2012 Seat Mii stop start

195
In the engine compartment
Colour indicatorNecessary operations
light yellow or col-
ourlessThe electrolyte level of the vehicle's battery is too low.
Have the battery checked and, where applicable, re-
placed by a Specialised workshop.
blackThe electrolyte level of the vehicle's battery is correct.
WARNING
Working with the vehicle battery involves a risk of corrosion, explosions
and electric shock.
● Always wear protective gloves and eye protection.
● Battery acid is very corrosive and caustic. It can burn skin and cause
blindness. When handling the battery, protect yourself from splashes of
acids, above all your hands, arms and face.
● Never tilt the vehicle battery. Battery acid could spill out of the open-
ings to release gases and cause corrosion damage.
● Never open the vehicle battery.
● If battery acid splashes on you, immediately rinse your eyes and skin
abundantly with water for several minutes. Then seek medical care imme-
diately.
● If acid is swallowed by mistake, consult a doctor immediately.

Charging, replacing and connecting or disconnecting the
battery
Charging the battery
The vehicle battery should be charged by a specialised workshop only, as
batteries using special technology have been installed and they must be
charged in a controlled environment ⇒ 
. SEAT recommends visiting a
Technical Service. Replacing a vehicle battery
The battery has been developed to suit the conditions of its location and
has special safety features. If the battery must be replaced, consult a Tech-
nical Service for information on electromagnetic compatibility, the size and
maintenance, performance and safety requirements of the new battery in
your vehicle before you purchase one. SEAT recommends you have the bat-
tery replaced by a Technical Service.
Use only maintenance-free genuine batteries conforming to TL 825 06 and
VW 7 50 73 Standards. These standards must be dated April 2008 or later.
Vehicles fitted with the Start-Stop system are equipped with a special bat-
tery. Therefore, this battery must only be replaced by another of the same
specifications.
Disconnecting the vehicle's battery
If you must disconnect the battery from the electrical system, please note
the following:
●
Switch off the ignition and all electrical equipment.
● The vehicle must be unlocked before disconnecting the battery, other-
wise the alarm will be triggered.
● First disconnect the negative cable and then the positive ⇒ 
.
Connecting the vehicle's battery
● Before reconnecting the battery, switch off the engine, the ignition and
electric devices.
● First reconnect the positive cable and then the negative ⇒ 
.
Different control lamps may light up after connecting the battery and switch-
ing the ignition on. They will be turned off after a short trip at a speed of
between 15 - 20 km/h (10 - 12 mph). If the warning indicators remain lit,
please visit a specialised workshop to have the vehicle checked.
If the battery has been disconnected for a long time, it is possible that the
next service date is not displayed or calculated correctly ⇒ page 17. Respect
Vehicle diagramPrior to a journey...While drivingCare, cleaning and mainte-
nanceIf and whenTechnical Data

210Vehicle care and maintenance
Wheels and tyres
Introduction
SEAT recommend that all work on tyres and wheels is carried out by a Speci-
alised workshop. They have the necessary special tools and replacement
parts, trained personnel and facilities for disposing of the old tyres. SEAT
recommends visiting a Technical Service.
Additional information and warnings:
● Transporting ⇒ page 97
● Braking, stopping and parking ⇒ page 134
● Caring for and cleaning the vehicle exterior ⇒ page 197
● Notes for the user ⇒ page 233
● Vehicle tool kit ⇒ page 246
● Wheel trims ⇒ page 248
● Change wheel ⇒ page 250
● Tire Mobility Set ⇒ page 256
WARNING
The vehicle cannot be totally controlled or braked if the tyres (new or
used) are worn or damaged.
● Incorrect use of wheels and tyres could make driving more dangerous
and result in serious accidents and damage.
● All four wheels must be fitted with radial tyres of the same type, size
(rolling circumference) and the same tread pattern.
● New tyres do not give maximum grip and will not have reached their
maximum braking capacity to start with, and therefore need running in.
To prevent accidents and major damage, extreme caution should be tak-
en for the first 600 km (400 miles).
WARNING (Continued)
● Check tyre pressures regularly and ensure they are maintained at the
pressures indicated. If the tyre pressure is too low, the tyres could over-
heat, resulting in tread detachment or even burst tyres.
● Never drive on damaged (punctured, cut, cracked or dented) or worn
tyres. Driving on damaged or worn tyres could result in burst tyres, seri-
ous accidents or damage. Worn or damaged tyres must be replaced im-
mediately.
● Never exceed the maximum permitted speed or loads specified for the
type of tyre fitted on your vehicle.
● The efficiency of driver and brake assist systems also depends on the
grip of the tyres.
● If you notice unusual vibration or if the vehicle pulls to one side when
driving, stop the vehicle immediately and check the tyres and wheels for
damage.
● To minimise the risk of losing control of the vehicle or causing a seri-
ous accident, never undo the bolted joints of beadlock wheels.
● Never mount used tyres or wheels if you are not sure of their previous
history. They may be damaged, although the damage is not immediately
visible.
● Old tyres, even if they have never been used, may lose air or burst un-
expectedly while driving, especially at high speeds, resulting in serious
accident and injury. If tyres are over six years old, they should only be
used in an emergency and with extreme caution.
Note
For technical reasons, it is not generally possible to use the wheels from
other vehicles. In some cases, this may also be true for the same model of
wheel. Please refer to the vehicle documents or ask at a Technical Service. 

