2012 RENAULT KANGOO engine

JauneNoirNoir texte
5.37
ENG_UD14563_2
Anomalies de fonctionnement (X61 - F61 - K61 - Renault)
ENG_NU_813-11_FK61_Renault_5
On the road POssIBle causeswhat tO DO
Vibrations. Tyres not inflated to the correct pres-
sure, incorrectly balanced or dam-
aged. Check the tyre pressures: if this is not the
problem, have them checked by an ap
-
proved Dealer.
Coolant boiling in the coolant reservoir. Mechanical fault: damaged cylinder
head gasket.Stop the engine.
Contact an approved Dealer.
Smoke under the bonnet. Short circuit or cooling system leak.Stop, switch off the ignition, stand away
from the vehicle and contact an approved
dealer.
The oil pressure warning light comes
on: while cornering or braking The level is too low. Top up the engine oil level (refer to the in-
formation on “Engine oil level: topping up/
filling” in Section 4).
is slow to go out or remains lit under
acceleration Loss of oil pressure.
Stop the vehicle and contact an approved
Dealer.
White smoke from the exhaust. This is not necessarily a fault. Smoke
may be caused by regeneration of
the particle filter.Refer to the information on “Special fea
-
tures of diesel versions” in Section 2.
OPeratIng F aults (2/4)

5.38
ENG_UD14563_2
Anomalies de fonctionnement (X61 - F61 - K61 - Renault)
ENG_NU_813-11_FK61_Renault_5
Jaune NoirNoir texte
On the road POssIBle causeswhat tO DO
Steering becomes heavy. Assistance overheating.Consult an approved Dealer.
The engine overheats. The coolant
temperature indicator and the STOP
warning light come on. Engine cooling fan not working.
Stop the vehicle, switch off the engine and
contact an approved Dealer.
Coolant leaks. Check the coolant reservoir: it should con-
tain fluid. If there is no coolant, consult an
approved Dealer as soon as possible.
OPeratIng Faults (3/4)
radiator: If there is a lack of coolant, remember that it must never be topped up using cold coolant while the engine is
very warm. After any procedure on the vehicle which has involved even partial draining of the cooling system, it must
be refilled with a new mixture prepared in the correct proportions. Reminder: only products approved by our Technical
Department may be used for this purpose.

6.1
ENG_UD29766_11
Sommaire 6 (X61 - F61 - K61 - Renault)
ENG_NU_813-11_FK61_Renault_6
Section 6: Technical specifications
Vehicle identification plates . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.2
Engine identification plates . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.3
Engine specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.4
Weights (in kg) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.5
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.6
Replacement parts and repairs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.8
Service sheets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.9
Anti-corrosion check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.15

vehicle identification plates .................................... (current page)
6.3
ENG_UD26104_4
Plaques d’identification moteur (X61 - F61 - K61 - Renault)
ENG_NU_813-11_FK61_Renault_6
Quote the details given on engine
plate C on all communication or
orders.
(Location varies depending on engine)
1 Engine type.
2 Engine suffix.
3 Engine number.
Engine identification plates
engine identification plates
c
c
c
c
12
3

engine specifications ............................................. (current page)
engine technical specifications ................... (up to the end of the DU)
6.4
ENG_UD9738_2
Caractéristiques moteurs (X61 - F61 - K61 - Renault)
ENG_NU_813-11_FK61_Renault_6
Engine specifications
Versions 1.6 16V1.61.5 dci
engine type
(see engine plate) K4M
K7MK9K
cubic capacity (cc) 1 598 1 598 1 461
t ype of fuel
octane Rating It is
essential that you use unleaded petrol of the octane rating
stated on the label inside the fuel filler flap.
If not available, for a limited time only, use unleaded fuel:
– with an octane rating of 91 for a label showing 95 or 98;
– with an octane rating of 87 for a label showing 91, 95 or 98. Diesel
The label located in the fuel filler flap indicates authorised fuels.
spark plugs Only use the spark plugs specified for your vehicle’s engine.
The type should be marked on a label affixed inside the engine
compartment. If it is not then contact your approved dealer.
Fitting spark plugs which are not to specification may damage
the engine. —
engine specifications

weights .................................................................. (current page)
towing .................................................................... (current page)
towing a caravan ................................................... (current page)
towing weights ...................................... (up to the end of the DU)
6.5
ENG_UD26105_4
Masses (X61 - F61 - K61 - Renault)
ENG_NU_813-11_FK61_Renault_6
Weights (in kg)
t he weights indicated are for a basic vehicle without options: they vary depending on the your vehicle’s equipment.
contact an approved dealer.
Maximum permissible all-up weight (MMac)
t otal train weight (MtR) Van version
estate version all terrain
Weights are indicated on the vehicle identification plate (refer to the information on “Vehicle identification plates” in Section 6)
Braked t railer Weight * found by calculating: MtR - MMac
Unbraked trailer weight * 600684696
permissible nose weight * 75
Maximum permissible load on roof 100 (including the carrying device)
* t owing weight (t owing a caravan, boat, etc.)
Towing is prohibited when the GTW - MAM calculation is equal to zero, or when the GTW is equal to zero (or is not listed) on the
identification plate.
– It is important to respect local towing regulations in force, specifically those set out in the Highway Code. Please contact your
authorised dealer about adapting any towing equipment.
– When towing, under no circumstances may the total train weight (vehicle + trailer) be exceeded . However the following is
permitted:
– the Maximum permissible weight at the rear may be exceeded by no more than 15%,
– the maximum permissible all-up weight may be exceeded by no more than 10% or 100 kg (whichever occu\
rs first).
In either case, the maximum speed of the vehicle and trailer must not exceed 48 mph (80 km/h) (van versions) or 60 mph
(100 km/h) (estate versions) and the tyre pressure must be increased by 0.\
2 bar (3 PSI).
– The engine output and climbing capability are reduced with altitude. We recommend that the maximum load be reduced by 10%
at an altitude of 1,000 metres and by an additional 10% for each 1,000 m\
etres thereafter.
Weight transfer on estate and 4Wd versions, average wheelbase
Depending on the local legislation, if the Maximum Authorised Mass of the vehicle has not been reached, up to 300 kg can be
transferred to the braked trailer, within the limits of the Gross Train Weight.
Weights (in kg)

