2013 FORD F650 oil filter

SEVERE SERVICE - ON/OFF ROAD IN DIRTY CONDITIONS OR 20000 MILES (32000 KM) OR FEWER
ANNUALLY
(Miles, kilometers or months - whichever occurs first)
Miles (x 1000) 55 60 65 70 75 80 85 90 95 100
Kilometers (x 1000) 88 96 104 112 120 128 136 144 152 160
Months 33 36 39 42 45 48 51 54 57 60
Engine
Engine oil and filter - change (diesel engine) See manufacturer’s recommendation.
Engine oil and filter - change (gasoline engine) Every 5000 miles (8000 km) or three months (see note at end
of table regarding alternate schedule)
Engine coolant - check level and concentration••••••••••
Engine coolant - check freeze-protection and additive
(corrosion inhibitor) strength (diesel engine)••••••••••
Extended life coolant - add extender (diesel engine) See manufacturer’s recommendation.
Extended life coolant - replace (diesel engine) See manufacturer’s recommendation.
Engine coolant - replace (gasoline engine) At six years or 100000 miles (160000 km) (whichever comes
first), then every three years or 50000 miles (80000 km)
Engine air filter - inspect (gasoline engine)••••••••••
Engine air filter - replace (gasoline engine)••
Replace spark plugs•
Inspect accessory drive belt(s) Inspect at 100000 miles (160000 km) and 120000 miles
(192000 km). Replace at 150000 miles (240000 km) if not
replaced in the last 100000 miles (160000 km).
Scheduled Maintenance311
2013 F-650/750(f67)
Owners Guide gf, 2nd Printing, March 2013
USA(fus)

SEVERE SERVICE - ON/OFF ROAD IN DIRTY CONDITIONS OR 20000 MILES (32000 KM) OR FEWER
ANNUALLY (Continued)
(Miles, kilometers or months - whichever occurs first)
Miles (x 1000) 55 60 65 70 75 80 85 90 95 100
Kilometers (x 1000) 88 96 104 112 120 128 136 144 152 160
Months 33 36 39 42 45 48 51 54 57 60
Non-driving Front Axle
Drag link/kingpin and bushing/tie rod ends - lubricate••••••••••
Wheel bearing - grease type - repack•••
Wheel bearing - oil type - change oil•••
Wheel bearing - oil type - check level••••••••••
Brake System
Master cylinder - check fluid level (hydraulic brakes)••••••••••
Parking brake relay lever/linkage - lubricate (hydraulic
brakes)•••
S-cam - lubricate (air brakes)••••••••••
Slack adjusters - lubricate (air brakes)•••
Steering
Power steering filter - replacement•
Power steering fluid - change•••
Power steering fluid - check level••••••••••
Steering column U-joints/slip joint - lubricate••••••••••
Steering gear Ross TAS - output seal - lubricate•••
312Scheduled Maintenance
2013 F-650/750(f67)
Owners Guide gf, 2nd Printing, March 2013
USA(fus)

SEVERE SERVICE - ON/OFF ROAD IN DIRTY CONDITIONS OR 20000 MILES (32000 KM) OR FEWER
ANNUALLY (Continued)
(Miles, kilometers or months - whichever occurs first)
Miles (x 1000) 55 60 65 70 75 80 85 90 95 100
Kilometers (x 1000) 88 96 104 112 120 128 136 144 152 160
Months 33 36 39 42 45 48 51 54 57 60
Meritor - filter change Every 100000 miles (160000 km)
Meritor - petroleum oil - change Every 25000 miles (40000 km) or annually (whichever comes
first)
Meritor - synthetic oil - change Every 100000 miles (160000 km) or annually (whichever comes
first)
Cab Components
Door hinges/latches/strikers/lock cylinders - lubricate•••
Seat adjuster slides - lubricate•••
Diesel Exhaust Fluid (DEF) System
Check and refill DEF system••••••••••
Note:If your vehicle is equipped with a gasoline engine, the engine oil and filter changes should
observe the normal schedule unless conditions, such as low-speed operation or stationary use, exist
where a schedule based on engine hours is recommended. In this type of schedule, the engine oil
and filter should be replaced every 250 engine hours.
314Scheduled Maintenance
2013 F-650/750(f67)
Owners Guide gf, 2nd Printing, March 2013
USA(fus)

Child safety seats - booster
seats .............................................31
Cleaning your vehicle ...............242
engine compartment ..............245
exterior ....................................242
instrument panel ....................247
interior .....................................246
plastic parts ............................244
washing ....................................242
waxing .....................................244
wheels ......................................248
wiper blades ............................245
Climate control (see Air
conditioning or Heating) ............88
Clock ......................................79–80
Clutch ................................133, 229
adjusting ..................................230
fluid ..........................................229
specifications ..........................264
Coolant ......................................219
checking and adding ..............219
refill capacities ........................277
specifications ..........................264
Cruise control ...........................166
Customer Assistance ................184
Getting assistance outside the
U.S. and Canada .....................191
Getting roadside assistance ...184
Getting the service you
need .................................189, 204
Ordering additional owner’s
literature .................................192
Utilizing the
Mediation/Arbitration
Program ...................................191
D
Daytime running lamps
(see Lamps) ................................57Defrost .........................................88
Diesel exhaust fluid (DEF) .....120
Diesel Particulate Filter
(DPF) ........................................106
Dipstick
automatic transmission fluid...223
engine oil .................................217
Doors
lubricant specifications ..........264
Drivebelt ....................................263
Driving under special
conditions
through water .........................183
E
Electronic message center .........74
Emergencies, roadside
jump-starting ..........................185
running out of fuel .................116
Emergency Flashers .................185
Emission control system ..130, 288
catalytic converter ..................213
End user license agreement ....364
Engine ........................................263
cleaning ...................................245
coolant .....................................219
fail-safe cooling .......................222
lubrication specifications .......264
Engine block heater .................111
Engine fan .................................219
Engine oil
checking and adding ......217–218
dipstick ....................................217
filter, specifications ................280
refill capacities ........................277
specifications ..........................264
Index373
2013 F-650/750(f67)
Owners Guide gf, 2nd Printing, March 2013
USA(fus)