2015 PEUGEOT 4008 check engine

212
4008_en_Chap08_verifications_ed01-2014
Running out of fuel (Diesel)
On vehicles fitted with the 1.6 litre
HDi 110 engine, the fuel system must be
manually primed if you run out of fuel; refer to
the corresponding Diesel engine compartment
view.
1.6 litre HDi engine
F Fill the fuel tank with at least five litres of diesel.
F

O
pen the bonnet.
F

I
f necessary, unclip the styling cover for
access to the priming pump.
F

S
queeze and release the priming pump
repeatedly until resistance is felt (there
may be resistance at the first press).
F

O
perate the starter until the engine starts
(if the engine does not start at the first
attempt, wait around 15 seconds before
trying again).
F

I
f the engine does not start after a few
attempts, operate the priming pump again
then start the engine.
F

C
lip the styling cover back in place.
F

C
lose the bonnet.
Checks

213
4008_en_Chap08_verifications_ed01-2014
Checking levels
take care when working under the bonnet, as certain areas of the engine may be extremely hot (risk of burns) and the cooling fan could start at
any time (even with the ignition off).
Oil level
the check of the the level is done
out with the dipstick, located under
the bonnet. Refer to the description
of your engine compartment for the
position of the dipstick.Engine oil change
Refer to the warranty and maintenance record
for details of the interval for this operation.
In order to maintain the reliability of the engine
and emission control system, never use
additives in the engine oil.
Oil specification
the oil must be the correct grade for your
engine and conform to the manufacturer's
recommendations.
Check all of these levels regularly, in line with the warranty and maintenance record.
t
o
p them up if necessary, unless other wise indicated.
If a level drops significantly, have the corresponding system checked by a P
e
uge
Ot
dealer or a qualified workshop.
Dipstick
there are two marks on the dipstick:
A = maximum
If the level is above this
mark, contact a P
e

uge
Ot

dealer or a qualified
workshop.
B = minimum
to

p up the level through the
oil filler orifice, using the
correct grade of oil for your
engine.
t
h
e level must never
be below this mark.
th

is check will only be correct if the vehicle is
on level ground and the engine has been off for
more than 30 minutes.
It is normal to top up the oil level between
two services (or oil changes). P
e

uge
Ot


recommends that you check the level, and top
up if necessary, every 3 000 miles (5 000 km).
After topping up the oil, the check when
switching on the ignition with the oil level
indicator in the instrument panel is not valid
during the 30 minutes after topping up.
8
Checks

214
4008_en_Chap08_verifications_ed01-2014
Coolant level
the coolant level should be between
the two marks.In addition, as the cooling system is
pressurised, wait at least one hour after
switching off the engine before carrying out any
work.
to a

void any risk of scalding, unscrew the cap
by two turns to allow the pressure to drop.
When the pressure has dropped, remove the
cap and top up the level.
Fluid specification
the coolant must conform to the
manufacturer's recommendations.
th

e brake fluid level should be close
to the "MA X" mark. If it is not, check
the brake pad wear.
Brake fluid level
Changing the fluid
Refer to the warranty and maintenance record
for details of the interval for this operation.
Fluid specification
the brake fluid must conform to the
manufacturer's recommendations and meet the
DO
t3 o

r DO
t4 s
tandard.
The cooling fan may star t after switching
off the engine; take care with ar ticles and
clothing that might become caught by the
fan blades. When the engine is warm, the temperature of
the coolant is regulated by the fan.
Checks

215
4008_en_Chap08_verifications_ed01-2014
Avoid prolonged contact of used oil or
fluids with the skin.
Most of these fluids are harmful to
health or indeed very corrosive.
Do not discard used oil or fluids into
sewers or onto the ground.
ta

ke used oil to a P
e
uge
Ot
dealer or
a qualified workshop (France) or to an
authorised waste disposal site.
Used products
To p p i n g u p
the reservoir must be topped up without delay
by a Pe ugeOt dealer or a qualified workshop.
Additive level
(1.6 HDi 110 Diesel versions
with particle filter)
the additive reservoir low level is indicated by
the display of this message.
Fluid specification
For optimum cleaning, this fluid must not be
topped up with or replaced with plain water.
Screenwash and headlamp
wash fluid
to check or top up the fluid, stop the
vehicle, apply the parking brake and
switch off the engine.
F

O

pen the bonnet and secure it with the
st ay.
F

O

pen the filler cap for the screenwash
reservoir.
F

C

heck the level using the gauge, then top-
up if necessary.
F

R

efit the cap on the reservoir and close the
bonnet. In wintry conditions, the use of fluid with
an ethyl alcohol or methanol base is
recommended.
8
Checks

