about 30 seconds be­
fore starting the engine.
Ad Blue can freeze at very low temperatures. If th is happens, the system will not detect
that the Ad Blue was refilled and it wi ll contin ­
ue to inform yo u of the low Ad Blue level. The
message turns off as soon as the tank thaws
out again .
Fuel and R efueling
219

-Do not remove the engine cover under any
circumstances. This increases the risk of
burns.
- If work on the fuel system or the electrical
system is necessary:
- Always d isconnect the battery.
- Never smoke or work near heaters or open
flames. Flu ids in the engine compartment
could start a fire.
- Keep an app roved fire ext inguisher imme­
d iate ly availab le.
- To avo id electr ical shock and personal injury
wh ile the eng ine is running or being started,
never touch:
- Ignition cables
- Other components of the high voltage
electronic ignition system.
- If you must perform a check or repa ir with
the engine running:
- First, fully apply the parking brake, move
selector lever to "P" (Park).
- Always use extreme caution to prevent
cloth ing, jewelry, or long hair from get­
ting caught in the radiator fan, V-belts or
other mov ing parts, or from contacting
hot parts. Tie back ha ir before starti ng,
and do not wear clothi ng that will hang or
d roop into t he engine.
- Min imize exposu re to emission and chem i­
cal hazards¢ .&.-
_& WARNING
California Proposition 65 Warn ing:
- E ngine exhaust, some of its constituents,
and certain vehicle components contain or
em it chem ica ls known to the St ate of C ali­
f orn ia to cause cancer and bi rth de fects and
reproductive harm . In addition, certain flu­
ids contained in ve hicles and certain prod­
ucts of component wear contain or emit
Ch eck ing and Filling
chemicals known to the State of California
to cause cancer and birth defects or other
reproductive harm.
- Battery posts, term inals and related acces­
sories contain lead and lead compounds,
chemicals known to the State of Californ ia
to cause cancer and reproductive harms.
Was h hands afte r handling .
([) Note
When adding flu ids, always make sure that
they are poured into the proper co nta iner or
fille r opening, otherwise serious damage to
vehicle systems w ill occur.
® For the sake of the environment
To detect leaks in time, inspect the veh icle
floor pan from unde rneath regularly . If you
see spots from oil or other veh icle fluids, have
your vehicle inspected by an authorized Audi
dealer.
Closing the engine hood
.,.. Pull the hood down un til the press ure from the
struts is reduced.
.,.. Let the hood
drop down and latch in p lace . Do
not try to push it shut;
it may fail to engage
¢ _& .
_& WARNING
--A hood that is not completely latched co uld
fly up and block your view while driv ing.
- When you close the engine hood, check it to
make sure the safety catch has properly en­
gaged . The hood s hou ld be flush with the
sur rounding vehicle body parts.
- If you notice while driv ing that the hood is
not secured properly, stop at once and close
it.
-
221

Check ing and F illing
oil du ring the break -in period than they consume
after oil consumption has stabilized .
Unde r no rmal condi tions, the rate of o il con­
sumpt ion depends on the quality and viscosity of
the oi l, the RPM (revolutions per minute) at
which the engine is operat ed, the ambient tem­
perature and road cond itions . Further factors are
the amount of oil dilut ion from water condensa­
tion or fuel residue and the oxidation level of the
oil. As any eng ine is subject to wear as m ileage
bu ilds up, the oil consumption may increase over
time until rep lacement of worn components may
become necessa ry .
W ith all these variables com ing into play, no
standard rate of oil consumpt ion ca n be estab­
lished or specified . There is no a lternative to reg­
ular and frequent checking of the oil leve l, see
Note .
If the ye llow eng ine oil level war ning symbol in
the instrument cluster
II lights up, you should
check t he oil leve l as soon as possib le
¢
page 224 o r ¢ page 225. Top off the o il at
your ea rliest convenience ¢
page 225.
A WARNING
Before you check anything in the engine com ­
partment, a lways read and heed a ll WARN­
INGS ¢.&
in Working in the engine compart­
ment on page 220.
(D Note
Driving with an insufficient oil level is likely to
cause severe damage to the engine .
@ Tips
-The oil pres sure warning display. i s not
an indicator of the o il level. Do not rely on
i t. Instead , check the oil level in your en­
gine at regular intervals, preferably ea ch
time you refuel , and always befo re going
on a long trip.
- If you have the impression your engine con­
sumes excessive amounts of oil, we recom­
mend that you co nsul t yo ur Audi dealer to
have the cause of your concern p roperly di ­
agnosed . Keep in mind that the acc urat e
224
meas urement of oi l consumption re quires
great care and may take some t ime. Yo ur
Audi dea ler has instructions about how to
meas ure o il consumption acc urately.
Checking the engine oil level
App lies to: vehicles wi th oil level indicato r
Fig. 198 Disp lay : o il leve l ind icato r
.,. Par k your veh icle on a leve l su rface.
.,. Shut the eng ine off when it is warm .
.,. Switch o nly the ignition back on.
.,. Wait approximate ly two minutes.
.,. Select:
!CAR ! function button > Car systems
control button > Servicing & checks > Oil le vel.
.,. Check the oil level in the display c> fig . 198 . Add
eng ine oi l if the ba r of the oil leve l ind icator is
nea r "m in"
¢ page 225 .
Depend ing on the way the vehicle is driven and
the operating cond it ions, oil consumpt io n can be
u p to 1/2 qua rt pe r 600 miles (0 .S liter per
1,000 km). Consumpt ion may be h igher w it hi n
the first 3, 000 mi les (5,00 0 km).
(D Tips
The o il level indicato r in the MMI Display is
o nl y an information display. If t he oi l level is
l ow, a m inimum oil w arn ing appea rs in the in­
str ument clus ter. Ad d oil ¢
page 225. If the
hood has been opened, the curren t oil level is
shown in the instrument cluster the next t ime
the ignition is switched on .