2015 FORD F450 hood open

3.
Add only enough fluid through the filler
opening so that the fluid level is at the
bottom of the opening.
Only use fluid that meets Ford
specifications. See Capacities and
Specifications (page 301).
BRAKE FLUID CHECK
Fluid levels between the
MIN and MAX
lines are within the normal operating range;
there is no need to add fluid. If the fluid
levels are outside of the normal operating
range, the performance of the system
could be compromised; seek service from
your authorized dealer immediately.
POWER STEERING FLUID
CHECK
Check the power steering fluid. See
Scheduled Maintenance
(page 457). If
adding fluid is necessary, use only
MERCON LV ATF
Note: This procedure is for vehicles with
gasoline engines. Vehicles with diesel
engines are similar. See Under Hood
Overview in your diesel supplement.
Check the fluid level when it is at ambient
temperature.
1. Check the fluid level in the reservoir. It should be between the MIN and MAX
range. Do not add fluid if the level is
within this range.
2. If the fluid level is low, add fluid to bring
the fluid level up to between the MIN
and MAX range.
3. Switch the engine on.
4. While the engine idles, turn the steering
wheel left and right several times.
5. Switch the engine off. 6. Recheck the fluid level in the reservoir.
Do not add fluid if the level is between
the MIN and MAX range.
7. If the fluid is low, add fluid in small amounts, continuously checking the
level until it is between the MIN and
MAX range. For proper fluid type, See
Capacities and Specifications (page
301). Be sure to put the cap back on the
reservoir.
WASHER FLUID CHECK WARNING
If you operate your vehicle in
temperatures below 40°F (5°C), use
washer fluid with antifreeze
protection. Failure to use washer fluid with
antifreeze protection in cold weather could
result in impaired windshield vision and
increase the risk of injury or accident. Add fluid to fill the reservoir if the level is
low. Only use a washer fluid that meets
Ford specifications. See
Capacities and
Specifications (page 301).
State or local regulations on volatile
organic compounds may restrict the use
of methanol, a common windshield washer
antifreeze additive. Washer fluids
containing non-methanol antifreeze
agents should be used only if they provide
cold weather protection without damaging
the vehicle ’s paint finish, wiper blades or
washer system.
FUEL FILTER
Your vehicle is equipped with a lifetime
fuel filter that is integrated with the fuel
tank. Regular maintenance or replacement
is not needed.
243
Super Duty (), enUSA Maintenance

Headlamp Aiming Target
8 feet (2.4 meters)
A
Center height of lamp to ground
B
25 feet (7.6 meters)
C
Horizontal reference line
D
Vertical Aim Adjustment Procedure
1. Park the vehicle directly in front of a wall or screen on a level surface,
approximately 25 feet (7.6 meters)
away.
2. Measure the height of the headlamp bulb center from the ground and mark
an 8 foot (2.4 meter) horizontal
reference line on the vertical wall or
screen at this height.
Note: To see a clearer light pattern for
adjusting, you may want to block the light
from one headlamp while adjusting the
other.
3. Turn on the low beam headlamps to illuminate the wall or screen and open
the hood. 4. On the wall or screen you will observe
a flat zone of high intensity light
located at the top of the right hand
portion of the beam pattern. If the top
edge of the high intensity light zone is
not at the horizontal reference line, the
headlamp will need to be adjusted. 5. Locate the vertical adjuster on each
headlamp. Using a Phillips #2
screwdriver, turn the adjuster either
clockwise or counterclockwise in order
to adjust the vertical aim of the
headlamp.
6. Repeat steps 3 thru 5 to adjust the other headlamp.
7. Close the hood and turn off the lamps.
Horizontal Aim Adjustment
Horizontal aim is not required for this
vehicle and is not adjustable.
247
Super Duty (), enUSA MaintenanceE142592 E142465 E163806

