2015 Citroen C4 PICASSO RHD fuel

312
Running out of fuel (Diesel)
On vehicles fitted with HDi engines, the fuel system   must   be   primed   if   you   run   out   of   fuel;  
r

efer   to   the   corresponding   engine   compartment  
v

iew.
1.6 HDi engine
F Fill   the   fuel   tank   with   at   least   five   litres   of  d
iesel.
F
 
O
pen   the   bonnet.
F
 
I
f   necessary,   unclip   the   styling   cover   for  
a

ccess   to   the   priming   pump.
F
 
S
queeze   and   release   the   priming   pump  
r

epeatedly   until   resistance   is   felt   (there  
m

ay   be   resistance   at   the   first   press).
F
 
O
perate   the   starter   until   the   engine   starts  
(

if   the   engine   does   not   start   at   the   first  
a

ttempt,   wait   around   15   seconds   before  
t

rying
 ag
ain).
F
 
I
f   the   engine   does   not   start   after   a   few  
a

ttempts,   operate   the   priming   pump   again  
t

hen   start   the   engine.
F
 
R
efit   the   styling   cover   and   clip   it   in   place.
F
 
C
lose   the   bonnet.
If
 
the
 
tank
 
on
 
your
 
vehicle
 
is
 
fitted
 
with
 
a

 
misfuel
 
prevention
 
device,
 
refer
 
to
 
the
 
"

Misfuel
 
prevention
 
(Diesel)"
 
section.
If
 
the
 
engine
 
does
 
not
 
start
 
first
 
time,
 
d

on't
 
keep
 
trying
 
but
 
start
 
the
 
procedure
 
a

gain
 
from
 
the
 
beginning.
1.6 BlueHDi engine
F Fill   the   fuel   tank   with   at   least   five   litres   of  D
iesel.
F
 
S
witch   on   the   ignition   (without   starting   the  
e

ngine).
F
 
W
ait   around   6   seconds   and   switch   off   the  
ig

nition.
F
 
R
epeat   the   operation   10   times.
F
 
O
perate   the   starter   to   run   the   engine.
Checks

316
Avoid prolonged contact of used oil or fluids   with   the   skin.
Most
  of   these   fluids   are   harmful   to  
h

ealth   or   indeed   very   corrosive.
Do
  not   discard   used   oil   or   fluids   into  
s

ewers   or   onto   the   ground.
Take
  used   oil   to   a   CITROËN   dealer   or  
a

  qualified   workshop   (France)   or   to   an  
a

uthorised   waste   disposal   site.
Used products
To p p i n g u p
The reservoir must be topped up without delay by   a   CITROËN   dealer   or   a   qualified   workshop.
Diesel fuel additive level
(Diesel with particle filter)
The additive reservoir low level is indicated   by   fixed   illumination   of  
t

his   warning   lamp,   accompanied   by  
a

n   audible   signal   and   a   message  
t

hat   the   particle   filter   additive   level  
i

s   too   low.
The
 
warning
 
lamp
 
comes
 
on
 
when
 
the
 
ignition
 
i

s
 
switched
 
on,
 
or
 
every
 
time
 
the
 
stalk
 
is
 
o

perated,
 
until
 
the
 
reservoir
 
is
 
refilled.
Next
 
time
 
you
 
stop,
 
refill
 
the
 
screenwash
 
/
 
h

eadlamp
 
wash
 
reservoir.
Screenwash/headlamp
wash level low
In the case of vehicles fitted with h eadlamp   washers,   when   the   fluid r

eservoir   low   level   is   reached   this
 w

arning   lamp   comes   on   in   the
 i

nstrument   panel,   accompanied   by   an
 a

udible   signal   and   a   message.
Checks

319
AdBlue® additive and SCR system
f
or
 
BlueHDi   Diesel   engines
To assure respect for the environment and c
onformity   with   the   new   Euro   6   emissions  
s

tandard,   without   adversely   affecting   the  
p

er formance   or   fuel   consumption   of   Diesel  
e

ngines,   CITROËN   has   taken   the   decision   to  
e

quip   its   vehicles   with   an   effective   system   that  
a

ssociates   SCR   (Selective   Catalytic   Reduction)  
w

ith   a   particle   filter   (FAP)   for   the   treatment   of  
e

xhaust   gases.
Presentation of the SCR system
Using an additive called AdBlue® containing u
rea,
 
