2014 FIAT FREEMONT maintenance schedule

Coolant Checks
Check engine coolant (antifreeze) protection every
12 months (before the onset of freezing weather,
where applicable). If coolant is dirty or rusty in appear-
ance, the system should be drained, flushed, and re-
filled with fresh coolant. Check the front of the A/C
condenser for any accumulation of bugs, leaves, etc.
If dirty, clean by gently spraying water from a garden
hose vertically down the face of the condenser.
Check the coolant recovery bottle tubing for brittle
rubber, cracking, tears, cuts, and tightness of the con-
nection at the bottle and radiator. Inspect the entire
system for leaks.
Cooling System – Drain, Flush, And Refill
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
If the solution is dirty or contains a considerable
amount of sediment, clean and flush with a reliable
cooling system cleaner. Follow with a thorough rinsing
to remove all deposits and chemicals. Properly dispose
of the old engine coolant (antifreeze) solution.Selection Of Coolant – Gasoline Engine
Use only the manufacturer's recommended coolant.
Refer to “Fluids, Lubricants, and Genuine Parts” in
“Technical Specifications” for further information.
•
Mixing of engine coolant (antifreeze)
other than specified engine coolant (an-
tifreeze), may result in engine damage
and may decrease corrosion protection. If a non-
specified engine coolant (antifreeze) is intro-
duced into the cooling system in an emergency, it
should be replaced with the specified engine cool-
ant (antifreeze) as soon as possible.
• Do not use plain water alone or alcohol-based
engine coolant (antifreeze) products. Do not use
additional rust inhibitors or antirust products, as
they may not be compatible with the radiator
engine coolant (antifreeze) and may plug the
radiator.
• This vehicle has not been designed for use with
Propylene Glycol based engine coolant (anti-
freeze). Use of Propylene Glycol based engine
coolant (antifreeze) is not recommended.
334
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICING AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS

Points To Remember
NOTE:When the vehicle is stopped after a few
kilometers of operation, you may observe vapor com-
ing from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant
to enter the radiator.
If an examination of your engine compartment shows
no evidence of radiator or hose leaks, the vehicle may
be safely driven. The vapor will soon dissipate.
• Do not overfill the coolant recovery bottle.
• Check coolant freeze point in the radiator and in the coolant recovery bottle. If antifreeze needs to be
added, contents of coolant recovery bottle must also
be protected against freezing.
• If frequent coolant additions are required, or if the level in the coolant recovery bottle does not drop
when the engine cools, the cooling system should be
pressure tested for leaks.
• Make sure that the radiator and coolant recovery bottle overflow hoses are not kinked or obstructed.
• Keep the front of the radiator clean. If your vehicle is equipped with air conditioning, keep the front of the
condenser clean. • Do not change the thermostat for Summer or Win-
ter operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs
may result in unsatisfactory coolant performance,
poor gas mileage, and increased emissions.
BRAKE SYSTEM
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Riding the brakes can lead to brake fail-
ure and possibly

an accident . Driving
with your foot resting or riding on the brake
pedal can result in abnormally high brake tem-
peratures, excessive lining wear, and possible
brake damage.You would not have your full brak-
ing capacity in an emergency.
Car maintenance should be done at a
FIAT Dealership. For routine and minor
maintenance operations you wish to
carry out yourself, we do recommend you have
the proper equipment , genuine FIAT spare parts
and the necessary fluids; do not however carry out
these operations if you have no experience.
337
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS
AND
MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS

