2014 Ram 1500 oil

MAINTENANCE SCHEDULE — 6.7L CUMMINS® DIESEL ENGINE
CAUTION!
Failure to perform the required maintenance items may result in damage to the
vehicle.
At Each Stop For Fuel
• Check the engine oil level at least 30 minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the
accuracy of the oil level reading. Add oil only when the level is at or below the ADD
or MIN mark.
Once A Month
• Inspect the batteries, and clean and tighten the terminals as required.
• Check the fluid levels of the coolant reservoir, brake master cylinder, and automatic transmission (if equipped), and add as needed.
At Each Oil Change
• Change the engine oil filter.
• Inspect the exhaust system.
• Check the coolant level, hoses, and clamps.
• Lubricate outer tie rod ends.
Inspection and service should also be performed anytime a malfunction is observed
or suspected. Retain all receipts.
MAINTAINING YOUR VEHICLE
225

Oil Change Indicator System — Cummins® Diesel
Your vehicle is equipped with an engine oil change indicator system. This system will
alert you when it is time to change your engine oil by displaying the words “Oil Change
Due” on your Electronic Vehicle Information Center (EVIC). The oil change reminder will
remind the owner to change the engine oil every 15,000 miles or 500 hours, whichever
comes first, except for the Chassis Cab models that are using B20 biodiesel, which are
12,500 miles or 400 hours, whichever comes first. Failure to change the engine oil per
the maintenance schedule can result in internal engine damage.
Your authorized dealer will reset the oil change indicator message after completing
the scheduled oil change. If a scheduled oil change is performed by someone other than
your authorized dealer, the message can be reset by referring to the steps described
under “Instrument Cluster Warning Lights” in “What To Do In Emergencies” in this
guide or “Electronic Vehicle Information Center (EVIC)” in “Understanding Your
Instrument Panel” in your Owner’s Manual on the DVD for further information.
Replace the engine oil and oil filter every 15,000 miles (24 000 km) or six months, or
sooner if prompted by the oil change indicator system. Under no circumstances should oil
change intervals exceed 15,000 miles (24 000 km) or six months, whichever comes first.
NOTE:
•
Under no circumstances should oil change intervals exceed 15,000 miles (24,000 km) or
six months or 500 Hours, whichever comes first.
• Replace the engine oil and oil filter every 12,500 miles (20 000 km) when running B20 fuel (Chassis Cab Only).
If Chassis Cab models are operated with greater than 5% levels of Biodiesel, the oil
change interval must not exceed 12,500 miles (20 000 km) under any circum-
stances. See the Fuel Requirements section for more information regarding opera-
tion of Chassis Cab models configured for use with Biodiesel blend (B6-B20) fuel
meeting ASTM specification D-7467.
Perform Service Indicator — Cummins® Diesel
Your vehicle will require emissions maintenance at a set interval. To help remind you
when this maintenance is due, the Electronic Vehicle Information Center (EVIC) will
display “Perform Service”. When the “Perform Service” message is displayed on the
EVIC it is necessary to have the emissions maintenance performed. Emissions
maintenance may include replacing the Closed Crankcase Ventilation (CCV) filter
element. The procedure for clearing and resetting the “Perform Service” indicator
message is located in the appropriate Service Information.
MAINTAINING YOUR VEHICLE
226

Maintenance Chart – Cummins® Diesel Engine
Miles:
7,500
15,000
22,500
30,000
37,500
45,000
52,500
60,000
67,500
75,000
82,500
90,000
97,500
Or Months: 6 12 18 24 30 36 42 48 54 60 66 72 78
Or Kilometers:
12,000
24,000
36,000
48,000
60,000
72,000
84,000
96,000
108,000
120,000
132,000
144,000
156,000
Rotate the tires. XXXXXXXXXXXXX
Lubricate front drive shaft fitting (4x4). XXXXXXXXXXXXX
Lubricate outer tie rod ends. XXXXXXXXXXXXX
Replace engine fuel filter element. XXXXXX
Replace chassis mounted fuel filter element. XXXXXX
Inspect the brake linings. X X X X
Inspect and adjust parking brake. X X X X
Inspect the front and rear axle surfaces. If gear oil leakage
is suspected, check the fluid level. If using your vehicle
for police, taxi, fleet, off-road or frequent trailer towing
change the axle fluid. XXXXXX
Inspect drive belt; replace as required. XXXX
Check the transfer case fluid (4x4). XX
Change the transfer case fluid (4x4). X
Inspect the front suspension, tie rod ends and boot
seals for cracks or leaks and all parts for damage, wear,
improper looseness or end play; replace if necessary. XXXXXX
Inspect wheel bearings. XXX
Change automatic transmission fluid
(AS69RC transmission only). XXX
MAINTAINING YOUR VEHICLE
227

