2013 Lancia Thema engine overheat

HAZARD WARNING
FLASHERS
The Hazard Warning flasher switch is
located in the center of the instrument
panel between the center air outlets.Press the switch to turn on the
Hazard Warning flashers.
When the switch is activated, all di-
rectional turn signals will flash on and
off to warn oncoming traffic of an
emergency. Press the switch a second
time to turn off the Hazard Warning
flashers.
This is an emergency warning system
and it should not be used when the
vehicle is in motion. Use it when your
vehicle is disabled and it is creating a
safety hazard for other motorists.
When you must leave the vehicle to
seek assistance, the Hazard Warning
flashers will continue to operate even
though the ignition is placed in the
OFF position.
NOTE: With extended use the
Hazard Warning flashers may
wear down your battery. IF YOUR ENGINE
OVERHEATS
In any of the following situations, you
can reduce the potential for overheat-
ing by taking the appropriate action.
 On the highways — slow down.
 In city traffic — while stopped,
place the transmission in NEU-
TRAL, but do not increase the en-
gine idle speed.
NOTE: There are steps that you
can take to slow down an impend-
ing overheat condition:
 If your air conditioner (A/C) is on, turn it off. The A/C system
adds heat to the engine cooling
system and turning the A/C off
can help remove this heat.
 You can also turn the tempera- ture control to maximum heat,
the mode control to floor and the
blower control to high. This al-
lows the heater core to act as a
supplement to the radiator and
aids in removing heat from the
engine cooling system.
CAUTION!
Driving with a hot cooling system
could damage your vehicle. If the
temperature gauge reads “H,” pull
over and stop the vehicle. Idle the
vehicle with the air conditioner
turned off until the pointer drops
back into the normal range. If the
pointer remains on the “H,” turn
the engine off immediately and call
for service.WARNING!You or others can be badly burned
by hot engine coolant (antifreeze) or
steam from your radiator. If you see
or hear steam coming from under
the hood, do not open the hood until
the radiator has had time to cool.
Never try to open a cooling system
pressure cap when the radiator or
coolant bottle is hot.
254

3. Connect the negative end(-)of the
jumper cable to the negative (-)post
of the booster battery.
4. Connect the opposite end of the
negative (-)jumper cable to the re-
mote negative (-)post of the vehicle
with the discharged battery.WARNING!
Do not connect the cable to the
negative post (-)of the discharged
battery. The resulting electrical
spark could cause the battery to
explode and could result in per-
sonal injury.
5. Start the engine in the vehicle that
has the booster battery, let the engine
idle a few minutes, and then start the
engine in the vehicle with the dis-
charged battery.
Once the engine is started, remove the
jumper cables in the reverse sequence:
6. Disconnect the negative (-)jumper
cable from the remote negative (-)
post of the vehicle with the discharged
battery. 7. Disconnect the negative end
(-)of
the jumper cable from the negative (-)
post of the booster battery.
8. Disconnect the opposite end of the
positive (+)jumper cable from the
positive (+)post of the booster bat-
tery.
9. Disconnect the positive (+)end of
the jumper cable from the remote
positive (+)post of the discharged
vehicle.
If frequent jump-starting is required
to start your vehicle you should have
the battery and charging system in-
spected at your authorized dealer.
CAUTION!Accessories that can be plugged into
the vehicle power outlets draw
power from the vehicle’s battery,
even when not in use (i.e., cellular
phones, etc.). Eventually, if plugged
in long enough, the vehicle’s battery
will discharge sufficiently to degrade
battery life and/or prevent the en-
gine from starting.
FREEING A STUCK
VEHICLE
If your vehicle becomes stuck in mud,
sand, or snow, it can often be moved
by a rocking motion. Turn your steer-
ing wheel right and left to clear the
area around the front wheels. Then
shift back and forth between DRIVE
and REVERSE. Using minimal accel-
erator pedal pressure to maintain the
rocking motion, without spinning the
wheels, is most effective.CAUTION!Racing the engine or spinning the
wheels may lead to transmission
overheating and failure. Allow the
engine to idle with the transmission
in NEUTRAL for at least one minute
after every five rocking-motion
cycles. This will minimize overheat-
ing and reduce the risk of transmis-
sion failure during prolonged efforts
to free a stuck vehicle.
262

