2012 TOYOTA HILUX check engine

494 4-3. Do-it-yourself maintenance
HILUX_EE (OM0K132E)
Using the gauge (if equipped)
CAUTION
When adding washer fluid
Do not add washer fluid when the engine is hot or running as washer fluid
contains alcohol and may catch fire if spilled on the engine etc.
NOTICE
Do not use any fluid other than washer fluid
Do not use soapy water or engine antifreeze instead of washer fluid.
Doing so may cause streaking on the vehicle’s painted surfaces.
Diluting washer fluid
Dilute washer fluid with water as necessary.
Refer to the freezing temperatures listed on the label of the washer fluid bot-
tle.
The washer fluid level can be checked by
observing the position of the level on the
liquid-covered holes in the gauge.
If the level falls below the second hole
from the bottom (the “LOW” position),
refill the washer fluid.
Current
fluid level

509
4-3. Do-it-yourself maintenance
4
Maintenance and care
HILUX_EE (OM0K132E)
Checking and replacing fuses
If any of the electrical components do not operate, a fuse may have
blown. If this happens, check and replace the fuses as necessary.
Turn the engine switch off.
Open the fuse box cover.
Engine compartment
Push the tab in and lift the lid
off.
Driver’s side instrument panel for left-hand drive vehicles
(front and rear sides)
Remove the lower instrument
panel.
Rear side: Inspection and
replacement of the fuses, con-
tact any authorized Toyota
dealer or repairer, or another
duly qualified and equipped
professional.
STEP1
STEP2

554 5-2. Steps to take in an emergency
HILUX_EE (OM0K132E)
*: Driver’s seat belt buzzer:
The driver’s seat belt buzzer sounds to alert the driver that his or her seat
belt is not fastened. The buzzer sounds intermittently for 30 seconds after
the vehicle reaches a speed of 15 km/h (9 mph). Then, if the seat belt is still
unfastened, the buzzer will sound in a different tone for 90 more seconds.
Warning lightWarning light/DetailsCorrection procedure
(for front
passenger)
Front passenger’s seat
belt reminder light
Warns the front passen-
ger to fasten his/her seat
belt
Fasten the seat belt.
Unengaged “Park” warn-
ing light (if equipped)
The transmission “Park”
mechanism is not
engaged.Shift front drive control lever
to “H2” or “H4” or “L4”.
Low engine oil level warn-
ing light
Indicates that engine oil
level is lowCheck the level of engine oil
and add more oil if neces-
sary.
(remains on)Engine oil change
reminder light
Indicates that the engine
oil should be changed
Comes on approximately
30000 km (18000 miles)
after the engine oil has
been changed (and the oil
maintenance date has
been reset)Have the engine oil and oil
filter checked and/or
changed by any authorized
Toyota dealer or repairer, or
another duly qualified and
equipped professional. After
changing the engine oil, the
oil change system should
be reset. (P. 484)

5
573 5-2. Steps to take in an emergency
When trouble arises
HILUX_EE (OM0K132E)
CAUTION
Using the tire jack
Improper use of the tire jack may cause the vehicle to suddenly fall off the
jack, leading to death or serious injury.
Do not use the tire jack for any purpose other than replacing tires or install-
ing and removing tire chains.
Only use the tire jack that comes with this vehicle for replacing a flat tire.
Do not use it on other vehicles, and do not use other tire jacks for replac-
ing tires on this vehicle.
Always check that the tire jack is securely set to the correct jack up point.
Do not put any part of your body under the vehicle while it is supported by
the jack.
Do not start or run the engine while your vehicle is supported by the jack.
Do not raise the vehicle while someone is inside.
When raising the vehicle, do not put an object on or under the jack.
Do not raise the vehicle to a height greater than that required to replace
the tire.
Use a jack stand if it is necessary to get under the vehicle.
Take particular care when lowering the vehicle to ensure that no one working
on or near the vehicle may be injured.
Do not continue jacking up once the
yellow caution line has appeared.
yellow
caution line

