2012 VOLKSWAGEN TRANSPORTER tow bar

Technical data
Technical data
Vehicle data
COJ Introduction
This chapter contains information on the following subjects:
Vehicle identification data . . . . . . . . . . . . . . . . . 451
Dimensions ........................... . 452
Unless otherwise specified, the technical data of the basic model apply. The values quoted here may differ if additional equipment is fitted, for differ-ent models, for special vehicles or if country-specif-ic equipment is fitted. All data in the official vehicle documents take precedence over these data.
Engine
The vehicle data sticker and the official vehicle documents show which engine is installed in your vehicle.
Weight
The values for the kerb weight in the following ta-bles apply for the road-ready vehicle with driver (75 kg), service fluids including fuel tank carrying 90% of its capacity and, if applicable, toolkit and spare tyre =>&.Additional equipment and retrofit-ted accessories increase the stated kerb weight and reduce the maximum permitted load accord-ingly.
The load comprises the weights of the following:
• Passengers
• Allluggage
• Roof load including the mounts or roof bars and the load carrier system
• Drawbar load when towing a trailer
Performance figures
The performance figures were measured without equipment which may influence performance, such as a roof carrier or mud flaps.
Gross combination weight rating
The gross combination weight ratings listed are on-ly applicable for altitudes up to 1 ,000 m above sea level. The maximum weight of the car and trailer must be reduced by approximately 10% for every further 1 ,000 m in altitude.
450 I Tcchn1cal data
Descriptions of the tables
Gearbox abbreviations: MG = manual gearbox, DSG® = dual clutch gearbox DSG®.
Additional information and warnings:
• Transporting =:o page 125
• Driving with respect for the environment =:.page 278
• Fuel =:.page 343
• Engine oil =:o page 353
• Engine coolant =:o page 358
• Wheels and tyres =>page 367
• Consumer information =>page 404
,A WARNING
Exceeding the maximum permissible weights, payload, dimensions, vehicle speed and axle weight rating could cause damage to the vehicle, accidents and serious Injuries.
• Do not exceed the permitted weights, loads, dimensions and maximum speeds.
• The actual axle loads must never exceed the maximum permissible axle loads.
• The payload and the distribution of the load In the vehicle have an effect on the driv-ing response and braking distance of the ve-hicle. Adjust your speed accordingly.
,A WARNING
Accidents and severe injuries can occur if the maximum permitted gross combination weight Is exceeded.
• Never exceed the specified gross combi-nation weight rating.
The payload should be distributed as evenly as possible in the vehicle. When transporting heavy objects in the luggage compartment, they should be placed either in front of or over the rear axle in order to minimise the effect on the vehicle's handling.

Index
Numbers and Symbols
12-volt socket California . . . . . . . . . . . . . . . . . . . . . . . . . 244
2-seat arrangement Stowage compartment in armrest . . . . . . 184
2-seat arrangement, Business . . . . . . . . . . 182 Adjusting armrest . . . . . . . . . . . . . . . . . . . 184 Adjusting seats . . . . . . . . . . . . . . . . . . . . . 183 Ash tray . .. .. . . . .. . . .. . . • . .. . .. .. . 186 Centre console . . . . . • . . . . . . . . . . . . . . . 185 Cigarette lighter . . . . . . . • . . • . . . . . . . . . 186 Controls . . . . . . . . . . . . . . . . . . . . . . . . . . 183 Drink holder . . . . . . . . . . . . . . . . . . . . . . . 186 Features . . . . . . . . . . . . . . . . . . . . . . . . . . 182 Front stowage compartment . . . . . . . . . . 186 Moving . . . . . . . . . . . . . . . . . . . . . . . . . . . 185 Refrigerator box . . . . . . . . . . . . . . . . . . . . 186 Seat heater . . . . . . . . . . . . . . . . . . . . . . . 183 Upper stowage compartment . . . . . . . . . . 186 230-volt Euro socket . . . . . . . . . . . . . . . . . . 245
230-volt grounded safety socket . . . . . . . . 246
