2015 OPEL KARL brakes

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
18 In Brief
Starting the Engine
Check before starting off
.Tyre pressure and condition0
Tyre Pressure 0175.
. Engine oil level and fluid levels
0Engine Oil 0158.
. All windows, mirrors, exterior
lighting and number plates are
free from dirt, snow and ice and
are operational.
. Proper position of mirrors, seats,
and seat belts
0Convex
Mirrors 027, Seat Position 033,
Three-Point Seat belt 037.
. Brake function at low speed,
particularly if the brakes are wet.
Starting the engine
.
Turn key to position 1.
. Move the steering wheel slightly
to release the steering
wheel lock.
. Operate clutch and brake.
. Automatic transmission in P
or N.
. Do not operate accelerator
pedal.
. Turn key to position 3 and
release Starting the engine.
0
Starting the Engine 0136.
Stop-start system
If the vehicle is at a low speed or at
a standstill and certain conditions
are fulfilled, activate an Autostop as
follows:
.
depress the clutch pedal
. set the lever in neutral
. release the clutch pedal
An Autostop is indicated by the
needle at the AUTOSTOP position
in the tachometer.
To restart the engine, depress the
clutch pedal again.

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
80 Instruments and Controls
Vehicle Messages
Messages are indicated mainly in
the Driver Information Centre (DIC),
in some cases together with a
warning and signal buzzer.
PressSET/CLR, MENUor turn the
adjuster wheel to confirm a
message.
The vehicle messages are
displayed as code numbers.
No. Vehicle message
2 No remote detected, Press clutch
to restart
3 Coolant level low add coolant 4 A/C Off due to high engine temp
5 Steering column is locked
6 Step on brake to release park
brake
7 Turn steering wheel, Turn key Off,
Then On
8 Turn key Off, Then On
–repeat
breath test
9 Turn steering wheel, Start vehicle
again
11 Brakes worn
12 Vehicle overloaded
13 Compressor overheated
15 Check high mounted brake lamp
16 Check brake lamps
17 Headlight levelling malfunction
18 Left dipped beam failure
19 Check rear fog lamp
20 Check right dipped beam lamp
21 Check left position lamp
22 Check right position lamp
23 Reversing light failure
24 Number plate light failure 25 Check left front indicator lamp
26 Left rear turn indicator failure
27 Check right front indicator lamp
28 Check right rear indicator lamp
29 Check trailer brake lamp
30 Check trailer reversing lamp
31 Check left trailer indicator lamp
32 Check right trailer indicator lamp
33 Check trailer rear fog lamp
34 Check trailer rear lamp
35 Replace Battery In Remote Key
36 Stabilitrak Initialising
38 Take steering (text approval still
pending)
48 Side detection system
unavailable
49 Lane departure warning
unavailable
50 Reset bonnet
–see owner's
manual
52 Change timing belt
53 Tighten fuel cap / Electric
vehicles

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
134 Driving and Operating
Driving and
Operating
Driving Information
Control of a Vehicle . . . . . . . . . . . 134
Steering . . . . . . . . . . . . . . . . . . . . . . 135
Starting and Operating
New Vehicle Run-In . . . . . . . . . . 135
Ignition Positions . . . . . . . . . . . . . 135
Starting the Engine . . . . . . . . . . . 136
Retained AccessoryPower (RAP) . . . . . . . . . . . . . . . . 137
Automatic Engine Start/Stop Feature . . . . . . . . . . . . . . . . . . . . . 137
Parking . . . . . . . . . . . . . . . . . . . . . . . 139
Engine Exhaust
Engine Exhaust . . . . . . . . . . . . . . 140
Catalytic Converter . . . . . . . . . . . 140
Manual Gearbox
Manual Gearbox . . . . . . . . . . . . . . 141
Brakes
Brakes . . . . . . . . . . . . . . . . . . . . . . . 141
Antilock Brake System (ABS) . . . . . . . . . . . . . . . 142
Parking Brake . . . . . . . . . . . . . . . . 142
Brake Assist . . . . . . . . . . . . . . . . . . 143 Hill Start Assist (HSA) . . . . . . . . 143
Ride Control Systems
Traction Control
System (TCS) . . . . . . . . . . . . . . . 143
Electronic Stability Control (ESC) . . . . . . . . . . . . . . . 144
Object Detection Systems
Parking Assist . . . . . . . . . . . . . . . . 146
Driver Assistance Systems
Driver Assistance Systems . . . 148
Cruise Control . . . . . . . . . . . . . . . . 148
Speed Limiter . . . . . . . . . . . . . . . . . 149
Lane DepartureWarning (LDW) . . . . . . . . . . . . . 150
Fuel
Fuel (for Petrol Engines) . . . . . . 152
Filling the Tank . . . . . . . . . . . . . . . 152
Fuel Consumption -CO2-Emissions . . . . . . . . . . . . . 154
Driving Information
Control of a Vehicle
Never coast with engine not
running (except during
Autostop)
Many systems will not function in
this situation (e.g. brake servo unit,
power steering). Driving in this
manner is a danger to yourself and
others.
Idle boost
If charging of the vehicle battery is
required due to vehicle battery
condition, the power output of the
alternator must be increased. This
will be achieved by an idle boost
which may be audible.
Pedals
To ensure the pedal travel is
uninhibited, there must be no mats
in the area of the pedals.