NOTE: Press the "ESC Off"
switch, to place the Electronic Sta-
bility Control (ESC) system in
"Partial Off" mode, before rocking
the vehicle. Refer to “Electronic
Brake Control” in “Starting And
Operating” for further informa-
tion.Once the vehicle has been
freed, press the "ESC Off" switch
again to restore "ESC On" mode.CAUTION!
 When “rocking” a stuck vehicleby shifting between DRIVE and
REVERSE, do not spin the
wheels faster than 24 km/h, or
drivetrain damage may result.
 Revving the engine or spinning
the wheels too fast may lead to
transmission overheating and
failure. It can also damage the
tires. Do not spin the wheels
above 48 km/h while in gear (no
transmission shifting occurring).
WARNING!
Fast spinning tires can be danger-
ous. Forces generated by excessive
wheel speeds may cause damage, or
even failure, of the axle and tires.
A tire could explode and injure
someone. Do not spin your vehicle's
wheels faster than 48 km/h or for
longer than 30 seconds continu-
ously without stopping when you
are stuck and do not let anyone
near a spinning wheel, no matter
what the speed.
TOW EYES
Your vehicle is equipped with tow
eyes, which are mounted in the front
and the rear.CAUTION!
Tow eyes are for emergency use
only, to rescue a vehicle stranded
off road. Do not use tow eyes for
tow truck hookup or highway tow-
ing. You could damage your ve-
hicle. Tow straps are recommended
when towing the vehicle; chains
may cause vehicle damage.
WARNING!
Stand clear of vehicles when pull-
ing with tow eyes. Tow straps and
chains may break, causing serious
injury.
SHIFT LEVER
OVERRIDE — 5 SPEED
TRANSMISSION
If a malfunction occurs and the shift
lever cannot be moved out of the
PARK position, you can use the fol-
lowing procedure to temporarily
move the shift lever:
1. Turn the engine OFF.
2. Firmly apply the parking brake.
3. Remove the rubber liner from the
storage tray (located next to the
shifter on the center console).
4. Press and maintain firm pressure
on the brake pedal.
263

meet the Emission standards. The
system manages engine combustion to
allow the exhaust system’s catalyst to
trap and burn Particulate Matter
(PM) pollutants with no input or in-
teraction on your part.
Refer to “Electronic Vehicle Informa-
tion Center (EVIC)” in “Understand-
ing Your Instrument Cluster” for fur-
ther information.
EXHAUST SYSTEM
The best protection against carbon
monoxide entry into the vehicle body
is a properly maintained engine ex-
haust system.
Whenever a change is noticed in the
sound of the exhaust system, when
exhaust fumes can be detected inside
the vehicle, or when the underside or
rear of the vehicle is damaged, have a
competent mechanic inspect the com-
plete exhaust system and adjacent
body areas for broken, damaged, de-
teriorated, or mispositioned parts.
Open seams or loose connections
could permit exhaust fumes to seepinto the passenger compartment. In
addition, have the exhaust system in-
spected each time the vehicle is raised
for lubrication or oil change. Replace
as required.
WARNING!
Exhaust gases can injure or kill.
They contain carbon monoxide
(CO), which is colorless and odor-
less. Breathing it can make you un-
conscious and can eventually poi-
son you. To avoid breathing CO,
refer to “Safety Tips/Exhaust Gas”
in “Things To Know Before Start-
ing Your Vehicle” for further infor-
mation.CAUTION!The catalytic converter requires the
use of unleaded fuel only. Leaded
gasoline will destroy the effective-
ness of the catalyst as an emissions
control device and may seriously re-
duce engine performance and cause
serious damage to the engine.
Under normal operating conditions,
the catalytic converter will not require
maintenance. However, it is impor-
tant to keep the engine properly tuned
to assure proper catalyst operation
and prevent possible catalyst damage.CAUTION!Damage to the catalytic converter
can result if your vehicle is not kept
in proper operating condition. In the
event of engine malfunction, par-
ticularly involving engine misfire or
other apparent loss of performance,
have your vehicle serviced promptly.
Continued operation of your vehicle
with a severe malfunction could
cause the converter to overheat, re-
sulting in possible damage to the
converter and the vehicle.NOTE: Intentional tampering
with emissions control systems can
result in civil penalties being as-
sessed against you.
280

