2013 Lancia Flavia battery

LANCIA engine air cleaner filters are
a high quality filter and are recom-
mended.
MAINTENANCE-FREE
BATTERY
The top of the maintenance-free bat-
tery is permanently sealed. You will
never have to add water, nor is peri-
odic maintenance required.
NOTE: The battery is stored in a
compartment behind the left front
fender and is accessible without
removing the tire and wheel. Re-
mote battery terminals are located
in the engine compartment for
jump-starting. Refer to “Jump-
Starting Procedures” in “What To
Do In Emergencies” for further
information.
To access the battery, turn the steering
wheel fully to the right and remove
the inner fender shield.
WARNING!
 Battery fluid is a corrosive acidsolution and can burn or even
blind you. Do not allow battery
fluid to contact your eyes, skin, or
clothing. Do not lean over a bat-
tery when attaching clamps. If
acid splashes in eyes or on skin,
flush the area immediately with
large amounts of water.
 Battery gas is flammable and ex-
plosive. Keep flame or sparks
away from the battery. Do not use
a booster battery or any other
booster source with an output
greater than 12 Volts. Do not al-
low cable clamps to touch each
other.
 Battery posts, terminals, and re- lated accessories contain lead and
lead compounds. Wash hands af-
ter handling.
CAUTION!
 It is essential when replacing thecables on the battery that the
positive cable is attached to the
positive post and the negative
cable is attached to the negative
post. Battery posts are marked
positive (+) and negative (-) and
are identified on the battery case.
Cable clamps should be tight on
the terminal posts and free of cor-
rosion.
 If a “fast charger” is used while the battery is in the vehicle, dis-
connect both vehicle battery
cables before connecting the
charger to the battery. Do not use
a “fast charger” to provide start-
ing voltage.
193

WEATHER STRIP CARE –
SOFT AND HARD TOP
Lubricate all top and door glass
weather strips periodically with a
weather strip lubricant to keep them
soft and pliable.FUSES
INTEGRATED POWER
MODULE
The Integrated Power Module is lo-
cated in the engine compartment near
the air cleaner assembly. This center
contains cartridge fuses and mini
fuses. A label that identifies each
component may be printed on the in-
side of the cover. Refer to the graphic
below for FUSES/TIPM location.
Cavity
Cartridge Fuse Mini Fuse Description
1 40 Amp Green —Power Top Module
2 —
20 Amp Yellow
Brake Vacuum Pump
3 — 10 Amp Red Center High Mounted Stop Light
(CHMSL)/Brake Switch
4 — 10 Amp RedIgnition Switch
5 — 20 Amp YellowTrailer Tow (when present)
6 — 10 Amp RedPower Mirror Switch/Climate Controls
7 — 30 Amp GreenIgnition Off Draw (IOD) Sense 1
8 — 30 Amp GreenIgnition Off Draw (IOD) Sense 2
9 40 Amp Green Battery Feed – Power Seats (for
versions/markets, where provided)
Integrated Power Module
208

CAUTION!
 When installing the IntegratedPower Module cover, it is impor-
tant to ensure the cover is prop-
erly positioned and fully latched.
Failure to do so may allow water
to get into the Integrated Power
Module, and possibly result in an
electrical system failure.
 When replacing a blown fuse, it is important to use only a fuse hav-
ing the correct amperage rating.
The use of a fuse with a rating
other than indicated may result in
a dangerous electrical system
overload. If a properly rated fuse
continues to blow, it indicates a
problem in the circuit that must
be corrected. VEHICLE STORAGE
If you will not be using your vehicle
for more than 21 days, you may want
to take steps to preserve your battery.
 Disengage the mini-fuse in the
Power Distribution Center labeled
IOD (Ignition Off-Draw).
 Or disconnect the negative cable from the battery. Refer to “Prepa-
ration for Jump Start” in “Jump-
Starting” to identify the location of
the negative post.
 Anytime you store your vehicle, or keep it out of service (i.e., vacation)
for two weeks or more, run the air
conditioning system at idle for
about five minutes in the fresh air
and high blower setting. This will
ensure adequate system lubrication
to minimize the possibility of com-
pressor damage when the system is
started again. REPLACEMENT BULBS
All the inside bulbs are brass or glass
wedge base. Aluminum base bulbs are
not approved and should not be used
for replacement.
LIGHT BULBS –
Interior Bulb No.
Front Courtesy/Reading
Lamp . . . . . . . . . . . . . 578/W5W
Center Courtesy/Reading
Lamp . . . . . . . . . . . . . 578/W5W
Glove Box Lamp . . . . . . . . . 194
Shift Indicator
Lamp . . . . . . . . . . . IKLE14140
Rear Compartment (Trunk)
Lamp . . . . . . . . . . . . . . . . . . 579
NOTE: For lighted switches, see
your authorized dealer for re-
placement.
212

