2013 DODGE JOURNEY air condition

Refrigerant Recovery And Recycling
R-134a Air Conditioning Refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
Protection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by authorized dealer or other
service facilities using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C system
sealers, stop leak products, seal conditioners, compressor
oil, and refrigerants.
A/C Air Filter – If Equipped
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Do not remove the A/C air filter while the blower is
operating or personal injury may result.
The A/C air filter is located in the fresh air inlet behind
the glove box. Perform the following steps to replace the
filter:
1. Open the glove box and remove all contents.
2. Push the retaining tab on each side of the glove box
inward while gently pulling the glove box door out-
ward until both tabs clear the door opening in the
instrument panel.
538 MAINTAINING YOUR VEHICLE

•If frequent engine coolant (antifreeze) additions are
required, the cooling system should be pressure tested
for leaks.
•
Maintain engine coolant (antifreeze) concentration at a
minimum of 50% OAT coolant (conforming to MS-12106)
and distilled water for proper corrosion protection of
your engine which contains aluminum components.
•Make sure that the coolant expansion bottle overflow
hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean.
•
Do not change the thermostat for Summer or Winter
operation. If replacement is ever necessary, install ONLY
the correct type thermostat. Other designs may result in
unsatisfactory engine coolant (antifreeze) performance,
poor gas mileage, and increased emissions.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
WARNING!
Riding the brakes can lead to brake failure and
possibly a collision. Driving with your foot resting or
riding on the brake pedal can result in abnormally
high brake temperatures, excessive lining wear, and
possible brake damage. You would not have your full
braking capacity in an emergency.
552 MAINTAINING YOUR VEHICLE

Frequency Of Fluid Change
Refer to the “Maintenance Schedule” for the proper
maintenance intervals.
Appearance Care And Protection From Corrosion
Protection Of Body And Paint From Corrosion
Vehicle body care requirements vary according to geo-
graphic locations and usage. Chemicals that make roads
passable in snow and ice and those that are sprayed on
trees and road surfaces during other seasons are highly
corrosive to the metal in your vehicle. Outside parking,
which exposes your vehicle to airborne contaminants,
road surfaces on which the vehicle is operated, extreme
hot or cold weather and other extreme conditions will
have an adverse effect on paint, metal trim, and under-
body protection.The following maintenance recommendations will enable
you to obtain maximum benefit from the corrosion
resistance built into your vehicle.
What Causes Corrosion?
Corrosion is the result of deterioration or removal of
paint and protective coatings from your vehicle.
The most common causes are:
•Road salt, dirt and moisture accumulation.
•Stone and gravel impact.
•Insects, tree sap and tar.
•Salt in the air near seacoast localities.
•Atmospheric fallout/industrial pollutants.
7
MAINTAINING YOUR VEHICLE 559

CavityCar-
tridge
FuseMini-
FuseDescription
F168 10 Amp
RedAir Conditioner
Clutch
F169 40 Amp
GreenEmissions – Partial
Zero Emissions
Vehicle Motor
F170 15 Amp
BlueEmissions – Partial
Zero Emissions
Vehicle Actuators
F172 20 Amp
YellowSpare
F173 25 Amp
NaturalAnti Lock Brake
Valves
F174 20 Amp
YellowSiren – If EquippedCavityCar-
tridge
FuseMini-
FuseDescription
F175 30 Amp
GreenSpare
F176 10 Amp
RedPowertrain Control
Modules
F177 20 Amp
YellowAll Wheel Drive
Module – If Equipped
F178 25 Amp
NaturalSunroof – If Equipped
F179 10 Amp
RedBattery Sensor
F181 100
Amp
BlueElectrohydraulic
Steering (EHPS) –
If Equipped
7
MAINTAINING YOUR VEHICLE 571