230-volt power supply . . . . . . . . . . . . . . . . . 245 Residual current circuit breaker . . . . . . . . 247
3-seat bench
A
Folding out the table . . . . . . . . . . . . . . . . . 74 Setting up the bed . . . . . . . . . . . . . • . . . . . 74
Abroad Extended trips with your vehicle 405 Selling the vehicle . . . . . . . . . . . . . . . . . . 405
ABS see Brake support systems . . . . . . . . . . . 275
ACC see Adaptive cruise control (ACC) . . . . . . 298
Accessing a service message . . . . . . . . . . . 23
Accessories . . . . . . . . . . . . . . . . . . . . . . . . . 394
Acoustic warnings Seat belt not fastened . . . . . . . . . . . . . . . . 80
Adaptive chassis control Fault . . . . . . . . . . . . . . . . . . . . . . . . . 317, 318 Function . . . . . . . . . . . . . . . . . . . . . . . . . . 318 Operation . . . . . . . . . . . . . . . . . 318
Adaptive chassis control (DCC) . . . . . . . . . 317 Indicator lamp . . . . . . . . . . . . . . . . . . . . . 317
Adaptive cruise control (ACC) . . . . . . . . . . 298 Displays . . . . . . . . . . . . . . . . . . . . . . . . . . 300 Fault . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 299 Indicator lamp . . . . . . . . . . . . . . . . . . . . . 300 Operating . . . . . . . . . . . . . . . . . . . . . . . . . 302 Radar sensor . . . . . . . . . . . . . . . . . . . . . . 301 Special driving situations . . . . . . . . . . . . . 305
Switching off temporarily . . . . . . . . . . . . . 304 Warning lamp . . . . . . . . . . . . . . . • . . • . . . 300
Ad Blue Indicator lamp . . . . . . . . . . . . . . . . . • . . . 347 Information . . . . . . . . . . . . . . . . . . . . . . . . 346 Refilling . . . . . . . . . . . . . . . . . . . . . . . . . . 348 Specification . . . . . . . . . . . . . . . . . . . . . . . 348 Tank capacity . . . . . . . . . . . . . . . . . . . . . . 346 Warning lamp . . . . . . . . . . . . . . . . . . . . . . 347
Additional battery California . . . . . . . . . . . . . . . . . . . . . . . . . 248 Charging . . . . . . . . . . . . . . . . . . . . . . . . . 247
Adjust Electrically adjustable front seat . . . . . . . . 66 Single seats in the passenger compartment .7.3
Adjusting Correct sitting position . . . . . . . . . . . . . . . . 63 Headlight range ..................... 113 Head restraints . . . . . . . . . . . . . . . . . . . . . . 67 Mechanical front seats . . . . . . . . . . . . . . . . 65 Memory seats . . . . . . . . . . . . . . . . . . . . . . 70 Single seats in the passenger compartment .73 Steering wheel . . . . . . . . . . . . . . . . . . . . . . 68
Adjusts Electric lumbar support adjustment . . . . . . 66
Aerial . . . . . . . . . . . . . . . . . . . . . . . . . . 124.406
AGM battery . . . . . . . . . . . . . . . . . . . . . . . . . 248
........................ Cleaning the dash panel . . . . . . . . . . . . . 392 Combined curtain and side airbags . . . . . . 94 Curtain airbags . . . . . . . . . . . . . . . . . . . . . . 95 Description . . . . . . . . . . . . . . . . . . . . . . . . . 90 Differences between front passenger front airbag systems . . . . . . . . . . . . . . . . . . . . 89 Faults . . . . . . . . . . . . • . . • . . . . . . . . . . . . 397 Front airbags . . . • . . • . . . . . • . . . . . • . . . . 92 Function . . . . . . . . . . . . . . . . . . . . . . . . . . . 90 Indicator lamp . . . . . . . . . . . . . . . . . . . . . . 89 Repairs . . . . . . . . . . . . . . . . . . . . . . . . . . . 397 Switching off the front passenger front air-bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93 Switching off with the key switch . . . . . . . . 93 Using child seats . . . . . . . . . . . . . . . . . . . . 93 Vehicle care . . . . . . . . . . . . . . . . . . . . . . . 392
Air conditioning system . . . . . . . . . . . . . . . 322 Air recirculation mode . . . . . . . . . . . . . . . 330 Climatic . . . . . . . . . . . . . . . . . . . . . . . . . . 323 Climatronic . . . . . • . . . . . . . . . . . . . . . . . . 325 Controls . . . . . . . . . . . . . . . . . . . . . . 323, 325 Fault . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 328 Indirect ventilation . . . . . . . . . . . . . . . . . . 329 Information . . . . . . . . . . • . . • . . . . . . . . . . 328 Settings . . . . . . . . . . . . . . . . . . . . . . . . . . 328 Things to note . . . . . . . . . . . . . . . . . . . . . 328
