209
Checking and refilling levels
Note
Diesel vehicles are fitted with a protective device that prevents the insertion
of the wrong fuel hose 1)
. It is only possible to refuel with Diesel nozzles.
● If the pump nozzle is worn, damaged, or if it is very small, it is possible
that it will not be able to open the protective device. Before trying to insert
the pump nozzle by turning it, try a different pump or request specialist
help.
● If you fill the tank from a reserve fuel canister, the protective device will
not open. One way to resolve this is to pour the fuel in very slowly.
Bonnet
Working on components in the engine compartment
Extra caution is necessary when working on components in
the engine compartment. Always be aware of the danger of injury and scalding as well as the risk of
accident or even fire when working in the engine compartment (e.g. when
checking and refilling fluids). Always observe the warnings listed below
and follow all general safety precautions. The engine compartment of the
vehicle is a potentially hazardous area ⇒
.
WARNING
● Switch the ignition off.
● Remove the ignition key.
WARNING (Continued)
● Apply the handbrake.
● If the vehicle has a manual gearbox, place the lever in neutral; if it
has an automatic gearbox, place the selector lever in position P.
● Wait for the engine to cool down.
● Keep children away from the engine compartment.
● Never spill liquids used for vehicle operation on the engine compart-
ment, as these may catch fire (e.g. the antifreeze in coolant).
● Take care not to cause short circuits in the electrical system, especial-
ly when working on the battery.
● If working inside the engine compartment, remember that, even when
the ignition is switched off, the radiator fan may start up automatically,
and therefore there is a risk of injury.
● Do not unscrew the cap on the coolant expansion tank when the en-
gine is hot. The cooling system is under pressure.
● Protect face, hands and arms by covering the cap with a large, thick
rag to protect against escaping coolant and steam.
● If it is necessary to work in the engine compartment while the engine
is running, the rotating components (for example, poly-V belt, alternator,
radiator fan) and the high voltage ignition system are an additional haz-
ard.
● Observe the following additional warnings if work on the fuel system
or the electrical system is necessary:
–Always disconnect the battery from the on-board network.
– Do not smoke.
– Never work near naked flames.
– Always keep an approved fire extinguisher immediately available.
1)
according to the country
Safety FirstOperating instructionsPractical TipsTechnical specifications
210Checking and refilling levels
CAUTION
When changing or topping up service fluids, make absolutely certain that
you fill the fluids into the correct reservoirs. Using the wrong fluids could
cause serious malfunctions and engine damage!
For the sake of the environment
Inspect the ground underneath your vehicle regularly so that any leaks are
detected at an early stage. If you find spots of oil or other fluids, have your
vehicle inspected at the workshop.
Note
On right-hand drive vehicles* some of the containers/reservoirs mentioned
below are located on the other side of the engine compartment.
Opening the bonnet
The bonnet is released from inside the vehicle.
Fig. 107 Release lever in driver footwell and cam below the bonnet Check that the windscreen wiper arms are not unfolded. Otherwise
the paint may be damaged.
The bonnet can only be unlocked when the driver door is open.
–
Pull the lever under the dash panel in the direction of the arrow
1
⇒ Fig. 107.
– Lift the bonnet slightly ⇒
.
– Press the release catch under the bonnet upwards ⇒ Fig. 107
2
. This will release the arrester hook under the bonnet.
– Open the bonnet.
WARNING
Never open the bonnet if you see steam or drips of coolant being re-
leased from the engine compartment. Failure to comply could result in
burns. Wait until no steam or coolant can be seen before opening the
bonnet.
Closing the bonnet
– Press the bonnet down until it locks into place.
– Make sure that the bonnet catches onto its clasp. Do not press
down too hard ⇒
.
213
Checking and refilling levels
– Briefly run the engine at idle speed until the operating tempera-
ture is reached and then stop.
– Wait two minutes.
– Pull out the dipstick. Wipe the dipstick with a clean cloth and
insert it again, pushing it in as far as it will go.
– Then pull it out once more and check the oil level ⇒ Fig. 108.
Top up with engine oil if necessary.
Oil level in area A
Do not add oil
⇒ .
Oil level in area B
You can add oil, but keep the level in this zone.
Oil level in area C
Oil
must be added. Afterwards, the oil level should be in the lined area
B.
Depending on how you drive and the conditions in which the vehicle is
used, oil consumption can be up to 0.5 l/1000 km. Oil consumption is likely
to be higher for the first 5000 km. For this reason the engine oil level must
be checked at regular intervals, preferably when filling the tank and before
a journey.
WARNING
Any work carried out in the engine compartment or on the engine must
be carried out cautiously.
● When working in the engine compartment, always observe the safety
warnings ⇒ page 209.