MAINTENANCE
SCHEDULEThe Scheduled Maintenance services
listed in this manual must be done at the
times or mileages specified to protect
your vehicle warranty and ensure the
best vehicle performance and reliability.
More frequent maintenance may be
needed for vehicles in severe operating
conditions, such as dusty areas and very
short trip driving. Inspection and ser-
vice should also be done anytime a mal-
function is suspected.The oil change indicator system will
remind you that it is time to take your
vehicle in for scheduled maintenance.On Electronic Vehicle Information
Center (EVIC) equipped vehicles “Oil
Change Required” will be displayed
in the EVIC and a single chime will
sound, indicating that an oil change is
necessary.
NOTE:

The oil change indicator message
will not monitor the time since the
last oil change. Change your ve-
hicles oil if it has been 12 months
since your last oil change even if
the oil change indicator message
is NOT illuminated.
 Under no circumstances should
oil change intervals exceed
12,000 km or 12 months, which-
ever comes first.
Your authorized dealer will reset the
oil change indicator message after
completing the scheduled oil change.CAUTION!
Failure to perform the required
maintenance items may result in
damage to the vehicle.
Thousands Of Kilometers 24 48 72 96 120 144 168 192 Months 12 24 36 48 60 72 84 96
Inspect and replace PCV valve if necessary. 
Check battery charge status and possibly recharge.        
Check tire condition/wear and adjust pressure, if necessary.        
Check operation of lighting system (headlamps, direction
indicators, hazard warning lights, luggage compartment,
passenger compartment, glove compartment, instrument
panel warning lights, etc.).        
Check operation of windshield washer system and adjust jets if
necessary.        
222

Thousands Of Kilometers 24 48 72 96 120 144 168 192Months 12 24 36 48 60 72 84 96
Check windshield/rear window wiper blade position/wear.        
Check cleanliness of hood and tailgate locks and cleanliness
and lubrication of linkages.        
Visually inspect condition of: exterior bodywork, underbody
protection, pipes and hoses (exhaust - fuel system - brakes),
rubber elements (boots, sleeves, bushes, etc.).        
Check conditions and wear of front disc brake pads.        
Check conditions and wear of rear disc brake pads.        
Check and, if necessary, top up fluid levels (brakes, windshield
washer, battery, engine coolant, etc.).        
Visually inspect the condition of accessory drive belt/s. 
Check the handbrake lever stroke and adjust it, if necessary. 
Check exhaust gas emissions.        
Check engine management system operation (via diagnostic
socket).        
Change the automatic transmission fluid and filter. (*) 
Replace spark plugs. 
Replace air filter cartridge. 
Change engine oil and replace oil filter.**
Change brake fluid (or every 24 months). 
Replace pollen filter.        
(*) Change the automatic transmis-
sion fluid and filter(s) at 96 kkm or
48 months if using your vehicle for
any of the following: city driving, short (less than 7-8 km) and repeated
journeys, or frequent trailer or cara-
van towing.
** The engine oil and the oil filter
must be changed when the instrument
panel warning light comes on or in
any case every 12 months.
223

Periodic Checks
Every1,000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 Power Steering Fluid;
 windshield washer fluid level;
 power steering fluid;
tire inflation pressure and condition; operation of lighting system (head- lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3,000 km, check and top up, if
required, the engine oil level. Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;

short, repeated journeys (less than
7-8 km) at sub-zero outside
temperatures; engine often idling or driving long
distances at low speeds or long pe-
riods of idleness.
You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi- tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;  visually inspect conditions of: en-
gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the accessory drive belts;
 check and, if necessary, change engine oil and replace oil filter;
 check and, if necessary, replace pol- len filter;
 check and, if necessary, replace air cleaner.
224

