2016.5 VAUXHALL VIVARO tow

Vehicle care173Put wheel bolts somewhere
where the threads will not be
soiled.
6. Change the wheel. Spare wheel 3 173.
7. Screw in the wheel bolts.
8. Lower the vehicle and remove jack.
9. Tighten each of the wheel bolts in
a crosswise sequence using the
wheel wrench. Ensure the wrench
locates securely. The wrench
should turn clockwise to tighten
the bolts. Invert the wrench if
necessary.
Tightening torque is 160 Nm.
10. Replace the wheel cover, ensuring that the valve hole in thewheel cover is aligned with the
tyre valve before installing.
Notice
If applicable, fit anti-theft bolts
nearest the tyre valve (otherwise it
may not be possible to refit the wheel
cover).11. Stow the replaced wheel 3 173
and the vehicle tools 3 163.
12. Have the new wheel balanced on the vehicle.
Check the tyre pressure of the
installed tyre 3 198.
Check the wheel bolt torque.
Have the defective tyre renewed or
repaired as soon as possible.
Spare wheel
Some vehicles are equipped with a
tyre repair kit instead of a spare wheel 3 169.
If mounting a spare wheel which is
different from the other wheels, this
wheel might be classified as a
temporary spare wheel and the
corresponding speed limits apply,
even though no label indicates this.
Seek the assistance of a workshop to
check the applicable speed limit.Caution
The use of a spare wheel that is smaller than the other wheels or in combination with winter tyres
could affect driveability. Have the defective tyre replaced as soon as
possible.
It may be necessary to jack the
vehicle up to gain access to the spare
wheel on a fully loaded vehicle with a
flat rear tyre.
Wheel changing 3 171.

176Vehicle carefar away from the discharged
vehicle battery as possible,
however at least 60 cm.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump start.
2. After 5 minutes, start the other engine. Start attempts should be
made for no longer than
15 seconds at an interval of
1 minute.
3. Allow both engines to idle for approx. 3 minutes with the leads
connected.
4. Switch on electrical consumers (e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.Towing
Towing the vehicle The towing eye is stowed with thevehicle tools 3 163.
Release cap using a suitable tool.
Screw the towing eye clockwise into
the front towing point and tighten fully
using the wheel wrench.
Attach a tow rope - or better still a tow rod - to the towing eye, never to the
bumper or front suspension units.
Caution
Do not tow the vehicle from the
rear. The front towing eye must
only be used for towing and not
recovering a vehicle.
Caution
Activate the child locks in the rear
doors if the rear seats are
occupied. Child locks 3 29.
Switch on ignition to permit operation
of brake lights, horn and windscreen
wipers, and move the steering wheel
slightly to release the steering wheel
lock.
Transmission in neutral.
Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.

Vehicle care177When the engine is not running,
considerably more force is needed to
brake and steer.
To prevent the entry of exhaust fumes
from the towing vehicle, switch on the
air recirculation system 3 104 and
close the windows.
Seek the assistance of a workshop.
After towing, unscrew the towing eye
and replace cap.
Towing another vehicle
The fixed towing eye is located under the rear bumper.
Attach a tow rope - or better still a tow
rod - to the rear towing eye, never to
the rear axle and suspension units.
The rear towing eye must only be
used for towing and not recovering a
vehicle.Caution
Drive slowly. Do not drive jerkily.
Excessive tractive force can
damage the vehicle.
Trailer hitch 3 142.
Appearance care
Exterior care
Locks The locks are lubricated at the factoryusing a high quality lock cylinder
grease. Use de-icing agent only when absolutely necessary, as this has adegreasing effect and impairs lockfunction. After using a de-icing agent,
have the locks regreased by a
workshop.
Washing
The paintwork of your vehicle is
exposed to environmental influences. Wash and wax your vehicle regularly.
When using automatic vehicle
washes, select a programme that
includes waxing. Restrictions for
filmed or matt painted body parts or decor tapes, see "Polishing and
waxing".
Bird droppings, dead insects, resin,
pollen and the like should be cleaned
off immediately, as they contain
aggressive constituents which can cause paint damage.

Vehicle care179Remove dirt residues from smearing
wiper blades by using a soft cloth and
window cleaner. Also make sure to
remove any residues such as wax,
insect residues and similar from the
window.
Ice residues, pollution and continuous wiping on dry windows will damage or
even destroy the wiper blades.
Wheels and tyres Do not use high-pressure jet
cleaners.
Clean rims with a pH-neutral wheel
cleaner.
Rims are painted and can be treated
with the same agents as the body.
Paintwork damage Rectify minor paintwork damage with
a touch-up pen before rust forms.
Have more extensive damage or rust areas repaired by a workshop.Underbody
Some areas of the vehicle underbody
have a PVC undercoating while other critical areas have a durable
protective wax coating.
After the underbody is washed, check
the underbody and have it waxed if
necessary.
Bitumen/rubber materials could
damage the PVC coating. Have
underbody work carried out by a
workshop.
Before and after winter, wash the
underbody and have the protective
wax coating checked.
Towing equipment
Do not clean the coupling ball bar with a steam-jet or high-pressure jet
cleaner.Interior care
Interior and upholstery Only clean the vehicle interior,
including the instrument panel fascia
and panelling, with a dry cloth or
interior cleaner.
Clean any leather upholstery with
clear water and a soft cloth. In case of
heavy soiling, use leather care.
The instrument cluster and the
displays should only be cleaned using
a soft damp cloth. If necessary use a
weak soap solution.
Clean fabric upholstery with a
vacuum cleaner and brush. Remove
stains with an upholstery cleaner.
Clothing fabrics may not be
colourfast. This could cause visible
discolourations, especially on light-
coloured upholstery. Removable
stains and discolourations should be
cleaned as soon as possible.
Clean seat belts with lukewarm water or interior cleaner.