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
Driving and Operating 141
Manual Gearbox
To engage reverse, depress the
clutch pedal and then engage the
reverse gear.
If the gear does not engage, set the
lever to neutral, release the clutch
pedal and depress again; then
repeat gear selection.
Do not slip the clutch unnecessarily.
When operating, depress the clutch
pedal completely. Do not use the
pedal as a foot rest.
Caution
It is not advisable to drive with the
hand resting on the selector lever.
Brakes
The brake system comprises two
independent brake circuits.
If a brake circuit fails, the vehicle
can still be braked using the other
brake circuit. However, braking
effect is achieved only when the
brake pedal is depressed firmly.
Considerably more force is needed
for this. The braking distance is
extended. Seek the assistance of a
workshop before continuing your
journey.
When the engine is not running, the
support of the brake servo unit
disappears once the brake pedal
has been depressed once or twice.
Braking effect is not reduced, but
braking requires significantly greater
force. It is especially important to
bear this in mind when being towed.
Control indicator
$0Brake and
Clutch System Warning Light 071.

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
Driving and Operating 143
Warning (Continued)
To reduce the operating forces of
the parking brake, depress the
foot brake at the same time.
See Brake and Clutch System
Warning Light 071.
Brake Assist
If the brake pedal is depressed
quickly and forcefully, maximum
brake force is automatically applied
(full braking).
Maintain continuous pressure on the
brake pedal for as long as full
braking is required. Maximum brake
force is automatically reduced when
the brake pedal is released.
Hill Start Assist (HSA)
The system helps prevent
unintended movement when driving
away on inclines.
When releasing the foot brake after
stopping on an incline, the brakes
remain on for a further two seconds. The brakes release automatically as
soon as the vehicle begins to
accelerate.
The hill start assist is not active
during an Autostop.
Ride Control Systems
Traction Control
System (TCS)
The Traction Control system (TC) is
a component of the Electronic
Stability Control system.
TC improves driving stability when
necessary, regardless of the tyre of
road surface or tyre grip, by
preventing the drive wheels from
spinning.
As soon as the drive wheels starts
to spin, engine output is reduced
and the wheel spinning the most is
braked individually. This
considerably improves the driving
stability of the vehicle on slippery
road surfaces.
TC is operational as soon as the
control indicator
Gextinguishes.
When TC is active
Gflashes.

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
Vehicle Care 155
Vehicle Care
General Information
Accessories andModifications . . . . . . . . . . . . . . . . 156
Vehicle Storage . . . . . . . . . . . . . . 156
End-of-Life Vehicle Recovery . . . . . . . . . . . . . . . . . . . . 157
Vehicle Checks
Doing Your OwnService Work . . . . . . . . . . . . . . . 157
Bonnet . . . . . . . . . . . . . . . . . . . . . . . 157
Engine Oil . . . . . . . . . . . . . . . . . . . . 158
Engine Coolant . . . . . . . . . . . . . . . 159
Washer Fluid . . . . . . . . . . . . . . . . . 160
Brakes . . . . . . . . . . . . . . . . . . . . . . . 160
Brake Fluid . . . . . . . . . . . . . . . . . . . 160
Battery . . . . . . . . . . . . . . . . . . . . . . . . 160
Wiper Blade Replacement . . . . 162
Bulb Replacement
Bulb Replacement . . . . . . . . . . . . 163
Headlamps and Parking Lamps . . . . . . . . . . . . . . . . . . . . . . 163
Fog Lamps . . . . . . . . . . . . . . . . . . . 165
Front Indicator Lamps . . . . . . . . 165
Taillights . . . . . . . . . . . . . . . . . . . . . . 165
Side Indicator Lamps . . . . . . . . . 167 Centre High-Mounted Brake
lamp (CHMBL) . . . . . . . . . . . . . . 167
Number Plate Lamp . . . . . . . . . . 168
Interior Lamps . . . . . . . . . . . . . . . . 168
Instrument Panel Illumination . . . . . . . . . . . . . . . . . . 168
Electrical System
Fuses . . . . . . . . . . . . . . . . . . . . . . . . 169
Engine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 170
Instrument Panel Fuse Block . . . . . . . . . . . . . . . . . . . . . . . . 172
Vehicle Tools
Tools . . . . . . . . . . . . . . . . . . . . . . . . . 173
Wheels and Tyres
Wheels and Tyres . . . . . . . . . . . . 174
Winter Tyres . . . . . . . . . . . . . . . . . . 174
Tyre Designations . . . . . . . . . . . . 174
Tyre Pressure . . . . . . . . . . . . . . . . 175
Tyre Pressure MonitorSystem . . . . . . . . . . . . . . . . . . . . . . 176
Tread Depth . . . . . . . . . . . . . . . . . . 179
Wheel Covers . . . . . . . . . . . . . . . . 180
Tyre Chains . . . . . . . . . . . . . . . . . . 180
Tyre Repair Kit . . . . . . . . . . . . . . . 180
Tyre Changing . . . . . . . . . . . . . . . . 184
Compact Spare Tyre . . . . . . . . . 186
Jump Starting
Jump Starting . . . . . . . . . . . . . . . . 188
Towing the Vehicle
Towing the Vehicle . . . . . . . . . . . 190
Appearance Care
Exterior Care . . . . . . . . . . . . . . . . . 191
Interior Care . . . . . . . . . . . . . . . . . . 192

