Page 451 of 743

1.Motor: The winch motor is powered by the vehicle
charging system and features a thermal protection
switch that automatically stops motor function in the
power-in direction if the motor gets too hot.
2. Remote Socket: The remote socket allows the remote
control to be attached to the control pack to allow the
winch to function.
3. Winch Drum With Integral Brake: The winch drum
allows the wire rope to be stored on the winch and
transmits force to the wire rope. The winch is
equipped with an integral brake that will stop rotation
of the winch drum if the winch motor is stopped.
4. 3-Stage Planetary Gear Set:Provides balance between
speed and pulling power.
5. Wire Rope: The wire rope allows the winch to be
connected to an anchor to provide a pulling force. 6.
Clutch Lever: The clutch lever allows the winch drum
to be disconnected from the winch motor to allow the
wire rope to be pulled from the winch by hand.
7. Remote Control: The remote control provides the
interface between the winch operator and the winch.
The remote control provides the ability to power the
winch in, out, and stop the winch. To operate the
winch, the toggle switch is pressed down to power the
winch in and up to power the winch out. The winch
will stop if the switch is left in the neutral (center)
position.
CAUTION!
If not installed, the hook strap must be placed on the
hook.
Fairlead: The fairlead acts as a guide for the wire rope
and minimizes damage to the rope.
5
STARTING AND OPERATING 449
Page 454 of 743

WARNING!(Continued)
•Never wrap wire rope back onto itself. Always use
a choker chain, wire choker rope or tree trunk
protector on the anchor.
• Never attach a recovery strap to the winch hook to
increase the length of a pull.
• Never attempt to tow a vehicle with the recovery
strap attached directly to the winch hook.
• Never use bungeestraps that develop tremendous
and potentially dangerous amounts of force when
stretched.
• Always disconnect the remote control when not in
use.
• Never winch when there are less than five wraps of
wire rope around the winch drum.
(Continued)
WARNING! (Continued)
•Always pass remote control through a window to
avoid pinching lead in door, then using remote
inside a vehicle.
• Never leave the remote control plugged into the
winch while free spooling, rigging or sitting idle.
General Information
Practice using your winch before you get stuck. Some key
points to remember when using your winch are:
1. Always take your time to assess the situation and plan your pull carefully.
2. Always take your time when using a winch.
3. Use the right equipment for the situation.
452 STARTING AND OPERATING
Page 455 of 743

4. Always wear leather gloves and do not allow the wirerope to slip through your hands when handling the
rope.
5. Only the operator should handle the wire rope and remote control.
6. Think safety at all times.
Vehicle Recovery Using The Winch
CAUTION!
• Always Know Your Winch: Take the time to fully
read and understand the included Installation and
Operations Guide, and Basic Guide to Winching
Techniques, in order to understand your winch and
the winching operation.
(Continued)
CAUTION! (Continued)
•Always inspect winch installation and wire rope
condition before operating the winch. Frayed,
kinked or damaged wire rope must be replaced
immediately. Loose or damaged winch installation
must be corrected immediately.
• Always be sure any element which can interfere
with safe winching operations is removed prior to
initiating winching.
• Always keep remote control lead clear of the drum,
wire rope and rigging.
• Inspect for cracks, pinches, frayed wires, or loose
connections. Replace if damaged.
• Be careful not to pull the Winch Cable Collar
through the rollers. Watch and listen to Winch for
proper snugness.
5
STARTING AND OPERATING 453
Page 459 of 743
7. Attach the Clevis/D-shackle and Tree Trunk Protector.Attach the shackle to the two ends of the strap or chain
and through the hook loop, being careful not to over
tighten (tighten and back-off 1/2 turn).
8. Lock the clutch. Lock the winch drum by rotating the clutch lever on the winch to engage. NOTE:
Always ensure the clutch is fully engaged or
disengaged.
9. Connect the remote control to the winch control box, located behind the front bumper. Be careful not to let
the remote control cord dangle in front of the winch. If
you choose to control the winch from inside your
vehicle, always pass the remote through a window to
avoid pinching the cord in the door. Always discon-
nect the remote control when not in use.
Clevis/D-Shackles
5
STARTING AND OPERATING 457
Page 463 of 743

the winch. Continue pulling until the vehicle is on
stable ground. If you are able to drive the vehicle, the
winching operation is complete.NOTE:
•Avoid overheating the winch motor. For extended
winching, stop at reasonable intervals to allow the
winch motor to cool down.
• What to look for under load: The wire rope must
always spool onto the drum as indicated by the
drum rotation decal on the winch. As you power-in,
make sure the wire rope winds evenly and tightly on
the drum. This prevents the outer wire wraps from
drawing into the inner wraps, binding and damag-
ing the wire rope. Avoid shock loads by using the
control switch intermittently to take up wire rope
slack. Shock loads can momentarily far exceed the
winch and wire rope ratings. During side pulls the
wire rope tends to stack up at one end of the drum.
This stack can become large enough to cause serious
damage to the winch. So, line up pulls as straight
ahead as possible and stop winching if the wire rope
comes close to the tie rods or mounting plate. To fix
Using The Remote Control
5
STARTING AND OPERATING 461
Page 465 of 743

