2015 Citroen BERLINGO MULTISPACE RHD fuel filter

12
Berlingo_2_VP_en_Chap01_vue-ensemble_ed02-2014
tEcHnIcAL dAtA - MAI nt E n A nc E
Identification markings, serial number
,   paint   code,   tyres  188
Snow
  chains  
167
Windscreen

  /   headlamp   wash,  
levels


144
Changing bulbs,


lighting
 
168-172 Checks

 
145-146
-


battery
,
-

gearbox,
-


air filter/passenger compartment filter,- oil  filter,
-  particle   filter,
-
 
parking
  brake,
-
 
brake
  pads,
-
 
brake
  drums,   discs.
Engine
  fuses  
173,
  176
o

pening the bonnet, stay

140 Levels


143-144
-
d iesel additive,
-  
engine
  oil   dipstick,
-  
power
  steering   fluid,
-  
brake
  fluid,
-  
coolant.
Bleeding
  water,   Diesel   filter  
146
W

arning
 
lamps
 
30-37
Under the bonnet-

d iesel
142
-


petrol

141
Fuel

  cut-off,   Diesel   priming  
148
AdBlue

  additive  
149-156
Dimensions

 
180-183
Petrol

 
engines
 
/
 
Weights
 
184-185
Diesel

 
engines
 
/
 

Weights
 
184,

 
186-187
Location

17
Limit the causes of excess consumption
Spread loads throughout the vehicle; place the heaviest
items  in   the   bottom   of   the   boot,   as   close   as   possible   to   the  
rear

  seats.
Limit
  the   loads   carried   in   the   vehicle   and   reduce   wind  
resistance

  (roof   bars,   roof   rack,   bicycle   carrier,   trailer...).  
Use

  a   roof   box   in   preference.
Remove
  roof   bars   and   roof   racks   after   use.
At
  the   end   of   winter,   remove   snow   tyres   and   refit   your  
summer

  tyres.
Observe the recommendations on maintenance
Check the tyre pressures regularly, when cold, referring to the  label   in   the   door   aperture,   driver's   side.
Carry
  out   this   check   in   particular:
-
 
before
  a   long   journey,
-

at each change of season,
-

 
after
  a   long   period   out   of   use.
d

on't forget the spare wheel and the tyres on any trailer or
caravan.
Have
  your   vehicle   serviced   regularly   (engine   oil,   oil   filter,  
air

  filter,   passenger   compartment   filter...)   and   observe   the  
schedule

  of   operations   recommended   in   the   maintenance  
and

  warranty   guide.
With
  a   Blue   HDi   Diesel   engine,   if   the   SCR   system   is  
faulty

  your   vehicle   becomes   polluting;   go   to   a   CITROËN  
dealer

  or   a   qualified   workshop   without   delay   to   have   the  
emissions

  of   nitrous   oxides   brought   back   to   the   legal   level.
When refuelling, do not continue after the third cut-off of
the
  nozzle   to   avoid   any   overflow.
At
  the   wheel   of   your   new   vehicle,   it   is   only   after   the   first  
1

  800   miles   (3   000   kilometres)   that   you   will   see   the   fuel  
consumption

  settle   down   to   a   consistent   average.
2
EcO-drIVInG
Motoring & Environment

Berlingo_2_VP_en_Chap03_Pret-a-partir_ed02-2014
28
dials
1. Distance  recorder   in   kilometres   /  miles.
2.
 
Screen.
3.

 
Fuel
  level,   coolant   temperature.
4.
 
Rev
  counter.
5.
 
T
rip   distance   recorder   /   service  
indicator

  zero   reset.
6.
 
Instrument
  panel   lighting   dimmer.
Level 2 display screen
Instrument panel
Level 1 display screen
displays
- Speed  limiter   /   Cruise   control.
-  
Kilometres
  /   Miles   travelled.
-
 
Service
  indicator,   total   kilometres   /  
miles.
-


Presence of water in the
d iesel
filter.
-
 
Diesel
  pre-heating.
Screens
The format of the information presented in the screen depends on
the  vehicle's   equipment.
Instruments and controls

+
ABS
Berlingo_2_VP_en_Chap03_Pret-a-partir_ed02-2014
33Warning lamp isindicatesSolution - action
Power
steering on. a fault with the
system.The vehicle retains conventional steering without
assistance.
  Have   it   checked   by   a   CITROËN  
dealer

  or   a   qualified   workshop.
d

oor open
detection on
  and   accompanied  
by

  a   message   in   the  
screen.that a door is not
closed

  correctly.Check
  that   all   of   the   doors   are   closed.
ABS remaining
  on.a fault with the anti-
lock
  braking   system.The
  vehicle   retains   conventional   braking.
Have
  it   checked   by   a   CITROËN   dealer   or   a  
qualified

  workshop.
ES
c
flashing. triggering of the a

SR
or
  DSC   regulation.The
  system   optimises   traction   and   improves   the  
directional

  stability   of   the   vehicle.
Chapter
  5,   "Driving   safety"   section.
remaining
  on.a fault with the
system.
  E.g.:   under-
inflation
  of   the   tyres.E.g.:
  check   the   pressure   of   the   tyres.   (Wheel  
speed

  sensor,   hydraulic   block,   ...).   Have   it  
checked

  by   a   CITROËN   dealer   or   a   qualified  
workshop.
u

nder-
inflation on.
The tyre pressure is
too
  low   in   or   more  
wheels.Check

