2015 Peugeot Bipper fuel cap

4
Bipper_en_Chap01_vue-ensemble_ed02-2014
EXTERIOR (LIGHT VAN)
Rear lamp, direction indicators, 3rd brake lamp ..........46-47, 164-165
Right-hand side:
fuel filler cap, fuel tank


...................
142
fuel cut-off ...............................
142-143
l

oad space

.................................
77-78
Rear doors

............................
36, 42-45
Opening/Closing to 180°

...........
42, 44
Number plate lamps

......................164
Rear parking sensors


......................88
Spare wheel, changing a wheel, tools
..................................... 155-157
towing, lifting .................................172
towbar .................................... 137-13

8
Dimensions


.............................
174-175
Accessories


............................
139-140
Roof rack

.......................................
139
Key, remote control, battery

........
36-38
Central locking


.....................
36, 42, 44
Opening/Closing front windows
....... 37
Confidential card .............................. 39
Alarm


...............................................
40
Wiper blades.................................. 156
Door mirrors


..................................... 51
Side repeater
................................. 163
Front lamps, foglamps,


direction indicators


... 46-47, 161-162
Headlamp beam height adjustment ....... 47
Changing bulbs.......................161-16 5
Opening/Closing doors

........

.................... 36, 38, 41-45
Opening the bonnet
....................... 144
Configuration -
Autoclose


.................... 42, 44, 83, 85 Brakes, pads..........................
147, 149
Hill start assist
.................................60
Braking assistance


.................112-113
trajectory control

....................113-115
tyres, pressures


....................159, 183
Snow chains


..................................160
Location

5
Bipper_en_Chap01_vue-ensemble_ed02-2014
EXTERIOR (COMBI)
Brakes, pads..........................147, 149
Hill start assist ................................. 60
Braking assistance


.................112-113
trajectory control

....................113-115
Under-inflation detection ......... 116-117
tyres, pressures


....................159, 183
Snow chains


.................................. 160
Dimensions


.............
176-177, 178-179
Accessories


............................
139-140
Roof bars

.......................................
139
Key, remote control, battery

........
36-38
Central locking


.....................
36, 42, 44
Opening/Closing front windows
....... 37
Confidential card .............................. 39
Alarm


...............................................
40
Wiper blades.................................. 166
Door mirrors


.....................................
51
Side repeater
................................. 163
Front lamps, foglamps, direction indicators


.................
46-47, 161-162
Headlamp beam height adjustment

....
47
Changing bulbs.......................161-165
Opening/Closing doors
........
.................... 36, 38, 41-45
Child lock
......................................... 45
Rear windows


.................................. 52
Opening the bonnet
....................... 144
Configuration -
Autoclose


.................... 42, 44, 83, 85 Right-hand side:
fuel filler cap, fuel tank


...................
142
fuel cut-off ...............................
142-143
Rear fittings ................................
80-81
Rear doors

............................
36, 42-45
Opening/Closing to 180°

...........
42, 44
Number plate lamps

......................
164
Rear parking sensors

......................
88
Spare wheel, changing a wheel, tools,
temporary puncture
repair kit ...............
155-157, 158-159
towing, lifting ................................. 172
towbar .................................... 137-13

8
Rear lamps, direction indicators,
3
rd brake lamp ..........46-47, 164-165
1
OVERVIEW
Location

34
Bipper_en_Chap03_pret-a-partir_ed02-2014
FUEL GAUGE
the fuel level is tested every time the
ignition is switched on.
If the gauge is positioned on:
-

f (full):
the capacity of the fuel tank is
approximately 45 litres.
-

e (empty):
the reserve is now being
used, the warning lamp comes on
continuously.
t

he low fuel warning first comes on when
approximately 6 litres of fuel is left.
COOLANT TEMPERATURE
- wait approximately 15 minutes to allow
the engine to cool down in order to check
the level and top it up if necessary.
t

he
cooling system is pressurised. In order to
avoid any risk of scalding, unscrew the
cap by two turns to allow the pressure to
drop.
When the pressure has dropped, check the
level and remove the cap to top up.
If the needle remains in the red zone, contact
a PEUGEOT or a qualified workshop.
EMISSION CONTROL
eOBD (european On Board Diagnosis) is a
diagnostics system which meets the exhaust
emissions standards for:
-