256Practical information
Anti-puncture kit*
Introduction
The Tyre Mobility Set* will reliably seal punctures caused by the penetration
of a foreign body of up to about 4 mm in diameter. Do not remove foreign
objects, e.g. screws or nails, from the tyre.
After inserting the sealant residue in the tyre, you must again check the tyre
pressure about 10 minutes after starting the engine.
You should only use the tire mobility set if the vehicle is parked in a safe
place, you are familiar with the procedure and you have the necessary tire
mobility set! Otherwise, you should seek professional assistance.
The tyre sealant must not be used in the following cases:
● If the wheel rim has been damaged.
● In outside temperatures below -20 °C (-4 °F).
● In the event of cuts or perforations in the tyre greater than 4 mm.
● If you have been driving with very low pressure or a completely flat tyre.
● If the sealant bottle has passes its use by date.
Additional information and warnings:
● Vehicle key set ⇒ page 28
● Braking, stopping and parking ⇒ page 134
● Wheels and tyres ⇒ page 210
● In case of emergency ⇒ page 240
● Wheel trims ⇒ page 248
WARNING
Using the tire mobility set can be dangerous, especially when filling the
tyre at the roadside. Please observe the following rules to minimise the
risk of injury:
● Stop the vehicle safely as soon as possible. Park your vehicle as safe
distance from surrounding traffic to fill the tyre.
● Ensure the ground on which you park is flat and solid.
● All passengers and particularly children must keep a safe distance
from the work area.
● Turn on the hazard warning lights to warn other road users.
● Use the tire mobility set only if you are familiar with the necessary
procedure. Otherwise, you should seek professional assistance.
● The tire mobility set is intended for temporary, emergency use only.
Use only until you can reach the nearest specialised workshop.
● Replace the repaired tyre with the tire mobility set as soon as possi-
ble.
● The sealant is a health hazard and must be cleaned immediately if it
comes into contact with the skin.
● Always keep the tire mobility set out of the reach of small children.
● Never use the approved jack, even if it has been approved for your ve-
hicle.
● Always stop the engine, apply the handbrake lever firmly and engage
gear if using a manual gearbox, in order to reduce the risk of vehicle in-
voluntary movement.
WARNING
A tyre filled with sealant does not have the same performance properties
as a conventional tyre.
● Never drive faster than 80 km/h (50 mph). 

