2014 Peugeot 508 Hybrid maintenance

237
508_en_Chap09_verifications_ed02-2014
Checking levels
take care when working under the
bonnet, as certain areas of the engine
may be extremely hot (risk of burns) and
the cooling fan could start at any time
(even with the ignition off).
Engine oil level
the check is carried out either when
the ignition is switched on using the
oil level indicator in the instrument
panel for vehicles with and electric oil
level gauge, or using the dipstick.
to e
nsure that the reading is correct,
your vehicle must be parked on a level
sur face and the engine having been off
for more than 30 minutes.
It is normal to top up the oil level between
two services (or oil changes). P
e

uge
Ot

recommends that you check the level, and top
up if necessary, every 3 000 miles (5 000 kms). Check all of these levels regularly, in line with the warranty and maintenance record. t
o
p them up if necessary, unless other wise indicated.
If a level drops significantly, have the corresponding system checked by a P
e
uge
Ot
dealer or a qualified workshop.
Checking using the dipstick
Refer to the "Petrol engine" or "Diesel engine"
section for the location of the dipstick in the
engine compartment of your vehicle.
F
t
a
ke the dipstick by its coloured grip and
remove it completely.
F

W
ipe the end of the dipstick using a clean
non-fluffy cloth.
F

R
efit the dipstick and push fully down, then
pull it out again to make the visual check:
the correct level is between the marks A
and B .
A = MA X
B = MIN If you find that the level is above the A mark or
below the B mark, do not star t the engine
.
-

I
f the level is above the MAX mark (risk
of damage to the engine), contact a
P
e

uge
Ot
dealer or a qualified workshop.
-

I
f the level is below the MIN mark, you
must top up the engine oil.
Oil grade
Before topping-up the oil or changing the oil,
check that the oil is the correct grade for your
engine and conforms to the manufacturer's
recommendations.
9
Checks

238
508_en_Chap09_verifications_ed02-2014
Power steering fluid level
the power steering fluid level should
be close to the "MA X" mark. With
the engine cold, unscrew the cap to
check the level.
th
e brake fluid level should be close
to the "MA X" mark. If it is not, check
the brake pad wear.
Brake fluid level
Changing the fluid
Refer to the warranty and maintenance record
for details of the interval for this operation.
Fluid specification
the brake fluid must conform to the
manufacturer's recommendations.
Topping up the engine oil level
Refer to the "Petrol engine" or "Diesel engine"
section for the location of the oil filler cap in the
engine compartment of your vehicle.
F
u
n
screw the oil filler cap to reveal the filler
aperture.
F

A
dd oil in small quantities, avoiding any
spills on engine components (risk of fire).
F

W
ait a few minutes before checking the
level again using the dipstick.
F

A
dd more oil if necessary.
F

A
fter checking the level, carefully refit the
oil filler cap and the dipstick in its tube.
After topping up the oil, the check when
switching on the ignition with the oil level
indicator in the instrument panel is not valid
during the 30 minutes after topping up.
Engine oil change
Refer to the warranty and maintenance record
for details of the interval for this operation.
In order to maintain the reliability of the engine
and emission control system, the use of
additives in the engine oil is prohibited.
Checks

240
508_en_Chap09_verifications_ed02-2014
Checks
12 V battery
the battery does not require any
maintenance.
However, check that the terminals
are clean and correctly tightened,
particularly in summer and winter.Refer to the warranty and maintenance
record for details of the replacement
intervals for these components.
Air filter and passenger compartment filter
Replace the oil filter each time the
engine oil is changed.
Refer to the warranty and
maintenance record for details of
the replacement interval for this
component.
Oil filterthe presence of this label, in particular with
the Stop & Start system, indicates the use of
a specific 12 V lead-acid battery with special
technology and specification. t
h
e involvement
of a P
e