–
–
–
CAUTION
If the oil level is above the area A do not start the engine. This could result
in damage to the engine and catalytic converter. Contact a Technical Serv-
ice.
Topping up engine oil
Top up gradually with small quantities of engine oil.
Fig. 109 In the engine
compartment: Engine oil
filler cap
Before opening the bonnet, read and observe the warnings ⇒
in
Working on components in the engine compartment on page 209.
– Unscrew cap from engine oil filler opening ⇒
Fig. 109.
– Top-up oil in small amounts, using the correct oil.
– To avoid over-filling with engine oil, you should top-up using
small quantities, wait a while and check the oil level before
adding any more oil.
Safety FirstOperating instructionsPractical TipsTechnical specifications
214Checking and refilling levels
–As soon as the oil level is in area B
, carefully close the cap.
The position of the oil filler opening is shown in the corresponding engine
compartment illustration ⇒ page 267.
Engine oil specification ⇒ page 211.
WARNING
Oil is highly inflammable! Ensure that no oil comes into contact with hot
engine components when topping up.
CAUTION
If the oil level is above the area A do not start the engine. This could result
in damage to the engine and catalytic converter. Contact a specialised work-
shop.
For the sake of the environment
The oil level must never be above area A. Otherwise oil can be drawn in
through the crankcase breather and escape into the atmosphere via the ex-
haust system.
Changing engine oil
The engine oil must be changed at the intervals given in the
service schedule. We recommend that you have the engine oil changed by a Technical Serv-
ice.
The oil change intervals are shown in the Maintenance Programme.
WARNING
Only change the engine oil yourself if you have the specialist knowledge
required!
● Before opening the bonnet, read and observe the warnings
⇒ page 209.
● Wait for the engine to cool down. Hot oil may cause burn injuries.
● Wear eye protection to avoid injuries, such as acid burns, caused by
splashes of oil.
● When removing the oil drain plug with your fingers, keep your arm
horizontal to help prevent oil from running down your arm.
● Wash your skin thoroughly if it comes into contact with engine oil.
● Engine oil is poisonous! Used oil must be stored in a safe place out of
the reach of children.
CAUTION
No additives should be used with engine oil. This could result in engine
damage. Any damage caused by the use of such additives would not be
covered by the factory warranty.
For the sake of the environment
● Because of the disposal problems, the necessary special tools and spe-
cialist knowledge required, we recommend that you have the engine oil and
filter changed by a Technical Service.
● Never pour oil down drains or into the ground.
● Use a suitable container when draining the used oil. It must be large
enough to hold all the engine oil.
219
Checking and refilling levels
Charging the battery
Terminals for charging the battery are fitted in the engine
compartment.
– Note the warnings ⇒
in Important safety warnings for han-
dling a vehicle battery on page 218 and ⇒ .
– Switch off all electrical equipment. Remove the ignition key.
– Raise the bonnet ⇒ page 210.
– Open the battery cover.
– Connect the charger clamps as described to the positive pole of
the battery (+) and, exclusively to an earth on the bodywork
(–).
– Only use a charger which is compatible for use with 12 V nomi-
nal voltage batteries. The charge must not exceed a voltage of
15 V.
– Now connect the battery charger to the power socket and switch
on.
– After charging the battery: switch off the battery charger and
disconnect the power socket cable.
– Finally disconnect the charger cables from the battery.
– Replace the battery cover correctly.
– Close the bonnet ⇒ page 210.
Important: Before you charge the battery make sure you read the manufac-
turer's instructions for using the battery charger.
WARNING
Never charge a battery that has frozen: replace battery! Failure to do so
may lead to an explosion.
Note
Use only the terminals in the engine compartment to charge the battery.
Replacing the battery
The new battery should have the same specifications (am-
perage, load and voltage) as the used battery.
Your vehicle is equipped with an intelligent power management system to
control the distribution of electrical energy ⇒ page 187. The power manage-
ment function ensures that the battery is charged much more efficiently
than on vehicles without a power management system. To maintain this
function after replacing the battery, we recommend that the replacement
battery used is of the same make and type as the original fitted battery. To
make proper use of the power management function after the battery has
been changed, have the battery coded to the power management mode at a
specialised workshop.
CAUTION
● Some vehicles, for example those with the Start-Stop system* are fitted
with a special battery (AGM-type or EFB-type battery). If any other type of
battery is fitted, the Start-Stop function may be considerably reduced and
the vehicle may not stop on repeated occasions.
● Make sure that the vent hose is always attached to the original opening
on the side of the battery. Gases or battery acid can otherwise escape and
possibly cause damage.
● The battery holder and clamps must always be correctly secured.
