2012 Seat Exeo ST service

267
If and when
The sealing compound must not be used in the following cases:
● If the cuts and punctures on the tyre are longer than 4 mm ⇒ Fig. 200 1
●
If the wheel rim has been damaged 2●
If you have been driving with very low pressure or a completely flat tyre
3
How to use the TMS (tyre mobility system) is described in the section Re-
pairing a tyre ⇒ page 268 and in the instructions supplied with the tyre
sealant can.
The TMS (tire mobility system) can be used at outside temperatures down
to - 20°C.
WARNING
After repairing a tyre please note the following points:
● Do not drive faster than 80 km/h.
● Avoid heavy acceleration, hard braking and fast cornering.
● Vehicle handling could be impaired.
● Tyres which have been sealed using the Tyre Mobility System are only
suitable for temporary use over a short period.
● After using the tyre sealant the tyre pressure monitoring system* may
malfunction. Therefore, please drive carefully to the next available speci-
alised workshop.
● The Tyre Mobility System must NOT be used:
– If the cuts and punctures on the tyre are longer or wider than
4 mm.
– if the wheel rim has been damaged.
– if you have been driving with very low pressure or a completely flat
tyre.
● Seek professional assistance if the repair of a tyre puncture is not
possible with the sealing compound.
WARNING (Continued)
● Do not allow the sealant to come into contact with your eyes, skin or
clothing.
● If you do come into contact with the sealant immediately rinse the
eyes or skin affected with clean water.
● Change clothing immediately if it becomes soiled with the tyre seal-
ant.
● Make sure you do not breathe in the fumes!
● If any of the tyre sealant is accidentally ingested, immediately rinse
the mouth thoroughly and drink lots of water.
–Do not induce vomiting. Seek medical assistance if needed.
● If any allergic reactions should occur get medical help immediately.
● Keep the sealant away from children.
For the sake of the environment
If you have to dispose of a sealant can, go to a specialised waste service or
to a SEAT Technical Service, where the product can be recycled in an appro-
priate waste container.
Note
● If sealant should leak out, leave it to dry. This way you can pull it off like
a piece of foil.
● Observe the expiry date stated on the sealing compound can. Have the
sealing compound exchanged by a specialised workshop. 
Safety FirstOperating InstructionsPractical TipsTechnical Specifications

272If and when
Note
Please note that the above list contains all data at the time of going to
press, so it is subject to modifications. If discrepancies should occur,
please refer to the sticker on the inside of the fuse cover for the correct in-
formation for your model. 
Bulbs
General information
You can change the following bulbs for exterior lights yourself:
● Main headlights: all bulbs (except xenon headlights)
● Tail lights: all bulbs
● Side turn signal bulb
The following bulbs can only be changed by a specialised workshop:
● Main headlights: Xenon* bulb ⇒ page 279
● Front fog lights: Bulb
As a rule, you require a certain degree of practical skill to change defective
bulbs. This applies in particular to those bulbs which are only accessible
from the engine compartment.
If in doubt, we recommend that you have defective bulbs changed by a spe-
cialised workshop or qualified mechanic.
If you do decide to change bulbs in the engine compartment yourself, be
aware of the safety risks involved ⇒ page 234 ⇒ 
in Types of bulbs on
page 273. The name of many of the lamps fitted by SEAT ends in "LL". This means Long
Life. These lamps are used for functions with a long service time (dipped
beam, side lights, daylight driving, etc.). This does not apply to lamps with
a shorter service time (turn signals, etc.). A lamp with the same name ex-
cept for the last two letters, "LL“ or “SLL”, is compatible, but will have a
service life of approximately half of the LongLife lamps.
When replacing lamp bulbs, the same type of bulb as originally fitted
should always be used where possible.