REMOVING A HEADLAMP
WARNING
Handle a halogen headlamp bulb
carefully and keep out of children
’s
reach. Grasp the bulb only by its
plastic base and do not touch the glass.
The oil from your hand could cause the
bulb to break the next time the headlamps
are operated. Note:
If the bulb is accidentally touched, it
should be cleaned with rubbing alcohol
before being used.
Note: This procedure is for replacing the
headlamps, park lamps or turn lamps.
1. Make sure the headlamp control is in the Off position and open the hood. 1.
Using masking tape or a marker, make
an alignment mark between one of the
grille brackets and the vehicle radiator
support to ensure correct grille
alignment during the installation
procedure. Do not scratch the black
coating from the radiator support.
2. Remove the two grille to headlamp assembly push pins and the four bolts
attaching the top of the grille to the
radiator support.
3. Pull the top of the grille forward to gain
access to the lower grille spring clips.
4. Depress the spring clips through the lower inner grille access openings using
a flat head screwdriver.
5. Pull the grill straight out to remove. 6. Remove the four bolts from the
headlamp assembly.
7. Pull the assembly straight out disengaging one snap clip from the
fender.
8. Disconnect the electrical connector by
squeezing the release tab and pushing
the connector forward, then pulling it
rearward.
248
Super Duty (), enUSA MaintenanceE163821 E163822

4
4WD
See: Four-Wheel Drive...................................... 153
A
A/C See: Climate Control......................................... 106
About This Manual...........................................7
Protecting the Environment................................ 7
ABS See: Brakes........................................................... 164
ABS driving hints See: Hints on Driving With Anti-Lock
Brakes................................................................ 164
Accessories....................................................429 Exterior style........................................................ 429
Interior style......................................................... 429
Lifestyle................................................................. 429
Peace of mind..................................................... 429
Accessories See: Replacement Parts
Recommendation............................................ 12
Adjusting the Headlamps........................246 Horizontal Aim Adjustment............................ 247
Vertical Aim Adjustment................................ 246
Adjusting the Pedals.....................................65
Adjusting the Steering Wheel....................62
Airbag Disposal
..............................................46
Air Conditioning See: Climate Control......................................... 106
Alarm See: Anti-Theft Alarm......................................... 61
Anti-Theft Alarm
.............................................61
Arming the Alarm.................................................. 61
Disarming the Alarm............................................ 61
Appendices....................................................433
Audible Warnings and Indicators.............82 Headlamps On Warning Chime...................... 82
Key in Ignition Warning Chime........................ 82
Parking Brake On Warning Chime.................. 83
Audio Control
...................................................62
Media........................................................................\
63
Seek, Next or Previous........................................ 63
Audio Input Jack............................................321
Audio System.................................................310 General Information.......................................... 310Audio Unit - Vehicles With: AM/FM/CD/
SYNC..............................................................312
Audio Unit - Vehicles With: AM/FM........311
Audio Unit - Vehicles With: Sony AM/ FM/CD............................................................315
Autolamps........................................................67 Autolamps - Programmable Exit
Delay
.................................................................... 68
Automatic Climate Control.......................107
Automatic Transmission............................147 Brake-Shift Interlock.......................................... 151
If Your Vehicle Gets Stuck In Mud or Snow................................................................... 152
Understanding the Shift Positions of a 6– Speed Automatic Transmission........148
Understanding the Shift Positions of the 5– Speed Automatic Transmission..........147
Understanding your SelectShift Automatic ™ transmission......................... 149
Automatic Transmission Fluid Check............................................................240
Checking Automatic Transmission Fluid................................................................... 240
Auxiliary Power Points................................132 110 Volt AC Power Points................................. 132
12 Volt DC Power Point..................................... 132
Locations................................................................ 132
Auxiliary Switches.......................................430
B
Bonnet Lock See: Opening and Closing the Hood...........232
Booster Seats..................................................24 Types of Booster Seats...................................... 25
Brake Fluid Check........................................243
Brakes
...............................................................164
General Information.......................................... 164
Breaking-In.....................................................207
Bulb Specification Chart............................251
C
California Proposition 65..............................11
Capacities and Specifications
.................301
Technical Specifications................................. 305
Car Wash See: Cleaning the Exterior.............................. 255
473
Super Duty (), enUSA Index

