2016.5 VAUXHALL VIVARO check engine

152Vehicle careWarning label
Meaning of symbols:● No sparks, naked flames or smoking.
● Always shield eyes. Explosive gases can cause blindness or
injury.
● Keep the vehicle battery out of reach of children.
● The vehicle battery contains sulfuric acid which could cause
blindness or serious burn
injuries.
● See the Owner's Manual for further information.
● Explosive gas may be present in the vicinity of the battery.
Diesel fuel filter
The diesel fuel filter is accessible from the underside of the vehicle.
Drain filter of residual water at every
engine oil change.
Place a container underneath the
filter housing. Loosen the knurled
screw on the lower part of the filter by approx. one turn, to drain off the
water.
The filter is drained as soon as water-
free diesel fuel emerges. Retighten
the screw.
Check diesel fuel filter at shorter
intervals if the vehicle is subjected to
extreme operating conditions.
Diesel fuel system bleeding
If the fuel tank has been run dry, it will be necessary to air vent or bleed the
diesel fuel system.
Refuel then proceed as follows:
With ignition key

154Vehicle careBulb replacement
Switch off the ignition and turn off the relevant switch or close the doors.
Only hold a new bulb at the base. Do
not touch the bulb glass with bare
hands.
Use only the same bulb type for
replacement.
Bulb check After a bulb replacement, switch on
the ignition, operate and check the
lights.
Headlights
Low beam and high beam Replace headlight bulbs from within
the engine compartment.
1. Remove protective cover by rotating it anticlockwise.
2. Remove harness connector.
3. Release retaining clip and remove
bulb.
4. Renew bulb and install retaining clip ensuring that bulb is in correctorientation.
5. Install harness connector and protective cover.
Sidelights
1.Remove bulb holder from reflector
housing by rotating it
anticlockwise.
2. Renew bulb.
3. Install bulb holder in reflector housing.
Fog lights
Access the front fog light bulb from
beneath the vehicle.

Vehicle care165
The tyre pressure information label
on the driver's door frame indicates
the original equipment tyres and the
correspondent tyre pressures.
Always inflate tyres to the pressures
shown on the label.
Tyre pressures 3 198.
The tyre pressure data refers to cold tyres. It applies to summer and winter tyres.
Always inflate the spare tyre to the
pressure specified for full load.
Incorrect tyre pressures will impair
safety, vehicle handling, comfort and
fuel economy and will increase tyre
wear.
Tyre pressures differ depending on
various options. For the correct tyre
pressure value, follow the procedure
below:
1. Identify the engine identifier code.
Engine data 3 187.
2. Identify the respective tyre.
The tyre pressure tables show all
possible tyre combinations 3 198.
For the tyres approved for your
vehicle, refer to the EEC Certificate of Conformity provided with your vehicle
or other national registration
documents.
The driver is responsible for correct adjustment of tyre pressure.9 Warning
If the pressure is too low, this can
result in considerable tyre warm-
up and internal damage, leading to tread separation and even to tyre
blow-out at high speeds.
9 Warning
For specific tyres the
recommended tyre pressure as
shown in the tyre pressure table may exceed the maximum tyre
pressure as indicated on the tyre.
Never exceed the maximum tyre
pressure as indicated on the tyre.
Temperature dependency
Tyre pressure depends on the
temperature of the tyre. During
driving, tyre temperature and
pressure increase.
Tyre pressure values provided on the
tyre information label and tyre
pressure chart are valid for cold tyres, which means at 20 °C. The pressure
increases by nearly 1.5 psi for a
10 °C temperature increase. This
must be considered when warm tyres
are checked.

