Page 114 of 288
Downloaded from www.Manualslib.com manuals search engine 2 3 ( 5 $ 7 , 1 * < 2 8 5 9 ( + , & / (
0 6 (
release the clutch. When you hear a
change in the engine’s sound, slowly press
the accelerator while continuing to gradu-
ally release the clutch.
6 K L I W L Q J
All forward gears are synchronized, which
provides for quiet, and easy shifting.
Always depress the clutch pedal all the
way to the floor before shifting gears.
Ensure that the engine rpm does not rise
to the red zone of the tachometer.
61MS2A005
Reverse gear (6MT model): while lifting up
the ring, shift the gearshift lever to the
rightmost position and engage the gear. ' R Z Q V K L I W L Q J P D [ L P X P D O O R Z D E O H V S H H G V
0 7 P R G H O
0 7 P R G H O
*NOTE:
You may not accelerate to the maximum
allowable speed because of the driving sit-
uation and/or the vehicle condition. ( ; $ 0 3 / (
Downshifting km/h (mph)
2nd to 1st 35 (22)
3rd to 2nd 65 (40)
4th to 3rd 100 (62)
5th to 4th 145 (90)*
Downshifting km/h (mph)
2nd to 1st 40 (25)
3rd to 2nd 70 (43)
4th to 3rd 115 (71)
5th to 4th 160 (99)*
6th to 5th 200 (124)*
NOTICE
: K H Q G R Z Q V K L I W L Q J W R D O R Z H U J H D U
P D N H V X U H Q R W W R G R Z Q V K L I W D W W K H
V S H H G I D V W H U W K D Q W K H P D [ L P X P
D O O R Z D E O H V S H H G V I R U W K H Q H [ W O R Z H U
V S H H G R U V H Y H U H H Q J L Q H G D P D J H F D Q
U H V X O W
: $ 5 1 , 1 *
Page 117 of 288
Downloaded from www.Manualslib.com manuals search engine
2 3 ( 5 $ 7 , 1 * < 2 8 5 9 ( + , & / (
0 6 (
& D Q F H O O D W L R Q R I W K H & U X L V H & R Q W U R OThe “SET” indicator light will go off and the
cruise control will be canceled temporarily
with following procedures:
• Push the “CANCEL” switch (2).
• Depress the brake pedal.
• Depress the clutch pedal.
• The vehicle speed falls more than about
20 percent from the set speed.
• Any time the vehicle speed falls below
40 km/h (25 mph).
To resume the previously set speed, push
the “RES +” switch (3) and turn on the
“SET” indicator light. Besides, the vehicle
speed has to be above 40 km/h (25 mph)
when the vehicle is not in the above condi-
tions.
To turn off the cruise control system, push
the “CRUISE” switch (1) and make sure
the “CRUISE” indicator light is off.
Also, if the malfunction indicator light in the
instrument cluster comes on or blinks, the
cruise control system will be turned off.
NOTE:
If you turn off the cruise control system, the
previously set speed in the memory is
cleared. Reset your cruising speed again.
3 D U N L Q J 6 H Q V R U V L I H T X L S S H G
61MM0A192
(1) Symbol representing an obstacle
detected by parking sensor*
* This symbol represents an obstacle
that is located to the right rear at
the vehicle.
• The parking sensor system uses ultra-
sonic sensors to detect obstacles near
the rear bumper. If obstacles are sensed
while you are parking or moving the
vehicle slowly, the system warns you by
sounding a buzzer and displaying sym-
bols representing the obstacles on the
information display in the instrument
cluster.
• The system emits an ultrasonic wave
and the relevant sensor detects the
return of the wave reflected by an obsta-
cle. The system measures the time
taken by the ultrasonic wave to reach the
obstacle and return from it, from which it
determines the obstacle’s position.
• The parking sensor function can be used
when you press the engine switch tochange the ignition mode to “ON”, the
gearshift lever is in “R” position and the
parking sensor switch is in the “ON”
position. This function is helpful in the
following cases: pulling over to the curb;
parallel-parking the vehicle; steering the
vehicle into a garage; driving along an
alley; and moving slowly in a place with
obstacles.
(1)
: $ 5 1 , 1 *
Page 226 of 288
Downloaded from www.Manualslib.com manuals search engine 7-3INSPECTION AND MAINTENANCE
64MS0-74E
Interval: This interval should be judged by odometer reading
or months, whichever comes first.
FREE INSPECTION
PERIODIC MAINTENANCE AT COST
km (x1000)
1
5
10
20
30
40
50
60
70
80
months
1
6
12
24
36
48
60
72
84
96
Engine
1-1
l
l
l
R
l
R
l
R
l
R
1-2- - RRRRRRRR
1-3
l
l
l
l
l
l
l
l
l
l
1-
) ) ) ) ) ) ) ) ) )
1-
Engine Coolant (Level, Leakage)
Engine oil and engine oil
F I L T E R
Cooling system hoses and connections (Leakage and Damage)
Engine Mounting and -anifold &ixing . O I S E , E A K A G E $ A M A G E E T C
Exhaust System (Noise, Leakage etc.