Fuel and Refueling.......................................139
Fuel Consumption........................................143
Calculating Fuel Economy.............................. 143
Filling the Tank..................................................... 143
Fuel Filter........................................................243
Fuel Quality....................................................140 Choosing the Right Fuel.................................. 140
Choosing the Right Fuel With a Flex Fuel Vehicle (If Equipped)................................... 140
Diesel Engine....................................................... 140
Octane Recommendations............................ 140
Fuel Shutoff
....................................................213
Fuses.................................................................223
Fuse Specification Chart...........................223 Passenger Compartment Fuse
Panel
.................................................................. 228
Power Distribution Box.................................... 223
G
Garage Door Opener See: Universal Garage Door Opener............124
Gauges................................................................77 Engine Coolant Temperature Gauge............78
Engine Oil Pressure Gauge................................ 78
Fuel Gauge.............................................................. 78
Information Display............................................. 79
Transmission Fluid Temperature Gauge................................................................... 78
General Information on Radio Frequencies...................................................47
General Maintenance Information........457 Multi-point Inspection..................................... 459
Owner Checks and Services......................... 458
Protecting Your Investment........................... 457
Why Maintain Your Vehicle?.......................... 457
Why Maintain Your Vehicle at Your Dealership?..................................................... 457
Getting Assistance Outside the U.S. and Canada.........................................................220
Getting the Services You Need................217 Away From Home............................................... 217
Global Opening
...............................................72
Opening the Windows........................................ 72H
Handbrake
See: Parking Brake............................................. 165
Hazard Warning Flashers
...........................213
HDC See: Using Hill Descent Control..................... 172
Head Restraints..............................................113 Adjusting the Head Restraint.......................... 114
Heated Seats
..................................................119
Rear Heated Seats ............................................ 120
Heated Steering Wheel
...............................64
Heated Windows and Mirrors....................111 Heated Exterior Mirror......................................... 111
Heated Rear Window.......................................... 111
Heating See: Climate Control......................................... 106
Hill Start Assist
..............................................165
Switching the System On and Off...............166
Using Hill Start Assist....................................... 165
Hints on Controlling the Interior Climate..........................................................109
Cooling the Interior Quickly............................. 110
General Hints....................................................... 109
Heating the Interior Quickly............................ 109
Recommended Settings for Cooling ..........110
Recommended Settings for Heating...........110
Side Window Defogging in Cold Weather............................................................... 111
Hints on Driving With Anti-Lock Brakes............................................................164
Hood Lock See: Opening and Closing the Hood...........232
I
Ignition Switch
...............................................135
In California (U.S. Only).............................218
Information Display Control.......................63 Type 1........................................................................\
63
Type 2....................................................................... 64
Information Displays
....................................84
General Information........................................... 84
476
Super Duty (), enUSA Index

Manual Seats..................................................115
Manual Lumbar ................................................... 116
Moving the Seat Backward and Forward.............................................................. 115
Recline Adjustment............................................ 115
Media Hub......................................................322
Memory Function
..........................................116
Easy Entry and Exit Feature.............................. 117
Message Center See: Information Displays................................. 84
Mirrors See: Heated Windows and Mirrors.................111
See: Windows and Mirrors................................. 71
Mobile Communications Equipment.......13
Moonroof...........................................................75 Bounce-Back.......................................................... 76
Opening and Closing the Moonroof..............75
Venting the Moonroof......................................... 76
Motorcraft Parts..........................................302
MyFord Touch ™
...........................................362
General Information......................................... 362
MyFord Touch ™ Troubleshooting.........422
MyKey Troubleshooting...............................55
MyKey ™..............................................................51
Principle of Operation.......................................... 51
N
Navigation.......................................................414 cityseekr................................................................. 416
Map Mode............................................................. 418
Navigation Map Updates............................... 420
Navigation Voice Commands....................... 420
Point of Interest (POI) Categories...............415
Quick-touch Buttons....................................... 420
Setting a Destination........................................ 414
Setting Your Navigation Preferences...........417
Normal Scheduled Maintenance
..........460
6.2L and 6.8L Gasoline Engines.................. 460
6.7L Diesel Engine.............................................. 461
O
Oil Check See: Engine Oil Check...................................... 235
Opening and Closing the Hood..............232 Ordering Additional Owner's
Literature.......................................................221
Obtaining a French Owner ’s Manual...........221
Overhead Console........................................134
P
Parking Aid
.......................................................174
Rear Sensing System......................................... 174
Parking Aids
.....................................................174
Parking Brake.................................................165
Passive Anti-Theft System........................60
SecuriLock ™......................................................... 60
PATS See: Passive Anti-Theft System.................... 60
Pedals.................................................................65
Perchlorate.........................................................11
Phone
..............................................................396
Making Calls........................................................ 398
Pairing Subsequent Phones.......................... 398
Pairing Your Phone for the First Time........397
Phone Menu Options....................................... 398
Phone Settings.................................................. 400
Phone Voice Commands................................ 401
Receiving Calls................................................... 398
Text Messaging.................................................. 399
Post-Crash Alert System...........................216
Power Door Locks See: Locking and Unlocking............................. 56
Power Seats
....................................................116
Power Lumbar...................................................... 116
Power Recline....................................................... 116
Power Steering Fluid Check.....................243
Power Take-Off
.............................................152
Power Windows...............................................71
Accessory Delay.................................................... 72
Bounce-Back........................................................... 71
One-Touch Up or Down...................................... 71
Power Sliding Back Window............................ 72
Window Lock.......................................................... 72
R
Rear Axle
..........................................................162
Rear Seat Armrest........................................123
478
Super Duty (), enUSA Index