303
Description of specifications
Drawbar load
The maximum permitted drawbar load on the ball joint of the towing bracket
must not exceed 75 kg.
In the interest of road safety, we recommend that you always tow approach-
ing the maximum drawbar load. The response of the trailer on the road will
be poor if the drawbar load is too small.
If the maximum permissible drawbar load cannot be met (e.g. with small,
empty and light-weight single axle trailers or tandem axle trailers with a
wheelbase of less than 1 metre), a minimum of 4% of the actual trailer
weight is legally required for the drawbar load.
WARNING
● For safety reasons, do not exceed the 80 km/h limit. This is also valid
in countries where higher speeds are permitted.
● Never exceed the maximum trailer weights or the drawbar load. If the
permissible axle load or the permissible total weight is exceeded, the
driving characteristics of the vehicle may change, leading to accidents,
injuries and damage to the vehicle.

Wheels
Tyre pressure, snow chains, wheel bolts
Tyre pressures
The sticker with the tyre pressure values can be found on the inside of the
tank flap. The tyre pressure values given there are for cold tyres. The slightly
raised pressures of warm tyres must not be reduced. ⇒ 
Snow chains
Snow chains may be fitted only to the front wheels. Consult the chapter “wheels” of this manual.
Wheel bolts
After the wheels have been changed, the
tightening torque of the wheel
bolts should be checked as soon as possible with a torque wrench ⇒ 
.
The tightening torque for steel and alloy wheels is 120 Nm.
WARNING
● Check the tyre pressure at least once per month. Checking the tyre
pressure is very important. If the tyre pressure is too high or too low,
there is an increased danger of accidents, particularly at high speeds.
● If the torque of the wheel bolts is too low, they could loosen while the
vehicle is in motion. Risk of accident! If the tightening torque is too high,
the wheel bolts and threads can be damaged.
Note
We recommend that you ask your Technical Service for information about
appropriate wheel, tyre and snow chain size. 
Safety FirstOperating InstructionsPractical TipsTechnical Specifications

304Technical specifications
Technical specifications
Engine specifications Checking fluid levels
From time to time, the levels of the different fluids in the ve-
hicle must be checked. Never fill with incorrect fluids, other-
wise serious damage to the engine may be caused.
Fig. 248 Diagram for the location of the various elements Vehicle battery
Engine oil filler cap
Brake fluid reservoir
Engine oil dipstick
1
234
Coolant expansion tank
Windscreen washer fluid container
Hydraulic fluid reservoir for power steering
The checking and refilling of service fluids are carried out on the compo-
nents mentioned above. These operations are described in the ⇒ page 234.
Overview
You will find further explanations, instructions and restrictions on the tech-
nical specifications as of ⇒ page 300.
Note
The layout of parts may vary depending on the engine. 
567