Index 465

Supplementary heater . . . . . . • . . . . . . . . 345 Winter diesel . . . . . . . . . . . . . . . . . . . . . . 345
Diesel engines Technical data . . . . . . . . . . . • . . . . . . . . . 455
Diesel partlcutate filter . . . . . . • . . . . . . . . . 409 ............................. 408 Gear-change indicator . . . . . . . . . . . . . . . 268 Indicator lamp . . . . . . . . . . . • . . . . . . . . . 407 Regeneration . . . . . . . . . . . . . . . . . . . . . . 409 Things to note . . . . . . . . . . . . . . . . . . . . . 346
Differential lock see Brake support systems . . . . . . . . . . . 275
Digital clock . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Digital voice enhancement . . . . . . . . . . . . . 173 Setting the volume . . . . . . . . • . . • . . . . . . 173 Switching on and off . . . . . . . . . . . . . . . . . 173
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . 452
Dipped beam headlights . . . . . . . . . . . . . . . 108
Display Adaptive cruise control . . . . . . . . . . . . . . . 300
Displays . . . . . . . . . . . . . . . . . . . . . . . . . . 20, 21 Area monitoring system . . . . . . . . . . . . . . 308 Front Assist .. .. .. .. .. .. .. .. .. . .. .. 308 Instrument cluster . . . . . . . . . . . . . . . . . . . 21
Disposal Airbag system . . . . . . . . . . . . . . . . . . . . . 407 Belt tensioner . . . . . . . . . . . . • . . . . . . . . . . 87 End-of-life vehicle . . . . . . . . . . . . . . . . . . 407
Door arresters . . . . . . . . . . . . . . . . . . . . . . . . 54
Door release lever . . . . . . . . . . . . . . . . . . . . 5, 9
Doors .................•............. 45 Manual opening . . . . . . . . . . . . . . . . . . . . 414 Warning lamp . . . . . . . . . • . . . . . • . . . . . . . 45
Drawbar load . . . . . . . . . . . . . . . . . . . . . . . . 140 Loading the trailer . . . . . . . . • . . . . . . . . . 146
Drawers .....................•....... 76
Drink holder . . . . . . . . . . . . . . . . . . . . . • . . . 153 California . . . . . . . . . • . . • . . . . . . . . • . . . 215 Centre console . . . . . . . . . . . . . . . . . . . . . 154 Living area . . . . . . . . . . . . . . . . . . . . . . . . 154
Driver Alert System . . . . . . . . . . . . . . . . . . . 315 Fault . . . . . . . . . . . . . . . . • . . . . . . . . • . . . 316 Function . . . . . . . . . . . . . • . . . . . • . . • . . . 316 Operation by the user . . • . . . . . . . . • . . . 316 Switching on and off........ . . . . . . . . . 316
Driver assist systems see Assist systems . . . . . . . . . . . . . . . . . 282 Driver door Overview ........................... 9
Driving Before setting off . . . . . . . . . . . . . . . . . . . . 33 Data recording . . . . . . . . . . . . . . . . . . . . . 398 Driving abroad . . . • . . . . . . . . . . . . . . . . . . 34 Driving tips . . . . . . . . . . . . . . . . . . . . . . . . . 33 Economically . . . . . . . . . . . . . . . . . . . . . . 278 Engine and transmission guard . . . . . . . . . 33
470 I Index
Fuel gauge . . . . . . . . . . . . . . . . . . . . . . . . 341 Fuel level too low . . . . . . . . . . . . . . . . . . . 341 Off-road driving . . . . . . . . . . . . . . . . . . . . . 33 Parking on a downward incline . . . . . . . . 272 Parking on an upward incline . . . . . . . . . . 272 Preparing for a journey . . . . . . . . . . . . . . . 33 Pulling away on an incline . . . . . . . . . . . . 267 Stopping on an incline . . . . . . . . . . . . . . . 267 Through salt water . . . . . . . . . . . . . . . . . . . 35 Towing ........................... 448 Water on the roads . . . . . . . . . . . • . . . . . . . 35 With a trailer . . . . . . . . . . . . . . . . . . . . . . . 146 with dual clutch gearbox . . . . . . . . . . . . . 266 With Loaded vehicle . . . . . . . . . . . . . . . . . 125 With respect for the environment . . . . . . . 278