CO (carbon monoxide),
-


HC (unburnt hydrocarbons),
-


NOx (nitrous oxides) or particles detected

by oxygen sensors placed upstream and
downstream of the catalytic converters.
Refer to the "Checks -
l
evels" section. Refer to the "Checks -
l evels" section.
t

he driver is warned of any
fault with this emission control
system by flashing of this specific
warning lamp in the instrument
panel.
If the needle enters the red zone, or
if the warning lamp comes on:
The needle is positioned between c (cold)
and h (hot): normal operation.
In arduous conditions of use or hot climatic
conditions, the needle may move close to
the red graduations.
-

stop immediately

, switch off the ignition.
t

he cooling fan may continue to operate
for a certain time up to approximately
10

minutes.
Instruments and controls

38
Bipper_en_Chap03_pret-a-partir_ed02-2014
KEY
this locks and unlocks the doors on the
vehicle, opens and closes the fuel filler cap,
as well as starting and stopping the engine.
REMOTE CONTROL BATTERY
Reference: CR 2032/3 volts. -
use the screwdriver as a lever to extract

the battery holder housing 2,
- remove the housing and change the
battery 3 observing the polarities,
-

put the battery holder housing
2 back
inside the key and secure it by turning the
screw 1.
Changing the remote control
battery
there is a risk of damage if
the replacement battery does not
conform.
Only use batteries which are identical or of
an equivalent type to those recommended
by a P
euge O t
dealer
.
take used batteries

to an approved collection point.
-

press the button to eject the


key,
-
turn the screw
1 from the
closed padlock to the open
padlock using a screwdriver
with a thin tip,
Switching off the engine leads to a loss
of braking assistance.
Access

142
Bipper_en_Chap08_verifications_ed02-2014
FILLING WITH FUEL
Capacity of the fuel tank: approximately 45 litres.
Low fuel level
When the minimum fuel tank level
is reached, this warning lamp
comes on. When it first comes on,
you have approximately 6 litres
of fuel remaining. Refuel without delay to
avoid running out of fuel.
An arrow in the instrument panel indicates
which side of the vehicle the filler flap is
located.
Refuelling must be done with the engine off.
-

Open the fuel filler flap.
-


Hold the filler cap with one hand.
-


With the other hand, insert the key
, then
turn it a third of a turn.
-

Remove the filler cap and hang it on the

hook, located on the inside of the filler
flap.
FUEL CUT-OFF
In the event of a serious collision, a device
automatically cuts off the fuel supply to the
engine and the vehicle's electrical supply.
It also automatically unlocks the doors
and switches on of the courtesy lamps. A
message appears in the instrument panel
screen according to version.
turn the key to the

STOP position to prevent
discharging of the battery.
Check that there is no smell or leak of fuel
outside the vehicle.
With Stop & Start, never refuel with the
system in S
t
OP

mode; you must switch
off the ignition with the key. When the fuel filler flap is open, a
safety system prevents sliding of the
side door (Combi).
A label affixed to the inside of the flap
reminds you of the type of fuel to be used.
Opening the filler cap may cause a noise
resulting from the inrush of air.
t

his vacuum
is quite normal and results from the sealing
of the fuel system.
When filling the fuel tank, do not continue
after the 3rd cut-off of the nozzle; this could
cause malfunctions.
After filling the fuel tank, lock the filler cap
and close the flap.
Fuel

180
Bipper_en_Chap10_caracteristique_ed02-2014
DIESEL ENGINES1.4 litre HDi 70 hp1.3 litre HDi 75 hp
Gearboxes ManualManualElectronic
g

ears 555
eu

standard maximum power (kW)* 5055
Cubic capacity (cc) 1 3991 248
Bore x stroke (mm) 73.7 x 8269.6 x 82
Max power engine speed (rpm) 4 0003 750
eu

standard max torque (Nm) 160190
Max torque engine speed (rpm) 2 7501 750
Fuel DieselDiesel
Catalytic converter Ye sYe s
Particle emissions filter (PEF) NoYe s
Stop & Start NoYe s
Engine oil capacity with filter replacement (litres) 3.83.0
*
The maximum power corresponds to the value type-approved on a t

est bed, under conditions defined in European legislation (Directive 1999/99/EC).
Engines

181
Bipper_en_Chap10_caracteristique_ed02-2014
PETROL ENGINE1.4 litre 75 hp
Gearbox Manual
g

ears 5
eu

standard maximum power (kW)* 54
Cubic capacity (cc) 1 360
Bore x stroke (mm) 75 x 77
Max power engine speed (rpm) 5 200
eu

standard max torque (Nm) 11 8
Max torque engine speed (rpm) 2 600
Fuel
u

nleaded petrol
Stop & Start No
Engine oil capacity with filter replacement (litres) 3.0
*
The maximum power corresponds to the value type-approved on a t

est bed, under conditions defined in European legislation (Directive 1999/99/EC).
Engines
TECHNICAL DATA
10