-l-l-I-I-l
1- Exhaust Gas Recirculation Valve
D13A engine ----C--C--
FUEL
2-1.
Air cleaner filter element
Paved-road
Clean after 5,000 KM. Replace after every 40,000 KM.
Dusty Condition
Clean after 2,500 KM or as required. Replace after every 40,000 KM.
Replace more frequently if dust condition is severe.
2-2.
Fuel tank cap, fuel lines and connections (Leakage and Damage)
-
l
-
-
-
l
-
-
-
l
2-3.
Fuel Filter and Water Draining
I
l
I
R
I
R
I
R
I
R
CLUTCH AND TRANSMISSION
3-1.
Clutch fluid (level, leakage)
l
l
l
R
l
R
l
R
l
R
3-2.Clutch slipping (Dragging or Excess Damage) llllllllll
3-3.
Manual Transmission/Transfer or Differential Oil (Level, Leakage)
Replace at 1,60,000 km or 10 years whichever comes first
I
I
I
I
I
I
I
I
I
I
DRIVE SHAFT
4-1.
Drive shaft boot (boot damage)
-
l
l
l
l
l
l
l
l
l
BRAKE
5-1.
Brake Fluid (Level, Leakage)
I
I
I
R
I
R
I
R
I
R
5-2. Brake pedal (pedal - wall clearance) I I I I I I I I I I
5-3.
Parking brake lever and cable (Play, damage)
I
I
I
I
I
I
I
I
I
I
5-4.Brake disc and pad (Wear) – I I I I I I I I I
Page 236 of 288
Downloaded from www.Manualslib.com manuals search engine , 1 6 3 ( & 7 , 2 1 $ 1 ' 0 $ , 1 7 ( 1 $ 1 & (
0 6 (
& O X W F K 3 H G D O ) O X L G & R Q W U R O & O X W F K
64MS141
Check the clutch pedal for smooth opera-
tion and clutch fluid level from time to time.
If clutch dragging is felt with the pedal fully
depressed, have the clutch inspected by
D X W K R U L V H G 0 D U X W L 6 X ] X N L Z R U N V K R S. If the
clutch fluid level is near the “MIN” triangle
mark, fill it up to the “MAX” triangle mark
with MARUTI genuine brake fluid.
) X H O ) L O W H U
64MS175
The fuel filter works as a water sedimentor
as well.
Drain water according to the Periodic
Maintenance Schedule. To drain water:
1) Place a pan or ample rag under the fuel
filter drain nozzle.
2) Loosen the drain screw (1). The water
will be drained.
3) Tighten the drain screw when the water
changes to the diesel fuel.
7 L J K W H Q L Q J W R U T X H I R U G U D L Q V F U H Z
1 P N J P O E I W
% U D N H V % U D N H ) O X L G
64MS141
Check the brake fluid level by looking at
the reservoir in the engine compartment.
Check that the fluid level is between the
“MAX” and “MIN” triangle mark. If the
brake fluid level is near the “MIN” triangle
mark, fill it up to the “MAX” triangle mark
with MARUTI GENUINE BRAKE FLUID.
MAX
MIN
(1)
( ; $ 0 3 / (
MAX
MIN
Page 286 of 288
Downloaded from www.Manualslib.com manuals search engine 6 3 ( & , ) , & $ 7 , 2 1 6
0 6 (
*1 When tire replacement is necessary and if the specified load index and speed rated tire is not available, then use a tire of higher load
index and speed rating.
*2: The spare wheel provided with alloy wheel variant is steel wheel rim, hence follow 4 tire rotation only.
(Refer: Section
“Inspection and maintenance”)
, 7 ( 0 : K H H O V D Q G 7 L U H V
Tire size, front and rear
205/60R16 92H
*1*2
Tire size, spare
205/60R16 92H
*2 (Steel wheel)
Rim size 205/60R16 tire: 16X6J
Tire pressures For the specified tire pressure, see the Tire Information Label located
on the driver’s door lock pillar.
, 7 ( 0 5 H F R P P H Q G H G ) X H O / X E U L F D Q W V D Q G & D S D F L W L H V D S S U R [
Fuel 48 L
Engine oil D13A 3.2 L (replacement with oil filter)
D16AA 5.25 L (replacement with oil filter)
Engine coolant D13A 6.0 L (including reservoir tank)
D16AA 5.5 L (including reservoir tank)
Manual transaxle oil 5M/T 2.6 L
6M/T 2.1 L
Brake fluid / Clutch fluid Refill to the proper oil level according to the instructions in the “INSPEC-
TION AND MAINTENANCE” section.