584
5-2. Steps to take in an emergency
HILUX_EE (OM0K132E)
If your vehicle overheats
If your engine overheats:
Stop the vehicle in a safe place and turn off the air condi-
tioning system.
Check to see if steam is coming out from under the hood.
If you see steam:
Stop the engine. Carefully lift the hood after the steam sub-
sides and then restart the engine.
If you do not see steam:
Leave the engine running and carefully lift the hood.
Check to see if the cooling fan is operating.
If the fan is operating:
Wait until the temperature of the engine (shown on the
instrument panel) begins to fall and then stop the engine.
If the fan is not operating:
Stop the engine immediately and call any authorized Toyota
dealer or repairer, or another duly qualified and equipped
professional.
After the engine has cooled
down sufficiently, check the
engine coolant level and
inspect the radiator core (radi-
ator) for any leaks.
STEP1
STEP2
STEP3
STEP4

615
6-1. Specifications
6
Vehicle specifications
HILUX_EE (OM0K132E)
Fuel infor mation
If you plan to drive in foreign countries
Low sulfur diesel fuel may not be available, so please check the availability
with your distributor.
If your engine knocks
Consult any authorized Toyota dealer or repairer, or another duly quali-
fied and equipped professional.
You may occasionally notice light knocking for a short time while acceler-
ating or driving uphill. This is normal and there is no need for concern.
EU area:
Your vehicle must use only diesel fuel conforming to European stan-
dard EN590.
Except EU area (except Russia):
Your vehicle must use only diesel fuel that contains 50 ppm or less
of sulfur and has a cetane number of 48 or higher.
Except EU area (Russia):
You must only use diesel fuel with a cetane number of 48 or
higher.
Your vehicle must use only diesel fuel confirming to GOST
R52368-2005 (Sulfur max 50 ppm).

624 Alphabetical index
HILUX_EE (OM0K132E)
Emergency flashers
Switch ................................... 540
Emergency, in case of
If the engine will not start ...... 576
If the shift lever cannot be
shifted from P ..................... 577
If the vehicle has discharged
battery................................. 579
If the warning buzzer
sounds ................................ 549
If the warning light
turns on............................... 549
If you have a flat tire ............. 557
If you lose your keys ............. 578
If you run out of fuel and
the engine stalls.................. 587
If you think something is
wrong .................................. 547
If your vehicle becomes
stuck ................................... 588
If your vehicle needs to be
towed .................................. 541
If your vehicle overheats ....... 584Engine
Compartment ........................ 480
Engine switch........................ 162
Hood ..................................... 478
How to start the
engine................................. 162
Identification number ............ 599
If the engine will not start ...... 576
If you run out of fuel and
the engine stalls ................. 587
If your vehicle
has to be stopped
in an emergency ................. 590
Ignition switch ....................... 162
Overheating .......................... 584
Engine coolant
Capacity ................................ 606
Checking ............................... 486
Preparing and checking
before winter....................... 234
Engine coolant temperature
gauge...................................... 176
Engine immobilizer system .... 103
Engine oil
Capacity ........................ 602, 604
Checking ............................... 482
Preparing and checking
before winter....................... 234
Engine switch .......................... 162
Engine switch light .................. 433E

629 Alphabetical index
HILUX_EE (OM0K132E)
Stuck
If your vehicle becomes
stuck ................................... 588
Sun visors ................................ 444
Switch
Engine switch ........................ 162
Fog light switch ..................... 195
Ignition switch ....................... 162
Light switches ....................... 191
Power door lock switch ........... 61
Power window switch .............. 92
Window lock switch ................. 93
Wipers and washer
switch.................................. 199
Tachometer .............................. 176
Tail lights
Replacing light bulbs ............. 535
Switch ................................... 191
Wattage................................. 614
Tailgate ....................................... 64
Telephone switch..................... 382
Theft deterrent system
Engine immobilizer
system ................................ 103
Tire inflation pressure ............. 500Tires
Chains................................... 234
Checking ............................... 496
If you have a flat tire ............. 557
Inflation pressure .................. 500
Replacing .............................. 557
Rotating tires......................... 496
Size ....................................... 612
Snow tires ............................. 234
Spare tire .............................. 557
Tools ......................................... 557
Towing
Emergency towing ................ 541
Trailer towing ........................ 238
Traction control ....................... 220
Trailer towing ........................... 238
TRC ........................................... 220
Trip information
display .................................... 185
Trip meter ................................. 176
Turn signal lights
Replacing
light bulbs ........... 532, 534, 535
Switch ................................... 173
Wattage ................................ 614
T