Cavity Cartridge Fuse Micro FuseDescription
F55 20 Amp Yellow E38 Radio – If Equipped
F56 15 Amp Blue Additional Diesel Content –
If Equipped
F57 20 Amp YellowTransmission
F58 20 Amp Yellow
(Gas Engine) /
25 Amp Natural
(Cummins Diesel) Engine Cooling Pump
F60 15 Amp BlueUnderhood Lamp
F61 20 Amp Yellow Power Take-off Unit – If Equipped
F62 10 Amp Red Air Conditioning Clutch
F63 20 Amp Yellow Ignition Coils (Gas), Urea Heater
(Cummins Diesel)
F64 25 Amp Natural Fuel Injectors/Powertrain
F65 10 Amp RedUSB interface
F66 10 Amp Red Sunroof/Passenger Window
Switches/Rain Sensor
F67 10 Amp Red CD/DVD/Bluetooth Hands-free
Module – If Equipped
F69 15 Amp Blue Mod SCR 12V (Cummins Diesel) –
If Equipped
F70 30 Amp GreenFuel Pump Motor
F71 25 Amp Natural Amplifier
F72 10 Amp Red Voltage Stabilizer Modules –
If Equipped
F74 20 Amp Yellow
(Gas & 1500 LD Diesel)/10 AmpRed (CumminsDiesel Engine) Brake Vacuum Pump Gas/Diesel –
If Equipped
F75 10 Amp Red Coolant Temperature
Valve Actuator
F76 10 Amp Red Antilock Brakes/Electronic
Stability Control
F77 10 Amp Red Drivetrain Control Module/Front
Axle Disconnect Module
F78 10 Amp Red Engine Control Module/Electric
Power Steering
F79 15 Amp BlueClearance Lights
F80 10 Amp Red Universal Garage Door
Opener/Compass
MAINTAINING YOUR VEHICLE
232

TIRE PRESSURES
Check the inflation pressure of each tire, including the spare tire, at least monthly
and inflate to the recommended pressure for your vehicle.
The tire pressures recommended for your vehicle are found on the “Tire and Loading
Information” label located on the driver’s side door opening.
NOTE:
Refer to the Owner's Manual on the DVD
for more information regarding tire warn-
ings and instructions.
WARNING!
•Overloading of your tires is dangerous. Overloading can cause tire failure, affect
vehicle handling, and increase your stopping distance. Use tires of the recom-
mended load capacity for your vehicle. Never overload them.
•Improperly inflated tires are dangerous and can cause collisions. Under-inflation
is the leading cause of tire failure and may result in severe cracking, component
separation, or “blow out”. Over-inflation reduces a tire’s ability to cushion shock.
Objects on the road and chuck holes can cause damage that results in tire failure.
Unequal tire pressures can cause steering problems. You could lose control of
your vehicle. Over-inflated or under-inflated tires can affect vehicle handling and
can fail suddenly, resulting in loss of vehicle control.
WHEEL AND WHEEL TRIM CARE
All wheels and wheel trim, especially aluminum and chrome plated wheels, should
be cleaned regularly with a mild soap and water to prevent corrosion.
To remove heavy soil and/or excessive brake dust, use MOPAR
®Wheel Cleaner or
equivalent or select a non-abrasive, non-acidic cleaner.
Tire And Loading Information Location (Example)
MAINTAINING YOUR VEHICLE
234

OFF-ROAD CAPABILITIES
How do I shift into different four-wheel drive selections? pg. 126
UTILITY
How do I know how much I can tow with my Ram Truck? pg. 136
How do I adjust the gain on the Integrated Trailer Brake Module? pg. 138
WHAT TO DO IN EMERGENCIES
How do I change a flat tire? pg. 178
How do I Jump-Start my vehicle? pg. 190
MAINTAINING YOUR VEHICLE
Where is my Fuse Block located? pg. 230
What type of oil do I use? pg. 205
How often should I change my engine’s oil?
• Gasoline Engine pg. 214
• Cummins
®Diesel Engine pg. 225
• 1500 Diesel Engine pg. 219
FREQUENTLY ASKED QUESTIONS
240