NOTE: How to spool under no load:Arrange the re-
mote control lead so it cannot be caught in the winch.
Arrange the wire rope so it will not kink or tangle when
spooled. Be sure any wire rope already on the spooling
drum is wound tightly and evenly layered. Tighten and
straighten the layer if necessary. Keep the wire rope
under light tension and spool the wire rope back and
onto the winch drum in even layers. Stop frequently to
tighten and straighten the layers as necessary. Repeat this
process until the winch hook is the same distance as the
full length of the remote control from the winch. Pinch
the hook between your thumb and forefinger and attach
the hook strap. Hold the hook strap between the thumb
and forefinger to keep tension on the wire rope. Walk the
wire rope towards the fairlead, carefully spooling in the
remaining wire rope. By pulsing the remote control
switch.
18. Store the hook on the most outboard loop of the tow hook. 19. Disconnect the remote control. Disconnect the remote
control cord from the control box and store in a clean
and dry place. Winching operations are now com-
plete. Put the cap on the solenoid plug-in.
NOTE: Always store the remote control in a protected,
clean, dry area.
5
STARTING AND OPERATING 463
Page 735 of 743

Mirrors............................. .132
Outlet (Auxiliary Electrical Outlet) ...........205
Seats ............................... .137
Sliding Rear Window ....................223
Steering ............................. .466
Sunroof ............................. .202
Windows ..............................43
Power Steering Fluid ...................... .700
Pregnant Women and Seat Belts ................63
Pretensioners Seat Belts ..............................62
Programmable Electronic Features .............283
Programming Transmitters (Remote Keyless Entry) . .23
Radial Ply Tires ......................... .501
Radiator Cap (Coolant Pressure Cap) ...........655
Radio Operation ......................... .313
Rain Sensitive Wiper System .................171
Ramp Travel Index ....................... .423Rear Axle (Differential)
.....................663
Rear Cargo Area Utility Rails .................240
Rear Park Sense System .....................180
Rear Seat, Folding ........................ .146
Rear Window Features .....................222
Rear Window, Sliding ..................... .223
Reclining Rear Seats ...................... .145
Recorder, Event Data .......................81
Recreational Towing ...................... .566
Shifting into Transfer Case Neutral (N) ........569
Shifting out of Transfer Case Neutral (N) ......572
Reformulated Gasoline .....................527
Refrigerant ............................. .649
Reminder, Seat Belt .........................62
Remote Control Starting System .........................30
Remote Keyless Entry (RKE) ..................23
Remote Sound System (Radio) Controls ..........311
Remote Starting System ......................30
10
INDEX 733
Page 737 of 743

Sentry Key (Immobilizer)....................18
Sentry Key Programming ....................20
Sentry Key Replacement .....................19
Service Assistance ........................ .713
Service Contract ......................... .715
Service Manuals ......................... .718
Settings, Personal ........................ .283
Shifting ............................... .352
Automatic Transmission ..................355
Transfer Case ......................... .390
Transfer Case, Shifting into Transfer Case
Neutral (N) .......................... .569
Transfer Case, Shifting out of Transfer Case
Neutral (N) .......................... .572
Shift Lever Override ...................... .624
Shoulder Belts ............................50
Shoulder Belt Upper Anchorage ................58
Side Airbag ..............................73
Signals, Turn ........................... .120Sliding Rear Window
Power .............................. .223
SmartBeams ............................ .160
Snow Chains (Tire Chains) ...................509
Snow Plow ............................. .561
Snow Tires ............................. .502
Spare Tire .............................. .503
Spark Plugs ............................ .698
Speed Control (Cruise Control) ................177
Speedometer ............................ .260
Stabilizer/Sway Bar System ..................420
Starting .................................30
Automatic Transmission ..................342
Cold Weather ......................... .345
Engine Fails to Start .....................345
Remote ...............................30
Starting Procedures (Gas Engines) .............342
Steering Power .............................. .466
10
INDEX 735