2015 FORD F750 catalytic converter

High Beam
It illuminates when you turn on the headlamp high beam.
Low Fuel Level (gasoline engine only)
It illuminates when the fuel level is low or near empty. Refuel
as soon as possible.
Parking Brake Warning
It momentarily illuminates when you turn the ignition to the on
position (with the engine off). It also illuminates when you
apply the parking brake. If the parking brake warning lamp
does not illuminate at these times, seek service immediately.
Vehicles equipped with the Power Park Parking Brake option: If the park
brake warning lamp begins to blink after setting the parking brake on
your vehicle, this may indicate a failure in the parking brake system.
Seek service from an authorized dealer immediately.
Powertrain Malfunction/Reduced Power/Electronic Throttle
Control (gasoline engine only)
It illuminates when a powertrain fault exists. Contact an
authorized dealer as soon as possible.
Service Engine Soon
It illuminates when you turn the ignition to the on position to
check the bulb and to indicate whether the vehicle is ready for
Inspection/Maintenance (I/M) testing.
Solid illumination after you start the engine indicates the on-board
diagnostics (OBD-II) system has detected a malfunction.
WARNING:Under engine misfire conditions, excessive exhaust
temperatures could damage the catalytic converter, the fuel
system, interior floor coverings or other vehicle components, possibly
causing a fire.
P
70Instrument Cluster
2015 F-650/750(f67)
Owners Guide gf(ownloose), 1st Printing, December 2013
Canadian_French(fr_can)

•Checking that the pitman arm (steering arm at steering gear)
mounting is tight and locked. Check system for leaks or hose chafing.
Repair immediately, if necessary.
•Maintaining proper steering gear and power steering pump lubricant
levels.
•Checking steering column joint bolts and steering linkage, particularly
for body-to-chassis clearance.
Steering Column Joint Bolts
As a good maintenance practice, check steering column joint bolt
tightness every 60000 miles (96000 kilometers) or annually, whichever
occurs first. Do not overtighten the bolts.
Hydraulic System
Whenever draining and refilling the power steering’s hydraulic system for
any reason, bleed air from the system before returning the vehicle to
service. Failure to bleed the hydraulic system properly can result in
degradation of power system performance.
Consult an authorized dealer who is aware of the proper procedures for
filling and bleeding the system.
Catalytic Converter (Diesel Engine)
Note:If your vehicle is equipped with a catalytic converter or muffler,
do not blend waste oil with diesel fuel. Operate only on ultra-low sulfur
(less than 15 parts per million sulfur) diesel fuel with a cetane value of
45 or higher.
If your diesel engine is equipped with a catalytic converter, it is
important to review the maintenance schedule to make sure proper
functioning of the catalytic converter. Also, take precautions not to
damage the catalytic converter when servicing your engine or storing
your vehicle.
Diesel Exhaust Fluid (DEF), Diesel Particulate Filter (DPF) and
Select Catalyst Reduction (SCR) System
See your engine operator’s manual for information about DEF, DPF and
SCR system service
Air Induction System
WARNING:When performing maintenance to any turbocharged
engine with engine air inlet piping disconnected, keep loose
clothing, jewelry and long hair away from the engine air inlet piping. A
turbocharger compressor air inlet protective shield should be installed
over the turbocharger air inlet to reduce the risk of personal injury or
death.
Maintenance205
2015 F-650/750(f67)
Owners Guide gf(ownloose), 1st Printing, December 2013
Canadian_French(fr_can)

Vehicles equipped with a diesel engine cannot use diesel fuel blended
with waste oil if equipped with a catalytic converter-muffler. Waste lube
oil blending in fuel plugs the catalytic converter-muffler, resulting in a
significant loss of engine power.
Noise Emissions Warranty, Prohibited Tampering Acts and
Maintenance
On January 1, 1978, Federal regulations became effective governing the
noise emissions on trucks over 10000 pounds (4536 kilograms) GVWR.
The following statements concerning prohibited tampering acts and
maintenance and the noise warranty are found in the warranty
information, and are applicable to completed trucks.
Tampering with Noise Control System Prohibited
Federal law prohibits the following acts or the causing thereof: (1) The
removal or rendering inoperative, by any person other than for purposes
of maintenance, repair or replacement, of any device or element of
design incorporated into any new vehicle for the purpose of noise control
prior to its sale or delivery to the ultimate purchaser or while it is in use,
or (2) the use of the vehicle after such device or element of design has
been removed or rendered inoperative by any person.
Among those acts presumed to constitute tampering are the following
acts listed:
Vehicle System Acts
Acoustical shielding Removal of noise shields, hood blanket, tunnel
liner or acoustical absorptive material.
Engine Removal or rendering inoperative the engine
speed governor to allow engine speed to exceed
manufacturer specifications. Removal of engine
mounted noise shield or oil pan enclosure.
Engine air induction Removal of the air duct, silencer, air cleaner,
and/or air cleaner element and baffle in air
cleaner; re-indexing of air cleaner.
346Scheduled Maintenance
2015 F-650/750(f67)
Owners Guide gf(ownloose), 1st Printing, December 2013
Canadian_French(fr_can)

