2014 VOLVO V60 gearbox

09 Wheels and tyres
09
}}
* Option/accessory, for more information, see Introduction.325
Taking out the spare wheel1. Loosen the straps, lift out the spare wheel
from the cargo area and remove it from the spare wheel bag.
2. Fold up the cargo area floor.
3. Lift the tools and jack out from the foam block.
RemovingSet up warning triangle (p. 329) if a wheel is replaced in trafficked location. The car andjack* must be on a firm horizontal surface.
1. Apply the parking brake, (p. 293) andengage reverse gear, or position P if the
car has an automatic gearbox.
WARNING
Check that the jack is not damaged, that the threads are thoroughly lubricated andthat it is free from dirt.
NOTE
Volvo recommends only using the jack* that belongs to the car model in question,which is indicated on the jack's label. The label also indicates the jack's maxi- mum lift capacity at a specified minimumlifting height.
2. Take out the jack*, wheel wrench* and removal tool for wheel covers* located under the cargo floor in the cargo area. Ifanother jack is selected, see Raising thecar (p. 341).
3. Place chocks in front of and behind the wheels which will remain on the ground toprevent them from rolling. Use heavywooden blocks or large stones for exam-ple. 4. Cars with steel rims have removable
wheel covers. Use the removal tool tohook in and pull off any full-wheel wheelcovers. Alternatively, the wheel coverscan be pulled away by hand.
ProCarManuals.co’

10 Maintenance and service
10
* Option/accessory, for more information, see Introduction.365
For more information on the car's battery - Electrical system (p. 410).
Battery - Start/Stop
Cars with the Start/Stop function are equip- ped with two 12 V batteries - one extra pow-erful battery for starting and one support bat-tery that helps during the Start/Stop func-tion's starting sequence. For more information on Start/Stop - see Start/Stop* (p. 279). For more information on the car's battery - see Jump starting with battery (p. 270) andStarter battery - specification (p. 411).
BatteryStartingAuxiliary
Cold start capacity
A
,
CCA (A)760180
Size B
,
L×W×H (mm)278×175×190150×90×130
Capacity (Ah)7010
A In accordance with the SAE standard.
B Largest possible size.
IMPORTANT
When replacing batteries in cars with the Start/Stop function, the AGM 12
type bat-
teries must be fitted.
NOTE
• The higher the current take-off in the car (extra cooling/heating, etc.) themore the batteries must be charged =increased fuel consumption.
• When the capacity of the battery hasfallen below the lowest permissiblelevel then the Start/Stop function isdisengaged.
Temporarily reduced Start/Stop function due to high current take-off means: •
The engine starts automatically 13
without
the driver depressing the clutch pedal (manual gearbox).
• The engine starts automatically withoutthe driver lifting his/her foot off the footbrake pedal (automatic gearbox).
12
Absorbed Glass Mat
13 Automatic starting can only take place if the gear lever is in neutral position.
ProCarManuals.co’

10 Maintenance and service
10
371
FunctionA
Solenoid clutch A/C (5, 6-cyl.); Valves (1.6 l, engine B4204T7;5-cyl., 6-cyl.); Engine controlmodule (6-cyl.); Solenoids (6-cyl. without turbo); Actuatormotors, intake manifold (6-cyl.without turbo); Mass air flowsensor (engine B4204T7; 5-cyl.petrol); Oil level sensor (5-cyl.diesel)10
Valves (4-cyl. 2.0 lB
); Oil pump
(4-cyl. 2.0 l petrol B
); Lambda-
sond, centre (4-cyl. 2.0 l pet- rol B
); Lambda-sond, rear (4-cyl.
2.0 l diesel)15
Lambda-sonds (1.6 l petrol, engine B4204T7); Lambda-sond (5-cyl. diesel); Controlmodule, radiator roller cover(1.6 l diesel, 5-cyl. diesel)10
Lambda-sond, front (4-cyl. 2.0 l B
); Lambda-sond, rear (4-
cyl. 2.0 l petrol B
); EVAP valve
(5, 6-cyl. petrol); Lambda- sonds (5, 6-cyl. petrol)15
FunctionA
Coolant pump (1.6 l petrol Start/Stop); Crankcase ventila-tion heater (5-cyl. petrol); Oilpump automatic gearbox(5-cyl.petrol Start/Stop)10
Ignition coils (4-cyl. 2.0 l pet- rol B
)15
Diesel filter heater20
Control module, radiator roller cover (5-cyl. petrol)5
Crankcase ventilation heater (5-cyl. diesel); Oil pump auto-matic gearbox (5-cyl. dieselStart/Stop)10
Solenoid clutch A/C (4-cyl. 2.0 l B
); Glow control module (4-
cyl. 2.0 l diesel); Oil pump (4- cyl. 2.0 l diesel)15
Coolant pump (4-cyl. 2.0 l pet- rol B
)50
Glow plugs (diesel)70
FunctionA
Cooling fan (1.6 l, 4-cyl. 2.0 l petrol, 5-cyl. petrol)60
Cooling fan (6-cyl., 4-cyl. 2.0 l diesel, 5-cyl. diesel)80
Power steering100
A For cars with the Start/Stop function this fuse location is empty - see instead Fuses - in the engine compartment'scold zone (p. 377).
B Does not apply to the B4204T7 engine.
C However, does apply to the B4204T7 engine.
Related information
• Fuses - under glovebox (p. 372)
• Fuses - in the control module under the glovebox (p. 374)
• Fuses - in cargo area (p. 376)
ProCarManuals.co’