203Changing tyre and wheel size ...168
Charging system .......................... 86
Child locks ................................... 29
Child restraint installation locations ................................... 60
Child restraints.............................. 59
Child restraint systems ................59
Cigarette lighter ........................... 79
Cleaning the vehicle ...................177
Climate control ............................. 15
Climate control systems .............103
Clock ............................................ 77
Coat hooks ................................... 67
Coin holder ................................... 66
Control indicators.......................... 82
Control of the vehicle .................115
Controls ........................................ 75
Controls in steering wheel ............75
Convex shape .............................. 37 Coolant ....................................... 148
Coolant and antifreeze ...............182
Coolant heater ............................ 108
Cooling (A/C) .............................. 104
Cornering light .............................. 98
Cruise control ...................... 90, 133
Cupholders .................................. 67
Curtain airbag system .................. 57D
Danger, Warnings and Cautions ...4
Dashboard .................................... 10
Daytime running lights ............97, 98
Declaration of conformity ............199
DEF ............................................ 123
Demisting and defrosting ..............15
Diesel exhaust fluid ....................123
Diesel fuel filter .......................... 152
Diesel fuel system bleeding .......152
Diesel particle filter ....................122
Directional tyres ..................164, 173
Distance to service .......................81
Document tray .............................. 67
Door locks..................................... 23
Door open .................................... 90
Door panel storage .......................68
Doors ............................................ 29
Double cab ................................... 68
DPF (diesel particle filter) ...........122
Driver assistance systems ..........133
Driver Information Centre .............90
Driving characteristics and towing tips .............................. 142
Driving economically................... 114
Driving hints ................................ 114
E ECO mode .................................. 114
ecoScoring.................................... 93Electric adjustment ......................37
Electrical accessories ...................78
Electrical system......................... 159
Electronic climate control system 105
Electronic data recording ..............39
Electronic key system ...................22
Electronic Stability Program 87,
131, 143
Electronic Stability Program off ...87
End-of-life vehicle recovery .......145
Engine air filter............................ 148
Engine air flow indicator .............148
Engine coolant ........................... 148
Engine coolant temperature ........87
Engine data ............................... 187
Engine exhaust .......................... 122
Engine identification ...................185
Engine oil ...........147, 182, 186, 197
Engine oil additives ....................182
Engine oil level ............................ 92
Engine oil pressure ......................88
Engine oil viscosity grades .........182
Enhanced Traction function 130, 131
Entry lighting .............................. 101
Event data recorders ..................201
Exhaust gases ....................122, 176
Exit lighting ................................ 102
Exterior care .............................. 177
Exterior light ................................. 89

206Seat belt ........................................ 8
Seat belt reminder .......................85
Seat belts ..................................... 49
Seat folding .................................. 45
Seat heating ................................. 46
Seat position ................................ 43
Seats ............................................ 68
Selective catalytic reduction .......123
Service ............................... 113, 181
Service display ............................ 81
Service information ....................181
Service vehicle soon .................... 86
Side airbag system ......................56
Sidelights ...................................... 96
Side turn signal lights ................156
Sliding door .................................. 29
Spare wheel ............................... 173
Spare wheel security tool ...........163
Speed limiter......................... 79, 136
Speedometer ............................... 79
Starting and operating ................116
Starting off ................................... 17
Starting the engine ...............17, 118
Steering ...................................... 115
Steering column controls ..............75
Steering wheel adjustment ......9, 75
Steering wheel controls ...............75
Stop engine .................................. 86
Stop-start system.................. 17, 119
Storage ......................................... 66Storage box.................................. 68
Storage compartment ...................67
Storage compartments .................66
Sun visors .................................... 41
Symbols ......................................... 4
T
Tablet holder................................. 66 Tachograph ............................ 90, 95
Tachometer ................................. 80
Tailgate ......................................... 32
Tailgate emergency release .........32
Tail lights ................................... 155
Technical data ............................ 187
Temporary spare wheel ..............173
Three-point seat belt .................... 50
Toll road stickers .......................... 39
Tools .......................................... 163
Top-tether fastening eyes ............65
Torx key ...................................... 163
Tow bar....................................... 142
Towing ................................ 142, 176
Towing another vehicle .............177
Towing a trailer ........................... 143
Towing eye ......................... 163, 176
Towing the vehicle .....................176
Traction Control system ............. 130
Trailer coupling ........................... 142
Trailer stability assist .................143
Trailer towing ............................. 143Transmission ............................... 16
Tread depth ............................... 167
Trip computer .............................. 93
Trip odometer .............................. 80
Turbo engine warm-up ...............118
Turn and lane-change signals .....99
Turn signal ................................... 84
Tyre chains ................................ 168
Tyre changing ............................. 171
Tyre designations ......................164
Tyre pressure ............................ 164
Tyre pressure monitoring system ............................... 88, 166
Tyre pressures ........................... 198
Tyre repair kit ............................. 169
Tyres .......................................... 164
Tyres and wheel size, changing. 168
U Ultrasonic parking assist............. 136
Underseat storage .......................68
Upholstery .................................. 179
Upshift .......................................... 87
Using this manual ..........................3
V Vehicle battery ...................150, 174
Vehicle checks............................ 146
Vehicle data ................................ 186
Vehicle data recording and privacy ..................................... 201