  the   tyre   pressure   as   soon   as   possible.  
This

  check   should   preferably   be   done   with   the  
tyres

  cold.
flashing then remaining  on,  
accompanied

  by  
the Service warning
lamp,

  and   depending  
on

  equipment,   the  
display

 
of
 
a
 
message.
The tyre pressure
monitoring  system  
has a fault or one of
the wheels does not
have

  a   sensor. Detection
  of   under-inflation   is   no   longer   assured.  
have

  it   checked   by   a   CITROËN   dealer   or   a  
qualified

  workshop.
Particle
filter on. a
  problem   with   the  
particle

  filter   (fuel  
additive

  level,   risk   of  
blockage, ...). Have

  the   filter   checked   by   a   CITROËN   dealer   or  
a

  qualified   workshop.
Chapter
  7,   "Levels"   section.
Instruments and controls
rEAdY tO GO
3

Berlingo_2_VP_en_Chap03_Pret-a-partir_ed02-2014
37
Warning lamp in the
screenis
indicates Solution - action
c

ruise
control on.
cruise
  control   selected.Manual
  selection.
Chapter
  4,   "Steering   mounted   controls"   section.
Speed limiter on.speed
  limiter   selected.Manual
  selection.
Chapter
  4,   "Steering   mounted   controls"   section.
Gear shift
indicator on.a
  recommendation  
independent of the type and
density

  of   traffic.To
  reduce   fuel   consumption,   change   to   an  
appropriate

  gear   with   a   manual   gearbox.  
The driver retains responsibility to follow this
indication

  or   not.
d

iesel pre-
heating on.climatic
  conditions   requiring  
pre-heating.W

ait   until   the   warning   lamp   goes   off   before  
operating

  the   starter.
Presence of
water in the
Diesel filter
on and
accompanied    by  
a

  message   in   the  
screen.
water in the Diesel filter.Have   the   filter   bled   by   a   CITROËN   dealer   or   a  qualified
  workshop   without   delay.
Chapter   7,   "Checks"   section.
According
  to   country.
Service
spanner on.that a service will be due
shortly. Refer
  to   the   list   of   checks   in   the   maintenance   and  
warranty

  guide.   Have   the   service   carried   out   by   a  
CITROËN

  dealer   or   a   qualified   workshop.
timeflashing. adjustment

  of   the   time.Use
  the   left-hand   button   on   the   instrument   panel.
Chapter
  3,   "Instruments   and   controls"   section.
Instruments and controls
REadY To Go
3

Berlingo_2_VP_en_Chap07_Verification_ed02-2014
 149
AdBLuE® AddItIVE
A

nd S
cr
SYS t EM
FO
r B
L
u
E H dI dIESEL


E

n
GI
n
ES
To assure respect for the environment and   conformity   with   the   new   Euro   6  
emissions

  standard,   without   adversely  
af

fecting   the   performance   or   fuel  
consumption

  of   Diesel   engines,  
CITROËN

  has   taken   the   decision   to  
equip

  its   vehicles   with   an   effective  
system

  that   associates   SCR   (Selective  
Catalytic Reduction) with a particle
filter

  (FAP)   for   the   treatment   of   exhaust  
gases.
Presentation of the Scr system
Using an additive called adBlue®
containing urea, a catalytic converter
turns up to 85% of nitrous oxides
(
no
x) into nitrogen and water, which
are
 
harmless
 
to
 
health
 
and
 
the
 
environment.
The

a
dBlue
® additive is held in a
special
 
tank
 
located   under   the   boot  
at

 
the
 
rear
 
of   the   vehicle.   It   has   a  
capacity

 
of
 
17   litres:   this   provides   a  
driving

 
range   of   about   12   500   miles  
(20

 
000 km),   after   which   an   alert  
is triggered warning you when the
reserve

 
remaining   is   enough   for   just  
1
 
500
 
miles
 
(2   400   km).
d

uring each scheduled service of
your vehicle by a CITR
o Ë n dealer
or
 
a
 
qualified   workshop,   the  
AdBlue®
additive
 
tank
 
is
 
refilled
 
in
 
order
 
to
 
allow  
normal

 
operation
 
of
 
the
 
SCR
 
system.
If
 
the
 
estimated
 
mileage
 
between
 

two services is greater than
12 500 miles
 
(20
 
000
 
km),
 
we
 
recommend

 
that
 
you
 
go
 
to
 
a
 
CITROËN  
dealer

 
or
 
a
 
qualified
 
workshop
 
to
 
have  
the

 
necessary
 
top-up
 
carried
 
out.
o
nce the a dBlue
® tank is empty, a
 
system
 
required   by   regulations  
prevents

 
starting
 
of   the   engine.
If the SCR

is faulty, the level of
emissions
 
from
 
your
 
vehicle   will   no  
longer

 
meet
 
the
 
Euro
 
6   standard:   you  
vehicle

 
becomes
 
polluting.
In
 
the
 
event
 
of
 
a
 
confirmed   fault  
with

 
the
 
SCR
 
system,
 
you   must   go  
to

 
a
 
CITROËN
 
dealer
 
or   a   qualified  
workshop

 
as
 
soon
 
as
 
possible:   after  
a
 
running
 
distance
 
of
 
650   miles  
(1
 
100
 
km),
 
a
 
system
 
will   be   triggered  
automatically

 
to
 
prevent   engine  
starting.
AdBlue® additive
cHEcKS
7