2015 Ram 5500 Chassis Cab oil level

Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
Lubricant Selection
Refer to “Fluids, Lubricants, and Genuine Parts” in
“Maintaining Your Vehicle” for further information.
NOTE:The presence of water in the gear lubricant will
result in corrosion and possible failure of differential
components. Operation of the vehicle in water, as may be
encountered in some off-highway types of service, will
require draining and refilling the axle to avoid damage.
Limited-Slip Differentials DO NOT REQUIRE any
limited slip oil additive (friction modifiers).
NOTE: Slight noise and mild shuddering may be evi-
dent while turning a vehicle with limited slip differential
on concrete or dry pavement. These conditions should be
considered normal operation of the limited slip differen-
tial.
Transfer Case
Drain And Refill
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
Lubricant Selection
Refer to “Fluids, Lubricants, and Genuine Parts” in
“Maintaining Your Vehicle” for further information.
Fluid Level Check
This fluid level can be checked by removing the filler
plug. The fluid level should be to the bottom edge of the
filler plug hole with the vehicle in a level position.
Automatic Transmission — If Equipped
Selection Of Lubricant
It is important to use the proper transmission fluid to
ensure optimum transmission performance and life. Use
524 MAINTAINING YOUR VEHICLE

4. Fully apply the parking brake and press the brake.
5. Place the shift lever momentarily into each gear posi-tion (allowing time for the transmission to fully en-
gage in each position), ending with the transmission in
PARK.
6. Wipe the area around the dipstick clean to prevent dirt from entering the transmission.
7. Remove the dipstick, wipe it clean and reinsert it until seated.
8. Remove the dipstick again and note the fluid level on both sides. The fluid level reading is only valid if there
is a solid coating of oil on both sides of the dipstick.
Note that the holes in the dipstick will be full of fluid
if the actual level is at or above the hole. The fluid level
should be between the “HOT” (upper) reference holes
on the dipstick at normal operating temperature. If the
fluid level is low, add fluid through the dipstick tube to bring it to the proper level.
Do not overfill.Use
ONLY the specified fluid (see Fluids, Lubricants, and
Genuine Parts for fluid specifications). After adding
any quantity of oil through the dipstick tube, wait a
minimum of two minutes for the oil to fully drain into
the transmission before rechecking the fluid level.
NOTE: If it is necessary to check the transmission below
the operating temperature, the fluid level should be
between the two “COLD” (lower) holes on the dipstick
with the fluid at 60-70°F / 16-21°C for 66RFE transmis-
sion, or 68-86°F / 20-30°C for AS66RC transmission. Only
use the COLD region of the dipstick as a rough reference
when setting the fluid level after a transmission service
or fluid change. Re-check the fluid level, and adjust as
required, once the transmission reaches normal operating
temperature.
7
MAINTAINING YOUR VEHICLE 527

MAINTENANCE SCHEDULE
Your vehicle is equipped with an automatic oil change
indicator system. The oil change indicator system will
remind you that it is time to take your vehicle in for
scheduled maintenance.
Based on engine operation conditions, the oil change
indicator message will illuminate. This means that ser-
vice is required for your vehicle. Operating conditions
such as frequent short-trips, trailer tow, extremely hot or
cold ambient temperatures, and E85 fuel usage will
influence when the “Oil Change Required” message is
displayed. Severe Operating Conditions can cause the
change oil message to illuminate as early as 3,500 miles
(5,600 km) since last reset. Have your vehicle serviced as
soon as possible, within the next 500 miles (805 km).
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If a
scheduled oil change is performed by someone other
than your authorized dealer, the message can be reset byreferring to the steps described under “Electronic Vehicle
Information Center (EVIC)/Driver Information Display
(DID)” in “Understanding Your Instrument Panel” for
further information.
NOTE:
•
Gasoline Engines
• Under no circumstances should oil change intervals
exceed 8,000 miles (13,000 km) or twelve months,
whichever comes first.
• Severe Duty
•
Change Engine Oil at 4000 miles (6,500 km) if the vehicle
is operated in a dusty and off road environment. This
type of vehicle use is considered Severe Duty
Once A Month Or Before A Long Trip:
• Check engine oil level
• Check windshield washer fluid level
560 MAINTENANCE SCHEDULES

•Check the tire inflation pressures and look for unusual
wear or damage
• Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering and automatic trans-
mission and fill as needed.
• Check function of all interior and exterior lights
Required Maintenance
Refer to the Maintenance Schedules on the following
pages for required maintenance.
At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Change oil and filter.
• Rotate the tires. Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
At Every Oil Change Interval As Indicated By Oil Change Indicator System:
•Inspect battery and clean and tighten terminals as
required.
• Inspect automatic transmission fluid if equipped
with dipstick.
• Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
• Inspect engine cooling system protection and
hoses.
• Inspect exhaust system.
• Inspect engine air cleaner if using in dusty or
off-road conditions.
• Lube the front drive shaft fitting. 8
MAINTENANCE SCHEDULES 561