a
 
catalytic
 
converter
 
turns
 
up   to   85%  
o

f
 
nitrous
 
oxides
 
(NOx)
 
into
 
nitrogen   and  
w

ater,
 
which
 
are
 
harmless
 
to
 
health   and   the  
e

nvironment. The
  AdBlue
® additive is held in a special t
ank
 
located
  under   the   boot   at   the   rear   of  
t

he
 
vehicle.
 
It   has   a   capacity   of   17   litres:   this  
p

rovides
 
a
 
driving   range   of   about   12   500   miles  
(

20
 
000
 
km),
  after   which   an   alert   is   triggered  
w

arning
 
you
 
when   the   reserve   remaining   is  
e

nough
 
for
 
just   1   500   miles   (2   400   km).
During
 
each
  scheduled   service   of   your   vehicle  
b

y
 
a
 
CITROËN   dealer   or   a   qualified   workshop,  
t

he
 
AdBlue
® additive tank is refilled in order to a
llow
 
normal   operation   of   the   SCR   system.
If
 
the
 
estimated   mileage   between   two   services  
i

s
 
greater
 
than   12   500   miles   (20   000   km),   we  
r

ecommend
  that   you   go   to   a   CITROËN   dealer  
o

r
 
a
 
qualified   workshop   to   have   the   necessary  
t

op-up
 
carried   out. Once
  the   AdBlue
® tank is empty, a s
ystem
 
required
  by   regulations  
p

revents
 
starting
 
of   the   engine.
If the SCR

is faulty, the level of
emissions
 
from
 
your   vehicle   will   no  
l

onger
 
meet
 
the
 
Euro   6   standard:   you  
v

ehicle
 
becomes
 
polluting.
In
 
the
 
event
 
of
 
a
 
confirmed   fault  
w

ith
 
the
 
SCR
 
system,   you   must   go  
t

o
 
a
 
CITROËN
 
dealer   or   a   qualified  
w

orkshop
 
as
 
soon   as   possible:   after  
a

 
running
 
distance   of   650   miles  
(

1 100
 
km),
 
a
 
system   will   be   triggered  
a

utomatically
 
to
 
prevent   engine   starting.
8
Checks

328
Petrol engineV Ti 120e -THP 130 THP 15 0
Gearbox Manual
(5-speed) Manual
(5-speed) Manual
(6-speed)
Model code:
3D... 3E... 3A... 5FS0/1
HNYM/1S
  -   M/2SM5FV8
  -   8/1
Cubic capacity (cc) 1
  5981
  1991
  598
Bore
  x   stroke   (mm) 77
  x   85.875
  x   90.577
  x   85.8
Max
  power*:   EU   standard   (kW) 8896115
Max
  power   engine   speed   (rpm) 6
  0005
  5006
  000
Max
  torque:   EU   standard   (Nm) 160230 240
Max
  torque   engine   speed   (rpm) 4
  2501
  7501
  400
Fuel UnleadedUnleadedUnleaded
Catalytic converter yesyesyes
Oil capacity (in litres)
(with
  filter   replacement) 4.25
4.254.25
Petrol engines and gearboxes
3D...: CITROËN   C4   Picasso   (5 -seat). 3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
3E...:  CITROËN   Grand   C4   Picasso   (5 -seat).
*
  The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
Technical data

329
3D...: CITROËN   C4   Picasso   (5 -seat). 3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
3E...:  CITROËN   Grand   C4   Picasso   (5 -seat).
*
  The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
Petrol engine
THP 150 / 165e-THP 165
Gearbox Automatic
(6-speed) Automatic
(6-speed)
Model code:
3D... 3E... 3A... 5 GX
 5
GYA - A /1- A / 2- D -Y-Y/1-Y/ 2
5GX   5GZ A
Cubic capacity (cc) 1   598
1   598
Bore   x   stroke   (mm)
77   x   85.8
77   x   85.8
Max   power*:   EU   standard   (kW)
110   /   121
121
Max   power   engine   speed   (rpm)
6   000
6   000
Max   torque:   EU   standard   (Nm)
240 240
Max   torque   engine   speed   (rpm)
1   400
1   400
Fuel UnleadedUnleaded
Catalytic converter yesyes
Oil capacity (in litres)
(with   filter   replacement)
4.25
4.25
9
Technical data