Towing...............................................................191
Traction Control.............................................167
Principle of Operation....................................... 167
Trailer Sway Control....................................192
Transfer Case Fluid Check........................242
Transmission Code Designation............304
Transmission ...................................................
147
Transmission See: Transmission............................................... 147
Transporting the Vehicle
..........................204
U
Under Hood Overview - 6.2L...................233
Under Hood Overview - 6.8L..................234
Universal Garage Door Opener................124 CAR2U® Home Automation System..........124
HomeLink Wireless Control System............127
USB Port
...........................................................321
Using Cruise Control....................................178 Switching Cruise Control Off.......................... 178
Switching Cruise Control On.......................... 178
Using Four-Wheel Drive
.............................153
4WD Indicator Lights........................................ 154
Driving Off-Road With Truck and Utility Vehicles.............................................................. 157
Electronic Shift-On-the-Fly (ESOF) 4WD system................................................................ 153
How Your Vehicle Differs From Other Vehicles.............................................................. 157
Manual Shift On Stop (MSOS) 4WD system................................................................ 153
Using a Manual Shift On Stop (MSOS) 4wd system............................................................... 154
Using the Electronic Shift on the Fly 4WD system............................................................... 156
Using Hill Descent Control.........................172 Hill descent modes............................................. 172
Using MyKey With Remote Start Systems..........................................................55
Using Snow Chains.....................................282
Using Stability Control
...............................169
AdvanceTrac® with Roll Stability Control ™
(RSC®).............................................................. 169Using SYNC™ With Your Media
Player............................................................345
Accessing Your Play Menu............................. 349
Connecting Your Digital Media Player to the USB Port.......................................................... 345
Media Menu Features...................................... 348
Media Voice Commands................................ 346
System Settings.................................................. 351
What's Playing?................................................. 346
Using SYNC™ With Your Phone.............327 Accessing Features through the Phone
Menu................................................................... 331
Accessing Your Phone Settings.................... 334
Making Calls........................................................ 330
Pairing a Phone for the First Time...............328
Pairing Subsequent Phones.......................... 328
Phone Options during an Active Call.........330
Phone Voice Commands................................ 328
Receiving Calls................................................... 330
System Settings................................................. 335
Text Messaging................................................... 333
Using Traction Control
................................167
System Indicator Lights and
Messages.......................................................... 168
Using Voice Recognition...........................325 Initiating a Voice Session................................ 325
System Interaction and Feedback..............326
Utilizing the Mediation/Arbitration Program (Canada Only)
.........................219
V
Vehicle Care
...................................................255
General Information......................................... 255
Vehicle Certification Label.......................303
Vehicle Identification Number................303
Vehicle Storage............................................260 Battery.................................................................... 261
Body....................................................................... 260
Brakes..................................................................... 261
Cooling system.................................................... 261
Engine..................................................................... 261
Fuel system........................................................... 261
General.................................................................. 260
Miscellaneous...................................................... 261
Removing Vehicle From Storage.................. 261
Tires........................................................................\
. 261
481
Super Duty (), enUSA Index