quality water will reduce the amount
of corrosion protection in the engine
cooling system.Please note that it is the owner's respon-
sibility to maintain the proper level of
protection against freezing according to
the temperatures occurring in the area
where the vehicle is operated.NOTE: Mixing engine coolant
(antifreeze) types will decrease the
life of the engine coolant (anti-
freeze) and will require more fre-
quent engine coolant (antifreeze)
changes.
Cooling System Pressure Cap
The cap must be fully tightened to
prevent loss of engine coolant (anti-
freeze), and to ensure that engine
coolant (antifreeze) will return to the
radiator from the coolant recovery
bottle.The cap should be inspected and
cleaned if there is any accumulation of
foreign material on the sealing surfaces.
WARNING!
 The warning words “DO NOTOPEN HOT” on the cooling sys-
tem pressure cap are a safety pre-
caution. Never add engine cool-
ant (antifreeze) when the engine
is overheated. Do not loosen or
remove the cap to cool an over-
heated engine. Heat causes pres-
sure to build up in the cooling
system. To prevent scalding or in-
jury, do not remove the pressure
cap while the system is hot or
under pressure.
 Do not use a pressure cap other
than the one specified for your
vehicle. Personal injury or engine
damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine
coolant (antifreeze) is a regulated
substance requiring proper disposal.
Check with your local authorities to
determine the disposal rules for your
community. To prevent ingestion by
animals or children, do not store
ethylene glycol-based engine coolant
(antifreeze) in open containers or allow it to remain in puddles on the
ground. If ingested by a child or pet,
seek emergency assistance immedi-
ately. Clean up any ground spills im-
mediately.
Coolant Level
The coolant bottle provides a quick
visual method for determining that
the coolant level is adequate. With the
engine OFF and cold, the level of the
coolant in the bottle should be be-
tween the ranges indicated on the
bottle.
The radiator normally remains com-
pletely full, so there is no need to
remove the radiator cap unless check-
ing for engine coolant (antifreeze)
freeze point or replacing engine cool-
ant (antifreeze). Advise your service
attendant of this. As long as the en-
gine operating temperature is satis-
factory, the coolant bottle need only
be checked once a month.
When additional engine coolant (an-
tifreeze) is needed to maintain the
proper level, it should be added to the
coolant bottle. Do not overfill.
283

Electric Remote Mirrors. . . . . . . . .68
Electronic Brake Control System . .216
Anti-Lock Brake System . . . . .216
Brake Assist System . . . . . . . .216
Traction Control System . . . . .216
Electronic Speed Control (Cruise Control) . . . . . . .120, 121
Electronic Stability Control (ESC) . . . . . . . . . . . .217
Electronic Vehicle Information Center (EVIC) . . . . . . . .138, 163
Emergency Deck Lid Release . . . . .27
Emergency, In Case of Freeing Vehicle When Stuck . .262
Hazard Warning Flasher . . . . .254
Jump Starting . . . . . . . . . . . .260
Overheating . . . . . . . . . . . . .254
Towing . . . . . . . . . . . . . . . .266
Emergency Trunk Release . . . . . . .27
Engine Air Cleaner . . . . . . . . . . . . .275
Break-In Recommendations . . .55
Compartment . . . . . . . .271, 272
Compartment
Identification . . . . . . . .271, 272
Coolant (Antifreeze) . . . .281, 302
Cooling . . . . . . . . . . . . . . . .281
Exhaust Gas Caution . . . . . . . .56
Fails to Start . . . . . . . . . . . .196 Flooded, Starting
. . . . . . . . .196
Fuel Requirements . . . . . . . .238
Jump Starting . . . . . . . . . . . .260
Oil . . . . . . . . . . . . . . .274, 302
Oil Change Interval . . . .168, 274
Oil Disposal . . . . . . . . . . . . .275
Oil Filter . . . . . . . . . . . . . . .275
Oil Selection . . . . .274, 275, 302
Oil Synthetic . . . . . . . . . . . .275
Overheating . . . . . . . . . . . . .254
Starting . . . . . . . . . . . . . . . .195
Temperature Gauge . . . . . . . .162
Enhanced Accident Response Feature . . . . . . . . . . . . . . . . . .43
Entry System, Illuminated . . . . . . .17
Ethanol . . . . . . . . . . . . . . . . . .239
Event Data Recorder . . . . . . . . . . .45
Exhaust Gas Caution . . . . . . . . . .56
Exhaust System . . . . . . . . . .56, 280
Exterior Folding Mirrors . . . . . . . .67
Exterior Lighting . . . . . . . . . . . .109
Exterior Lights . . . . . . . . . . . . . .58
Filler Location Fuel . . . . . . . . . .160
Filters Air Cleaner . . . . . . . . . . . . .275
Air Conditioning . . . . . .189, 277
Engine Oil . . . . . . . . . .275, 302 Flashers
Hazard Warning . . . . . . . . . .254
Turn Signal . . . . . . .58, 112, 158
Flash-To-Pass . . . . . . . . . . . . . .112
Flooded Engine Starting . . . . . . .196
Floor Console . . . . . . . . . . . . . .148
Fluid, Brake . . . . . . . . . . . . . . .304
Fluid Capacities . . . . . . . . . . . . .302
Fluid Leaks . . . . . . . . . . . . . . . . .58
Fluid Level Checks . . . . . . . . . . .287
Automatic Transmission . . . . .286
Brake . . . . . . . . . . . . . . . . .285
Cooling System . . . . . . . . . . .281
Engine Oil . . . . . . . . . . . . . .274
Transfer Case . . . . . . . . . . . .287
Fluids, Lubricants and Genuine Parts . . . . . . . . . . . . .302
Fog Lights . . . . . . . . . . . . . . . .158
Fog Lights, Rear . . . . . . . . . . . .111
Folding Rear Seat . . . . . . . . . . . .105
Forward Collision Warning . .132, 166
Freeing A Stuck Vehicle . . . . . . . .262
Fuel . . . . . . . . . . . . . . . . .238, 240
Additives . . . . . . . . . . . . . . .239
Conserving . . . . . . . . . . . . . .169
Diesel . . . . . . . . . . . . . . . . .240
Filler Door (Gas Cap) . . . . . .160
Gasoline . . . . . . . . . . . . . . .238
Gauge . . . . . . . . . . . . . . . . .160
322

