2015.5 VAUXHALL ZAFIRA TOURER fuel filter

124Instruments and controls
No.Vehicle message26Left rear turn signal failure27Right front turn signal failure28Right rear turn signal failure29Check trailer brake light30Check trailer reversing light31Check left trailer turn signal32Check right trailer turn signal33Check trailer rear fog light34Check trailer rear light35Replace battery in radio remote
control48Clean side blind zone alert
system49Lane departure warning
unavailable53Tighten gas cap54Water in diesel fuel filterNo.Vehicle message55Diesel particle filter is full
3 16256Tyre pressure imbalance on
front axle57Tyre pressure imbalance on
rear axle58Tyres without TPMS sensors
detected59Open and then close driver
window60Open and then close front
passenger window61Open and then close rear left
window62Open and then close rear right
window65Theft attempted66Service theft alarm system67Service steering wheel lock68Service power steeringNo.Vehicle message69Service suspension system70Service level control system71Service rear axle74Service AFL75Service air conditioning76Service side blind zone alert
system77Service lane departure warning79Top up engine oil81Service transmission82Change engine oil soon83Service adaptive cruise control84Engine power is reduced89Service vehicle soon94Shift to park before exiting95Service airbag128Bonnet open

Driving and operating157Starting and operating
New vehicle running-in Do not brake unnecessarily hard for
the first few journeys.
During the first drive, smoke may
occur because of wax and oil
evaporating off the exhaust system.
Park the vehicle in the open for a
while after the first drive and avoid
inhaling the fumes.
During the running-in period, fuel and engine oil consumption may be
higher and the cleaning process of the diesel particle filter may take
place more often. Autostop may be
inhibited to allow for charging of the
vehicle battery.
Diesel particle filter 3 162.Ignition switch positions0=ignition off1=steering wheel lock released,
ignition off2=ignition on, for diesel engine:
preheating3=starting
Retained power off
The following electronic systems can
work until the driver's door is opened
or at the latest for 10 minutes after the
ignition is switched off:
■ power windows
■ power outlets
Power to the Infotainment system will continue to operate for 30 minutes or
until the key is removed from the
ignition switch, regardless of whether
any door is opened.
Starting the engine
Manual transmission: operate clutch.
Automatic transmission: operate
brake and move the selector lever to
P or N.
Do not operate the accelerator pedal.

162Driving and operatingEngine exhaust9Danger
Engine exhaust gases contain
poisonous carbon monoxide,
which is colourless and odourless and could be fatal if inhaled.
If exhaust gases enter the interior
of the vehicle, open the windows.
Have the cause of the fault
rectified by a workshop.
Avoid driving with an open load
compartment, otherwise exhaust
gases could enter the vehicle.
Diesel particle filter
The diesel particle filter system filters
harmful soot particles out of the
exhaust gases. The system includes
a self-cleaning function that runs
automatically during driving without
any notification. The filter is cleaned
by periodically burning off the soot
particles at high temperature. This
process takes place automatically
under set driving conditions and may
take up to 25 minutes. Typically it
needs between 7 and 12 minutes. Autostop is not available and fuel
consumption may be higher during
this period. The emission of smells
and smoke during this process is
normal.
Under certain driving conditions, e.g.
short distances, the system cannot
clean itself automatically.
If the cleaning of the filter is required
and if previous driving conditions did
not enable automatic cleaning, it will
be indicated by control indicator %.
Simultaneously Diesel partic. filter is
full continue driving or warning
code 55 appears in the Driver
Information Centre.
% illuminates when diesel particle
filter is full. Start cleaning process as
soon as possible.
% flashes when diesel particle filter
has reached the maximum filling
level. Start cleaning process
immediately to avoid damage to the
engine.
Cleaning process
To activate cleaning process,
continue driving, keep engine speed
above 2000 revolutions per minute.
Shift down if necessary. Diesel
particle filter cleaning is then started.
If g illuminates additionally,
cleaning is not possible, seek the
assistance of a workshop.Caution
If the cleaning process is
interrupted, there is a risk of
provoking severe engine damage.

284Technical dataCapacitiesEngine oilEngineB14NELB14NET,
B14NET LPGB16XNT CNGB16SHT,
B16SHLA18XEL,
A18XERincluding Filter [l]4.04.04.55.54.5between MIN and MAX [l]1.01.01.01.01.0EngineB16DTH,
B16DTJA20DT,
A20DTLA20DTHB20DTH,
B20DTJA20DTRincluding Filter [l]5.04.54.55.254.5between MIN and MAX [l]1.01.01.01.01.0
Fuel tank
Petrol/diesel, refilling quantity [l]58Natural gas CNG, refilling quantity [kg] or [l]
Petrol, refilling quantity25 kg 4)
or 144 l
14Liquid gas LPG, refilling quantity [l]604) At 20 MPa/200 bar/2900 psi and 15°C.

