2015 TOYOTA HILUX torque

1674-1. Before driving
4
Driving
HILUX_OM_OM0K219E_(EE)
NOTICE
■When driving the vehicle
● Do not depress the accelerator and brake pedals at the same time during
driving, as this may restrain driving torque.
● On vehicles with automatic transmission, do not use the accelerator pedal
or depress the accelerator and brake pedals at the same time to hold the
vehicle on a hill.
● On vehicles with manual transmission, do not shift gears unless the clutch
pedal is fully depressed. After shifting, do not release the clutch pedal
abruptly. Doing so may damage the clutch, transmission and gears.
● On vehicles with manual transmission, observe the following to prevent
the clutch from being damaged.
• Do not rest your foot on the clutch pedal while driving.Doing so may cause clutch trouble.
• Do not use any gear other than the 1st gear when starting off and mov- ing forward.
Doing so may damage the clutch.
• Do not use the clutch to hold the vehicle when stopping on an uphill grade.
Doing so may damage the clutch.
● On vehicles with manual transmission, do not shift the shift lever to R
when the vehicle is still moving. Doing so may damage the clutch, trans-
mission and gears.
● On vehicles with manual transmission, if you cannot accelerate the vehicle
even when the clutch is engaged and the accelerator pedal is depressed,
this may mean that the clutch is slipping, and the vehicle may be rendered
undriveable. Have any authorized Toyota dealer or repairer, or another
duly qualified and equipped professional inspect the vehicle as soon as
possible.
HILUX_OM_OM0K219E_(EE).book Page 167 Wednesday, May 14, 2014 3:06 PM

4697-2. Steps to take in an emergency
7
When trouble arises
HILUX_OM_OM0K219E_(EE)
CAUTION
■Replacing a flat tire
● Observe the following precautions.
Failure to do so may result in serious injury:
• Lower the spare tire completely to the ground before removing it fromunder the vehicle.
• Do not try to remove the wheel ornament by hand. Take due care in handling the ornament to avoid unexpected personal injury.
• Do not touch the disc wheels or the area around the brakes immediately after the vehicle has been driven.
After the vehicle has been driven the disc wheels and the area around
the brakes will be extremely hot. Touching these areas with hands, feet
or other body parts while changing a tire, etc. may result in burns.
● Failure to follow these precautions could cause the wheel nuts to loosen
and the tire to fall off, resulting in death or serious injury.
• Have the wheel nuts tightened with a torque wrench to 105 N•m(10.7 kgf•m, 77 ft•lbf) as soon as possible after changing wheels.
• Do not attach a heavily damaged wheel ornament, as it may fly off the wheel while the vehicle is moving.
• When installing a tire, only use wheel nuts that have been specifically designed for that wheel.
• If there are any cracks or deformations in the bolt screws, nut threads or bolt holes of the wheel, have the vehicle inspected by any authorized
Toyota dealer or repairer, or another duly qualified and equipped profes-
sional.
• When installing the wheel nuts, be sure to install them with the tapered ends facing inward. ( →P. 403)
■ When take out the spare tire
● Be careful not to touch the exhaust, as you may burn yourself.
● Be careful not to injure yourself by trapping your hands in or becoming
caught in the rear under protection.
HILUX_OM_OM0K219E_(EE).book Page 469 Wednesday, May 14, 2014 3:06 PM

4727-2. Steps to take in an emergency
HILUX_OM_OM0K219E_(EE)
Firmly tighten each wheel nut
two or three times in the order
shown in the illustration.
Tightening torque:
105 N•m (10.7 kgf•m, 77 ft•lbf)
Vehicles with spare tire of the
same wheel type as the
installed tires: Reinstall the
wheel ornament. 4
5
HILUX_OM_OM0K219E_(EE).book Page 472 Wednesday, May 14, 2014 3:06 PM

513
8
8-1. Specifications
Vehicle specifications
HILUX_OM_OM0K219E_(EE)
X15 inch tires
X16 inch tires
Tires and wheels
Tire size 255/70R15C 112/110S
Tire inflation
pressure
(Recommended
cold tire inflation
pressure)Front wheel
kPa (kgf/cm2 or
bar, psi)
Rear wheel
(unloaded)
kPa (kgf/cm
2 or
bar, psi)
Rear wheel
(loaded)
kPa (kgf/cm
2 or
bar, psi)
200 (2.0, 29)200 (2.0, 29)250 (2.5, 36)
Wheel size15 × 7JJ, 15 × 7J
Wheel nut torque 105 N•m (10.7 kgf•m, 77 ft•lbf)
Tire size 205R16C 8PR 110/108S
Tire inflation
pressure
(Recommended
cold tire inflation
pressure)Front wheel
kPa (kgf/cm2 or
bar, psi)
Rear wheel
(unloaded)
kPa (kgf/cm
2 or
bar, psi)
Rear wheel
(loaded)
kPa (kgf/cm
2 or
bar, psi)
240 (2.4, 35)240 (2.4, 35)320 (3.2, 46)
Wheel size16 × 6J
Wheel nut torque 105 N•m (10.7 kgf•m, 77 ft•lbf)
HILUX_OM_OM0K219E_(EE).book Page 513 Wednesday, May 14, 2014 3:06 PM

5148-1. Specifications
HILUX_OM_OM0K219E_(EE)
X17 inch tires (type A)
X17 inch tires (type B)
Tire size265/65R17 112S
Tire inflation
pressure
(Recommended
cold tire inflation
pressure)
XDLX grade models with 1KD-FTV engine
230 kPa (2.3 kgf/cm
2 or bar, 33 psi)
XSR grade models with 2KD-FTV engine
Single-cab models
230 kPa (2.3 kgf/cm
2 or bar, 33 psi)
Double-cab and extra-cab models
200 kPa (2.0 kgf/cm
2 or bar, 29 psi)
XOther models
200 kPa (2.0 kgf/cm
2 or bar, 29 psi)
Wheel size17 × 7 1/2J
Wheel nut torque105 N•m (10.7 kgf•m, 77 ft•lbf)
Tire size 225/70R17C 108/106S
Tire inflation
pressure
(Recommended
cold tire inflation
pressure)
Front wheel kPa
(kgf/cm2 or bar,
psi)
Rear wheel
(unloaded)
kPa (kgf/cm
2 or
bar, psi)
Rear wheel
(loaded)
kPa (kgf/cm
2 or
bar, psi)
Single-cab
models240 (2.4, 35)240 (2.4, 35)300 (3.0, 44)
Extra-cab and
double-cab
models
240 (2.4, 35)240 (2.4, 35)
300 (3.0, 44)*1
300 (3.0, 44)*2, 3
320 (3.2, 46)*2, 4
Wheel size17 × 6J
Wheel nut torque 105 N•m (10.7 kgf•m, 77 ft•lbf)
HILUX_OM_OM0K219E_(EE).book Page 514 Wednesday, May 14, 2014 3:06 PM