216
4008_en_Chap08_verifications_ed01-2014
Checks
12 V battery
Electrolyte level
For access to the battery, refer to the
"12V battery" section.Refer to the warranty and
maintenance record for details of
the replacement intervals for these
components.
Air filter and passenger compartment filter
Replace the oil filter each time the
engine oil is changed.
Refer to the warranty and
maintenance record for details of
the replacement interval for this
component.
Oil filter
If necessary, top up using distilled water,
removing the battery cap from each cell.
Check the electrolyte level at least
once a month.
When carrying out work on the battery, refer
to "12V battery" section for details of the
precautions to be taken before disconnecting
the battery and following its reconnection.
un

less other wise indicated, check these components in accordance with the warranty and maintenance record and according to your engine.
Other wise, have them checked by a P
e

uge
Ot

dealer or a qualified workshop.
th

e electrolyte level must be between the
"LOW
eR LeVeL

" and "
uP

P
eR LeVeL

" marks.
Depending on the environment (e.g. dusty
atmosphere) and the use of the vehicle
(e.g. city driving), replace them twice as often
if necessary
.
A clogged passenger compartment filter may
have an adverse effect on the per formance
of the air conditioning system and generate
undesirable odours.
Checks

217
4008_en_Chap08_verifications_ed01-2014
Manual gearbox
Refer to the warranty and
maintenance record for servicing of
the gearbox.
"CVT" gearbox
Refer to the warranty and
maintenance record for servicing of
the "CV
t" g
earbox.
Particle filter (Diesel)
the start of saturation of the particle filter is
indicated by the temporary illumination of this
warning lamp accompanied by a message in
the instrument panel screen. As soon as the traffic conditions permit,
regenerate the filter by driving at a
speed of at least 25 mph (40 km/h) for
about 20 minutes (with the 1.6 litre HDi
engine the minimum speed is 36 mph
(60 km/h)).
If the warning lamp stays on, this
indicates a low additive level.
On a new vehicle, the first particle
filter regeneration operations may be
accompanied by a "burning" smell,
which is per fectly normal.
Following prolonged operation of the
vehicle at very low speed or at idle,
you may, in exceptional circumstances,
notice the emission of water vapour at
the exhaust on acceleration.
t
h
is does
not affect the behaviour of the vehicle
or the environment.
8
Checks

335
4008_en_Chap11_index-alpha_ed01-2014
ABS and eBFD systems ...............................142
Accessories .................................................. 204
Accessory socket, 12V
......................90, 92, 93
Access to bulbs


............................................. 183
Active stability control (ASC)
........................14 4
Adjusting headlamps


.................................... 13 3
Adjusting head restraints


................................73
Adjusting seat belt height
............................. 14

6
Adjusting the steering wheel


..........................79
Airbag, knee


.......................................... 152, 15 4
Airbags


.......................................................... 150
Airbags, curtain
..................................... 15

3, 15 4
Airbags, front ......................................... 150, 15 4
Airbags, lateral


...................................... 152, 15 4
Air conditioning


......................................... 10, 81
Air conditioning, automatic
................................................ 8

1, 8 4
Air conditioning, manual


...........................81, 82
Air filter
.......................................................... 216
Air flow

..............................
..............................80
Air intake


................................................... 83, 86
Air vents


.......................................................... 80
Alarm


............................................................... 65
Anti-lock braking system (ABS)
....................142
Anti-theft


................................................. 61, 102
Apple
® player ............... 2 78, 279, 280, 304, 306
Armrest, front ...................................... 74, 90, 93
Armrest, rear
................................................... 76
A

SC
........
....................................................... 14 4
Ashtray, portable


....................................... 90, 92
Audible warning


............................................ 141
Audio-CD
..............................

.......276, 303, 323
Audio file formats

.......................................... 2

76
Audio streaming (Bluetooth)
..............................

............330, 331
Audio systems
............................... 249, 289, 311
Audio-telematics


........................................... 249
Automatic illumination of headlamps


...................................... 128, 13 0Automatic operation of hazard
warning lamps

............................................
141
Automatic rain sensitive windscreen wipers

......................................
13 6
Automatic switching off of lighting
..............................
......................
13 0
Auxiliary sockets

...........
94, 278 -281, 304-308, 328 -329
ACCapacity, fuel
tank ............................................................. 210
CD changer
...............................

....................325
CD MP3
........................................ 276, 303, 325
Central locking


.......................................... 52-59
Changing a bulb


..................................... 182-187
Changing a fuse


..................................... 18 8 -19 3
Changing a wheel


.................................. 175 -178
Changing a wiper blade


........................................................... 197
Changing the remote control battery
........................................................... 60
C

hanging the time

.............................. 44, 46, 49
Checking levels
...................................... 21

3 -215
Checking the engine oil level


........................................................ 213
Checks
...............

.................................... 2 07-218
Children
...............................

...149, 151, 155 -170
Child lock
...............................

