2012 VOLVO S60 headlight bulb

08 Maintenance and specifications
Replacing bulbs
08
306* Option/accessory, for more information, see Introduction.
Introduction
All bulb specifications are listed on page 311.
The following bulbs should only be replaced by
a trained and qualified Volvo service techni-
cian:
•Dome lighting
•Reading lights
•Glove compartment lighting
•Footwell lighting
•Turn signals in the door mirrors
•Approach lighting in the door mirrors
•Active Bending Lights and LED bulbs
See page 311 for a list of bulb specifications.
NOTE
For information regarding any other bulbs
not mentioned in this section, please con-
tact your Volvo retailer or a trained and
authorized Volvo service technician.
WARNING
•The engine should not be running when
changing bulbs.
•If the engine has been running just prior
to replacing bulbs in the headlight hous-
ing, please keep in mind that compo-
nents in the engine compartment will be
hot.
WARNING
•Active Bending Lights* – due to the high
voltage used by these headlights, these
bulbs should only be replaced by a
trained and qualified Volvo service tech-
nician.
•Turn off the lights and remove the
remote key from the ignition before
changing any bulbs.
Headlight housing
The entire headlight housing must be lifted out
when replacing all front bulbs.

08 Maintenance and specifications
Replacing bulbs
08

307
CAUTION
Never touch the glass of bulbs with your fin-
gers. Grease and oils from your fingers
vaporize in the heat and will leave a deposit
on the reflector, which will damage it.
NOTE
•Always switch off the ignition before
starting to replace a bulb.
•The optional Active Bending Light bulbs
contain trace amounts of mercury.
These bulbs should always be disposed
of by a trained and qualified Volvo serv-
ice technician.
Removing the headlight housing1. Switch off the ignition by briefly pressing
the START/STOP ENGINE button.
2. Remove the remote key from the ignition
slot
1.
3. (Upper illustration under "Headlight hous-
ing")
Withdraw the headlight housing's lock-
ing pins.
Remove the headlight housing by alter-
natively pulling the front and rear edges
until it can be lifted out.
CAUTION
When disconnecting the connector, pull on
the connector itself and not on the wiring.
4. (Lower illustration under "Headlight hous-
ing")
Unplug the wiring connector by holding
down the clip with your thumb.
Pull out the connector with the other
hand.
5. Lift out the housing and place it on a soft
surface to avoid scratching the lens.
6. Replace the defective bulb(s).
Reinserting the headlight housing
1. Plug in the connector until it clicks into
place.
2. Reinstall the headlight housing and locking
pins. The short locking pin should be clos-
est to the grille. Check that they are cor-
rectly inserted. The headlight housing must
be properly inserted and secured in place
before the lighting is switched on or the
remote key is inserted into the ignition slot.
3. Check that the lights function properly.
1Does not apply to vehicles with the optional keyless drive.

08 Maintenance and specifications
Replacing bulbs
08
308
Removing the cover to access the
bulbs
NOTE
Before starting to replace a bulb, see
page 306.
1. Loosen the cover's four retaining screws
with the tool (1) provided in the vehicle's
tool kit (see page 290). The screws should
not be removed completely.
CAUTION
Use the tool from the vehicle's tool kit to
loosen the screws. A screwdriver or other
sharp object could scratch the headlight.
2. Push the cover to the side.Reinstall the cover in the reverse order.
Low beam, Halogen
1. Remove the headlight housing from the
vehicle (see page 306).
2. Remove the cover over the bulbs (see
page 308).
3. Unplug the connector from the bulb.
4. Remove the bulb by pulling it straight out.
5. The guide lug on the new bulb should be
straight up when the bulb is inserted into
the holder and the bulb should snap into
place.
6. Put the cover back into position and rein-
stall the headlight housing.
High beam, Halogen
1. Remove the headlight housing from the
vehicle (see page 306).
2. Remove the cover over the bulbs (see
page 308).
3. Remove the bulb by turning it counter-
clockwise and pulling it straight out.
4. Remove the connector from the bulb.
5. Press the new bulb into the socket and turn
it clockwise to put it in place. It can only be
secured in one position.
6. Reinsert the bulb holder into the headlight
housing.
7. Put the cover back into position and rein-
stall the headlight housing.

08 Maintenance and specifications
Replacing bulbs
08

309 Extra high beam
2
1. Remove the headlight housing from the
vehicle (see page 306).
2. Remove the cover over the bulbs (see
page 308).
3. Remove the bulb by turning it counter-
clockwise and pulling it straight out.
4. Remove the connector from the bulb.
5. Press the new bulb into the socket and turn
it clockwise to put it in place. It can only be
secured in one position.
6. Put the cover back into position and rein-
stall the headlight housing.
Turn signals
1. Remove the headlight housing from the
vehicle (see page 306).
2. Remove the cover by pulling it straight out.
3. Pull the holder to access the bulb.
4. Press in the bulb and turn it to remove it
from the holder.
5. Press and turn the new bulb into place.
6. Reinsert the bulb holder into the headlight
housing.
7. Put the cover back into position and rein-
stall the headlight housing.
Taillight housing
The bulbs in the taillight cluster are replaced
from inside the trunk (not the LED functions).
NOTE
Before starting to replace a bulb, see
page 306.
1. Remove the covers in the left/right panel to
access the bulb holder.
2. Press the catches together and pull out the
bulb holder.
3. Remove the defective bulb by pressing it in
slightly and it turning counterclockwise
before pulling it out.
2Models with optional Active Bending Lights only.

