2015 Abarth 500 maintenance schedule

AIR CLEANER/
POLLEN FILTER
For filter replacement, contact an
Abarth Dealership.
BATTERY
The car is fitted with a low-maintenance
battery: no electrolyte top-ups with
distilled water are needed in standard
conditions of use.
INSPECTING THE
CHARGE AND THE
ELECTROLYTE LEVEL
The operations must be carried out as
described in this Owner Handbook only
by specialised personnel. Any top-up
operations must be carried out by
skilled personnel and by an Abarth
Dealership.
REPLACING THE
BATTERY
136) 137) 138) 139)
33)
4)
If required, replace the battery with an
original spare part with the same
specifications.
If a battery with different specifications
is fitted, the service intervals given in
the "Scheduled Servicing Plan" will no
longer be valid.
Follow the battery manufacturer's
instructions for maintenance.USEFUL ADVICE FOR
EXTENDING THE LIFE OF
YOUR BATTERY
To avoid draining your battery and
make it last longer, observe the
following instructions:
❒when you park the car, ensure that
the doors, tailgate and bonnet are
closed properly, to prevent any lights
from remaining on inside the
passenger compartment;
❒switch off all roof lights inside the car:
the car is however equipped with a
system which switches all interior
lights off automatically;
❒do not keep accessories (e.g. radio,
hazard warning lights, etc.) switched
on for a long time when the engine
is not running;
❒before performing any operation on
the electrical system, disconnect
the negative battery pole;
❒completely tighten the battery
terminals.
IMPORTANT If the charge level remains
under 50% for a long time, the battery
is damaged by sulphation, reducing
its capacity and efficiency at start-up.
162
SERVICING AND MAINTENANCE

RUBBER HOSES
As far as the maintenance of the brake
system and fuel supply system rubber
hoses is concerned, follow the
"Scheduled Servicing Plan" in this
chapter carefully.
Ozone, high temperatures and
prolonged lack of fluid in the system
may cause hardening and cracking of
the hoses, with possible leaks. Careful
checking is therefore necessary.
WINDSCREEN/REAR
WINDOW WIPER
BLADES
Replace the blades if the rubber edge is
deformed or worn. In any case, it is
advisable to replace them
approximately once a year.
144)
A few simple precautions can reduce
the possibility of damage to the blades:
❒if the temperature falls below zero,
make sure that ice has not frozen
the rubber against the glass. Use a
de-icing product to release it if
required;
❒remove any snow from the glass: in
addition to protecting the blades,
this prevents effort on the motor and
overheating;
❒do not operate the windscreen and
rear window wipers on dry glass.REPLACING THE
WINDSCREEN WIPER
BLADES
Proceed as follows:
❒raise the wiper arm A fig. 130 and
position the blade so that it forms
an angle of 90° with the arm;
❒press the button A and extract the
blade C fig. 130 from the arm B
fig. 130;
❒insert the new blade making sure it is
locked into place.
130AB0A0112
165