293
Child restraint installationlocations ................................... 61
Child restraints.............................. 60
Child restraint systems ................60
Cigarette lighter .........................103
Climate control ............................. 15
Climate control systems .............147
Clock........................................... 101
Code ........................................... 123
Control indicators........................ 107
Control of the vehicle .................156
Controls ........................................ 96
Convex shape .............................. 28
Coolant and antifreeze ...............268
Cruise control ....................116, 176
Cupholders .................................. 66
Curtain airbag system .................. 58
Curve lighting.............................. 138
D Danger, Warnings and Cautions ...4
Daytime running lights ...............138
Declaration of conformity ............288
DEF ............................................ 163
Diesel exhaust fluid ....................163
Diesel fuel system bleeding .......228
Diesel particle filter .............114, 162
Door open .................................. 116
Door panel storage .......................67
Doors ............................................ 24Driver assistance systems..........176
Driver Information Centre ...........117
Driving characteristics and towing tips .............................. 216
Driving hints ................................ 156
E Electric adjustment ......................28
Electrical system......................... 237
Electric parking brake .........112, 171
Electric parking brake fault .........112
Electronic climate control system 149
Electronic driving programmes ..168
Electronic Stability Control.......... 174
Electronic Stability Control and Traction Control system ..........114
Electronic Stability Control off..... 114
End-of-life vehicle recovery .......221
Engine compartment fuse box ...239
Engine coolant ........................... 224
Engine coolant temperature gauge ..................................... 106
Engine data ............................... 275
Engine exhaust .......................... 162
Engine identification ...................271
Engine oil ................... 222, 268, 272
Engine oil pressure ....................115
Entry lighting .............................. 145
Event data recorders ..................290
Exit lighting ................................ 145Exterior care .............................. 263
Exterior light ............................... 115
Exterior lighting ....................12, 135
Exterior mirrors ............................. 28
F
Fault ........................................... 168
First aid kit ................................... 92
Fixed air vents ........................... 154
Flex-Fix system ............................ 70
Fog light ..................................... 116
Fog lights ................................... 232
Folding mirrors ............................. 28
Folding tray .................................. 92
Following distance indication ......189
Forward collision alert................. 186
Front airbag system .....................57
Front fog lights ........................... 142
Front seats.................................... 37
Front storage ................................ 67
Fuel............................................. 206
Fuel consumption - CO 2-
Emissions ............................... 214
Fuel for diesel engines ..............206
Fuel for liquid gas operation .......207
Fuel for natural gas operation ...208
Fuel for petrol engines ...............206
Fuel gauge ................................. 105
Fuel selector .............................. 105
Fuses ......................................... 237

295
Oil, engine.................. 222, 268, 272
Operate pedal ............................. 112
Outside temperature ..................100
Overhead console .......................67
Overrun cut-off ........................... 158
P Parking ................................ 18, 161
Parking assist ............................ 192
Parking brake ............................ 171
Parking lights ............................. 143
Particulate filter ........................... 162
Performance .............................. 279
Performing work ........................221
Pollen filter ................................. 155
Power outlets ............................. 102
Power seat adjustment ................40
Power steering............................ 113
Power steering fluid ....................224
Power windows ............................ 30
Preheating ................................. 114
Puncture ..................................... 253
Q Quickheat ................................... 153
R
Radio Frequency Identification (RFID) ..................................... 291
Radio remote control ...................20Reading lights ............................ 145
Rear carrier system ......................70
Rear floor storage cover ..............83
Rear fog light .....................116, 143
Rear seats .................................... 43
Rear storage ................................. 81
Rear view camera ...................... 200
Rear window wiper/washer ........ 100
Recommended fluids and lubricants ........................ 268, 272
Reduced engine power ..............115
Refuelling ................................... 209
Retained power off .....................157
Reversing lights .........................143
Ride control system ....................173
Roller blinds ................................. 32
Roof .............................................. 33
Roof load ...................................... 94
Roof rack ..................................... 93
S Safety net .................................... 90
Seat adjustment ....................... 6, 37
Seat belt ........................................ 8
Seat belt reminder .....................110
Seat belts ..................................... 49
Seat position ................................ 37
Second row seats ........................43
Selective catalytic reduction .......163
Selector lever ............................. 167Service ............................... 155, 267
Service display .......................... 107
Service information ....................267
Service vehicle soon .................. 112
Side airbag system ......................57
Side blind spot alert ....................198
Sidelights .................................... 135
Side turn signal lights ................236
Spare wheel ............................... 256
Speed limiter............................... 178
Speedometer ............................. 104
Starting and operating ................157
Starting off ................................... 17
Starting the engine ....................157
Steering ...................................... 156
Steering wheel adjustment ......9, 96
Steering wheel controls ...............96
Stop-start system........................ 159
Storage ......................................... 65
Storage compartment ...................65
Storage compartments .................65
Sunvisor lights ........................... 145
Sun visors .................................... 32
Symbols ......................................... 4
T
Tachometer ............................... 105
Tail lights ................................... 233
Third row seats ............................ 48
Three-point seat belt .................... 50