Driving abroad Checklist . . . . . . . . . . . . . . . . . . . . . . . . . . 34 Headlights . . . . . . . . . . . . . . . . . • . . • . . . . 111
Driving economically . . . . . . . . . . . . . . . . . 278
Driving safely . . . . . . . . . . . . . . . . . . . . . . . . . 33
Driving through salt water . . . . . . . . . . . . . . 35
Driving through water . . . . . . . . . . • . . . . . . . 35
Driving tips . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 Spare wheel . . . . . . . . . . . . . . . . . . . . . . . 374
Driving with respect for the environment . 278
DSG see Dual clutch gearbox . . . • . . • . . . . . . 266
DSG dual clutch gearbox Changing gear . . . . . . . . . . . . . . . . . . . . . 264 Fault . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 267 Malfunction . . . . . . . . . . . . . . . . . . . . . . . . 268 Pulling away on an incline . . . . . . . . . . . . 267 Safety interlock for ignition key . . . . . . . . 258 Stopping on an incline . . . . . . . . . . . . . . . 267
Dual clutch gearbox . . . . . . . . . . . . . . 260, 266 also refer to Changing gears . . . . . . . . . . 260 Coasting function . . . . . . . . . . . . . . . . . . . 266 Driving . . . . . . . . . . . . . . . . . • . . . . . . . . . 266 Dual clutch gearbox . . . . . . . . . . . . . . . . . 266 Kickdown function . . . . . . . . . . . . . . . . . . 266 Towing ........................... 447 Unlocking the selector lever lock manually .4.15
Dual clutch gearbox DSG . . . . . . . . . . . . . . 264
Dust filter . . . . . . . . . . . . . . . . . . . . . . . . . . . 322
DVD player . . . . . . . . • . . • . . . . . . . . . . . . . . 167 Main menu . . . . . . . . . • . . • . . . . . . . . . . . 171 Settings . . . . . . . . . . . . . . . . . . . . . . . . . . 171
DVE ................................ 173
Dynamic headlight range control .....•... 113
E
E10 Refuelling . . . . . . . . . . . . . . . . . . . • . . . . . 344 EDL see Brake support systems . . . . . . . . . . . 275

<. CD
" "'
Temperature display Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . 359 Outside temperature . . . . . . . . . . . . . . . . . 21
Things to note Automatic car wash . . . . . . . . . . . . . . . . . 381 Diesel particulate filter . . . . . . . . . . . . . . . 346 Disconnecting the vehicle battery . . . . . . . 24 Engine juddering . . . . . . . . . . . . . . . . . . . 343 Engine not running smoothly . . . . . . . . . . 343 Folding in the mirrors . . . . . . . . . . . . . . . . 124 High-pressure cleaner . . . . . . . . . . . 144, 382 If vehicle has not been used for long peri-ods.............................. 39 Parking . . . . . . . . • . . . . . . . . . . 269, 272, 453 ParkPilot . . . . . . . . . . . . . . . . . . . . . . 288, 290 Push-starting . . . . . . . . . . . . . . . . . . . . . . 257 Radio reception . . . . . . . . . . . . . . . . . . . . 406 Removing the vehicle key . . . . . . . . . . . . 258 Smoke . . . . . . . . . . . . . . . . . . . . . . . 339, 345 Switch-off delay . . . . . . . . . . . . . . . . . . . . 334 Tow-starting . . . . . . . . . . . . . . . . . . . 257, 446 Towing .................•......... 447 Towing a trailer . . . . . . . . . . . . . . . . . . . . . 147 Washing the vehicle . . . . . . . . . . . . . . . . . 381 Water underneath the vehicle . . . . . . . . . 328 Wipers ............................ 118
Tightening torque Wheel bolts . . . . . . . . . . . . . . . . . . . . . . . 421
Timer .....................•.......... 20
TIN................................. 376
Tiptronic . . . . . . . . . . . . . . . . . . • . . . . . . . . . 266
Toolkit see Vehicle toolkit . . . . . . . . • . . . . . . . . . 416 Torches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 152 Small torch . . . . . . . . . . . . . . . . . . . . . . . . 152 Torch behind front passenger seat . . . . . . 153