........................170
Child seats

..............................
............15 6, 15 6,
160 -162, 169
Child seats, ISOFIX

...................................... 16

6
Cigarette lighter ............................................... 92
Closing the boot
.............................................. 63
Closing the doors


............................................ 62
Colour screen
....................... 2

50, 253, 290, 293
Connectors, audio
........................... 9

4, 278 -281,
304, 305, 328 -329
Controls for air conditioning


....................................... 82, 84
Coolant
...............................

.............................35
Coolant level


................................................. 214
Courtesy lamp, front


............................................................. 13 8
Courtesy lamp, rear
...................................... 13 9
Cruise control
................................................ 12

0
Cup holder

...............................
........................90
CV
t g

earbox

......................................... 10 5 , 217
Battery


................................................... 19 4, 216
Battery, charging


........................................... 19 6
Battery, remote control
............................. 6

0, 61
Bluetooth (telephone)


.................... 237, 288, 308
Bluetooth telephone with voice recognition


.......................... 2 37-24 8
Bonnet


........................................................... 207
Bonnet stay


................................................... 207
Boot


................................................................. 63
Boot lamp


...................................................... 140
Bottle holder


.................................................... 90
Brake discs
.................................................... 2

18
Brake lamps


.................................................. 18 6
Brake pads


.................................................... 218
Braking assistance system

......................................................... 142
Bulbs (changing, type)
........................... 18

2-187
B
.
Alphabetical index

338
4008_en_Chap11_index-alpha_ed01-2014
Seats, electric ................................................. 72
Seats, rear ....................................................... 75
Serial number, vehicle


......................................................... 235
Service indicator


............................................. 33
Servicing
...............................

..........................10
Setting the clock
................................ 44, 46, 48
Sidelamps


..................................... 182, 18 4, 18 6
Side repeater
..............................

..................185
Ski flap
..............................

..............................76
Snow chains
.................................................. 18

1
Spare wheel
...............................

...........114 , 17 6
Speedometer


.................................................. 12
Spotlamps, side


............................................ 185
Starting the vehicle


................................... 98, 99
Steering mounted controls, audio


............................ 251, 291, 314
Stopping the vehicle


.................................98, 99
Stop & Start system (Auto Stop
g
o
)
............................................ 111
St

orage

................................................ 76, 91, 96
Stowing rings


............................................ 96, 97
Sun visor


......................................................... 91
System, ABS
................................................. 142
System, audio-CD .................................. 311-333
System, audio-telematics
..................... 24

9 -288t CL ................................................................
14 4te
chnical data .......................................219 -232
te

lephone

............................................308, 309
te

lephone,with voice
recognition


...........................................2 37-24 8
te

mperature adjustment
...........................8

2, 84
te

mperature, coolant

......................................35
te

mporary puncture repair kit

......................171
th

ird brake lamp

...................................18 6, 187
thr

ee flashes function
(direction indicators)


...................................141
tM

C (
tr
affic info)
..........................................26

8
to

o l s

..............................................................175
to

tal distance recorder

...................................32
to

uch screen audio- CD system ...................289
tou

ch screen audio-telematic system

..........249
to

w b a r

...........................................................201
to

wed loads

...........................220-225, 227-232
to

wing another vehicle
.................................20

0
tP

(
tr
affic information)
.................2

74, 301, 320
tra

ction control (
tC
L)
...................................14

4
tr

affic information (
tM
C)
..............................26

8
tr

ajectory control systems ............................14 4
ty

re pressures

......................................114 , 2 3 5
ty

r e s

........................................................1 0 , 114
ty

re under-inflation detection

.................15 , 114
un

der-inflation (detection)
......................1

5 , 114
unl

ocking
..............................
....................52, 56
u

SB

..................94, 278 -281, 304-305, 328 -329
TU
Screen (audio equipment) .................44, 46, 48
Screen, instrument panel


....................................................... 19 - 31
Screen menu


........................................ 253, 294
Screenwash, front


......................................... 13 5
Screen-wash reservoir


.................................215
SD card
........................................ 265, 279, 280
Seat adjustment
...............................

.........71, 72
Seat back storage pockets
..............................

...........................95
Seat belts
............................................... 14

6 -149
Seat belts warning lamp


............................................................ 146
Repair kit, puncture


.......................................
171
Replacing bulbs

.....................................
182-187
Replacing fuses
..............................
.......
18 8 -19 3
Replacing the air filter

...................................
216
Replacing the oil filter
................................... 2
16
Replacing the passenger compartment filter

......................................
216
Replacing wiper blades .................................197
Rev counter

.....................................................
12
Reversing camera

.........................................
126
Reversing lamps

...................................
18 6, 187
Roof bars
....................................................... 20
3
Roof blind

........................................................
70
Routine checks

.....................................
216, 218
Running out of fuel (Diesel)
....................................................... 2
12
ta

ble of weights
.....................2

20-225, 227-232
tab

les of engines

..................................219, 226
ta

bles of fuses ..............................................188
S
Alphabetical index