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
160 Vehicle Care
checked and have the cause of the
coolant loss remedied by a
workshop.
Washer Fluid
Fill with clean water mixed with a
suitable quantity of washer fluid
which contains antifreeze.
Caution
Only washer fluid with a sufficient
antifreeze concentration provides
protection at low temperatures or
a sudden drop in temperature.(Continued)
Caution (Continued)
Use of washer fluid containing
isopropanol can damage exterior
lamps.
Brakes
In the event of minimum thickness
of the brake lining, a squealing
noise sounds during braking.
Continued driving is possible but
have the brake lining replaced as
soon as possible.
Once new brake linings are
installed, do not brake
unnecessarily hard for the first few
journeys.
Brake Fluid
{Warning
Brake fluid is poisonous and
corrosive. Avoid contact with
eyes, skin, fabrics and painted
surfaces.
The brake fluid level must be
between theMINand the MAX
marks.
If fluid level is below the MINmark,
seek the assistance of a workshop.
Brake and clutch fluid
0
Recommended Fluids and
Lubricants 0195.
Battery
Vehicles without stop-start system
will be equipped with a lead acid
battery. Vehicles with stop-start
system will be equipped with an
AGM battery which is not a lead
acid battery.

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
208 Index
IndexA
Accessories andModifications . . . . . . . . . . . . . . . . . . 156
Accessory Power . . . . . . . . . . . . . . . 137
Adjustable Air Vents . . . . . . . . . . . . 131
Adjustments Seat, Initial Drive . . . . . . . . . . . . . . . 33
Air Conditioning . . . . . . . . . . . . . . . . 126
Air Conditioning Regular Operation . . . . . . . . . . . . . . . . . . . . . 132
Air Filter, Passenger Compartment . . . . . . . . . . . . . . . . . 132
Air Intake . . . . . . . . . . . . . . . . . . . . . . . 132
Airbags Curtain . . . . . . . . . . . . . . . . . . . . . . . . . 43
Front . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Light On-Off . . . . . . . . . . . . . . . . . . . . 70
On-Off Light . . . . . . . . . . . . . . . . . . . . 70
On-Off Switch . . . . . . . . . . . . . . . . . . 43
Safety Belt Tensioner Light . . . . . 70
Side . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
System Check . . . . . . . . . . . . . . . . . . 38
Alarm System Anti-theft . . . . . . . . . . . . . . . . . . . . . . . . 26
AM-FM Radio . . . . . . . . . . . . . . . . . . . 102
Anti-theft Alarm System . . . . . . . . . . . . . . . . . . 26
Antilock Brake System (ABS) . . . 142 Antilock Brake System
(ABS) (cont'd)
Warning Light . . . . . . . . . . . . . . . . . . . 71
Appearance Care
Exterior . . . . . . . . . . . . . . . . . . . . . . . 191
Interior . . . . . . . . . . . . . . . . . . . . . . . . 192
Audio System Theft-Deterrent Feature . . . . . . . . . 92
Auto Stop Mode . . . . . . . . . . . . . . . . . 74
Automatic
Engine Start/Stop Feature . . . . 137
Auxiliary Devices . . . . . . . . . . . . . . . . . . . . . . . 108
B
Battery . . . . . . . . . . . . . . . . . . . . . . . . . 160
Jump Starting . . . . . . . . . . . . . . . . . 188
Power Protection . . . . . . . . . . . . . . . 91
Blade Replacement, Wiper . . . . . 162
Bluetooth
Overview . . . . . . . . . . . . . . . . . . . . . .116
Bonnet . . . . . . . . . . . . . . . . . . . . . . . . . 157
Bonnet Ajar Light . . . . . . . . . . . . . . . . 74
Brakes . . . . . . . . . . . . . . . . . . . . . 141, 160 Antilock . . . . . . . . . . . . . . . . . . . . . . . 142
Assist . . . . . . . . . . . . . . . . . . . . . . . . . 143
Brake and Clutch SystemWarning Light . . . . . . . . . . . . . . . . . 71
Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 160