2014 TOYOTA HIGHLANDER HYBRID check engine

JOBNAME:1491132-2014-hhvWG-E PAGE:52SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
110,000 milesor132 months
Check installation ofdriver’s floormat Inspect andadjust allfluid levels Inspect wiperblades Replace engineoiland oilfilter1
Rotate tires Visually inspectbrakelinings/drums and
brake pads/discs
Additional Maintenance Itemsfor
Special Operating Conditions
2
Drivingondirt roads ordusty roads: Inspect balljoints anddust covers Inspect driveshaft boots Inspect engineairfilter Inspect steering linkageandboots Re-torque driveshaft bolt Tighten nutsandbolts onchassis and
body
Driving whiletowing, usingacar-top
carrier, orheavy vehicle loading6: Tightennutsandbolts onchassis and
body
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
115,000 milesor138 months
Check installation ofdriver’s floormat Inspect andadjust allfluid levels Inspect wiperblades Rotate tires Visually inspectbrakelinings/drums and
brake pads/discs
Note: If0W-20 oilWAS NOTused at
the last oilchange, replaceengineoil
and oilfilter.
1
Additional Maintenance Itemsfor
Special Operating Conditions2
Drivingondirt roads ordusty roads: Inspect balljoints anddust covers Inspect driveshaft boots Inspect engineairfilter Inspect steering linkageandboots Re-torque driveshaft bolt Replace engineoiland oilfilter1
Tighten nutsandbolts onchassis and
body
Driving whiletowing, usingacar-top
carrier, orheavy vehicle loading6: Replace engineoiland oilfilter1
Tighten nutsandbolts onchassis and
body
Repeated tripsofless than fivemiles in
temperatures below32°F/0°C:
Replace engineoiland oilfilter1
Extensive idlingand/or lowspeed driving
for along distance suchaspolice, taxior
door-to-door deliveryuse:
Replaceengineoiland oilfilter1
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
Maintenance Log
MAINTENANCE
52MaintenanceLog

JOBNAME:1491132-2014-hhvWG-E PAGE:53SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
120,000 milesor144 months
Check installation ofdriver’s floormat Inspect andadjust allfluid levels Inspect wiperblades Re-torque driveshaft bolt Replace cabinairfilter Replace engineairfilter Replace engineoiland oilfilter1
Replace sparkplugs3
Rotate tires
Inspect thefollowing:
__Automatic transmission fluid
__ Ball joints anddust covers
__ Brake linesandhoses
__ Brake linings/drums andbrake
pads/discs
4
__ Drive belts
__ Drive shaftboots
__ Engine/Inverter coolant
5
__Exhaust pipesandmountings __
Front differential oil
__ Fuel lines andconnections, fueltank
band andfueltank vapor ventsystem
hoses
__ Fuel tank capgasket
__ Radiator, condenser and/orintercooler
__ Rear differential oil
__ Steering gearbox
__ Steering linkageandboots
Additional Maintenance ItemsforSpecial Operating Conditions
2
Drivingondirt roads ordusty roads: Tighten nutsandbolts onchassis andbody
Driving whiletowing, usingacar-top carrier, orheavy vehicle loading6: Replace automatic transmission fluid Replacefrontdifferential oil Replacereardifferential oil Tightennutsandbolts onchassis andbody
DEALERSERVICEVERIFICATION:
D
AT E:
M
ILEAGE:
1Reset theoilreplacement reminderlight(“MAINT REQD”)orthe message “OILMAINTENANCE REQUIRED”onthe
multi-information displayaftermaintenance atevery 5,000 miles.
2Perform theseservice itemsonlyifyou drive primarily undertheconditions indicated.3Maintenance servicesofspark plugs arerequired undertheterms ofthe Emissions ControlWarranty.4Inspectthickness measurement anddisc runout.5Refer to“Engine/Inverter Coolant”inthe “Explanation ofMaintenance Items”section inthe back ofthis guide for
more information.
6Notallvehicles aredesigned fortowing. Refertoyour Vehicle Owner’s Manualfordetails.
Maintenance Log
MAINTENANCE
MaintenanceLog53