332
Diesel engineHDi 90e-HDi 90
Airdream BlueHDi 100
Gearbox Manual
(5-speed) Electronic
 g

earbox
(6-speed) Manual
(6-speed)
Model code:
3D... 3E... 3A... 9HP0/1
9HP8/1PS/2PS BHY6/1S
  -   6/2SM
Cubic capacity (cc) 1
  5601
  560
Bore
  x   stroke   (mm) 75
  x   88.375
  x   88.3
Max
  power*:   EU   standard   (kW) 6873
Max
  power   engine   speed   (rpm) 4
  0003
  750
Max
  torque:   EU   standard   (Nm) 230254
Max
  torque   engine   speed   (rpm) 1
  7501
  750
Fuel
die

sel
die
sel
Catalytic converter yesyes
Particle filter yesyes
Oil capacities (in litres)
(with
  filter   replacement) 3.75
3.75
.../S:
  e-HDi   model   fitted   with   Stop   &   Start.
3D...:
 

CITROËN   C4   Picasso   (5 -seat).
Diesel engines and gearboxes
3E...: CITROËN   Grand   C4   Picasso   (5 -seat).
3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
*
 
The
 
maximum
 
power
 
corresponds
 
to
 
the
 
value
 
type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
Technical data

333
Diesel engines and gearboxes
.../S: e-HDi model fitted with Stop & Start.
3 D...:  CITROËN   C4   Picasso   (5 -seat).3E...: 
CITROËN   Grand   C4   Picasso   (5 -seat).
3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
Diesel engine
HDi 115e-HDi 115
Airdream
Gearbox Manual
(6-speed) Manual
(6-speed) Electronic
(6-speed)
Model code:
3D... 3E... 3A... 9HC-8/1
9HC8/1S9HC8/1PS   -   8/2PS
Cubic capacity (cc) 1   560
1   560
Bore   x   stroke   (mm)
75   x   88.3
75   x   88.3
Max   power*:   EU   standard   (kW)
85 85
Max   power   engine   speed   (rpm)
3   600
3   600
Max   torque:   EU   standard   (Nm)
270 270   -   285
Max   torque   engine   speed   (rpm)
1   750
1   750
Fuel
die
sel
die
sel
Catalytic converter yesyes
Particle filter noyes
Oil capacities (in litres)
(with   filter   replacement)
3.75
3.75
*   The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
9
Technical data

334
Diesel engines and gearboxes
.../S: e-HDi model fitted with Stop & Start.
3 D...:  CITROËN   C4   Picasso   (5 -seat).3E...: 
CITROËN   Grand   C4   Picasso   (5 -seat).
3A...:  CITROËN   Grand   C4   Picasso   (7-seat).
Diesel engine
BlueHDi 115/120BlueHDi 135/15 0
Gearbox Manual
(6-speed) Manual
(6-speed) Automatic
(6-speed)
Model code :
3D... 3E... 3A... BHZ/BHXM/S-M/1SAHX/AHR/AHV/

AHS   M/S   -   M/1S
AHXT/S   -   T/1S
Cubic capacity (cc) 1   560
1   997
Bore   x   stroke   (mm)
75   x   88.3
85   x   88
Max   power*:   EU   standard   (kW)
85   /   88
11 0
Max   power   engine   speed   (rpm)
3   500
3   750
Max   torque:   EU   standard   (Nm)
300 370
Max   torque   engine   speed   (rpm)
1   750
1   750
Fuel
die
sel
die
sel
Catalytic converter yesyes
Particle filter yesyes
Oil capacities (in litres)
(with   filter   replacement)
-
6 .1
*   The   maximum   power   corresponds   to   the   value   type-approved   on   a   test   bed,   under   conditions   defined   in   European   legislation   (Directive   1999/99/EC).
Technical data