259
Practical information
● Start the vehicle engine and leave it running.
● Attach the connector ⇒ Fig. 146 9
to a 12 volt socket of the vehicle
⇒ page 117.
● Connect the air compressor with the ON/OFF switch ⇒ Fig. 146 8
.
● Keep the air compressor running until it reaches 2.0 to 2.5 bar
(29-36 psi / 200-250 kPa) ⇒ 
. Maximum operation time 8 minutes ⇒ .
● Disconnect the air compressor.
● If it is not possible to achieve an air pressure of 2.0 to 2.5 bar
(29-36 psi / 200-250 kPa), unscrew the tyre inflator tube from the tyre valve.
● Move the vehicle some 10 metres forwards or backwards so that the
sealant is evenly distributed in the tyre interior.
● Securely screw the compressor tyre inflator tube into the tyre valve and
repeat the inflation process.
● If the indicated pressure can still not be reached, the tyre is too badly
damaged. The tyre cannot be sealed with the anti-puncture kit. Do not con-
tinue driving. You should obtain professional assistance ⇒ 
.
● Disconnect the air compressor and unscrew the flexible inflator tube
from the tyre valve.
● When the tyre pressure is between 2.5 and 2.0 bars, immediately con-
tinue driving without exceeding 80 km/h (50 mph).
● After 10 minutes, Check the pressure again ⇒ page 259.
WARNING
When inflating the wheel, the air compressor and the inflator tube may
become hot.
● Protect hands and skin from hot parts.
● Do not place the hot flexible inflator tube or hot air compressor on
flammable material.
WARNING (Continued)
● Allow them to cool before storing the device.
● If it is not possible to inflate the tyre to at least 2.0 bars (29 psi /
200 kPa), the tyre is too badly damaged. The sealant is not in a good con-
dition to seal the tyre. Do not continue driving. You should obtain profes-
sional assistance.
CAUTION
Switch off the air compressor after a maximum of 8 operational minutes to
avoid overheating! Before switching on the air compressor again, let it cool
for several minutes. 
Check after 10 minutes of driving
Screw the inflator tube ⇒ Fig. 146 5 again and check the pressure on the
gauge 6.
1.3 bar (19 psi / 130 kPa) and lower:
● Stop the vehicle! The tyre cannot be sealed sufficiently with the tyre mo-
bility set.
● You should obtain professional assistance ⇒ 
.
1.4 bar (20 psi / 140 kPa) and higher:
● Set the tyre pressure to the correct value again ⇒ page 210.
● Carefully resume your journey until you reach the nearest specialised
workshop without exceeding 80 km/h (50 mph).
● Have the damaged tyre replaced. 
Vehicle diagramPrior to a journey...While drivingCare, cleaning and mainte-
nanceIf and whenTechnical Data

274Practical information
How to jump start: description
Fig. 159 Diagram of con-
nections for vehicles
without Start-Stop sys-
tem
Fig. 160 Diagram of con-
nections for vehicles
with Start-Stop system
Jump lead terminal connections
1. Switch off the ignition of both vehicles ⇒ 
.
2. For vehicles without Start-Stop system :–
Connect one end of the red jump lead to the positive +
termi-
nal of the vehicle with the flat battery A ⇒ Fig. 159.
– Connect the other end of the red jump lead to the positive ter-
minal +
in the vehicle providing assistance B.
– Connect one end of the black jump lead to the negative terminal
–
of the vehicle providing assistance B ⇒ Fig. 159.
– Connect the other end of the black jump lead X
to a solid met-
al component bolted to the engine block or to the engine block
itself of the vehicle with the flat battery. However, connect it to
a point as far as possible from the battery A
.
3. For vehicles with Start-Stop system :
– Connect one end of the red jump lead to the positive +
termi-
nal of the vehicle with the flat battery A ⇒ Fig. 160.
– Connect the other end of the red jump lead to the positive ter-
minal +
in the vehicle providing assistance B.
– Connect one end of the black jump lead X
to a suitable ground
terminal, a solid piece of metal in the engine block, or to the en-
gine block ⇒ Fig. 160.
– Connect the other end of the black jump lead X
to a solid met-
al component bolted to the engine block or to the engine block
itself of the vehicle with the flat battery. However, connect it to
a point as far as possible from the battery A
.
4. Position the leads in such a way that they cannot come into contact with any moving parts in the engine compartment. 

287
Description of specifications
Petrol engine 1.0 55 kW (75 PS) Start-Stop
Engine specifications Power output in kW (PS) rpm 55 (75)/6200
Maximum torque in Nm at rpm 95/3000-4300
No. of cylinders/capacity in cm3
3/999
Fuel 95 super RON a)
a)
Research Octane Number = Anti-detonation rating of the petrol.
Performance Maximum speed in km/h (mph) 172
Acceleration from 0-80 km/h (0-50 mph) in sec. 8,3
Acceleration from 0-100 km/h (0-60 mph) in sec. 13,2
Consumption (l/100 km) / CO
2 emissions (g/km)
Urban cycle 5,1 / 118
Extra-urban cycle 3,7 / 86
Combined 4,2 / 98
Weights
Gross vehicle weight in kg 1290
Weight in running order (with driver) in kg 940
Gross front axle weight in kg 561
Gross rear axle weight in kg 379
Permitted roof load in kg 50