uge
Ot
dealer or a qualified workshop
is essential when replacing or disconnecting
the battery.
Particle filter (Diesel)
the start of saturation of the
particle filter is indicated by
the temporary illumination of
this warning lamp accompanied by a message
in the multifunction screen.
As soon as the traffic conditions permit,
regenerate the filter by driving at a
speed of at least 40 mph (60 km/h) until
the warning lamp goes off.
If the warning lamp stays on, this
indicates a low additive level.
On a new vehicle, the first particle
filter regeneration operations may be
accompanied by a "burning" smell,
which is per fectly normal.
Following prolonged operation of the
vehicle at very low speed or at idle,
you may, in exceptional circumstances,
notice the emission of water vapour at
the exhaust on acceleration.
t
h
is does
not affect the behaviour of the vehicle
or the environment.
un

less other wise indicated, check these components in accordance with the warranty and maintenance record and according to your engine.
Other wise, have them checked by a P
e

uge
Ot

dealer or a qualified workshop.
When carrying out work on the battery, refer
to the "12 V battery" section for details of the
precautions to be taken before disconnecting
the battery and following its reconnection. Depending on the environment (e.g. dusty
atmosphere) and the use of the vehicle (e.g.
city driving), replace them twice as often if
necessary
.
A clogged passenger compartment filter may
have an adverse effect on the per formance
of the air conditioning system and generate
undesirable odours.
Checks

241
508_en_Chap09_verifications_ed02-2014
Manual gearbox
the gearbox does not require any
maintenance (no oil change).
Refer to the warranty and
maintenance record for the details
of the level checking interval for this
component.
Automatic gearbox
the gearbox does not require any
maintenance (no oil change).
Refer to the warranty and
maintenance record for details of
the level checking interval for this
component.Brake wear depends on the style
of driving, particularly in the case
of vehicles used in town, over short
distances. It may be necessary to
have the condition of the brakes checked, even
between vehicle services.
un
less there is a leak in the circuit, a drop in
the brake fluid level indicates that the brake
pads are worn.
Brake pads
For information on checking brake
disc wear, contact a Pe ugeOt
dealer or a qualified workshop.
Brake disc wear Electric parking brake
this system does not require any
routine servicing. However, in
the event of a problem, have the
system checked by a P
e

uge
Ot

dealer or a qualified workshop.
Only use products recommended by
P
e

uge
Ot
or products of equivalent
quality and specification.
In order to optimise the operation of
units as important as those in the
braking system, P
e

uge
Ot
selects and
offers very specific products.
After washing the vehicle, dampness,
or in wintry conditions, ice can form
on the brake discs and pads: braking
efficiency may be reduced. Make light
brake applications to dry and defrost
the brakes.
Parking brake
If excessive travel or a loss of
effectiveness of this system is
noticed, the parking brake must
be checked, even between
two


services.
Checking this system must be done by a
P
e

uge
Ot

dealer or a qualified workshop. For more information, refer to the "
el

ectric
parking brake - Operating faults" section.
Electronic gearbox
the gearbox does not require any
maintenance (no oil change).
Refer to the warranty and
maintenance record for details
of the checking interval for this
component.
9
Checks

366
508_en_Chap12_recherche-visuelle_ed02-2014
Maintenance - technical data
Identification markings 2 64
Dimensions 262-263
Running out of fuel (Diesel)

2

31
Checking levels
23

7-239
-

oil
-

b

rake fluid
-

p

ower steering fluid
-


coolant
-
s

creenwash/headlamp wash fluid
-

f

uel additive (Diesel)
AdBlue
® additive 24 2-249
Checking components 2 40-241
-

1

2 V battery
-

a

ir filter
-
p

assenger compartment filter
-

o

il filter
-

p

article filter (Diesel)
-


gearbox
-

b

rake pads / discs
-
par

king brake
-

e

lectric parking brake
Changing bulbs
2

00-206
-

front
-

rear 12V batter y
21

1-214
Removing/refitting the 12V batter y

215 -218
Load reduction, economy mode
2
19
en

gine compartment fuses
2
07, 210
Opening the bonnet
2
30
un

der the bonnet, petrol
2
32-233
un

der the bonnet, Diesel
23
4-236
Petrol engines

2
50 -251
Diesel engines
2

54-257Petrol weights

2
52-253
Diesel weights 2 58-261
Visual search

369
Navigation ..................................................... 298
Number plate lamps ...................................... 20
6
Oil change


..................................................... 237
Oil consumption


............................................ 237
Oil filter
...............