Front airbags .................................. 114
Front light clusters (bulb
replacement) ................................ 139
Front roof light ................................ 33
Fuel consumption .......................... 191
Fuel cut-off system......................... 35
Fuel supply..................................... 175
Fuel tank plug ................................ 65
Fuse boxes (location) ..................... 144
Fuses (replacement) ....................... 144
Gear Shift Indicator (system) ......... 69
Glove compartment ....................... 37
Handbrake.................................... 123
Hazard warning lights..................... 35
HBA system ................................... 54
Headlight alignment corrector ........ 51
Headlights (adjusting headlights
abroad) ........................................ 52
Headlights...................................... 51
Headlights (washing) ...................... 168
Head restraints............................... 17
– Rear head restraints .................. 17
Heated rear window (activation) ..... 25
Heating and ventilation ................... 22
Hill Holder system .......................... 54
Identification data
– bodywork paint plate ................. 172
– chassis marking ........................ 172
– engine marking.......................... 172– identification data plate.............. 172
Ignition switch ................................ 14
Installing electrical/electronic
devices ........................................ 61
Interior fittings ................................ 36
Interior roof light (bulb
replacement) ................................ 142
Interiors (cleaning) .......................... 169
Isofix child restraint system
setup ........................................... 110
iTPMS ............................................ 56
Lifting the car ................................ 149
Lubricants (specifications) .............. 188
Luggage compartment................... 45
– closing ...................................... 45
– extending the luggage
compartment ............................ 46
Luggage compartment light
(bulb replacement) ....................... 143
Luggage compartment light ........... 34
Main beam headlights (bulb
replacement) ................................ 140
Main beam headlights .................... 30
Maintenance and care.................... 154
– heavy-duty use of the car .......... 158
– periodic checks ......................... 158
– scheduled servicing ................... 154
– Scheduled Servicing Plan .......... 155
Manual climate control system ....... 24
– controls ..................................... 24
– maintenance ............................. 25Menu items .................................... 71
MSR system .................................. 54
Number plate lights (bulb
replacement) ................................ 142
Paintwork (maintenance) ............... 167
Parking .......................................... 123
Parking sensors ............................. 62
Passenger side front airbag ............ 115
Performance .................................. 185
Plugs (type) .................................... 174
Pollen filter ..................................... 162
Power socket ................................. 38
Preparation to install a portable
navigation system ........................ 39
Pretensioners ................................. 103
– Load limiters.............................. 103
Protecting the environment ............ 65
Radiofrequency remote control:
ministerial approvals..................... 194
Radio ............................................. 60
Radio transmitters and mobile
phones......................................... 61
Rear light clusters (bulb
replacement) ................................ 141
Rear seats (backrest release).......... 16
Rear view mirrors ........................... 19
Rear window washer (jets).............. 166
Rear window wiper/washer ............ 32
Reconfigurable multifunction
display ......................................... 68
INDEX

Refuelling the car ........................... 64
Replacing an exterior bulb .............. 139
Replacing an interior bulb ............... 142
Rev counter ................................... 79
Rim Protector (tyres)....................... 181
Rims and tyres ............................... 180
Roof lights...................................... 33
Roof rack/ski rack .......................... 50
Rubber hoses ................................ 165
Safety ........................................... 102
– seat belts .................................. 102
Saving fuel ..................................... 125
SBR system ................................... 102
Scheduled Servicing Plan ............... 155
Seat belts
– using the seat belts ................... 102
Seat belts (maintenance) ................ 104
Seats ............................................. 15
– Front seats ................................ 15
Sensors
– parking ...................................... 62
Side airbags (Side bags -
Window bags) .............................. 118
Side bags (front side airbags) ......... 118
Side lights/daytime running lights
(bulb replacement) ....................... 140
Snow chains .................................. 127
Snow tyres ..................................... 127
Speedometer ................................. 79
Sport front seats ............................ 16SPORT .......................................... 34
Starting the engine ......................... 122
Starting the engine ......................... 130
Steering ......................................... 179
Steering wheel ............................... 18
Storage compartment .................... 37
Storage compartment under
passenger seat ............................ 38
Sun roof ......................................... 40
Sun visors ...................................... 37
Supplies ......................................... 187
Suspension .................................... 178
Symbols......................................... 10
Technical specifications ................ 172
The keys ........................................ 11
– CODE Card ............................... 11
– Key without remote control........ 11
– Key with remote control............. 12
Third brake lights (bulb
replacement) ................................ 141
Towing the car ............................... 150
Towing trailers ................................ 126
Transmission .................................. 176
TRIP button.................................... 81
Trip Computer ................................ 80
TTC system ................................... 55
Ty r e s
– inflation pressures ..................... 183
– snow tyres................................. 182
– tyres provided ........................... 182Tyres - maintenance ....................... 164
Using the gearbox ........................ 124
Warning lights and messages ....... 83
Weights.......................................... 186
Wheel rims
– dimensions................................ 182
– wheels and tyres ....................... 164
Wheels and tyres ........................... 164
– tyre inflation pressure................. 183
Window bags (side airbags for
head protection) ........................... 118
Window cleaning............................ 32
Windows (cleaning) ........................ 168
Windscreen/rear window washer
fluid .............................................. 160
Windscreen/rear window wiper
(blades) ........................................ 165
Windscreen washer (jets) ............... 166
Windscreen wiper/washer .............. 32