2014 FORD FIESTA wheel torque

•1.6L GTDI EcoBoost I4 engine
•Overboost function for increasedtorque
•Electronic overspeed function with6500 RPM redline
•ST-tuned 55 millimeters (2.17 inches)exhaust system with dual tips
•Ford B6 6-speed manual transaxle
•Sound symposer
•ST-tuned electric power assistedsteering
•Modified front suspension knuckle forimproved wheel end geometry
•ST-tuned springs, dampers, stabilizerbar and rear twist beam
•Increased diameter front brake rotors(278 millimeters x 23 millimeters) (10.9inches x 0.91 inches), rear brake rotors(253 millimeters x 10.2 millimeters (9.9inches x 0.40 inches) with uniquecalipers and ST-tuned brake pads
•Rear disc brakes with ST-tuned brakepads
•Enhanced torque vectoring withundersteer control
•AdvanceTrac stability enhancementsystem with three modes: Normal,Sport and Disabled
•17 inch x 7.0 inch wheels with 47.5millimeter offset
•P205/40-R17 Bridgestone RE050Asummer-only tires
•ST-engineered front and rear fasciasand rear wing
•Optional Recaro front seats withincreased lateral support and matchingrear seat covers
•ST-unique instrument panel appliques,shift knob, steering wheel and rockerscuff panels
•ST high-speed instrument cluster
5Fiesta (CCT)At a GlanceE163958

Enhanced Torque VectoringControl
Enhanced torque vectoring control iscomprised of two elements:
•Torque vectoring control which appliesbrake torque on the inner wheel in acurve for better traction and lessundersteer
•Cornering understeer control whichcontrols the yaw response of thevehicle under braking and accelerationon high and low friction surfaces.
No action is required to activate torquevectoring control. It operates automaticallydue to vehicle operating conditions.
Unlike electronic stability control,enhanced torque vectoring control doesnot slow the vehicle but does help controlexcessive wheel slip and gives the vehiclecornering agility. The system only increasesperformance. Because of this, enhancedtorque vectoring control is not disabledwhen the AdvanceTrac system is off.
14Fiesta (CCT)Stability Control (If Equipped)

BREAKING-IN
Your vehicle does not need an extensivebreak–in. Try not to drive continuously atthe same speed for the first 1000 miles(1600 kilometers) of new vehicleoperation. Vary your speed frequently inorder to give the moving parts a chance tobreak in.
Do not add friction modifier compoundsor special break–in oils since theseadditives may prevent piston ring seating.
GENERAL DRIVING POINTS
Operating at High Speeds
Your ST vehicle is capable of high speedsand is equipped with tires rated for thevehicle’s maximum speed. Remember todrive safely, obey all traffic laws and onlyoperate your ST vehicle at high speeds atlocations equipped and designed to do sosafely. Before operating your vehicle athigh speeds:
•Verify correct tire pressures. See Tires(page 20).
•Inspect wheels and tires for wear anddamage. Replace any damaged wheelsor tires.
•Do not operate your vehicle at highspeeds with more than two passengersor while carrying cargo.
Curbs, Parking Lot Obstacles andCommercial Car Washing
As part of its performance tuning package,your ST vehicle has a lower ride height thana standard Fiesta. Because of lower groundclearance, use caution when approachingcurbs, speed bumps or steep drivewayramps. It is recommended to cross speedbumps or driveway curbs slowly and at a45 degree angle to reduce the risk ofvehicle damage. Also, exercise extreme
care if using automated commercial carwashes. Do not drive through car washeswith the vehicle heavily loaded (multiplepassengers or luggage). Use onlycommercial car washes withoutmechanical tracks or hand wash to avoidpotential damage.
ENGINE OVERSPEED
Note:Always wait until the engine isproperly warmed up before running highengine speeds.
Your ST vehicle is equipped with anoverspeed feature to increase itsperformance range. The standardmaximum engine speed of 6375 RPM isindicated by a narrow redline on thetachometer face. The redline becomesthicker at the overspeed engine speed of6500 RPM.
This feature allows three seconds ofoverspeed above 6375 RPM. Once thethree second limit has been reached, theelectronically controlled rev limit rampsdown to 6375 RPM and holds there. Onceengine speed has dropped below 6175RPM, the overspeed timer is reset andthree seconds of overspeed up to amaximum of 6500 RPM is enabled.
Do not operate the engine at high RPM andlow load for sustained periods of time, asdamage may occur.
ENGINE OVERBOOST
Your ST vehicle offers a period ofadditional torque delivery referred to asoverboost or overtorque. This feature ofthe engine calibration broadens the RPMrange of the peak torque curve. This givesimproved performance during maneuverssuch as passing and vehicle launch.
15Fiesta (CCT)Driving Hints