Vehicle diagramPrior to a journey...While drivingCare, cleaning and mainte-
nanceIf and whenTechnical Data

malfunction . . . . . . . . . . . . . . . . . . . . . . . . 132
starting on a slope . . . . . . . . . . . . . . . . . . . 131
stopping on a slope . . . . . . . . . . . . . . . . . . 131
Axle loads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 281
B
BAS see Brake assist systems . . . . . . . . . . . . . . 140
Battery Change in the vehicle key . . . . . . . . . . . . . . 31
discharge . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Discharging . . . . . . . . . . . . . . . . . . . . . . . . 241
See Vehicle battery . . . . . . . . . . . . . . . . . . 193
Battery acid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Before consulting a specialised workshop . . . 238
Belt tension device . . . . . . . . . . . . . . . . . . . . . . . 65 Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Service and disposal . . . . . . . . . . . . . . . . . . 65
Belt tension limiter . . . . . . . . . . . . . . . . . . . . . . . 65
Bench . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101
Bonnet Closing . . . . . . . . . . . . . . . . . . . . . . . . . . . . 183
Opening . . . . . . . . . . . . . . . . . . . . . . . . . . . 183
Bottle capacity Windscreen washer water bottle . . . . . . . . . 94
Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 134 Brake servo . . . . . . . . . . . . . . . . . . . . . . . . . 138
Brake assist system (BAS) . . . . . . . . . . . . . . . . 140
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 141 Specification . . . . . . . . . . . . . . . . . . . . . . . . 141 Brakes
Assisted braking systems . . . . . . . . . . . . . 139
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . 141
Brake fluid level . . . . . . . . . . . . . . . . . . . . . 142
Brake pads . . . . . . . . . . . . . . . . . . . . . . . . . 137
Changing the brake fluid . . . . . . . . . . . . . . 142
Control lamp . . . . . . . . . . . . . . . . . . . . . . . . 135
Emergency brake indicator in case of sud-den braking . . . . . . . . . . . . . . . . . . . . . . . 241
Handbrake . . . . . . . . . . . . . . . . . . . . . . . . . 136
Running-in brake pads . . . . . . . . . . . . . . . . 137
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . 135
Brake servo . . . . . . . . . . . . . . . . . . . . . . . . 138, 139
Brake system Malfunction . . . . . . . . . . . . . . . . . . . . . . . . 138
Brake systems . . . . . . . . . . . . . . . . . . . . . . . . . 139
Breakdown Securing the vehicle . . . . . . . . . . . . . . . . . 240
Bulb fault See changing bulbs . . . . . . . . . . . . . . . . . . 264
C
Capacities Fuel tank . . . . . . . . . . . . . . . . . . . . . . . . . . . 290
Care See "Care of your vehicle" . . . . . . . . . . . . . 197
Vehicle interior . . . . . . . . . . . . . . . . . . . . . . 205
Care of your vehicle Exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . 197
Caring for paintwork . . . . . . . . . . . . . . . . . . . . . 202
Carrier system . . . . . . . . . . . . . . . . . . . . . . . . . . 104 Catalytic converter . . . . . . . . . . . . . . . . . . . . . . 237
Control lamp . . . . . . . . . . . . . . . . . . . . . . . . 236
Malfunctions . . . . . . . . . . . . . . . . . . . . . . . . 236
CCS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 152
central locking Deadlock . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Central locking . . . . . . . . . . . . . . . . . . . . . . . . . . 33 Central locking button . . . . . . . . . . . . . . . . . 36
locking and unlocking from the exterior . . . 34
locking and unlocking from the inside . . . . 36
Central locking system After airbag deployment . . . . . . . . . . . . . . . 33
Description . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Opening doors individually . . . . . . . . . . . . . 33
Centre console . . . . . . . . . . . . . . . . . . . . . . . 12, 13 Bottom part . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Top part . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Changing Windscreen wiper blades . . . . . . . . . . . . . 201
Changing a wheel . . . . . . . . . . . . . . . . . . . . . . 250 Changing a wheel . . . . . . . . . . . . . . . . . . . 255
Preparations . . . . . . . . . . . . . . . . . . . . . . . . 251
Raising the vehicle . . . . . . . . . . . . . . . . . . . 253
Wheel bolts . . . . . . . . . . . . . . . . . . . . . . . . . 251
Changing bulbs . . . . . . . . . . . . . . . . . . . . . . . . 264 Checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . 265
Front bumper . . . . . . . . . . . . . . . . . . . . . . . 267
Initial operations . . . . . . . . . . . . . . . . . . . . 265
in the headlights . . . . . . . . . . . . . . . . . . . . 266
Number plate light . . . . . . . . . . . . . . . . . . . 270
Rear lights . . . . . . . . . . . . . . . . . . . . . . . . . . 269
Sea changing bulbs . . . . . . . . . . . . . . . . . . 264
292 Index