AdjustablePedals ...........31
Air BagAdvanceFrontAirBag ......16
AirBags ...............16
AirBagWarningLight....16,173
FrontAirBag ............16
Rollover ...............16
SideAirBags ............16
SideImpacts ............16
Air Conditioning .....43,44,45,46
Air Suspension ...........40,42
Alarm Arm The System ..........14
Disarm The System ........14
Vehicle Security Alarm ......14
Alarm (Security Alarm) .........14
Anti-Lock Brake System (ABS) . . .173
Assistance Towing ..........169
Automatic Headlights .........34
Automatic High Beams ........34
Automatic Temperature Control (ATC) ............45
Automatic Transmission FluidType ............205
AxleFluid...............205
Back-Up Camera ............47
Battery Charging System Light .....172
Brake Fluid ..............205
Brake System WarningLight ..........171
Break-In Recommendations, New Vehicle .............32
BulbReplacement ..........235
Calibration,Compass.........116
CargoLight...............34
ChangeOilIndicator.........174
Charging System Light ........172
Check Engine Light
(Malfunction Indicator Light)...172 Child Restraints
CarSeat ...............17
Child Restraints ..........17
Child Seat Installation ....18,19
Installing Child Restraints
Using The Vehicle Seat Belt . . .19
Lower Anchors And Tethers
For Children ..........17,18
ChildSeat................18
Climate Control ........43,44,45
Cluster Warning/Indicator Lights AirBagWarningLight ......173
Brake Warning Light .......171
Compass Calibration .........116
Cooling System Coolant Capacity .........205
Cruise Control (Speed Control) ....35
CruiseLight...............35
Customer Assistance .........236
Customer Programmable Features ..............117
Defects, Reporting ..........237
Defroster, Rear Window ......43,44
Defroster, Windshield .......43,44
Diesel Engine Maintenance . .147, 158
Diesel Exhaust Fluid ......151, 164
Diesel Fuel Water Separator . .147, 158
DimmerControl.............34
Disabled Vehicle Towing .......169
Disarming, Security System ......14
Electronic Range Select (ERS). .38, 39
Electronics Your Vehicle's Sound System . . .50
Electronic Speed Control (Cruise Control) ...........35
Electronic Stability Control (ESC). .169
Electronic Throttle Control WarningLight ...........173
Electronic Vehicle Information Center (EVIC) ...........116
INDEX
241

Emergency, In Case ofFreeing Vehicle When Stuck . .196
Overheating ............175
Towing ........... 169, 196
Engine Block Heater ...........155
Break-In
Recommendations . .32, 145, 155
Compartment ...........199
Malfunction Indicator
(CheckEngine) ..........172
OilSelection ...........205
Overheating ............175
Starting ...............13
Stopping ..............13
Event Data Recorder .........197
Exhaust Brake .............157
Exhaust Regeneration ........148
Exterior Lights .............235
Filters EngineFuel ........ 147, 158
FlatTireStowage...........188
Fluid Capacities ............205
Fluids .................205
FogLights................34
Freeing A Stuck Vehicle .......196
Front And Rear ParkSense System...46
Front Heated Seats ...........27
Front ParkSense System ........46
Fuel Specifications ..........205
Fuse ..................230
Fuses..................230
Garage Door Opener (HomeLink
®)............120
Headlight ................34
Headlights Automatic .............34
Dimmer Switch ..........34
HighBeam .............33
Switch ...............34 Head Restraints
............24
Heated Seats ..............27
Heated Steering Wheel ........30
Heater, Engine Block .........155
High Beam/Low Beam Select (Dimmer) Switch ..........33
HomeLink
®
(Garage Door Opener) .......120
Hood Release .............198
HubCaps ...............186
Idle Up Feature ............158
Integrated Trailer Brake Controls . .138
Interior and Instrument Lights . . .7, 51
Intermittent Wipers (Delay Wipers) ............33
Introduction ...............3
Inverter Outlet (115V) ........123
Inverter, Power ............123
Jack Location .............176
Jump Starting .............190
KeyFob.................10 Arm The Alarm ...........14
Disarm The Alarm .........14
Keyless Enter-N-Go ...........12
Lock/Unlock ............12
Starting/Stopping .........13
LaneChangeandTurnSignals....33
Lane Change Assist ..........33
LATCH (Lower Anchors and TetherforCHildren)....17,18,19
Lights
Engine Temperature Warning. .170
TurnSignal .............33
Maintenance Record. . .218, 224, 229
Maintenance Schedule.... 214, 219, 225, 227
Malfunction Indicator Light(CheckEngine).......172
MemorySeat ..............26
INDEX
242