2015 Lancia Delta maintenance

ENGINE COOLANT B - Fig. 1
The coolant level must be checked when the engine is cold
and must range between the MIN and MAX marks on the
reservoir. If the level is low, slowly pour a mixture of 50%
demineralised water and 50% PARAFLU
UPof
PETRONAS LUBRICANTS through the filler neck until
the level reaches MAX.
The mixture of 50% PARAFLU
UPand 50% distilled wa-
ter protects against freezing down to temperatures of
–35°C. For particularly harsh climate conditions, we rec-
ommend using a mixture of 60% PARAFLU
UPand 40%
distilled water.
PA R A F L UUPanti-freeze is used in the engine
cooling system. Use the same fluid as in the
cooling system when topping up. PARAFLU-
UPcannot be mixed with any other type of fluid. If
this occurs, do not start the engine and contact your
Lancia Dealership immediately.
The cooling system is pressurised. If nec-
essary, only replace the plug with another
original one or the operation of the system
may be adversely affected. Do not remove the cap
from the reservoir when the engine is hot: danger
of scalding.
MAINTENANCE AND CARE241
233-256 Delta GB 1ed 03/04/14 13:27 Pagina 241

WINDSCREEN/REAR WINDOW WASHER FLUID
C - fig. 1
Remove the cap, operating on the special tab, to add fluid.
Use a mixture of water and TUTELA PROFESSIONAL
SC35 fluid, in the following concentrations:
❍30% TUTELA PROFESSIONAL SC35 and 70% wa-
ter in summer.
❍ 50% TUTELA PROFESSIONAL SC35 and 50% wa-
ter in winter.
In case of temperatures below –20°C, use undiluted
TUTELA PROFESSIONAL SC35 fluid.
Check fluid level through the reservoir.
Close the plug by pressing the centre section.
Do not travel with the windscreen washer
fluid reservoir empty: the windscreen wash-
er is essential for improving visibility.
Some commercial windscreen washer additives are
flammable. The engine compartment contains hot
parts which could cause a fire if they come into con-
tact with these additives.
BRAKE FLUID D - Fig. 1
Undo the plug and check that the liquid contained in the
reservoir is at the maximum level. The fluid level in the
reservoir must not exceed the MAX mark. If you need to
top up, you should use the brake fluid shown in the “Flu-
ids and lubricants” table (see chapter “6”).
NOTE Carefully clean the plug of the reservoir and the
surrounding surface.
Take great care to ensure that impurities do not enter the
reservoir when the plug is opened.
For topping-up, always use a funnel with integrated filter
with mesh equal to or lower than 0.12 mm.
IMPORTANT Brake fluid is hygroscopic (i.e. it absorbs
moisture). For this reason, if the car is mainly used in ar-
eas with a high degree of atmospheric humidity, the flu-
id should be replaced at more frequent intervals than spec-
ified in the “Scheduled Servicing Plan”.
242MAINTENANCE AND CARE
233-256 Delta GB 1ed 03/04/14 13:27 Pagina 242

Prevent brake fluid which is highly corrosive
from coming into contact with painted parts.
Should this occur, immediately wash with
water.
Brake fluid is poisonous and highly corro-
sive. In the event of accidental contact, im-
mediately wash the affected parts with wa-
ter and mild soap. Then rinse thoroughly. In case of
swallowing immediately call a doctor.
The πsymbol, on the container, indicates a
synthetic brake fluid, which is different from
a mineral fluid. Use of a mineral type fluid
will damage the special rubber seals of the braking
system beyond repair.
AIR CLEANER/POLLEN
FILTER/DIESEL FILTER
For filter replacement, contact a Lancia Dealership.
MAINTENANCE AND CARE243
233-256 Delta GB 1ed 03/04/14 13:27 Pagina 243

REPLACING THE BATTERY
If required, replace the battery with a genuine spare part
with the same specifications.
If a battery with different specifications is fitted, the ser-
vice intervals given in the “Scheduled Servicing Plan” will
no longer be valid.
Follow the battery manufacturer’s instructions for main-
tenance.
Advanced ESP system
If the battery is disconnected, the áwarning light will
switch on (together with a message in the display) to in-
dicate that the system must be realigned. To switch the
warning light off, carry out the following initialisation pro-
cedure:
❍ turn the ignition key to MAR:
❍ turn the steering wheel fully both clockwise and anti-
clockwise (to move from the position with the wheels
straight);
❍ turn the ignition key to STOP and then to MAR.
If the á warning light does not go out after a few seconds,
go to a Lancia Dealership.
244
MAINTENANCE AND CARE
Battery fluid is poisonous and corrosive.
Avoid contact with skin and eyes. Keep naked
flames or possible sources of sparks away
from the battery: risk of explosion or fire.
Using the battery when the fluid is too low
can damage it irreparably and generate a
risk of explosion.
BATTERY
The car is fitted with a low-maintenance battery F - fig.
1: no electrolyte top-ups with distilled water are needed
in standard conditions of use.
It does need to be checked regularly at a Lancia Dealer-
ship or by specialised personnel to make sure that it is
working properly.
233-256 Delta GB 1ed 03/04/14 13:27 Pagina 244