Control lampAirbag system . . . . . . . . . . . . . . . . . . . . . . . . 69
Brake pad wear warning . . . . . . . . . . . . . . 135
Brake system . . . . . . . . . . . . . . . . . . . . . . . 135
Catalytic converter . . . . . . . . . . . . . . . . . . . 236
City Safety Assist function . . . . . . . . . . . . . 156
Cruise control system (CCS) . . . . . . . . . . . . 152
Emission control system . . . . . . . . . . . . . . 236
Engine coolant . . . . . . . . . . . . . . . . . . . . . . 189
Engine management . . . . . . . . . . . . . . . . . 236
Engine oil sensor . . . . . . . . . . . . . . . . . . . . 185
ESC . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 135
Fuel level . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Hill hold . . . . . . . . . . . . . . . . . . . . . . . . . . . 160
Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Steering column lock . . . . . . . . . . . . . . . . . 147
Controlling function Electric exterior mirrors . . . . . . . . . . . . . . . . 96
Control units . . . . . . . . . . . . . . . . . . . . . . . . . . . 226 Reprogramming . . . . . . . . . . . . . . . . . . . . . 227
Convenience functions Reprogramming . . . . . . . . . . . . . . . . . . . . . 227
Coolant See engine coolant . . . . . . . . . . . . . . . . . . 189
Crossing a river Salt water . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Cruise control system . . . . . . . . . . . . . . . . . . . . 152
Cruise control system (CCS) Control lamp . . . . . . . . . . . . . . . . . . . . . . . . 152
Operations . . . . . . . . . . . . . . . . . . . . . . . . . 153 D
Damaged tyres . . . . . . . . . . . . . . . . . . . . . . . . . 216
Dangers of not using the seat belt . . . . . . . . . . 60
Dash panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 Airbag system . . . . . . . . . . . . . . . . . . . . 67, 208
Data link connector (DLC) . . . . . . . . . . . . . . . . 227
Data registry . . . . . . . . . . . . . . . . . . . . . . . . . . . 226
Data storage during the journey . . . . . . . . . . . 226
Data stored by the control units . . . . . . . . . . . 226
Daytime driving light . . . . . . . . . . . . . . . . . . . . . 87
De-icing the door lock cylinder . . . . . . . . . . . . 203
De-icing the locks . . . . . . . . . . . . . . . . . . . . . . . 203
Deadlock Deadlock . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
SAFELOCK . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
Deadlock (immobilizer) . . . . . . . . . . . . . . . . . . 123
Detail passenger seat . . . . . . . . . . . . . . . . . . . . . . . 14
Diagnostics connection . . . . . . . . . . . . . . . . . . 227
Differential lock See "Brake assist systems" . . . . . . . . . . . . 140
Digital clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . 290
Dipped beam headlights . . . . . . . . . . . . . . . . . . 86
Dipstick . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 186
Display . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 Instrument panel . . . . . . . . . . . . . . . . . . . . . 19
Disposal Airbag system . . . . . . . . . . . . . . . . . . . . . . . 235
Belt tension device . . . . . . . . . . . . . . . . . . . . 65
End-of-life vehicle . . . . . . . . . . . . . . . . . . . 235 Door handle
exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Door release lever interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38 Childproof locks . . . . . . . . . . . . . . . . . . . . . . 38
Emergency locking and unlocking . . . . . . 243
Drink holders . . . . . . . . . . . . . . . . . . . . . . . . . . 113 Centre console . . . . . . . . . . . . . . . . . . . . . . 114
Drinks bottles see Drink holders . . . . . . . . . . . . . . . . . . . . 113
Driver door Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Driver position . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Driving Check list . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Data storage . . . . . . . . . . . . . . . . . . . . . . . . 226
Driving abroad . . . . . . . . . . . . . . . . . . . . . . . 26
Driving through water . . . . . . . . . . . . . . . . . 27
Driving with an automatic gearbox . . . . . . 131
Ecological . . . . . . . . . . . . . . . . . . . . . . . . . . 144
Economic . . . . . . . . . . . . . . . . . . . . . . . . . . 144
Fuel gauge . . . . . . . . . . . . . . . . . . . . . . . . . 172
Fuel level to low . . . . . . . . . . . . . . . . . . . . . 173
Journey preparations . . . . . . . . . . . . . . . . . . 25
Parking downhill . . . . . . . . . . . . . . . . . . . . 137
Parking uphill . . . . . . . . . . . . . . . . . . . . . . . 137
Protection of the undercarriage . . . . . . . . . . 25
starting on a slope . . . . . . . . . . . . . . . . . . . 131
stopping on a slope . . . . . . . . . . . . . . . . . . 131
Tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 278
294 Index