Safety FirstOperating instructionsPractical TipsTechnical specifications
Emergency locking and unlocking . . . . . . . . . . 96
EngineAssisted starting . . . . . . . . . . . . . . . . . . . . 241
Preheating . . . . . . . . . . . . . . . . . . . . . . . . . 144
Start-Stop system . . . . . . . . . . . . . . . . . . . . 149
Starting up . . . . . . . . . . . . . . . . . . . . . . . . . 144
Starting up (driver messages with the me-chanical contact) . . . . . . . . . . . . . . . . . . . 145
Switching off (engine) . . . . . . . . . . . . . . . . 146
Engine compartment Closing the bonnet . . . . . . . . . . . . . . . . . . . 210
Opening the bonnet . . . . . . . . . . . . . . . . . . 210
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . 209
Engine coolant G 12 plus-plus . . . . . . . . . . . . . . . . . . . . . . 215
G 13 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 215
Specifications . . . . . . . . . . . . . . . . . . . . . . . 215
Engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 211 Changing . . . . . . . . . . . . . . . . . . . . . . . . . . 214
Checking oil level . . . . . . . . . . . . . . . . . . . . 212
Consumption . . . . . . . . . . . . . . . . . . . . . . . 212
Engine oil dipstick . . . . . . . . . . . . . . . . . . . 212
Inspection service . . . . . . . . . . . . . . . . . . . 211
Longlife inspection service . . . . . . . . . . . . 211
Oil properties . . . . . . . . . . . . . . . . . . . . . . . 212
Replace . . . . . . . . . . . . . . . . . . . . . . . . . . . . 211
Service intervals . . . . . . . . . . . . . . . . . . . . . 211
Specifications . . . . . . . . . . . . . . . . . . . . . . . 211
Temperature display . . . . . . . . . . . . . . . . . . . 77
Topping up . . . . . . . . . . . . . . . . . . . . . . . . . 213
Environment Ecological driving . . . . . . . . . . . . . . . . . . . . 191
Environmental friendliness . . . . . . . . . . . . 192 Environmental tip
Leaks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Environmental tips Filling the tank . . . . . . . . . . . . . . . . . . 207, 208
Environment warning . . . . . . . . . . . . . . . . . . . . 179
ESC Electronic stability control . . . . . . . . . . . . . 183
Mode Sport . . . . . . . . . . . . . . . . . . . . . . . . . 184
Multi-collision brake . . . . . . . . . . . . . . . . . 184
ESC Sport . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 184
Ethanol (fuel) . . . . . . . . . . . . . . . . . . . . . . . . . . 206
Exhaust tail pipe: Cleaning . . . . . . . . . . . . . . . 201
extending the rear lid locking time see rear lid . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Exterior anti-dazzle rear vision mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Exterior lighting Changing a bulb . . . . . . . . . . . . . . . . . . . . . 252
Exterior mirrors Adjust . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
heated . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
Heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
F
Fastening rings . . . . . . . . . . . . . . . . . . . . . . 18, 133
Fault in the gearbox (warning lamp) . . . . . . . . 162
Fault memory . . . . . . . . . . . . . . . . . . . . . . . . . . 189
Faults Panoramic sliding sunroof . . . . . . . . . . . . . 103
Faults in the gearbox (warning lamps) . . . . . . 162 Faulty bulbs
Changing a bulb . . . . . . . . . . . . . . . . . . . . . 252
Filling the tank . . . . . . . . . . . . . . . . . . . . . . . . . 207 Fuel gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Opening the fuel tank cap . . . . . . . . . . . . . 207
Floor mats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Fold the seats . . . . . . . . . . . . . . . . . . . . . . . . . . . 132
Fold the back seats . . . . . . . . . . . . . . . . . . . . . 132
Front airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 Description . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . 37
Front armrest . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 206 Consumption . . . . . . . . . . . . . . . . . . . . . . . 264
Diesel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
Ethanol . . . . . . . . . . . . . . . . . . . . . . . . . . . . 206
Fuel gauge . . . . . . . . . . . . . . . . . . . . . . . . . . 67
Fuel consumption . . . . . . . . . . . . . . . . . . . . . . . 264
Full-LED headlights . . . . . . . . . . . . . . . . . . . . . 252
Fuses Changing . . . . . . . . . . . . . . . . . . . . . . . . . . 249
Provision . . . . . . . . . . . . . . . . . . . . . . . . . . . 250
G
Gear-change indicator . . . . . . . . . . . . . . . . . . . . 68
Gearbox DSG see Automatic gearbox . . . . . . . . . . . . . . . 154
Gear recommendation . . . . . . . . . . . . . . . . . . . . 68
280 Index
Leather CareNatural leather . . . . . . . . . . . . . . . . . . . . . . 203