Tow-starting . . . . . . . . . . . . . . . . . . . . . 257, 446 Things to note . . . . . . . . . . . . . . . . . . . . . 446 Towing . . . . . . . . . . . . . . . . • . . . . . . . . . . . . 139 Another vehicle . . . . . . . . . . • . . . . . • . . . 447 Driving notes . . . . . . . . . . . . . . . . . . • . . . 448 Dual clutch gearbox . . . . • . . . . . . . . • . . . 447 Four-wheel drive . . . . . . . . . . . . . . . . . . . 447 Manual gearbox . . . . . . . . . . . . . . . . . . . . 447 Removing cover for towing eye at front . . 448 Technical requirements . . . . . . . . . . . . . . 141 Things to note . . . . . . . . . . . . . . . . . . . . . 447 Tow bar .......................... 447 Towing bracket . . . . . • . . . . . . . . . . . . . . . 447 Towing eye . . . . . . . . . . . . . . . . . . . . . . . . 448 Tow rope . . . . . . . . . . . . . . . . . . . . . . . . . 447 When not to tow . . . . . . . . . . . . . . . . . . . . 447 Your vehicle . . . . . . . . . . • . . . . . . . . . . . . 447
Towing bracket Fault . . . . . . . . . . . . . • . . . . . . . . . . . . . . . 145 Fitting . . . . . . . . . . . . . . . • . . . . . . . . . . . . 142 Removing . . . . . . . . . . . . . . . . . . . . . . . . . 144
Retrofitting . . . . . . . . . . . . . . . . . . . . . . . . 149 see Trailer . . . • . . . . . . . . . . . . . . . . . . . . 139
Towing eye . . . . . . . . . . . . . . . . . . . . . . . . . . 448 Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 447 Removing cover . . . . . . . . . . . . . . . . . . . . 448
Traction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 376
Traction control system (TCSI . . . . . . 275, 276
Trailer Anti-snaking coupling . . . . . . . . . . . . . . . . 142 Anti-theft alarm . . . . . . . . . . . . . . . . . . . . . 145 Connecting . . . . . . . . . . . . . . . . . . . . . . . . 144 Drawbar load . . . . . . . . . . . . . . . . . . 140, 146 Driving . . . . . . . . . . . . . . . . . . . . . . . . . . . 146 Emergency breakaway cable ...... 141,145 Exterior mirrors . . . . . . . . . . . . . . . . . . . . 142 Fault . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 145 Fire extinguisher . . . . . . . . . . . . . • . . . . . 142 Fitting the ball coupling . . . . . . . . . . . . . . 142 Headlight adjustment . . . . . . . . . . . . . . . . 146 Hitching . . . . . . . . . . . . . . . . . . . . . . . . . . 144 Loading . . . . . . . . . . . . . . . . . . . . . . . . . . 146 ParkPilot . . . . . . . . . . . . . . . . . . 288, 290, 291 Rear lights .................... 141,145 Removable ball coupling . . . . . . . . . . . . . 142 Removing the ball coupling . . . . . • . . . . . 144 Retrofitting a towing bracket . . . . . . . . . . 149 Socket . . . . . . . . . . . . . . . . . . . . . . . . . . . 145 Towing . . . . . . . . . . . . . . . . . . . . . . . 139, 146 Trailer stabilisation . . . . . . . . . . . . . . . . . . 14 7 Trailer weight . . . . . . . . . . . . . . . . . . 146, 450 Trailer stabilisation . . . . . . . . . . . . . . . . . . . 14 7
Trailer weight Loading the trailer . . . . . . . . . . . . . . . . . . 146 max. permissible . . . . . . . . . . . . . . . . . . . 450
Transporting Buckle straps . . . . . . . . . . . . . . . . . . . . . . 128 Driving with an open tailgate . . . . • . . . . . 129 Driving with open wing doors . . . . . . . . . . 129 Fastening rings . . . . . . . . . . . . . . . . . . . . 134 Net partition . . . . . . . . . . . . . . . . . . . . . . . 136 Ratchet straps . . . . . . . . . . . . . . . . . . . . . 128 Roof carrier . . . . . . . . . . . . . . . . . . . . . . . 139 T-shaped fastening ring . . . . . . . . . . . . . . 135 Trailer weight . . . . . . . . . . . . . . . . . . . . . . 450
Transporting items . . . . . . . . . . . . . . . . . . . 125 Driving tips . . . . . . . . . . . . . . . . . . . . . . . . 130 Loading the trailer . . . . . . . . . . . . . . . . . . 146 Roof carrier . . . . . . . . . . . . . . . . . . . . . . . 137 Stowing cargo . . . . . . . . . . . . . . . . . . . . . 127 Stowing items of luggage . . . . . . . . . . . . . 126 Towing . . . . . . . . . . . . . . . . . . . . . . . 139, 146
Tread depth . . . . . . . . . . . . . . . . . . . . . . . . . 372
Tread wear . . . . . • . . . . . . . . . . . . . . . . . . . . 376 Trip recorder . . . . . . . . . . . . . . . . . . . . • . . . . 20 Troubleshooting . . . . . . . . . . . . . . . . . . . . . 410
Turn Single seats in the passenger compartment .7.3
Index I 481