Maintenance Chart
Mileage or time passed
(whichever comes first)
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Additional Inspections
Inspect the CV/Universal joints. X XX XX
Inspect front suspension, tie rod
ends, and replace if necessary. XXX X X X X
Inspect the front and rear axle
surfaces. If gear oil leakage is
suspected, check the fluid level.
If using your vehicle for police,
taxi, fleet, off-road or frequent
trailer towing, change axle fluid. XXX X X X X
562 MAINTENANCE SCHEDULES

Auto Down Power Windows..................44
Automatic Door Locks ......................37
Automatic Headlights ..................... .151
Automatic High Beams .....................153
Automatic Temperature Control (ATC) ..........301
Automatic Transmission ....................524
Adding Fluid ......................... .527
Fluid and Filter Changes ..................528
Fluid Level Check ...................... .526
Fluid Type ........................... .524
Shifting ............................. .336
Special Additives ...................... .525
Axle Fluid ............................. .523
Axle Lubrication ......................... .523
Battery ................................ .502
Keyless Transmitter Replacement (RKE) ........27
Belts, Seat ...............................110
Body Builders Guide ........................6 Body Mechanism Lubrication
.................505
B-Pillar Location ......................... .389
Brake Control System, Electronic ..............371
Brake Fluid ............................ .521
Brake System ........................... .370
Anti-Lock (ABS) ....................... .371
Fluid Check .......................... .521
Master Cylinder ....................... .521
Parking ............................. .367
Warning Light ........................ .203
Brake/Transmission Interlock .................336
Bulb Replacement ........................ .547
Bulbs, Light .............................112
Cab Top Clearance Lights ...................552
Capacities, Antifreeze (Engine Coolant) ..........554
Capacities, Fluid ......................... .554
Caps, Filler Oil (Engine) .......................... .495
10
INDEX 579

Overheating.......................... .460
Engine Oil Viscosity ...................... .495
Enhanced Accident Response Feature ............70
Entry System, Illuminated ....................22
Ethanol ............................... .422
Event Data Recorder ........................74
Exhaust Gas Caution ...................... .109
Exhaust System .......................... .109
Exterior Lighting ......................... .151
Exterior Lights ...........................112
Filters Air Cleaner .......................... .496
Engine Fuel .......................... .555
Engine Oil ........................... .496
Engine Oil Disposal .....................496
Flashers Turn Signal ............................112
Flat Tire Stowage ........................ .472Flooded Engine Starting
....................331
Fluid, Brake ............................ .558
Fluid Capacities ......................... .554
Fluid Leaks .............................112
Fluid Level Checks Automatic Transmission ..................526
Brake ............................... .521
Power Steering ........................ .366
Fluids, Lubricants and Genuine Parts ...........555
Fog Lights ............................. .155
Four-Way Hazard Flasher ...................460
Four Wheel Drive ........................ .351
Freeing A Stuck Vehicle .....................477
Front Axle (Differential) .....................523
Fuel .................................. .421
Adding ............................. .426
Additives ............................ .424
Clean Air ............................ .422
Ethanol ............................. .422
10
INDEX 583

High Beam Indicator.....................205
High Beam/Low Beam Select ...............162
Illuminated Entry ........................22
Instrument Cluster ..................... .201
Interior ............................. .157
Oil Pressure .......................... .206
Passing ............................. .161
Seat Belt Reminder ..................... .205
Security Alarm ........................ .206
Service .............................. .546
Tire Pressure Monitoring (TPMS) ............207
Traction Control ....................... .379
Transfer Case ......................... .355
Turn Signal ............................112
Warning (Instrument Cluster Description) ......201
Limited-Slip Differential ....................361
Loading Vehicle ......................... .427
Tires ............................... .389
Locks ..................................34 Automatic Door
.........................37
Child Protection .........................38
Door .................................34
Power Door ............................36
Low Tire Pressure System ...................411
Lubrication, Body ........................ .505
Lug Nuts .............................. .461
Maintenance Free Battery ....................502
Maintenance Procedures ....................492
Maintenance Schedule ..................... .560
Malfunction Indicator Light (Check Engine) .......490
Manual, Service ......................... .574
Manual Transmission Fluid Level Check ...................... .524
Memory Seat ........................... .143
Methanol .............................. .422
Mirrors ................................117
Electric Powered ....................... .126
10
INDEX 587