WHEELS
Your ST vehicle is equipped with uniquewheels matched to the tires. These wheelsare more susceptible to damage due totheir diameter, width and low profile tires.To avoid damage to your wheels:
•Maintain proper tire pressure.
•Exercise caution when usingautomated, commercial car washes.Hand washing or using touchlesscommercial car washes withoutmechanical tracks is the best way toavoid potential damage.
•When installing wheels, always torquelug nuts to specification with a torquewrench.
•Inspect your wheels for damage on aregular basis. If a wheel is damaged,replace it immediately.
•If you encounter an abnormally harshimpact, inspect the outer diameter ofyour wheels, both inside and out, fordamage.
TIRES
Your ST vehicle is equipped with lowprofile, high performance tires that aredesigned to optimize the driving dynamicsyou expect in an ST vehicle. These tires arenot optimized for off-road or winter (snowor cold weather) performance, and theirride, noise and wear characteristics aredifferent than non-performance tires. Also,
because of their lower profile, the tires aremore susceptible to damage due topotholes and rough roads. To make surethat your tires perform as intended, it isimportant that you maintain your tiresproperly:
Note:Do not use tire chains on the originalwheels and tires of your vehicle. The use ofany type of tire chain on these tires maydamage your vehicle.
•Do not overload your vehicle. Maximumvehicle and axle weights are listed onthe tire information placard.
•Take extra caution when operating thevehicle near its maximum load,including assuring proper tire pressureand reducing speeds.
•Take extra caution when operating onrough roads to avoid impacts thatcould cause tire damage.
•If you encounter an abnormally harshimpact, inspect your tires for damage.
•Inspect your tires for damage on aregular basis. If a tire is damaged,replace it immediately.
•Proper suspension alignment is criticalfor maximum performance andoptimal tire wear. If you notice uneventire wear, have your alignment checked.
•When replacing tires, the only way tomaintain original performance is to usethe original equipment tire. If a differentsummer tire is used, it should be thesame size, speed rating and load ratingas the originally equipped tire. Replacetires as a set of four. Never mix tirebrands or models.
20Fiesta (CCT)Wheels and Tires

Wheel Lug Nut TorqueSpecifications
WARNING
When a wheel is installed, alwaysremove any corrosion, dirt or foreignmaterials present on the mountingsurfaces of the wheel or the surface of thewheel hub, brake drum or brake disc thatcontacts the wheel. Make sure that anyfasteners that attach the rotor to the hubare secured so they do not interfere withthe mounting surfaces of the wheel.Installing wheels without correctmetal-to-metal contact at the wheelmounting surfaces can cause the wheelnuts to loosen and the wheel to come offwhile the vehicle is in motion, resulting inloss of control.
Retighten the lug nuts to the specifiedtorque at 500 miles (800 kilometers) afterany wheel disturbance (such as tirerotation, changing a flat tire, wheelremoval).
lb-ft (Nm)*Bolt size
100 (135)M12 x 1.5
Torque specifications are for nut and boltthreads free of dirt and rust. Use only Fordrecommended replacement fasteners.
TECHNICAL SPECIFICATIONS
Wheel specifications
17 in. x 7.0 in.Diameter and width
47.5 mmOffset
5.8 in. (149.5 mm)Backspacing
63.3 mmCenter bore
22.5 lb. (10.2 kg)Weight
23Fiesta (CCT)Wheels and Tires

A
About This Supplement.................................3At a Glance..........................................................5Engine Specifications............................................7Suspension Specifications..................................7Vehicle Specifications...........................................6
B
Base Warranty.................................................26Breaking-In........................................................15
C
Capacities and Specifications...................24Technical Specifications....................................24Changing a Road Wheel..............................22Full Size Spare.......................................................22Wheel Lug Nut Torque Specifications..........23
D
Driving Hints......................................................15
E
Engine Oil Dipstick - 1.6LEcoBoost™....................................................19Engine Overboost...........................................15Engine Overspeed...........................................15
F
Fuel and Refueling.........................................10Fuel Quality.......................................................10OCTANE RECOMMENDATIONS......................10
G
General Driving Points...................................15Curbs, Parking Lot Obstacles andCommercial Car Washing.............................15Operating at High Speeds..................................15
I
Instrument Cluster...........................................9
Introduction........................................................3
M
Maintenance.....................................................18Manual Transmission - 1.6LEcoBoost™......................................................11Parking Your Vehicle.............................................12Recommended Shift Speeds............................11Reverse.......................................................................11Using the Clutch.....................................................11Motorcraft Parts.............................................24
P
Product History..................................................4GLOBAL PERFORMANCE VEHICLES .............4TEAM RS HISTORY................................................4
R
Roadside Assistance......................................17Roadside Emergencies..................................17
S
Stability Control...............................................13
T
Tires.....................................................................20Tire Pressure............................................................21Transmission......................................................11
U
Under Hood Overview - 1.6LEcoBoost™....................................................18Using Stability Control - 1.6LEcoBoost™.....................................................13Enhanced Torque Vectoring Control..............14Using Winter Tires...........................................21
W
Warning Lamps and Indicators - 1.6LEcoBoost™......................................................9Gauges........................................................................9
27Fiesta (CCT)Index