Locking and unlocking the vehicle . . . . . . 108
Replacing the battery . . . . . . . . . . . . . . . . . 100
Remote control keys . . . . . . . . . . . . . . . . . . . . . . 99 Re-synchronising . . . . . . . . . . . . . . . . . . . . 109
Removing and fitting the wheel . . . . . . . . . . . 265
Repairs Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Replacement of parts . . . . . . . . . . . . . . . . . . . . 228
Rev counter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 63
Reverse gear Automatic gearbox . . . . . . . . . . . . . . . . . . . 189
Manual gearbox . . . . . . . . . . . . . . . . . . . . . 186
Roof rack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 152 Attachment points . . . . . . . . . . . . . . . . . . . 152
Roof load . . . . . . . . . . . . . . . . . . . . . . . . . . . 153
Roof rails . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 152
Rubber seals . . . . . . . . . . . . . . . . . . . . . . . . . . . 220
Run-flat tyres . . . . . . . . . . . . . . . . . . . . . . . . . . 254
Running in Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 201
S SAFE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101
Safe driving . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 Aspects to take into account . . . . . . . . . . . . . 8
Before setting off . . . . . . . . . . . . . . . . . . . . . . 8
Driving safety . . . . . . . . . . . . . . . . . . . . . . . . . 8
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Safety equipment . . . . . . . . . . . . . . . . . . . . . . . . . 7
Safety instructions Engine compartment . . . . . . . . . . . . . . . . . 234 Safety notes
Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Curtain airbags . . . . . . . . . . . . . . . . . . . . . . . 43
Deactivating front passenger airbag . . . . . . 46
Front airbags . . . . . . . . . . . . . . . . . . . . . . . . 36
Seat belt tensioners . . . . . . . . . . . . . . . . . . . 28
Side airbags . . . . . . . . . . . . . . . . . . . . . . . . . 41
Using child seats . . . . . . . . . . . . . . . . . . . . . 47
Using seat belts . . . . . . . . . . . . . . . . . . . . . . 22
Seals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 220
Seat adjustment Lumbar support . . . . . . . . . . . . . . . . . . . . . 138
Seat belt cleaning . . . . . . . . . . . . . . . . . . . . . . 226
Seat belt position Pregnant women . . . . . . . . . . . . . . . . . . . . . 26
Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Seat belt protection . . . . . . . . . . . . . . . . . . . . . . 22
Seat belt release . . . . . . . . . . . . . . . . . . . . . . . . 26
Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19 Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . 24
Height adjustment . . . . . . . . . . . . . . . . . . . . 27
Incorrectly fastened . . . . . . . . . . . . . . . . . . . 27
Not worn . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . 22
Warning lamp . . . . . . . . . . . . . . . . . . . . . 19, 70
Seat belt tensioner Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 31
Seat belt tensioners . . . . . . . . . . . . . . . . . . . . . . 28
Seat belt warning lamp . . . . . . . . . . . . . . . . . . . 19
Seat heating . . . . . . . . . . . . . . . . . . . . . . . . . . . 171 Seats
Electric adjustment . . . . . . . . . . . . . . . . . . 137
Electric backrest adjustment . . . . . . . . . . . 138
Manual adjustment . . . . . . . . . . . . . . . . . . 135
Manual adjustment of lumbar support . . . 136
Manual backrest angle adjustment . . . . . 136
Moving the seat forwards and backwards 135
Seat height adjustment . . . . . . . . . . . . . . . 135
Seat upholstery Alcantara . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . 223
cleaning Alcantara . . . . . . . . . . . . . . . . . . . 224
Cleaning and maintenance of natural leath-er . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 225
cleaning the trim fabric . . . . . . . . . . . . . . . 224
synthetic leather . . . . . . . . . . . . . . . . . . . . 226
Selector lever positions . . . . . . . . . . . . . . . . . . 189
Service indicator . . . . . . . . . . . . . . . . . . . . . . . . 77
Servotronic . . . . . . . . . . . . . . . . . . . . . . . . . . . . 200
Side airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39 Description . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . 41
Side lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Sitting position Driver . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Front passenger . . . . . . . . . . . . . . . . . . . . . . 11
Sitting position, occupants . . . . . . . . . . . . . . . . 10
Ski bag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 151
Sliding/tilting sunroof . . . . . . . . . . . . . . . . . . . 114 Automatic close function . . . . . . . . . . . . . . 116
Closing . . . . . . . . . . . . . . . . . . . . . . . . . . . . 115
319
Index