||
11 Specifications
11
388
approval number. The label is visible when the right rear door is opened.
Label for parking heater.
Engine code and engine serial number.
Label for engine oil.
Gearbox type designation and serial num- ber.
Manual gearbox
Automatic gearbox
Car's identification number. (VIN Vehicle Identification Number)
Further information on the car is presented inthe registration document.
NOTE
It is not intended that the decals illustrated in the owner's manual should be exactreplicas of those in the car. They areincluded to show their approximateappearance and location in the car. Theinformation that applies to your particularcar is available on the respective decalsfor your car.
Related information
• Weights (p. 390)
• Engine specifications (p. 393)
ProCarManuals.co’

11 Specifications
11
}}
391
Towing capacity and towball loadTowing capacity and towball load for driving with a trailer can be read in the tables.
Max. weight braked trailer
EngineEngine codeAGearboxMax. weight braked trailer (kg)Max. towball load (kg)
T3B4164T3Manual, MMT6160075
T3B4164T3Automatic, MPS6160075
T4B4164TManual, MMT6160075
T4B4164TAutomatic, MPS6160075
T4
BB5204T8Automatic, TF-80SD180090
T4FB4164T2Manual, MMT6160075
T4FB4164T2Automatic, MPS6160075
T5B4204T11Automatic, TG-81SC160075
T5BB5204T9Automatic, TF-80SD180090
T6B4204T9Automatic, TG-81SC180090
T6 AWDB6304T4Automatic, TF-80SC180090
D2D4162TManual, MMT6130075
D2D4162TAutomatic, MPS6130075
D3D5204T7Manual, M66160075
D3D5204T7Automatic, TF-80SD160075
D4D4204T5Manual, M66180090
ProCarManuals.co’

||
11 Specifications
11
392
EngineEngine codeAGearboxMax. weight braked trailer (kg)Max. towball load (kg)
D4D4204T5Automatic, TG-81SC180090
D4 AWDD5244T12Automatic, TF-80SC180090
D4 AWDD5244T17Automatic, TF-80SC180090
D5D5244T11Manual, M66160075
D5D5244T15Automatic, TF-80SC180090
D5 AWDD5244T15Automatic, TF-80SC180090
A
Engine code, component and serial number can be read on the engine; see Type designations (p. 386).
B Only certain markets.
Max. weight unbraked trailer
Max. weight unbraked trailer (kg)Max. towball load (kg)
75050
Related information
• Weights (p. 390)
• Driving with a trailer (p. 306)
• Trailer stabiliser - TSA (p. 312)
ProCarManuals.co’

||
11 Specifications
11
394
EngineEngine codeAOutput
(kW/rpm)Output
(hp/rpm)Torque
(Nm/rpm)No. of cylin- dersBore
(mm)Stroke (mm)Swept vol- ume
(litres)Compres- sion ratio
D5D5244T11 C158/4000215/4000420/1500–3250581.093.152.40016.5:1
D5D5244T15D158/4000215/4000440/1500-3000581.093.152.40016.5:1
A
Engine code, component and serial number can be read on the engine; see Type designations (p. 386).
B Only certain markets.
C Manual gearbox
D Automatic gearbox
Related information
• Coolant - grade and volume (p. 398)
• Engine oil - grade and volume (p. 396)
ProCarManuals.co’

11 Specifications
11
397
EngineEngine codeAOil gradeVolume, incl. oil filter
(litres)
T3B4164T3Certified and factory-filled oil: Oil grade WSS-M2C925-A
options for service: Oil grade: ACEA A5/B5 Viscosity: SAE 5W–30approx. 4.1
T4B4164Tapprox. 4.1
T4FB4164T2approx. 4.1
T4 DB5204T8Oil grade: ACEA A5/B5 Viscosity: SAE 0W–30approx 5.5
T5
DB5204T9approx 5.5
T5B4204T11Castrol Edge Professional V 0W-20 or 0w20 VCC RBS0-2AEapprox. 5.4
T6B4204T9approx. 5.4
D4D4204T5approx. 5.6
A
Engine code, component and serial number can be read on the engine; see Type designations (p. 386).
B Manual gearbox
C Automatic gearbox
D Only certain markets.
Related information
• Engine oil - adverse driving conditions (p. 395)
• Engine oil - checking and filling (p. 346)
ProCarManuals.co’