Leather: Care . . . . . . . . . . . . . . . . . . . . . . . . . . 203
Leaving Home . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Lighting Changing a bulb . . . . . . . . . . . . . . . . . . . . . 252
Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 106 Acoustic warnings . . . . . . . . . . . . . . . . . . . 108
AUTO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109
Changing a bulb . . . . . . . . . . . . . . . . . . . . . 252
Coming home . . . . . . . . . . . . . . . . . . . . . . . 113
Control lamps . . . . . . . . . . . . . . . . . . . . . . . 106
Controls lighting . . . . . . . . . . . . . . . . . . . . . 114
Cornering lights . . . . . . . . . . . . . . . . . . . . . 109
Daytime driving light . . . . . . . . . . . . . . . . . 109
Fog light . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Functions . . . . . . . . . . . . . . . . . . . . . . . . . . 109
Headlight range control . . . . . . . . . . . . . . . 114
Instrument lighting . . . . . . . . . . . . . . . . . . 114
Interior lights . . . . . . . . . . . . . . . . . . . . . . . 115
Leaving home . . . . . . . . . . . . . . . . . . . . . . . 113
Main beam lever . . . . . . . . . . . . . . . . . . . . . 107
Motorway lights . . . . . . . . . . . . . . . . . . . . . 109
Parking light . . . . . . . . . . . . . . . . . . . . . . . . 109
Reading lights . . . . . . . . . . . . . . . . . . . . . . 115
Turn signal lever . . . . . . . . . . . . . . . . . . . . . 107
Load compartment in the luggage compart- ment
see Loading the luggage compartment . . . 17
Loading the luggage compartment . . . . . . . . . . 17
Locking/Unlocking In the lock cylinder . . . . . . . . . . . . . . . . . . . . 97
With the central locking switch . . . . . . . . . . 93 Longlife inspection service . . . . . . . . . . . . . . . 211
Luggage carrier . . . . . . . . . . . . . . . . . . . . . . . . . 131
Luggage compartment . . . . . . . . . . . . . . . . . . . 131
Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 132
Fastening rings . . . . . . . . . . . . . . . . . . . . . . 133
Luggage compartment lighting . . . . . . . . . 115
see also Loading the luggage compartment . .17
Lumbar support . . . . . . . . . . . . . . . . . . . . . . . . 125
M
Main beam assist . . . . . . . . . . . . . . . . . . . . . . . 111
Main beam headlight . . . . . . . . . . . . . . . . . . . . 108
Main beam lever . . . . . . . . . . . . . . . . . . . . . . . . 107
Maintenance Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 34
Manual gearbox . . . . . . . . . . . . . . . . . . . . . . . . 152 Kick-down . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Manual locking of passenger door in an emer- gency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Manual operation Selector lever . . . . . . . . . . . . . . . . . . . . . . . 163
Manual operation in an emergency Passenger door . . . . . . . . . . . . . . . . . . . . . . 97
Rear lid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Mobile phones . . . . . . . . . . . . . . . . . . . . . . . . . 230
Modifications (technical) . . . . . . . . . . . . . . . . . 230
Motorway lights . . . . . . . . . . . . . . . . . . . . . . . . 109
Mounting pin (tyre change) . . . . . . . . . . . . . . . 232
Mounting points (jack) . . . . . . . . . . . . . . . . . . . 238
Moving off Hill hold assist . . . . . . . . . . . . . . . . . . . . . . 148 Multi-collision Brake . . . . . . . . . . . . . . . . . . . . 184
Multiple CD loader . . . . . . . . . . . . . . . . . . . . . . 130
N
Navigation system CD-ROM Reade . . . . . . . . . . . . . . . . . . . . . . 130
Note regarding the environment Roof carrier . . . . . . . . . . . . . . . . . . . . . . . . . 131
Number of colour . . . . . . . . . . . . . . . . . . . . . . . 264
Number of seats . . . . . . . . . . . . . . . . . . . . . . . . . 19
O
Object holders . . . . . . . . . . . . . . . . . . . . . . . . . 129
Octane rating (petrol) . . . . . . . . . . . . . . . . . . . . 206
Odometer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Oil change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 214
Oil properties . . . . . . . . . . . . . . . . . . . . . . . . . . 212
One-touch opening and closing Electric windows . . . . . . . . . . . . . . . . . . . . . 101
Opening . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 86 Bonnet . . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
Fuel tank flap . . . . . . . . . . . . . . . . . . . . . . . 207
Panoramic sliding sunroof . . . . . . . . . . . . . 103
Panoramic sunroof . . . . . . . . . . . . . . . . . . . 103
Rear lid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . 100
Opening/Closing In the lock cylinder . . . . . . . . . . . . . . . . . . . . 97
With remote control . . . . . . . . . . . . . . . . . . . 91
With the central locking switch . . . . . . . . . . 93
282 Index