About Your Brakes. . . . . . . . . . .150
ABS (Anti-Lock Brake System) . . .151
Adding Engine Coolant (Antifreeze) . . . . . . . . . . . . . .199
Adding Fuel . . . . . . . . . . . . . . .167
Adding Washer Fluid . . . . . . . . .196
Additives, Fuel . . . . . . . . . . . . . .166
Airbag . . . . . . . . . . . . . . . . . . . .31
Airbag Deployment . . . . . . . . . . .36
Airbag Light . . . . . . .34, 37, 49, 112
Airbag Maintenance . . . . . . . . . . .37
Airbag, Side . . . . . . . . . . .32, 34, 35
Airbag, Window (Side Curtain) . . . .34
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . . . . . . . .192
Air Conditioner Maintenance . . . .194
Air Conditioning Filter . . . . .136, 194
Air Conditioning, Operating Tips . . . . . . . . . . . .135
Air Conditioning Refrigerant . . . .194
Air Conditioning System . . .129, 194
Air Pressure, Tires . . . . . . . . . . .157
Alarm (Security Alarm) . . . . . . . . .15
Alarm System (Security Alarm) . . . . . . . . . . . . . .15, 116
Alterations/Modifications, Vehicle . . .7
Antifreeze (Engine Coolant) . . . . . . . . . . . .198, 216
Disposal . . . . . . . . . . . . . . .200 Anti-Lock Brake System (ABS)
. . .151
Anti-Lock Warning Light . . . . . .151
Anti-Theft Security Alarm (Theft Alarm) . . . . . . . . . . . . .15
Ashtray . . . . . . . . . . . . . . . . . .103
Auto Down Power Windows . . . . . .20
Automatic Door Locks . . . . . . . . .19
Automatic Headlights . . . . . . . . . .94
Automatic Oil Change Indicator . . . . . . . . . . . .114, 121
Automatic Temperature Control (ATC) . . . . . . . . . . . .129
Automatic Transaxle . . . . . . .12, 140
Automatic Transmission . . . .141, 202
Adding Fluid . . . . . . . . . . . .203
Fluid and Filter Changes . . . .203
Fluid Level Check . . . . . . . . .203
Fluid Type . . . . . . . . . . . . . .202
Gear Ranges . . . . . . . . . . . . .143
Autostick . . . . . . . . . . . . . . . . .147
Auto Unlock, Doors . . . . . . . . . . .19
Battery . . . . . . . . . . . . . . . . . . .193
Keyless Transmitter
Replacement (RKE) . . . . . . . . .18
Location . . . . . . . . . . . . . . .193
Belts, Seat . . . . . . . . . . . . . . .24, 48
Body Mechanism Lubrication . . . .195
Brake Assist System . . . . . . . . . .154 Brake, Parking
. . . . . . . . . . . . . .150
Brakes . . . . . . . . . . . . . . . . . . .201
Brake System . . . . . . . . . . . . . . .201
Anti-Lock (ABS) . . . . . . . . . .151
Fluid Check . . . . . . . . . . . . .201
Master Cylinder . . . . . . . . . .201
Parking . . . . . . . . . . . . . . . .150
Warning Light . . . . . . . . . . .112
Brake/Transmission Interlock . . . .142
Break-In Recommendations, New Vehicle . . . . . . . . . . . . . . .47
Bulb Replacement . . . . . . . .212, 213
Bulbs, Light . . . . . . . . . . . . .50, 212
Calibration, Compass . . . . . . . . .123
Capacities, Antifreeze (Engine Coolant) . . . . . . . . . . .16
Capacities, Fluid . . . . . . . . . . . .216
Caps, Filler Fuel . . . . . . . . . . . . . . . . . .167
Oil (Engine) . . . . . . . . . . . . .189
Power Steering . . . . . . . . . . .153
Radiator (Coolant Pressure) . .199
Carbon Monoxide Warning . . . . . .48
Car Washes . . . . . . . . . . . . . . . .204
Cellular Phone . . . . . . . . . . .67, 129
Checking Your Vehicle For Safety . . . . . . . . . . . . . . . . . . .47
Checks, Safety . . . . . . . . . . . . . . .47
226