Vehicle System Acts
Exhaust Removal or rendering inoperative exhaust system
components including the catalytic converter -
muffler assembly, inlet pipe, outlet pipe,
resonator and flex pipe. Rotation of horizontal
exhaust system directional outlet pipe to cause
the exhaust to be emitted in a direction other
than the orientation your vehicle was originally
produced with.
Engine cooling Removal or rendering inoperative the fan clutch.
Removal or modification of the fan shroud.
Replacing a fixed fan with a fan of increased
diameter, different number of blades or different
pitch width.
DEF (Diesel
exhaust fluid)Removal or rendering inoperative DEF system
components including the DEF tank, dosing
module, dosing supply module, dosing control
unit, NOx electronic module or NOx sensor.
Emissions Control System(s) Laws
Federal law prohibits vehicle manufacturers, dealers and other persons
engaged in the business of repairing, servicing, selling, leasing or trading
motor vehicles, as well as fleet operators from knowingly removing or
rendering an emissions control device or system inoperative. Further,
modifications of the emissions control system(s) could create liability on
the part of individual owners under the laws of some states. In Canada,
modification of the emissions control system could create liability under
applicable Federal or Provincial laws.
Maintenance
Instructions for maintenance and service of the noise control system
have been included in the required maintenance services and in the
general maintenance section. To further help minimize noise emissions
degradation throughout the life of your vehicle, Ford Motor Company
recommends that you operate this vehicle in the manner described
within this owner’s manual. Caution should be exercised by the owner
when installing replacement parts to be sure that a tampering act (as
outlined above) is not committed. Note any inspection and service
performed in the maintenance log.
Scheduled Maintenance347
2015 F-650/750(f67)
Owners Guide gf(ownloose), 1st Printing, December 2013
Canadian_French(fr_can)

911 Assist™ ..............................308
A
ABS (see Brakes) .....................139
Accessing call history/phone
book during active call .............294
Accessing your media menu
features ......................................318
Accessing your phone menu
features ......................................296
Active call menu options .........294
Advanced menu options ...304, 324
Advanced menu options
(prompts, languages, defaults,
master reset, installing
applications) ..............................304
Air cleaner filter ...............228, 272
Air conditioning ..........................76
manual heating and air
conditioning system .................76
Air filter .............................228, 272
Air suspension ...........................162
Antifreeze (see Engine
coolant) .....................................212
Anti-lock brake system (see
Brakes) ......................................139
AppLink™ .................................313
Audio system
Single CD ........................277–278
Audio system
(see Radio) ........................277–278
Automatic transmission ....126, 128
fluid, adding ............................215
fluid, checking ........................215
fluid, refill capacities ..............268
fluid, specification ..................255Auxiliary input jack (Line in) ..280
Auxiliary powerpoint ..................91
Axle ............................134, 200, 219
lubricant specifications ..........255
refill capacities ........................268
B
Battery .......................................224
acid, treating emergencies .....224
jumping a disabled battery ....178
maintenance-free ....................224
replacement, specifications ...272
servicing ..................................224
Booster seats ...............................28
Brakelamp
bulb replacement ....................231
Brakes ........................138–139, 200
adjustment ..............................203
anti-lock ...................................139
anti-lock brake system (ABS)
warning light ...........................139
brake warning light ................139
fluid, checking and adding ....220
fluid, specifications .................255
parking ....................148, 152, 204
shift interlock ..........................127
trailer .......................................169
Bulbs ..........................................233
C
Catalytic converter (see
Emission control) .....................205
CD ......................................277–278
CD player ..................................275
Cell phone use ............................11
Child safety seats
attaching with tether straps ....36
378Index
2015 F-650/750(f67)
Owners Guide gf(ownloose), 1st Printing, December 2013
Canadian_French(fr_can)

in front seat ..............................33
in rear seat ................................33
LATCH .......................................36
Child safety seats - booster
seats .............................................28
Cleaning your vehicle ...............234
engine compartment ..............237
exterior ....................................234
instrument panel ....................238
interior .....................................238
plastic parts ............................236
washing ....................................234
waxing .....................................236
wheels ......................................239
wiper blades ............................237
Climate control (see Air
conditioning or Heating) ............76
Clock ..................................277–278
Clutch ................................123, 221
adjusting ..................................222
fluid ..........................................221
specifications ..........................255
Coolant ......................................212
checking and adding ......211–212
refill capacities ........................268
specifications ..........................255
Customer Assistance ................177
Getting assistance outside the
U.S. and Canada .....................184
Getting roadside assistance ...177
Getting the service you
need .................................182, 197
Ordering additional owner’s
literature .................................185
Utilizing the
Mediation/Arbitration
Program ...................................184D
Daytime running lamps (see
Lamps) .........................................56
Defrost .........................................76
Diesel exhaust fluid (DEF) .....110
Diesel Particulate Filter
(DPF) ..........................................96
Dipstick
automatic transmission
fluid ..........................................215
engine oil .................................210
Doors
lubricant specifications ..........255
Drivebelt ....................................254
Driving under special
conditions
through water .........................176
E
Electronic message center .........73
Emergencies, roadside
jump-starting ..........................178
running out of fuel .................106
Emergency Flashers .................178
Emission control system ..121, 345
catalytic converter ..................205
End user license agreement ....332
Engine ........................................254
cleaning ...................................237
coolant .....................................212
fail-safe cooling .......................214
lubrication specifications .......255
Engine block heater .................100
Engine fan .................................211
Index379
2015 F-650/750(f67)
Owners Guide gf(ownloose), 1st Printing, December 2013
Canadian_French(fr_can)