7. Wipe the dipstick clean and reinsert it until seated.Then, remove the dipstick and note the fluid level
on both sides. The fluid level reading is only valid if
there is a solid coating of oil on both sides of the
dipstick. Note that the holes in the dipstick will be
full of fluid if the actual level is at or above the hole.
• If the fluid is hot, the fluid level should be in the crosshatched area marked “HOT” (between the up-
per two holes in the dipstick).
• If the fluid is cold, the fluid level should be between the lower two holes in the area marked “COLD.”
If the fluid level is low, add fluid through the dipstick
tube to bring it to the proper level. Do not overfill.
After adding any quantity of oil through the dipstick
tube, wait at least two minutes for the oil to fully
drain into the transmission before rechecking the
fluid level.
8. Check for leaks. Release the parking brake.
To prevent dirt and water from entering the transmis-
sion after checking or replenishing fluid, make sure that
the dipstick cap is properly re-seated.• Using a transmission fluid other than
the manufacturer ’s recommended fluid
may cause deterioration in transmission
shift quality and/or torque converter shudder, and
will require more frequent fluid and filter
changes. Refer to “Fluids, Lubricants, and Genuine
Parts” in "Technical Specifications" for fluid
specifications.
• Dirt and water in the transmission can cause
serious damage. To prevent dirt and water from
entering the transmission after checking or re-
plenishing fluid, make sure that the dipstick cap is
re-seated properly.
Fluid And Filter Changes
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
In addition, change the fluid and filter if the fluid
becomes contaminated (with water, etc.), or if the
transmission is disassembled for any reason.
341
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS
AND
MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS

MANUAL TRANSMISSION
(for versions/markets, where provided)
Lubricant Selection
Use only manufacturers recommended transmission
fluid. Do not add any materials (other than leak detec-
tion dyes). Refer to “Fluids, Lubricants, and Genuine
Parts” in “Technical Specifications” for further informa-
tion.
Frequency Of Fluid Change
Change the manual transmission fluid at the intervals
shown in the “Maintenance Schedule” in this manual.
REAR DRIVE ASSEMBLY (RDA) –
AWD MODELS ONLY
Lubricant Selection
Use only the manufacturer's recommended fluid. Refer
to “Fluids, Lubricants, and Genuine Parts” in “Technical
Specifications” for further information.
Fluid Level Check
Visually inspect the unit at each oil change for leakage.
If leakage is detected, check the fluid level by removing
the fill plug. The fluid level should be maintained be-
tween the bottom of the fill hole to 4 mm below the fill
hole.
Add fluid, if necessary, to maintain the proper level.Frequency Of Fluid Change
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
POWER TRANSFER UNIT (PTU) –
AWD MODELS ONLY
Lubricant Selection
Use only the manufacturer's recommended fluid. Refer
to “Fluids, Lubricants, and Genuine Parts” in “Technical
Specifications” for further information.
Fluid Level Check
Visually inspect the unit at each oil change for leakage.
If leakage is detected, Check the fluid level by removing
the fill plug. The fluid level should be maintained be-
tween the bottom of the fill hole to 4 mm below the fill
hole.
Add fluid, if necessary, to maintain the proper level.
Frequency Of Fluid Change
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
342
KNOWING
YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICING AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS

Tread Wear Indicators
Tread wear indicators are in the original equipment
tires to help you in determining when your tires should
be replaced.
(fig. 200)
These indicators are molded into the bottom of the
tread grooves. They will appear as bands when the
tread depth becomes 2 mm. When the tread is worn to
the tread wear indicators, the tire should be replaced.
Refer to “Replacement Tires” in this section for further
information.Life Of Tire
The service life of a tire is dependent upon varying
factors including, but not limited to:
• Driving style
• Tire pressure
• Distance driven
• Performance tires, tires with a speed rating of V or
higher, and summer tires typically have a reduced
tread life. Rotation of these tires per the vehicle
maintenance schedule is highly recommended.
WARNING!
Tires and the spare tire should be re-
placed af ter

six years, regardless of the
remaining tread. Failure to follow this warning
can result in sudden tire failure. You could lose
control and have a collision resulting in serious
injury or death.
Keep dismounted tires in a cool, dry place with as little
exposure to light as possible. Protect tires from con-
tact with oil, grease, and gasoline.
(fig. 200)
1 — Worn Tire
2—NewTire
355
KNOWING
YOUR
VEHICLE
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS
AND
MESSAGES
IN AN
EMERGENCY
SERVICING
AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS

Locks..................................113
Automatic Door ........................115
Auto Unlock ..........................115
Child Protection ........................116
Door ...............................113
PowerDoor ...........................114
Steering Wheel ..........................19
Low Tire Pressure System ....................145
Lubrication, Body ..........................329
LuggageRack(RoofRack)....................132
LugNuts ...............................273
Maintenance Free Battery ....................326
Maintenance, General .......................323
Maintenance Procedures .....................323
Maintenance Schedule .......................311
Maintenance, Sunroof .......................113
Malfunction Indicator Light (Check Engine) .........264
Manual Transaxle ..........................342
Fluid Level Check .......................342
Lubricant Selection ......................342
Manual Transmission ........................237
Frequency of Fluid Change .................342
Lubricant Selection ......................342
Map/Reading Lights ..........................90
Marker Lights, Side .........................292
Master Cylinder (Brakes) .....................338
Methanol ...............................358
Methanol Fuel ............................358
Mini-Trip Computer .........................28
Mirrors..............................63, 100 Automatic Dimming ......................63
Electric Powered .........................64 Electric Remote
.........................64
Exterior Folding .........................65
Heated ...............................65
Outside ...............................64
Rearview ..............................63
Vanity ................................65
Mode Fuel Saver .............................27
Modifications/Alterations, Vehicle .................5
Monitor, Tire Pressure System .................145
Multi-Function Control Lever ...................88
Navigation System (Uconnect® gps) ..........159, 160
New Vehicle Break-In Period ..................229
Occupant Restraints .................187, 220, 223
Occupant Restraints (Sedan) ........218, 219, 220,222
Oct
ane Rating, Gasoline (Fuel) ..............358, 362
Odometer ..............................266
Oil Change Indicator .....................27,266
Oil Change Indicator, Reset .................27, 266
Oil, Engine ...........................324, 362
Capacity .............................361
Change Interval ......................27, 325
Checking .............................324
Dipstick ..............................324
Disposal .............................326
Filter ................................362
Filter Disposal .........................326
Recommendation .......................361
Viscosity .......................... 325, 361
Onboard Diagnostic System ...................143
Operating Precautions ......................143
374
KNOWING
YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICING AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS

Rocking Vehicle When Stuck..................304
Roof Rack (Luggage Rack) ....................132
Rotation, Tires ............................347
Safety Checks Inside Vehicle ...................226
Safety Checks Outside Vehicle .................228
Safety, Exhaust Gas .....................125, 226
Safety Tips ..............................225
Schedule, Maintenance ......................311
Seat Belt Maintenance .......................346
Seat Belt Reminder .........................198
Seat Belts ........................ 187, 188, 226
Adjustable Upper Shoulder Anchorage .........191
And Pregnant Women ....................198
Child Restraint .........................199
Front Seat .........................188, 189
Inspection ............................226
Operating Instructions ....................189
Pretensioners ..........................192
Rear Seat .............................188
Reminder .............................267
Untwisting Procedure ....................192
Seats ...................................45
Adjustment ............................45
Easy Entry .............................57
Heated ...............................46
Height Adjustment .....................45, 50
Power ................................45
Rear Folding .........................54, 58
Reclining ..............................49
Reclining Rear ........................56, 58
Seatback Release ....................50, 54, 58
Tilting ................................45 Security Alarm
.........................15, 269
Selection of Coolant (Antifreeze) ........334, 335, 362
Sentry Key (Immobilizer) ......................11
Sentry Key Programming ......................12
Sentry Key Replacement ......................11
Service Engine Soon Light (Malfunction Indicator) ....264
Shift Lever Override ........................303
Shoulder Belts ............................188
Shoulder Belt Upper Anchorage ................191
Side Airbag ..............................22

2
Side Repeater Lights ........................295
Side View Mirror Adjustment ...................64
Signals, Turn ....................88, 228, 265, 295
Snow Chains (Tire Chains) ....................357
SnowTires..............................352
Sound Systems ............................161
Sound Systems (Radio) ......................161
Spare Tire ........................275, 353, 354
Spark Plugs ..............................362
Specifications Fuel (Gasoline) .........................362
Oil .................................362
Speed Control (Cruise Control) .................96
Speedometer ..............................7
Starting ................................229
Cold Weather .........................231
Engine Fails to Start ......................231
Starting and Operating ......................229
Starting Procedures ........................229
Steering Column Controls ........................88
Column Lock ...........................60
Power ...............................144
376
KNOWING YOUR
VEHICLE
SAFETY
STARTING AND
DRIVING
WARNING LIGHTSAND
MESSAGES
IN AN
EMERGENCY
SERVICING AND CARE
TECHNICAL
SPECIFICATIONS
CONTENTS