2015 TATA SAFARI air filter

137
PRELIMINARY TROUBLE SHOOTINGPRELIMINAR PRELIMINARPRELIMINAR PRELIMINAR
PRELIMINAR
Y Y Y Y
Y
TR TRTR TR
TR
OUBLE SHOO OUBLE SHOOOUBLE SHOO OUBLE SHOO
OUBLE SHOO
TING TINGTING TING
TING
SR. NO. SR. NO.SR. NO. SR. NO.
SR. NO.
PROBLEM OBSERVED PROBLEM OBSERVEDPROBLEM OBSERVED PROBLEM OBSERVED
PROBLEM OBSERVED
PROBABLE CAUSE PROBABLE CAUSEPROBABLE CAUSE PROBABLE CAUSE
PROBABLE CAUSE
A AA A
A
CTION CTION CTION CTION
CTION
T TT T
T
O BE O BE O BE O BE
O BE
T TT T
T
AKEN AKENAKEN AKEN
AKEN
5 . Poor pickup Loose contact of connectors•Get defect rectified.
Blocked fuel filter
•Clean/replace fuel filter element
Clogged air filter
•Clean / replace the element
EGR malfunctioning
•Get checked & corrected
•Check for loose pipes &
connections.
6. Does not accelerate Accelerator pedal module defective
•Get defect rectified
7. Belt squeal Loose belt
•Get belt tension adjusted
Belt glazed
•Get belt replaced
CL CLCL CL
CL
UT UTUT UT
UT
CH CHCH CH
CH
1. Clutch does not get disengagedAir in the hydraulic system
•Bleed the system
Less fluid in the master cylinder
•Get the clutch fluid filled
2 . Clutch pedal goes too low Air in the hydraulic system
•Bleed the system
Less fluid in the master cylinder
•Get the clutch fluid filled
3. Clutch pedal return sluggishBlocking of vent in clutch fluid
•Open the cap from the bottle
bottle & clean the breather hole, if
clogged
GEAR BO GEAR BOGEAR BO GEAR BO
GEAR BO
X XX X
X
1. Hard gear shifting / Clutch does not disengage
•Get the clutch hydraulic system
crash engagementproperly attended
ProCarManuals.com

146
S E R V I C E S C H E D U L ESERVICE SCHEDULE SERVICE SCHEDULESERVICE SCHEDULE SERVICE SCHEDULE
SERVICE SCHEDULE
SR SRSR SR
SR
x 1000 km x 1000 kmx 1000 km x 1000 km
x 1000 km
NO NONO NO
NO
OPER OPEROPER OPER
OPER
A AA A
A
TIONS TIONSTIONS TIONS
TIONS
FREQUENCY FREQUENCYFREQUENCY FREQUENCY
FREQUENCY
1-1.5 1-1.51-1.5 1-1.5
1-1.5
15 1515 15
15
30 3030 30
30
45 4545 45
45
60 6060 60
60
75 7575 75
75
90 9090 90
90
105 105105 105
105
GENERAL GENERALGENERAL GENERAL
GENERAL
1 Wash the vehicle & Clean the condenser with compressed air Every Service x x x x x x x x
2 Check & Top up Fluids if required: Coolant, Brake / Clutch Fluid, Battery Electrolyte, Power Every Service x x x x x x x x
Steering Oil, Gear Box Oil, Transfer Case & Front Axle (4X4) / Rear Axle Oil
3 Drain water accumulated in Sedimenter (OR Whenever warning lamp glows) Every Service x x x x x x x x
4 Check Engine Compartment for loose Fasteners, Low pressure fuel lines, Coolant hoses, air hoses, Every Service x x x x x x x x
Vacuum hoses, hydraulic line connections for leakages if any, Attend if necessary
5 Check Underbody for loose Fasteners, hydraulic line connections, Exhaust system / Fuel Pipes for Every Service x x x x x x x x
Damages / Leakages if any. Attend if necessary
6 Apply grease on door latches, door lock, door check stop, striker, bonnet opening lever & lock Every Service x x x x x x x
plate, tailgate hinges & door lock inner ratchet.
7 Check & ensure normal working of engine using Diagnostic Equipment. Every Service x x x x x x x x
2.2L DICOR ENGINE 2.2L DICOR ENGINE2.2L DICOR ENGINE 2.2L DICOR ENGINE
2.2L DICOR ENGINE
1 *Clean air cleaner filter element, Change if red band appears on service indicator even after Every Service x x x x x x x
cleaning
2 *Change engine Oil and Oil filter. Use APICH4+MB228.3 or Higher grade Engine Oil.Every Service x x x x x x x x
OR 1 Year whichever is earlier
3 Check All accessory Drive belts, adjust tension if required, change if damaged Every Service x x x x x x x
OR 1 Year whichever is earlier
4 Change fuel filterEvery Service x x x x x x x
OR 2 Years whichever is earlier
5 *Replace air filter element (OR if RED band appears on Service Indicator) 45,000 km x x
6 Change coolant in the cooling system 60,000 km x
OR 2 Years whichever is earlier
7 Change Sedimenter / Water seperator1,05,000 km x
8 Change Timing Belt & Timing Belt Idler1,05,000 km x
ProCarManuals.com