MAINTENANCE AND CARE245
5
Incorrect installation of electric and elec-
tronic devices may cause severe damage to
your car. Go to a Lancia Dealership if you
want to install accessories (anti-theft system, ra-
dio phone, etc.): they will suggest the most suitable
devices and advise you if a higher capacity battery
needs to be installed.
Batteries contain substances that can be very
dangerous for the environment. It is advis-
able to have the battery changed by a Lancia
Dealership where it will be disposed of according
to the law.
If the vehicle must remain unused for a long
time at very low temperature, remove the bat-
tery and carry it to a warm place, in order to
avoid freezing.
When you must perform any operation on the
battery or near it, always protect your eyes
with special goggles.
233-256 Delta GB 1ed 03/04/14 13:28 Pagina 245

246MAINTENANCE AND CARE
USEFUL ADVICE FOR EXTENDING THE LIFE OF
YOUR BATTERY
To avoid draining your battery and make it last longer,
observe the following instructions:
❍when you park the car, ensure the doors, tailgate and
bonnet are closed properly, to prevent any light from
remaining on inside the passenger compartment;
❍ turn off the internal roof lights, although the car does
have an automatic system for switching off internal
lights;
❍ do not leave devices (e.g. car radio, hazard warning
lights, etc.) switched on for a long time when the en-
gine is not running;
❍ before performing any operation on the electrical sys-
tem, disconnect the negative battery cable;
❍ battery terminals should always be perfectly tightened.
IMPORTANT If the charge level remains under 50% for
a long time, the battery is damaged by sulphation, re-
ducing its capacity and efficiency at start-up. The battery will also be more at risk of freezing (this can
happen as early as –10°C). In case of prolonged idling, re-
fer to the “Car inactivity” paragraph, in chapter “3”.
If, after purchasing your car, you decide to install electri-
cal accessories which require a permanent electric power
supply (alarm, etc.) or accessories which have a serious
impact on the electrical balance, contact a Lancia Deal-
ership: their qualified personnel will suggest the most suit-
able Lancia Lineaccessori devices and assess the overall
electric consumption, checking whether the car’s electri-
cal system can cope or whether a more powerful battery
is required.
Since some of these devices continue to consume electric-
ity even when the engine is off, they gradually run down
the battery.
233-256 Delta GB 1ed 03/04/14 13:28 Pagina 246

WHEELS AND TYRES
Check the pressure of each tyre, including the space-saver
wheel, approximately every two weeks and before long
journeys: the pressure should be checked with the tyre rest-
ed and cold.
It is normal for the pressure to increase as the car is used;
see the “Wheels” paragraph in chapter “6” for the correct
tyre inflation pressure.
Incorrect pressure causes abnormal tyre wear fig. 2:
A normal pressure: tread evenly worn.
B low pressure: tread particularly worn at the edges.
C high pressure: tread particularly worn in the centre.
The tyres must be replaced when the tread is less than 1.6
mm thick. In any case, follow the laws in force in the coun-
try you are in.
fig. 2L0E0096m
IMPORTANT
❍Where possible, avoid braking suddenly, wheel-spin-
ning and crashing into curbs, potholes or other ob-
stacles. Driving for long stretches over bumpy roads
can damage the tyres;
❍ check the tyres regularly for cuts on the sides, swellings
or irregular tread wear. Go to a Lancia Dealership if
required.
❍ avoid overloading the car when travelling: this may
cause serious damage to the wheels and tyres;
❍ if a tyre is punctured, stop immediately and change it
to avoid damage to the tyre, wheel rim, suspension and
steering system;
❍ the tyre ages even if rarely used. Cracks in the tread and
on the side walls are a sign of ageing. Have the tyres
checked by specialised personnel if they have been fit-
ted for longer than 6 years. Remember to check the
space-saver wheel very carefully;
❍ when replacing the tyres, always fit new tyres, avoid-
ing those of dubious origin;
MAINTENANCE AND CARE247
233-256 Delta GB 1ed 03/04/14 13:28 Pagina 247

248MAINTENANCE AND CARE
❍if a tyre is replaced, you should also change the infla-
tion valve;
❍ to allow even wear between the front and rear tyres,
it is advisable to change them over every 10-15 thou-
sand kilometres, keeping them on the same side of the
car so as not to reverse the direction of rotation.
Remember that the road holding qualities of
your car also depend on the correct inflation
pressure of the tyres.
If the pressure is too low the tyre will get
overheated, with the risk of serious damage
to the tyre.
Avoid moving the tyres from the right side of
the vehicle to the left side and vice versa.
Do not repaint alloy wheel rims at temper-
atures higher than 150°C. The mechanical
specifications of the wheels might be ad-
versely affected.
233-256 Delta GB 1ed 03/04/14 13:28 Pagina 248