Page 332 of 400

08 Maintenance and service
Battery
08
330* Option/accessory, for more information, see Introduction.
NOTE
Tighten the screws to 30 Nm. Check the
torque with a torque wrench.
Fitting
1. Lower the battery into the battery box.
2. Move the battery inward and to the side
until it reaches the rear edge of the box.
3. Tighten the clamp that holds the battery.
4. Connect the ventilation hose.
> Check that it is correctly connected to
both battery and outlet in the body.
5. Connect the red positive cable.
6. Connect the black negative cable.
7. Press in the rear cover. (See Removal).8. Fit the rubber moulding. (See Removal).
9. Align the front cover and secure it with the
clips. (See removal).
For more information on the car's main battery
- see page 369
Eco Start/Stop DRIVe*
Cars with the Start/Stop function are equipped
with two 12 V batteries - one extra powerful
battery for starting and one standby battery
that helps during the Eco Start/Stop DRIVe
function's starting sequence.
For more information on Start/Stop - see
page 123.
For more information on the car's main battery
- see page 116 and 369.
BatteryStartSupport
Cold
start
capacity
A, CCA
(A)760120B
180C
SizeD,
L×W×H
(mm)278×175×190150×90×106B
150×90×130C
Capacity
(Ah)708B
10C
AIn accordance with the SAE standard.BRight-hand drive or left-hand drive cars with manual gear-
box.
CLeft-hand drive D3 with automatic gearbox.DLargest possible size.
IMPORTANT
When replacing batteries in cars with the
Start/Stop function, the AGM1 type batter-
ies must be fitted.
1Absorbed Glass Mat
ProCarManuals.com
Page 333 of 400

08 Maintenance and service
Battery
08
331
NOTE
•The higher the current take-off in the car
(extra cooling/heating, etc.) the more
the batteries must be charged =
increased fuel consumption.
•When the capacity of the battery has
fallen below the lowest permissible level
then the Start/Stop function is disen-
gaged.
Temporarily reduced Start/Stop function due
to high current take-off means:
•The engine starts automatically2 without
the driver depressing the clutch pedal
(manual gearbox).
•The engine starts automatically without the
driver lifting his/her foot off the foot brake
pedal (automatic gearbox).
Location of the batteries
A: Left-hand drive car. B: Right-hand drive car. 1.
Battery for starting3 2. Support battery.
The support battery normally requires no more
service than the normal battery that is used for
starting. A workshop should be contacted in
the event of questions or problems - an author-
ised Volvo workshop is recommended.
IMPORTANT
If the following instruction is not observed
then the Start/Stop function may temporar-
ily cease to work after the connection of an
external battery or battery charger:
•The negative battery terminal on the
car's main battery must never be used
for connecting an external battery or
battery charger - only the car chassis
may be used as the grounding point.
See the section "Start assistance" - for a
description of how the cable clamps must
be attached.
2Automatic starting can only take place if the gear lever is in neutral position.3The battery for starting is described in detail on page 328.
ProCarManuals.com
Page 355 of 400