Vehicle care167PunctureA puncture or severely under-inflated
tyre is indicated by illumination of
control indicator w together with C
3 86 and a corresponding message
appears in the DIC. Stop vehicle and
switch off engine.
Tyre pressure 3 198, Tyre repair kit
3 169, Spare wheel 3 173, Wheel
changing 3 171.
Relearn function
After a puncture has been repaired
and the driver has inflated the tyres to
the correct tyre pressure, TPMS
needs to recalculate.
Tyre pressure 3 198, Tyre repair kit
3 169.
During driving, select the tyre
pressure menu in the DIC by pressing button on end of wiper lever. Press
and hold button for approx.
5 seconds to initialise recalculation. A
corresponding message appears in
the DIC.
Several minutes of driving at a speed above 25 mph may be required tocomplete the relearn process. The
system can only provide limited
information during this time.
If problems occur during the relearn
process, control indicator w remains
illuminated and a warning message is
displayed in the DIC.
Driver Information Centre (DIC) 3 90.
Vehicle messages 3 91.
General information The use of tyre chains or
commercially available liquid tyre
repair kits can impair the function of
the system. Factory-approved tyre
repair kits can be used.Tyre repair kit 3 169, Tyre chains
3 168.
External high-power radio equipment
could disrupt the tyre pressure
monitoring system.
Each time the tyres are replaced,
TPMS sensors must be dismounted
and serviced by a workshop.
Tread depth
Check tread depth at regular
intervals.
Tyres should be replaced for safety
reasons at a tread depth of 2-3 mm
(4 mm for winter tyres).
For safety reasons it is recommended
that the tread depth of the tyres on
one axle should not vary by more than 2 mm.

206Seat belt ........................................ 8
Seat belt reminder .......................85
Seat belts ..................................... 49
Seat folding .................................. 45
Seat heating ................................. 46
Seat position ................................ 43
Seats ............................................ 68
Selective catalytic reduction .......123
Service ............................... 113, 181
Service display ............................ 81
Service information ....................181
Service vehicle soon .................... 86
Side airbag system ......................56
Sidelights ...................................... 96
Side turn signal lights ................156
Sliding door .................................. 29
Spare wheel ............................... 173
Spare wheel security tool ...........163
Speed limiter......................... 79, 136
Speedometer ............................... 79
Starting and operating ................116
Starting off ................................... 17
Starting the engine ...............17, 118
Steering ...................................... 115
Steering column controls ..............75
Steering wheel adjustment ......9, 75
Steering wheel controls ...............75
Stop engine .................................. 86
Stop-start system.................. 17, 119
Storage ......................................... 66Storage box.................................. 68
Storage compartment ...................67
Storage compartments .................66
Sun visors .................................... 41
Symbols ......................................... 4
T
Tablet holder................................. 66 Tachograph ............................ 90, 95
Tachometer ................................. 80
Tailgate ......................................... 32
Tailgate emergency release .........32
Tail lights ................................... 155
Technical data ............................ 187
Temporary spare wheel ..............173
Three-point seat belt .................... 50
Toll road stickers .......................... 39
Tools .......................................... 163
Top-tether fastening eyes ............65
Torx key ...................................... 163
Tow bar....................................... 142
Towing ................................ 142, 176
Towing another vehicle .............177
Towing a trailer ........................... 143
Towing eye ......................... 163, 176
Towing the vehicle .....................176
Traction Control system ............. 130
Trailer coupling ........................... 142
Trailer stability assist .................143
Trailer towing ............................. 143Transmission ............................... 16
Tread depth ............................... 167
Trip computer .............................. 93
Trip odometer .............................. 80
Turbo engine warm-up ...............118
Turn and lane-change signals .....99
Turn signal ................................... 84
Tyre chains ................................ 168
Tyre changing ............................. 171
Tyre designations ......................164
Tyre pressure ............................ 164
Tyre pressure monitoring system ............................... 88, 166
Tyre pressures ........................... 198
Tyre repair kit ............................. 169
Tyres .......................................... 164
Tyres and wheel size, changing. 168
U Ultrasonic parking assist............. 136
Underseat storage .......................68
Upholstery .................................. 179
Upshift .......................................... 87
Using this manual ..........................3
V Vehicle battery ...................150, 174
Vehicle checks............................ 146
Vehicle data ................................ 186
Vehicle data recording and privacy ..................................... 201