Once A Month Or Before A Long Trip:
•Check engine oil level
•Check windshield washer fluid level
•Check the tire inflation pressures and look for unusual
wear or damage
•Check the fluid levels of the coolant reservoir, brake
master cylinder, power steering and transmission as
needed
•Check function of all interior and exterior lights
Required Maintenance Intervals.
Refer to the maintenance schedules on the following
page for the required maintenance intervals.At Every Oil Change Interval As Indicated By
Oil Change Indicator System:
•Change oil and filter.
•Rotate the tires.Rotate at the first sign of irregu-
lar wear, even if it occurs before the oil indicator
system turns on.
•Inspect battery and clean and tighten terminals as
required.
•Inspect automatic transmission fluid if equipped
with dipstick.
•Inspect brake pads, shoes, rotors, drums, hoses
and park brake.
•Inspect engine cooling system protection and
hoses.
•Inspect exhaust system.
•Inspect engine air cleaner if using in dusty or
off-road conditions.
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
SMAINTENANCE SCHEDULES 587

Maintenance Chart
Refer to the Maintenance Schedules on the following pages for the required maintenance intervals.
Mileage or time passed
(whichever comes first)
20,000
30,000
40,000
50,000
60,000
70,000
80,000
90,000
100,000
110,000
120,000
130,000
140,000
150,000
Or Years: 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Or Kilometers:
32,000
48,000
64,000
80,000
96,000
112,000
128,000
144,000
160,000
176,000
192,000
208,000
224,000
240,000
Additional Inspections
Inspect the CV joints. X X X X X
Inspect front suspension, tie rod
ends, and replace if necessary.XXX X X X X
Inspect the brake linings, parking
brake function.XXX X X X X
Additional Maintenance
Replace engine air filter. X X X X X
Replace air conditioning filter. X X X X X X X
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S588 MAINTENANCE SCHEDULES

About Your Brakes........................422
ABS (Anti-Lock Brake System)................425
Adding Engine Coolant (Antifreeze)............549
Adding Fuel.............................477
Adding Washer Fluid......................543
Additives, Fuel...........................471
Airbag..................................63
Airbag Deployment........................74
Airbag Light.............................71
Airbag Maintenance........................76
Airbag, Side..............................66
Airbag, Window (Side Curtain)................67
Air Cleaner, Engine (Engine Air Cleaner Filter). . . .534
Air Conditioner Maintenance.................537
Air Conditioning Filter.....................384
Air Conditioning, Operating Tips..............385
Air Conditioning, Rear Zone.................379
Air Conditioning Refrigerant.................537
Air Conditioning System....................378Air Pressure, Tires.........................446
Alarm Light.............................301
Alarm, Panic.............................24
Alarm (Security Alarm)......................18
Alarm System (Security Alarm)................18
All Wheel Drive (AWD).....................417
Alterations/Modifications, Vehicle...............7
Antifreeze (Engine Coolant)..................547
Disposal..............................550
Anti-Lock Brake System (ABS)................425
Anti-Lock Warning Light....................300
Anti-Theft Security Alarm (Theft Alarm)..........18
Appearance Care.........................559
Arming Theft System (Security Alarm)...........18
Auto Down Power Windows..................41
Automatic Dimming Mirror..................116
Automatic Door Locks......................32
Automatic Headlights......................221
Automatic Oil Change Indicator...............311
606 INDEX

Filters
Air Cleaner...........................534
Air Conditioning.......................384
Engine Oil............................534
Engine Oil Disposal.....................534
Flashers
Hazard Warning........................498
Turn Signal...........................108
Flash-To-Pass............................225
Flexible Fuel Vehicles
Cruising Range.........................476
Engine Oil............................475
Fuel Requirements......................473
Maintenance...........................476
Replacement Parts.......................476
Starting..............................476
Flooded Engine Starting....................395
Floor Console............................271
Fluid, Brake.............................583Fluid Capacities..........................580
Fluid Leaks.............................108
Fluid Level Checks
Automatic Transmission..................555
Brake................................553
Cooling System.........................547
Engine Oil............................531
Power Steering.........................421
Fluids, Lubricants and Genuine Parts...........582
Fog Lights..............................223
Fog Light Service.........................575
Folding Rear Seat.........................209
Freeing A Stuck Vehicle.....................517
Fuel...................................468
Adding..............................477
Additives.............................471
Clean Air.............................469
Conserving
............................312
Ethanol..............................469
612 INDEX