High Beam/Low Beam Select
Switch. . . . . . . . . . . . . . . . . .96
Leveling . . . . . . . . . . . . . . . .97
Lights On Reminder . . . . . . . .94
On With Wipers . . . . . . . . .94, 99
Passing . . . . . . . . . . . . . . . . .96
Replacing . . . . . . . . . . . . . . .213
Switch . . . . . . . . . . . . . . . . . .94
Time Delay . . . . . . . . . . . . . .95
Head Restraints . . . . . . . . . . . . . .91
High Beam/Low Beam Select (Dimmer) Switch . . . . . . . . . . .96
Hood Prop . . . . . . . . . . . . . . . . .93
Hood Release . . . . . . . . . . . . . . . .93
Ignition . . . . . . . . . . . . . . . . . . .12
Key . . . . . . . . . . . . . . . . . . . .12
Lock . . . . . . . . . . . . . . . . . . .12
Ignition Key Removal . . . . . . . . . .12
Illuminated Entry . . . . . . . . . . . . .16
Immobilizer (Sentry Key) . . . . . . .13
Infant Restraint . . . . . . . . . . .39, 41
Information Center, Vehicle . . . . .119
Instrument Cluster . . . . . . .110, 111
Instrument Panel and Controls . . .109
Instrument Panel Lens Cleaning . .206
Integrated Power Module (Fuses) . . . . . . . . . . . . . . . . .208
Interior Appearance Care . . . . . . .205Interior Lighting
. . . . . . . . . . . . .96
Intermittent Wipers (Delay Wipers) . . . . . . . . . . . . .98
Introduction . . . . . . . . . . . . . . . . .4
Jump Starting . . . . . . . . . . . . . .179
Key-In Reminder . . . . . . . . . . . . .13
Keyless Entry System (Sedan) . . . .16
Key, Programming . . . . . . . . . . . .14
Key, Replacement . . . . . . . . . . . . .14
Keys . . . . . . . . . . . . . . . . . . . . .12
Key, Sentry (Immobilizer) . . . . . . .13
Knee Bolster . . . . . . . . . . . . . . . .31
Lane Change and Turn Signals . . . . . . . . . . .96, 115, 214
Lane Change Assist . . . . . . . . . . .96
Lap/Shoulder Belts . . . . . . . . . . . .24
Latches . . . . . . . . . . . . . . . . . . .50
Hood . . . . . . . . . . . . . . . . . .93
LATCH (Lower Anchors and Tether for CHildren) . . . . . .43, 44
Latch Plate . . . . . . . . . . . . . . . . .25
Lead Free Gasoline . . . . . . . . . . .164
Leaks, Fluid . . . . . . . . . . . . . . . .50
Leveling, Headlight . . . . . . . . . . .97
Life of Tires . . . . . . . . . . . . . . .159
Light Bulbs . . . . . . . . . . . . .50, 212 Lights
. . . . . . . . . . . . . . . . . .50, 94
Airbag . . . . . . . .34, 37, 49, 112
Automatic Headlights . . . . . . .94
Back-Up . . . . . . . . . . . . . . .214
Battery Saver . . . . . . . . . . . . .97
Brake Assist Warning . . . . . . .156
Brake Warning . . . . . . . . . . .112
Bulb Replacement . . . . . . . . .213
Courtesy/Reading . . . . . . . . . .96
Dimmer Switch,
Headlight . . . . . . . . . . . . .94, 96
Electronic Stability Program
(ESP) Indicator . . . . . . . . . .156
Engine Temperature
Warning . . . . . . . . . . . . . . .112
Exterior . . . . . . . . . . . . . . . . .50
Fog . . . . . . . . . . . .95, 115, 214
Headlight Leveling . . . . . . . . .97
Headlights . . . . . . . . . . . . . . .94
Headlights On Reminder . . . . .94
Headlights On With
Wipers . . . . . . . . . . . . . . .94, 99
Headlight Switch . . . . . . . . . .94
High Beam . . . . . . . . . . . . . . .96
High Beam Indicator . . . . . . .119
High Beam/Low Beam Select . .96
Illuminated Entry . . . . . . . . . .16
Interior . . . . . . . . . . . . . . . . .96
License . . . . . . . . . . . . . . . .215
229