100
Parking Brake :Lever type, Console
mounted, Cable
operated mechanical
linkages acting on rear
wheels.
9.0 9.09.0 9.0
9.0
FRAME : FRAME :FRAME : FRAME :
FRAME :
Frame :Ladder type cranked frame
with boxed section long
members and welded cross
members
Depth :110 mm (max.)
Width :60mm
10.0 10.010.0 10.0
10.0
SUSPENSION : SUSPENSION :SUSPENSION : SUSPENSION :
SUSPENSION :
Front :Double wishbone type
with Torsion bar springs.
Rear :Coil spring type 5 link
suspension
Shock Absorber : Hydraulic double acting
telescopic type at front
and rear.
Antiroll bar : At both front & rear.
FR FR FR FR
FR
AME AMEAME AME
AME
,, ,,
,
SUSPENSION, SUSPENSION, SUSPENSION, SUSPENSION,
SUSPENSION,
WHEELS & WHEELS & WHEELS & WHEELS &
WHEELS &
T TT T
T
YRES, YRES,YRES, YRES,
YRES,
FUEL FUEL FUEL FUEL
FUEL
T TT T
T
ANK , ANK ,ANK , ANK ,
ANK ,
BOD BOD BOD BOD
BOD
Y AND ELECTRIC Y AND ELECTRICY AND ELECTRIC Y AND ELECTRIC
Y AND ELECTRIC
AL SY AL SYAL SY AL SY
AL SY
STEM STEMSTEM STEM
STEM
11.0 11.011.0 11.0
11.0
WHEELS & WHEELS & WHEELS & WHEELS &
WHEELS &
T TT T
T
YRES : YRES :YRES : YRES :
YRES :
Tyres : 235/70 R 16
Radial with tube
Wheels rims : 6.5 J x 16 Steel rims
No. of wheels : Front 2, Rear 2, Spare -1
12.0 12.012.0 12.0
12.0
FUEL FUEL FUEL FUEL
FUEL
T TT T
T
ANK : ANK :ANK : ANK :
ANK :
Capacity :65 Litres
13.0 13.013.0 13.0
13.0
BODY : BODY :BODY : BODY :
BODY :
Type : Normal control all steel
shell with five doors.
14.0 14.014.0 14.0
14.0
ELECTRICAL SYSTEM : ELECTRICAL SYSTEM :ELECTRICAL SYSTEM : ELECTRICAL SYSTEM :
ELECTRICAL SYSTEM :
System Voltage : 12 Volts (-ve earth)
Alternator Capacity :120 / 125 Amps
Battery : 12 V, MF 70 Z
Capacity : 80 A/h, 20 Hr Rate
VEHICLE SPECIFICATIONS
ProCarManuals.com
119
B BB B
B
A AA A
A
T TT T
T
TER TERTER TER
TER
Y YY Y
Y
,, ,,
,
ST ST ST ST
ST
AR ARAR AR
AR
TING TING TING TING
TING
THE ENGINE THE ENGINE THE ENGINE THE ENGINE
THE ENGINE
WITH JUMP LEADS WITH JUMP LEADSWITH JUMP LEADS WITH JUMP LEADS
WITH JUMP LEADS
The use of a wrench to loosen and remove cables from the
terminals should be made. Always disconnect the negative
(-ve) cable first and reconnect it last. Clean the battery
terminals with a terminal cleaning tool or wire brush.
Reconnect and tighten the cables, coat the terminals with
petroleum jelly. If you need to connect the battery to a
charger, disconnect both cables to prevent damage to the
vehicle’s electrical system.
NOTICE NOTICENOTICE NOTICE
NOTICE
Charging the battery with the cables connected can
seriously damage your vehicle’s electronic controls.
Detach the battery cables before connecting battery to
a charger.
* Swallowing electrolyte can cause fatal poisoning if
immediate action is not taken.
Starting the Engine with Jump Leads Starting the Engine with Jump LeadsStarting the Engine with Jump Leads Starting the Engine with Jump Leads
Starting the Engine with Jump Leads
Your Safari with a discharged battery may be started by
transferring electrical power from a battery in another vehicle.
This may be dangerous as any deviation from the following
instructions could lead to personal injury or damage
resulting from battery explosion, as well as the damage to
the electrical systems in both vehicles.• Never expose the battery to open flames or sparks.
• Do not allow battery electrolyte to come in contact with
eyes, skins, fabrics or painted surfaces. The fluid
contains sulphuric acid which can cause injuries and
damage in the event of direct contact.
• To lessen the risk of injury wear eye protection when
working near any battery.
• Make sure that battery providing the jump start has the
same voltage as the battery in your vehicle (12 V). Its
capacity must not be substantially lower than that of the
discharged battery. The voltage and capacity are given
on the batteries.
• Do not disconnect the discharged battery from the vehicle.
• Switch off all unnecessary electrical loads.
• Do not lean over the battery during jump starting.
• Do not allow the terminals of one lead to touch those of
the other lead.
• Apply hand brake. Place gear shift lever to neutral.
Connect Leads in the Order as shown Connect Leads in the Order as shownConnect Leads in the Order as shown Connect Leads in the Order as shown
Connect Leads in the Order as shown
on next page on next page on next page on next page
on next page
•Do not connect lead to negative terminal of discharged
battery.
•The connection point should be as far away from the
discharged battery as possible.
M A I N T E N A N C E
ProCarManuals.com