Emergency activation . . . . . . . . . . . . . . . . . 116
Opening . . . . . . . . . . . . . . . . . . . . . . . . . . . 115
Snow chains . . . . . . . . . . . . . . . . . . . . . . . 258, 303
Solar-powered blower/sunroof . . . . . . . . . . . . 170
Solar sunroof . . . . . . . . . . . . . . . . . . . . . . . . . . 116
Spare keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Spare parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Spare wheel Steel rim . . . . . . . . . . . . . . . . . . . . . . . . . . . 261
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Speed warning . . . . . . . . . . . . . . . . . . . . . . . 84, 85
Speed warning function . . . . . . . . . . . . . . . . . . . 85
Start-Stop Activating and deactivating . . . . . . . . . . . . 177
Function . . . . . . . . . . . . . . . . . . . . . . . . . . . 176
Steam jets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 218
Steering Locking . . . . . . . . . . . . . . . . . . . . . . . . . . . . 173
Manual steering wheel adjustment . . . . . 172
Steering wheel controls . . . . . . . . . . . . . . . . . . . 94
Stopping the engine . . . . . . . . . . . . . . . . . . . . 175
Sun visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128
Switches on the driver door Electric windows . . . . . . . . . . . . . . . . . . . . . 112
Symbols Red symbols in central display . . . . . . . . . . 80
Yellow symbols on central display . . . . . . . 82
T Technical modifications . . . . . . . . . . . . . . . . . . 228
The danger of not using the seat belt . . . . . . . . 21 The environment
Heated rear window . . . . . . . . . . . . . . . . . . 128
Leaks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 235
Warming up the engine . . . . . . . . . . . . . . . 174
Tightening torque of wheel bolts . . . . . . . . . . 303
tiptronic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 187
tiptronic mode . . . . . . . . . . . . . . . . . . . . . . . . . 192
Tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 259
Tow-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . 297
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . 206, 297 Accessories . . . . . . . . . . . . . . . . . . . . . . . . . 208
Notes on towing . . . . . . . . . . . . . . . . . 206, 207
Removable towing bracket . . . . . . . . . . . . 209
Technical requirements . . . . . . . . . . . . . . . 206
Towing a trailer . . . . . . . . . . . . . . . . . . . . . . . . . 302
Towing bracket, fitting . . . . . . . . . . . . . . . . . . . 214
Towing eye . . . . . . . . . . . . . . . . . . . . . . . . . . . . 297
Towing eyes . . . . . . . . . . . . . . . . . . . . . . . . . . . 298
Tow starting General notes . . . . . . . . . . . . . . . . . . . . . . . 297
Traction control system How the system works . . . . . . . . . . . . . . . . 197
Traction control system (ASR) warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 71
Trailer weights . . . . . . . . . . . . . . . . . . . . . . . . . 302
Trip recorder . . . . . . . . . . . . . . . . . . . . . . . . . . . . 65
Turn signal lamps Hazard warning lights . . . . . . . . . . . . . . . . . 71
Trailer turn signals . . . . . . . . . . . . . . . . . . . . 69
Turn signals . . . . . . . . . . . . . . . . . . . . . . . . . 71
Turn signals . . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Tyre mobility system . . . . . . . . . . . . . . . . . . . . . 260 Tyre Mobility System . . . . . . . . . . . . . . . . . . . . 266
Tyre pressure . . . . . . . . . . . . . . . . . . . 69, 93, 249
Loss . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 251
Tyre pressure monitoring . . . . . . . . . . . . . . . . . 250
Tyre pressure monitoring system . . . . . . . . . . . 92
Tyre pressures . . . . . . . . . . . . . . . . . . . . . . . . . . 303
Tyre repair kit Tyre Mobility System . . . . . . . . . . . . . . . . . 266
Tyres and wheels Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . 255
Tyres service life . . . . . . . . . . . . . . . . . . . . . . . . 253
Tyres tread depth . . . . . . . . . . . . . . . . . . . . . . . 253
Tyres with directional tread pattern . . . . . . . . 249
U Underbody protection . . . . . . . . . . . . . . . . . . . 221
Upholstery Treating your upholstery . . . . . . . . . . . . . . 223
V
Vehicle care synthetic leather . . . . . . . . . . . . . . . . . . . . 226
Treating your upholstery . . . . . . . . . . . . . . 223
Vehicle data . . . . . . . . . . . . . . . . . . . . . . . . . . . 301
Vehicle identification data . . . . . . . . . . . . . . . . 301
Vehicle identification number . . . . . . . . . . . . . 301
Vehicle keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Vehicle maintenance electrically adjustable seats . . . . . . . . . . . 224
heated seats . . . . . . . . . . . . . . . . . . . . . . . . 224
320 Index