Mini-Trip Computer. . . . . . . . . .171
Mirrors . . . . . . . . . . . . . . . . . . . .67
Automatic Dimming . . . . . . . .67
Electric Powered . . . . . . . . . . .68
Electric Remote . . . . . . . . . . .68
Exterior Folding . . . . . . . . . . .67
Heated . . . . . . . . . . . . . . . . .69
Outside . . . . . . . . . . . . . . . . .67
Vanity . . . . . . . . . . . . . . . . . .69
Mode Fuel Saver . . . . . . . . . . . . . .169
Modifications/Alterations, Vehicle . . .7
Monitor, Tire Pressure System . . .234
Multi-Function Control Lever . . . .112
Navigation System (Uconnect™ gps) . . . . . . .138, 181
New Vehicle Break-In Period . . . . .55
Occupant Restraints . . . . .27, 41, 43
Occupant Restraints (Sedan) . . . . . . . . . . . .38, 41, 43
Octane Rating, Gasoline (Fuel) . . . . . . . . . . . . . .238, 302
Odometer . . . . . . . . . . . . . . . . .158
Oil Change Indicator . . . . . .158, 168
Oil Change Indicator, Reset . .158, 168
Oil, Engine . . . . . . . . . . . .274, 302
Capacity . . . . . . . . . . . . . . .302 Change Interval
. . . . . . .168, 274
Diesel . . . . . . . . . . . . . . . . .275
Dipstick . . . . . . . . . . . . . . . .274
Filter . . . . . . . . . . . . . .275, 302
Materials Added to . . . . . . . .275
Recommendation . .274, 275, 302
Synthetic . . . . . . . . . . . . . . .275
Viscosity . . . . . . . . . . . . . . .302
Oil Filter, Selection . . . . . . . . . . .275
Onboard Diagnostic System . . . . .273
Operating Precautions . . . . . . . . .273
Operator Manual (Owner's Manual) . . . . . . . . . . . . . . . . . .6
Outside Rearview Mirrors . . . . . . .67
Overdrive . . . . . . . . . . . . . . . . .207
Overdrive OFF Switch . . . . . . . . .207
Overhead Console . . . . . . . . . . . .140
Overheating, Engine . . . . . .163, 254
Owner's Manual (Operator Manual) . . . . . . . . . . . . . . . . . .6
Paint Care . . . . . . . . . . . . . . . . .288
Parking Brake . . . . . . . . . . . . . .213
Park Sense System, Rear . . . . . . .134
Passing Light . . . . . . . . . . . . . . .112
Pedals, Adjustable . . . . . . . . . . .119
Pets . . . . . . . . . . . . . . . . . . . . . .55 Placard, Tire and Loading
Information . . . . . . . . . . . . . .225
Power Deck Lid Release . . . . . . . . . .26
Distribution Center (Fuses) . . .294
Door Locks . . . . . . . . . . . . . .21
Mirrors . . . . . . . . . . . . . . . . .68
Outlet (Auxiliary Electrical
Outlet) . . . . . . . . . . . . . . . .145
Seats . . . . . . . . . . . . . . . . . .100
Steering . . . . . . . . . . . . . . . .212
Sunroof . . . . . . . . . . . .140, 142
Tilt/Telescoping Steering
Column . . . . . . . . . . . . . . . .117
Windows . . . . . . . . . . . . . . . .24
Power Steering Fluid . . . . . . . . . .304
Pregnant Women and Seat Belts . . .36
Pretensioners Seat Belts . . . . . . . . . . . . . . . .33
Programming Transmitters (Remote Keyless Entry) . . . . . . .18
Radial Ply Tires . . . . . . . . . . . . .229
Radiator Cap (Coolant Pressure Cap) . . . . . . . . . . . . .283
Radio Operation . . . . . . . . . . . . .184
Radio Remote Controls . . . . . . . .183
Radio (Sound Systems) . . . . . . . .181
Rain Sensitive Wiper System . . . .115
325