2015 DODGE JOURNEY radiator

rules for your community. To prevent ingestion by ani-
mals or children, do not store ethylene glycol-based
engine coolant in open containers or allow it to remain in
puddles on the ground. If ingested by a child or pet, seek
emergency assistance immediately. Clean up any ground
spills immediately.
Coolant Level
2.4L Engine —The coolant bottle provides a quick visual
method for determining that the coolant level is ad-
equate. With the engine idling and warm to normal
operating temperature, the level of the coolant in the
bottle should be between the “ADD” and “FULL” lines,
shown on the bottle.
3.6L Engine —The level of the coolant in the pressurized
coolant bottle should be between the “COLD” and
“FULL” range on the bottle when the engine is cold.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing engine coolant (anti-
freeze). Advise your service attendant of this. As long as
the engine operating temperature is satisfactory, the
coolant bottle need only be checked once a month. When
additional engine coolant (antifreeze) is needed to main-
tain the proper level, it should be added to the coolant
bottle. Do not overfill.
Points To Remember
NOTE:When the vehicle is stopped after a few miles/
kilometers of operation, you may observe vapor coming
from the front of the engine compartment. This is nor-
mally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot engine
coolant (antifreeze) to enter the radiator.
566 MAINTAINING YOUR VEHICLE

If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant expansion bottle.
•Check the coolant freeze point in the radiator and in
the coolant expansion bottle. If engine coolant (anti-
freeze) needs to be added, the contents of the coolant
expansion bottle must also be protected against freez-
ing.
•If frequent engine coolant (antifreeze) additions are
required, the cooling system should be pressure tested
for leaks.
•Maintain engine coolant (antifreeze) concentration at a
minimum of 50% OAT coolant (conforming to
MS-12106) and distilled water for proper corrosion
protection of your engine which contains aluminum
components.
•Make sure that the coolant expansion bottle overflow
hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
•Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory engine coolant (antifreeze)
performance, poor gas mileage, and increased emis-
sions.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
7
MAINTAINING YOUR VEHICLE 567

Cavity
Car-
tridge
Fuse
Mini-
FuseDescription
F106 60 Amp
Yellow
– Interior Power Dis-
tribution Center
Rail Run/Accessory
Relays
F139 40 Amp
Green
– Climate Control
System Blower
F140 30 Amp
Pink
– Power Locks
F141 40 Amp
Green
– Anti-Lock Brake
System
F142 40 Amp
Green
– Glow Plugs – If
Equipped
F143 40 Amp
Green
– Exterior Lights 1
Cavity
Car-
tridge
Fuse
Mini-
FuseDescription
F144 40 Amp
Green
– Exterior Lights 2
F145 30 Amp
Pink
– To Body Computer
– Lamp
F146 30 Amp
Pink
– Spare
F147 30 Amp
Pink
– Spare
F148 40 Amp
Green
– Radiator Fan Motor
F149 30 Amp
Pink
– Starter Solenoid
F150 – 25 Amp
Clear
Powertrain Control
Modules
586 MAINTAINING YOUR VEHICLE

CAUTION!(Continued)
OAT coolant (conforming to MS-12106), by an
authorized dealer as soon as possible.
•Do not use water alone or alcohol-based engine
coolant (antifreeze) products. Do not use additional
rust inhibitors or antirust products, as they may not
be compatible with the radiator engine coolant and
may plug the radiator.
•This vehicle has not been designed for use with
propylene glycol-based engine coolant (antifreeze).
Use of propylene glycol-based engine coolant (an-
tifreeze) is not recommended.
600 MAINTAINING YOUR VEHICLE

Brake Control System, Electronic..............434
Brake Fluid.............................601
Brake, Parking...........................431
Brakes.................................433
Brake System............................433
Anti-Lock (ABS)........................434
Fluid Check...........................568
Master Cylinder........................568
Parking..............................431
Warning Light.........................303
Brake/Transmission Interlock.................415
Break-In Recommendations, New Vehicle........102
Brightness, Interior Lights...................228
Bulb Replacement.........................589
Bulbs, Light.............................107
Camera, Rear............................248
Capacities, Fluid..........................597
Caps, Filler
Fuel.................................489
Oil (Engine)...........................541
Power Steering.........................430
Radiator (Coolant Pressure)................565
Carbon Monoxide Warning..................104
Cargo Area Cover.........................284
Cargo Area Features.......................280
Cargo Compartment.......................280
Light................................280
Luggage Carrier........................289
Cargo Load Floor.........................282
Cargo Management System..................282
Rollaway Tonneau Cover..................284
Tri-Fold Load Floor......................282
Cargo Tie-Downs.........................283
Cargo (Vehicle Loading)....................282
Car Washes.............................576
CellularPhone...........................372
624 INDEX

Coolant Pressure Cap (Radiator Cap)...........565
Cooling System...........................561
Adding Coolant (Antifreeze)...............563
Coolant Capacity.......................597
Coolant Level..........................561
Disposal of Used Coolant.................565
Drain, Flush, and Refill...................562
Inspection............................566
Points to Remember.....................566
Pressure Cap..........................565
Radiator Cap..........................565
Selection of Coolant (Antifreeze).............562
Corrosion Protection.......................575
Cupholders.............................273
Customer Assistance.......................613
Data Recorder, Event.......................75
Daytime Brightness, Interior Lights.............229
Daytime Running Lights....................224
Dealer Service............................545
Defroster, Rear Window.....................288
Defroster, Windshield......................106
Delay (Intermittent) Wipers..................230
Diagnostic System, Onboard.................543
Dimmer Switch, Headlight...................227
Dipsticks
Automatic Transmission..................571
Oil (Engine)...........................547
Power Steering.........................430
Disabled Vehicle Towing....................535
Disposal
Antifreeze (Engine Coolant)................565
Door Locks
Door Locks............................28
Key Fob . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28
Remote...............................28
Remote Keyless Entry (RKE)................28
Door Locks, Automatic......................31
626 INDEX

Owner’s Manual (Operator Manual).............4
Paint Care..............................575
Panic Alarm..............................22
Parking Brake............................431
ParkSense® System, Rear....................240
Passenger Seat Back Tilt (Easy Entry System)......216
Passing Light............................227
Pets...................................102
Phone (Pairing)...........................153
Phone (Uconnect®)........................120
Placard, Tire and Loading Information..........453
Power
Brakes...............................433
Distribution Center (Fuses)................585
Door Locks............................30
Inverter..............................271
Mirrors..............................117
Outlet (Auxiliary Electrical Outlet)...........266
Seats................................198
Steering..............................429
Sunroof..............................263
Transfer Unit..........................574
Windows..............................39
Power Steering Fluid.......................601
Power Transfer Unit.......................574
Pregnant Women and Seat Belts................54
Preparation for Jacking.....................516
Pretensioners
Seat Belts..............................54
Programming Transmitters (Remote Keyless Entry) . .20
Radial Ply Tires..........................460
Radiator Cap (Coolant Pressure Cap)...........565
Radio Operation..........................372
Radio Remote Controls.....................370
Rear Air Conditioning......................381
Rear Axle (Differential).....................574
636 INDEX