........................................... 240
Oil level .................................................... 30, 237
Opening the boot
..............................

..41, 44, 56
Opening the doors
...............................

...........41
Opening the panoramic sunroof blind


............62
Operation indicator lamps


........................14 -25Paint colour code
..........................................
264
Panoramic glass sunroof

................................
62
Parking brake

........................................
10 9 , 2 41
Parking brake, electric

....................
20, 103, 241
Parking lamps

...............................................
142
Parking sensors, front

...................................
13 5
Parking sensors, rear .................................... 13 4
Particle filter

..........................................239, 240
Passenger compartment filter

......................
240
P
e
uge
Ot C
ONN
eCt A
PPS
.......................
32
3
Peuge
O
t
Connect Assistance

...................
266
Peuge
O
t
Connect SOS
............................. 26
6
Player, CD MP3 ............................
286, 349, 350
Port, u
S
B
.......................
7
8, 286, 290, 350, 351
Priming the fuel system ................................
231
Programmable heating (Webasto) ..................98
Protecting children

.................
155 -170, 181, 183
Puncture

........................................................
18 6
Radio

....................................................280, 345
RDS


......................................................283, 346
Rear foglamp ................................ 140, 203, 204
Rear screen (demisting)


..................................97
Recharging the battery
................................. 2

14
Reduction of electrical load


..........................219
Regeneration of the particle filter


.............................................................240
Reinitialising the remote control
............... 4

9, 50
Remote control
........................................... 41

- 51
Removable screen (snow shield).................. 226
Removing a wheel
........................................195
Removing the battery .................................... 215
Removing the mat


...........................................77
Repair kit, puncture


.......................................18 6
Replacing bulbs


....................................200-206
N
O
P
R
Keeping children safe ............1 55 -170, 181, 183
Key ............................................................. 41- 51
Key, electronic


..................................... 41- 4 6 , 4 9
Keyless
e
n
try and
Starting


.................................... 42- 47, 101, 102
Key with remote control
................................102Main beam
...................................138, 200, 202
Maintenance ...................................................10
Map reading lamps


.......................................153
Markings, identification


.................................264
Massage function
...........................................70
Mat


..................................................................77
Menu


....................................274, 276, 278, 292,
294, 296, 312, 324, 326
Menu, main


...................................................344
Menus (
tou

ch screen)
..................................2

70
Mirror, rear view
..............................................75
Mirrors, door ...................................... 73, 74, 126
Motorised boot


..........................................5 7, 5 8
Mountings for ISOFIX seats


.........................16 4
MP3 CD
........................................286, 349, 350
Labels, identification
.....................................
26

4
Lamps, warning and indicator


..................14 -25
L
eD

s - light-emitting diodes

.................200-206
Level, AdBlue
® additive ................................. 242
Level, brake fluid ........................................... 23
8
Level, headlamp wash


.......................... 151, 2 3 9
Level, power steering fluid

............................ 23

8
Levels and checks
................................ 232-239
Light-emitting diodes - L
eD

s

.......200, 203, 204
Lighting bulbs (replacement)


...................................... 200-206
Lighting control stalk


............................. 13 8, 142
Lighting, guide-me home


...................... 142, 143
Lighting, interior


.................................... 153, 15 4
Lighting on reminder


..................................... 141
Loading


................................................... 10, 225
Load reduction mode


.................................... 219
Load space cover

...............................
.............81
Locating your vehicle
...................................... 48
L

ong objects, transporting
.............................. 78
L

ong fuel level


........................................... 21, 64
Luggage retaining strap


.................................. 79
L
KM
.
Alphabetical index