148
S E R V I C E S C H E D U L ESER SERSER SER
SER
VICE SCHEDULE VICE SCHEDULEVICE SCHEDULE VICE SCHEDULE
VICE SCHEDULE
ADDITIONAL MAINTENANCE SCHEDULE UNDER SEVERE DRIVING CONDITIONS :
A.. Driving in conditions such as Patrolling, Taxi, Pickup Van, Vehicle Towing, with Trailer Towing
B. Driving on Dusty / Sandy roads
C. More than 50% (in terms of kms) driving in heavy city traffic
D. Frequently operating in mountainous area
ITEMINTERVAL CONDITION
AB CD
1. Engine Oil & Oil Filter Change every 7500 kms.
z zz z
z
z zz z
z
z zz z
z
z zz z
z
2. Air Filter Element Clean at every 7500 kms. &
z zz z
z
replace at 30,000 kms.
3. Front (for 4X4) & Rear Axle Change First at 15000 kms
z zz z
z
z zz z
z
z zz z
z
z zz z
z
Oil Change & thereafter at 45,000 kms.
SR SRSR SR
SR
x 1000 km x 1000 kmx 1000 km x 1000 km
x 1000 km
NO NONO NO
NO
OPER OPEROPER OPER
OPER
A AA A
A
TIONS TIONSTIONS TIONS
TIONS
FREQUENCY FREQUENCYFREQUENCY FREQUENCY
FREQUENCY
1-1.5 1-1.51-1.5 1-1.5
1-1.5
15 1515 15
15
30 3030 30
30
45 4545 45
45
60 6060 60
60
75 7575 75
75
90 9090 90
90
105 105105 105
105
ELECTRICALS ELECTRICALSELECTRICALS ELECTRICALS
ELECTRICALS
1 Check headlamp focussing & functioning of other electrical equipment 15,000 km x x x x x x x
2 Check specific gravity of battery electrolyte 30,000 km x x x
HV HVHV HV
HV
A AA A
A
C CC C
C
1 Check the HVAC System for Satisfactory Performance & attend if required Every Service x x x x x x x x
WHEELS & WHEELS & WHEELS & WHEELS &
WHEELS &
T TT T
T
YRES YRESYRES YRES
YRES
1 Tyre rotation15,000 km x x x x x x x
* Under severe driving conditions, additional maintenance is required. Please Refer to “Additional Maintenance Schedule under severe driving conditions”:
P PP P
P
r rr r
r
ec ecec ec
ec
autions t autions tautions t autions t
autions t
o b o bo b o b
o b
e tak e take tak e tak
e tak
en while cleaning engine c en while cleaning engine cen while cleaning engine c en while cleaning engine c
en while cleaning engine c
ompar omparompar ompar
ompar
tmen tmentmen tmen
tmen
t : t :t : t :
t :
I I I I
I
t is r t is rt is r t is r
t is r
ec ecec ec
ec
ommended t ommended tommended t ommended t
ommended t
o use dr o use dro use dr o use dr
o use dr
y lo y loy lo y lo
y lo
w pr w prw pr w pr
w pr
essur essuressur essur
essur
e air e aire air e air
e air
.. ..
.
D D D D
D
o not use pr o not use pro not use pr o not use pr
o not use pr
essur essuressur essur
essur
ised isedised ised
ised
w ww w
w
a aa a
a
t tt t
t
er erer er
er
.. ..
.
ProCarManuals.com

155
A L P H A B E T I C A L I N D E X ALPHABETIC INDEX ALPHABETIC INDEX ALPHABETIC INDEX ALPHABETIC INDEX
ALPHABETIC INDEX
A AA A
A
Air Bags 2 2
Aggregate Numbers-Location 1 2
Air Conditioning52, 134
Air Filter & Filter Element 105
Analog Clock 66
Anti Lock Brake System 7 9
Ashtray 6 1
Audio Warning 2 1
Automatic Hub Lock 8 2
B BB B
B
Battery 118
Belt Tension 135
Bonnet Opening / Closing 7 0
Brake Fluid 115
Brakes 7 9
Branded Lubricants 9 5
C CC C
C
Catalytic Converter 132
Central Locking System 13
Child Lock 20
Cigarette Lighter 60
Clutch Fluid 115
Collapsible Steering column 2 1
Combi-Switch 33
Coolants 9 4
D DD D
D
Door Locks 20
Driving Controls 28
Driving in adverse conditions 85
Driving Safety 89
E
ECU 1 1 7
EGR System 132
Engine Compartment 104
Engine Coolant 73
Engine Cooling System 106
Engine oil 72
Engine Oil & Oil Filter 108
Environment Protection 8
F FF F
F
Flat tyre replacement 120
Follow Me Home Headlamp 64
Front & Rear Fog Lights 38
Front / Rear Axle Oil 112
Front Seat 56
Front Windshield / Door Glass Demister 5 4
Fuel 92
Fuel Economy 84
Fuel Gauge 50
Fuel level 72
Fuel Tank Flap Switch 38
Fuel Tank Flap 61
Fuses 130
G GG G
G
Gauges 4 7
Gear Box 78
Gear Box Oil 1 1 0
Gear Shift Lever 32
Glove Box 62
H HH H
H
Hazard Warning 39
Head Lamps & Headlamp Adjustment 113
Headlamp Leveling Switch 40
Headrest 57
Headrest adjustment 1 8
High mounted stop lamp 67
I II I
I
Ignition Switch 29
Immobiliser- Anti Theft Security System 31
Important Information 6,7
Indicators 43
Instrument Cluster 42
J JJ J
J
Jack & Tools 59
Jump Seats 59
ProCarManuals.com