09 Specifications
Type designations09
353
Knowing the car's type designation, vehicle
identification and engine numbers can facili-
tate all contact with an authorised Volvo dealer
regarding the car and when ordering spare
parts and accessories.
Type designation, vehicle identification
number, maximum permissible weights,
codes for colour and upholstery and type
approval number. The label is visible when
the right rear door is opened.
Label for parking heater.
Engine code, component and serial num-
bers.
Label for engine oil.
Gearbox type designation and serial num-
ber.
Manual gearbox
Automatic gearbox
Car's identification number. (VIN Vehicle
Identification Number)
Further information on the car is presented in
the registration document.
NOTE
The labels shown in the owner's manual are
not provided as exact reproductions of
those in the car. The purpose is to show
their approximate appearance and location
in the car. The information that applies to
your car in particular is available on the label
in question in your car.
ProCarManuals.com
Page 358 of 400
09 Specifications
Dimensions and weights 09
356
Towing capacity and towball load
EngineGearboxMax. weight braked trailer (kg)Max. towball load (kg)
T3AManual, MMT6160075
T4AManual, MMT6160075
T4AAutomatic, MPS6160075
T4FManual, MMT6160075
T4FAutomatic, MPS6160075
T5Manual, MMT6180090
T5Automatic, MPS6180090
T6 AWDAutomatic, TF-80SC180090
DRIVeManual, MMT6130075
D3Manual, M66160075
D3Automatic, TF-80SCB160075
D3Automatic, TF-80SDC160075
D5Manual, M66160075
D5Automatic, TF-80SC180090
D5 AWDAutomatic, TF-80SC180090
ADRIVe for certain markets.BWithout Start/Stop.CWith Start/Stop.
ProCarManuals.com
Page 360 of 400
09 Specifications
Engine specifications 09
358
Engine specifications
NOTE
Not all engines are available in all markets.
EngineEngine
codeAOutput
(kW/rpm)Output
(hp/rpm)Torque (Nm/
rpm)No. of
cylin-
dersBore
(mm)Stroke
(mm)Swept
volume
(litres)Com-
pression
ratio
T3BB4164T3110/5700150/5700240/1600–400047981.41.59610.0:1
T4BB4164T132/5700180/5700240/1600–500047981.41.59610.0:1
T4FB4164T2132/5700180/5700240/1600–500047981.41.59610.0:1
T5B4204T7177/5500240/5500320/1800-5000487.583.11.99910.0:1
T6B6304T4224/5600304/5600440/2100–4200682.093.22.9539.3:1
DRIVeD4162T84/3600115/3600270/1750-250047588.31.56016.0:1
D3D5204T3120/3500163/3500400/1500-2750581.0771.98416.5:1
D5D5244T11C158/4000215/4000420/1500–3250581.093.152.40016.5:1
D5D5244T15D158/4000215/4000440/1500-3000581.093.152.40016.5:1
AEngine code, component and serial number can be read on the engine, see page 352.BDRIVe for certain markets.CManual gearboxDAutomatic gearbox
ProCarManuals.com
Page 362 of 400
09 Specifications
Engine oil 09
360
Engine oil grade
EngineEngine codeRecommended oil gradeVolume, incl. oil filter
(litres)
T6B6304T4Oil grade: ACEA A5/B5
Viscosity: SAE 0W–30approx 6.8
D3D5204T3approx. 5.9
D5D5244T11Aapprox. 5.9
D5D5244T15Bapprox. 5.9
T5B4204T7Oil grade: ACEA A5/B5
Viscosity: SAE 5W–30
When driving under adverse conditions, use ACEA A5/B5 SAE 0W-30.approx. 5.4
DRIVeD4162Tapprox. 3.8
T3CB4164T3Certified and factory-filled oil: Oil grade WSS-M2C925-A
options for service:
Oil grade: ACEA A5/B5
Viscosity: SAE 5W–30approx. 4.1
T4CB4164Tapprox. 4.1
T4FB4164T2approx. 4.1
AManual gearboxBAutomatic gearboxCDRIVe for certain markets.
For filling engine oil, see page 313.
ProCarManuals.com
Page 363 of 400
09 Specifications
Fluids and lubricants09
361 Other fluids and lubricants
Manual gearboxVolume (litres)Prescribed transmission fluid
MMT61.7BOT 350M3M661.9
Automatic gearboxVolume (litres)Prescribed transmission fluid
MPS67.3BOT 341
TF-80SC7.0AW1
TF-80SD7.0AW1
FluidSystemVolume (litres)Prescribed grade
CoolantT510.5
Coolant recommended by Volvo mixed with 50% waterA, see the packaging.
T6, D3 and D58.9
T3B, T4B, C and T4FC9.2
T4B, D and T4FD9.8
DRIVe10.5
Brake fluidBrake system0.6DOT 4+
Power steering
fluidPower steering-WSS M2C204-A2 or equivalent product.
ProCarManuals.com
Page 364 of 400
09 Specifications
Fluids and lubricants 09
362
FluidSystemVolume (litres)Prescribed grade
Washer fluidCars with headlamp washing5.4Washer fluid recommended by Volvo - with frost protection during coldweather and below freezing point.
Cars without headlampwashing4.0
FuelPetrol engineapprox. 67Petrol: see page 274
Diesel engineapprox. 67Diesel: see page 275
AWater quality must fulfil the standard STD 1285.1.BDRIVeCManual gearboxDAutomatic gearbox
NOTE
Under normal driving conditions, the gear- box oil does not need to be changed duringits service life. However, this may be nec-essary under adverse driving conditions,see page 361.
ProCarManuals.com