10 Index
10
349
Bulbs
headlights...................................306, 308
introduction......................................... 306
license plate lights.............................. 310
specifications...................................... 311
trunk lighting....................................... 311
C
Camera, Park Assist................................ 191
Capacity weight....................................... 279
Catalytic converter................................... 257
Cell phone, hands-free connection......... 232
Cell phone voice control.......................... 240
Central locking system, introduction......... 54
Chains...................................................... 282
Check engine light..................................... 80
Child restraints
recalls and registration......................... 41
Child restraint systems.............................. 42
booster cushions.................................. 48
convertible seats.................................. 46
infant seats........................................... 44
ISOFIX/LATCH anchors........................ 49
top tether anchors................................ 50Child safety................................................ 39
booster cushions.................................. 48
child restraint systems.......................... 42
convertible seats.................................. 46
infant seats........................................... 44
Child safety locks...................................... 51
City Safety™............................................ 168
Climate system........................................ 144
air distribution............................. 140, 146
air vents.............................................. 141
Interior Air Quality System.................. 140
introduction......................................... 139
passenger compartment filter............ 140
refrigerant........................................... 139
Clock, setting............................................. 84
Cold weather driving................................ 252
Collision warning system.................173, 174
Compass in rearview mirror..................... 108
Conserving electrical current................... 251
Controls, center console.......................... 244
Convertible seats....................................... 46
Coolant............................................304, 341
Cooling system, general information....... 251
Corner Traction Control........................... 149
Courtesy lighting................................99, 100Crash event data....................................... 11
Crash mode............................................... 38
Cruise control..................................153, 154
adaptive.............................................. 155
Curb weight............................................. 279
Current, conserving................................. 251D
Defroster.................................................. 144
Detachable key blade..........................59, 62
Disconnecting the front passenger’s air-
bag....................................................... 29, 30
Dome lighting..................................... 99, 100
Door mirrors............................................. 106
Driver alert............................................... 181
Driver distraction warning.......................... 14
Driving economically................................ 250
Driving in cold weather............................ 252
Driving through water..............................251

10 Index
10
350
E
ECC.................................................144, 145
Economical driving.................................. 250
Electric parking brake.............................. 124
Electronic Climate Control.......142, 144, 145
air distribution table............................ 146
Interior Air Quality System.................. 145
Emergency locking retractor...................... 40
Emergency starting.................................. 116
Emergency towing...........................265, 266
Emission inspection readiness................ 299
Engine
overheating........................................... 83
specifications...................................... 338
starting................................................ 114
switching off....................................... 116
Engine compartment overview................301
Engine Drag Control (EDC)......................149
Engine oil
checking............................................. 302
low pressure warning light.............. 81, 82
specifications...................................... 339
volumes.............................................. 340
Environment............................................... 13Eyelets for anchoring loads..................... 259
F
Federal Clean Air Act............................... 298
Floor mats
cleaning.............................................. 329
placing correctly................................. 114
Fluid specifications.................................. 341
Fog lights
front/rear............................................... 98
Four C (active chassis system)................152
Front airbags.............................................. 25
disconnecting passenger’s side air-
bag.................................................. 29, 30
Front park assist.............................. 187, 189
Front seats...........................................88, 90
Fuel filler cap........................................... 257
Fuel filler door, opening........................... 256
Fuel level warning light.............................. 81
Fuel requirements............................ 254, 255
Fuel tank volume.....................................341
Fuses............................... 319, 320, 323, 326
G
Garage door opener
HomeLink® Wireless Control System. 111
Gasoline requirements............................. 255
Gas tank volume...................................... 341
Gauges...................................................... 79
Geartronic................................................ 119
Geartronic automatic transmission.. 118, 119
Generator warning light............................. 82
Glossary of tire terminology..................... 278
Grocery bag holder.................................. 260
Gross vehicle weight...............................279
H
Hazard warning flashers............................ 98
HD digital radio........................................ 215
Headlights
Active Bending Lights........................... 97
changing bulbs................................... 308
high/low beams.................................... 96
high beam flash.................................... 96
Headlight washers................................... 103

10 Index
10
355
U
Uniform Tire Quality Grading...................281
Unlocking the vehicle..........................57, 67
Upholstery care....................................... 328
V
Valet locking.............................................. 62
Vanity mirror............................................ 201
changing bulbs................................... 311
Vehicle Event Data..................................... 11
Vehicle loading................................259, 279
roof loads............................................ 261
Vehicle maintenance................................ 298
performed by the owner.....................299
Vehicle weights........................................ 337
Voice control
cell phones......................................... 240
Volvo and the environment........................ 13
Volvo maintenance.................................. 298
Volvo On Call Roadside Assistance........ 346
Volvo programs.......................................346
Volvo Sensus........................................... 130
W
Warning flashers, hazard........................... 98
Warning lights.......................... 79, 80, 81, 82
Warning symbol......................................... 83
Warning system, collision................173, 174
Warranties................................................ 298
Washer fluid..................................... 314, 341
Washers
headlight............................................. 103
windshield........................................... 102
Water, driving through............................. 251
Waxing..................................................... 328
Weights.................................................... 337
Wheels.....................................................270
changing............................................. 290
storing................................................. 271
Whiplash Protection System..................... 36
Windows
power.................................................. 104
Windshield
rain sensor.......................................... 102
washers.............................................. 103
wipers/washers................................... 102
Windshield washer fluid................... 314, 341Windshield wipers.................................... 313
Wiper blades
replacing windshield wipers............... 313