JOBNAME:1491132-2014-hhvWG-E PAGE:55SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
Drive ShaftBoots
Check thedrive shaft boots andclamps
for cracks, deterioration anddamage.
Replace anydeteriorated ordamaged parts
and, ifnecessary, repackthegrease.
Re-torque driveshaft bolt.Aqualified
technician shouldperform these
operations.
Driver’s FloorMat
•Only usethedriver’s floormat
designed specifically forthe model
and model yearofyour vehicle.
• Always properly securethedriver’s
floor matusing theretaining hooks.
• Never install another floormatontop
of the existing driver’sfloormat.
• Never install thedriver’s floormat
upside down.
Engine AirFilter
Replace atspecified intervals. When
performing inspections, checkfordamage,
excessive wearandoiliness, andreplace if
necessary.
Engine/Inverter Coolant
Drainthecooling systemandrefill withan
ethylene-glycol typecoolant. Inspecthoses
and connections forcorrosion andleaks.
Tighten connections andreplace parts
when necessary. Aqualified technician
should perform theseoperations. (For
further details, referto Radiator,
Condenser andHoses in the Vehicle
Maintenance andCare section ofthe
Owner’s Manual).
YourToyota isequipped withGenuine
Toyota SuperLong-Life Coolant.The
replacement intervalsforengine
coolant recommended inthis booklet
are based onreplacement with
Genuine ToyotaSuperLong-Life
Coolant orsimilar high-quality
non-silicate, non-amine,non-borate
ethylene-glycol coolantwithlong-life
hybrid organic acidtechnology (i.e.,a
combination oflow phosphates and
organic acids).Ifanother typeof
ethylene-glycol coolantisused,
replacement intervalsmaybedifferent.
Explanation ofMaintenance Items
MaintenanceLog55
MAINTENANCE

JOBNAME:1491132-2014-hhvWG-E PAGE:56SESS: 11OUTPUT: MonDec3010:35:57 2013
/tweddle/toyota/sched-maint/1491132-en-hhv/wg
Engine Oiland OilFilter
Replace theoilfilter anddrain andrefill
the engine oilatspecified intervals. For
recommended oilgrade andviscosity,
refer tothe
Owner’s Manual.
NOTE: Yourvehicle iscertified with
Genuine Toyota0W20motor oil.For
VEHICLES CERTIFIED FOR0W20 motor
oil, the oilchange interval is10,000 miles
or 12 months IF0W20 MOTOR OILIS
BEING USED.If0W20 isnot available,
5W20 mineral oilmay beused. However,
it must bereplaced atA5,000 milesor
6 month INTERVAL with0W20 motor oil.
For customers whoprimarily drivetheir
vehicle underanyofthe listed Special
Operating Conditions ,the motor oiland
filter should bereplaced at5,000 milesor
6 months, REGARDLESS OFTHE OIL
USED (ORCERTIFICATION OFTHE
VEHICLE).
Exhaust PipesandMountings
Visually inspecttheexhaust pipes,muffler
and hangers forcracks, deterioration and
damage. Starttheengine andlisten
carefully forany exhaust gasleakage.
Tighten connections orreplace partsas
necessary.
Front andRear Differential Oil
Inspectorreplace atspecified intervals.
When performing inspections, checkeach
component forsigns ofleakage. Ifyou
discover anyleakage, haveitrepaired bya
qualified technician immediately.
FuelLines andConnections,
Fuel Tank Band andFuel Tank
Vapor VentSystem Hoses
Visually inspectforcorrosion, damage,
cracks, andloose orleaking connections.
Tighten connections orreplace partsas
necessary.
Fuel Tank CapGasket
Visually inspectforcracks, deterioration
and damage andreplace ifnecessary.
Nuts andBolts onChassis and
Body
Re-tighten theseat-mounting boltsand
front/rear suspension memberretaining
bolts tospecified torque.
Radiator, Condenser and/or
Intercooler
Inspect fordamage, debris,corrosion and
signs ofdamage .Have anyproblem
repaired immediately byaqualified
technician.
Spark Plugs
Replace atspecified intervals. Installnew
plugs ofthe same typeasoriginally
equipped. Aqualified technician should
perform thisoperation.
Steering GearBox
Inspect forsigns ofleakage. Ifyou
discover anyleakage, haveitrepaired
immediately byaqualified technician.
Explanation ofMaintenance Items
56MaintenanceLog
MAINTENANCE