7.2
FRA_UD29767_11
Index (X61 - F61 - K61 - Renault)
ENG_NU_813-11_FK61_Renault_7
Jaune NoirNoir texte
AlphAbeticAl index (2/5)
emergency brake assist ......................................... 2.15 → 2.17
emergency braking ................................................ 2.15 → 2.17
emergency spare wheel ...................................................... 5.2
engine technical specifications .................................................. 6.4
engine coolant ..................................................................... 4.9
engine oil .......................................................... 1.54, 4.4 → 4.7
engine oil capacity ...................................................... 4.6 – 4.7
engine oil level ........................................................... 4.4 → 4.7
engine specifications ........................................................... 6.4
environment ....................................................................... 2.14
ESP: Electronic Stability Program .....1.54 – 1.55, 2.15 → 2.17
external temperature ......................................................... 1.68
F
faults operating faults ................................................ 5.36 → 5.39
filter .................................................................................... 4.10
particle filter ................................................................. 1.54
fitting a radio ........................................................... 5.32 – 5.33
fittings .................................................................... 3.23 → 3.27
fog lights ................................................................... 1.72, 5.17
front lights changing bulbs .................................................. 5.15 – 5.16
front passenger air bag deactivation ..................... 1.44 → 1.46
front seat adjustment ............................................. 1.18 → 1.20
front seats adjustment .......................................................1.18 → 1.20
fuel advice on fuel economy ................................... 2.11 → 2.13
capacity ........................................................................ 1.77
filling ........................................................ 1.52, 1.77 → 1.79
grade ............................................................................ 1.77
fuel economy ......................................................... 2.11 → 2.13
fuel filler cap .......................................................... 1.77 → 1.79fuel tank
capacity ............................................................ 1.77 → 1.79
fuel tank capacity ................................................... 1.77 → 1.79
fuses ....................................................................... 5.26 – 5.27
G
gear lever ............................................................................. 2.7
glove box ........................................................................... 3.23
h
handbrake ................................................................... 1.53, 2.8
hazard warning lights signal .............................................. 1.69
headlight beam adjustment ............................................... 1.73
headrest ................................................................. 1.14 → 1.17
heated seats .......................................................... 1.18 → 1.20
heating and air conditioning system ........................ 3.4 → 3.15
heating system ........................................................ 3.4 → 3.15
horn ................................................................................... 1.69
horn: flash ............................................................................. 1.69
sounding the horn ........................................................ 1.69
hubcap tool .......................................................................... 5.8
i
ignition switch ...................................................................... 2.2
indicators ................................................ 1.52, 1.69, 5.16, 5.21
indicators: direction indicators .............................................. 5.16, 5.21
instrument panel .............................................. 1.56 → 1.58
instrument panel .................................................... 1.52 → 1.67
instrument panel messages ...................................1.59 → 1.67
interior lighting: changing bulbs .................................................. 5.22 – 5.23
interior trim maintenance ..................................................... 4.16 – 4.17
Isofix ...................................................................... 1.37 → 1.43

7.4
FRA_UD29767_11
Index (X61 - F61 - K61 - Renault)
ENG_NU_813-11_FK61_Renault_7
Jaune NoirNoir texte
AlphAbeticAl index (4/5)
rear screen
demisting ................................................................ 3.2, 3.4
rear seats functions ........................................................... 3.28 – 3.29
rear view mirrors ................................................................ 1.47
remote control door locking batteries ....................................................................... 5.35
remote control electric door locking .............................. 1.2, 1.4
RENAULT ANTI-INTRUDER DEVICE (RAID) ...................1.13
replacement parts ................................................................ 6.8
reverse gear selecting .................................................... 2.7, 2.27 → 2.29
reversing sensor ..................................................... 2.25 – 2.26
roof bars ............................................................................ 3.34
running in ............................................................................. 2.2
S
seat belts ...................................................... 1.25 → 1.33, 1.53
see-me-home lighting ........................................................ 1.71
service sheets .......................................................... 6.9 → 6.14
side indicator lights changing bulbs ............................................................. 5.21
side protection devices ...................................................... 1.32
side windows ..................................................................... 3.20
signals and lights ................................................... 1.70 → 1.72
speakers ............................................................................ 5.33
special features of diesel versions .....................................2.10
special features of petrol vehicles ....................................... 2.9
speed limiter ................................................. 1.54, 2.18 → 2.20
starting the engine ..................................................... 2.3 → 2.6
steering wheel adjustment ................................................................... 1.24
stopping the engine ................................................... 2.3 → 2.6
storage compartment ............................................. 3.23 → 3.27
storage compartments ........................................... 3.23 → 3.27
sun visor ................................................................... 3.18, 3.24sunroof
............................................................................... 3.21
t
tailgate ................................................. 1.8 → 1.10, 3.30 – 3.31
technical specifications ....................................... 6.2, 6.6 → 6.8
temperature regulation ............................................ 3.4 → 3.15
tool kit .................................................................................. 5.8
towing .................................................................................. 6.5
breakdown ................................................................... 5.30
towing a caravan ................................................................. 6.5
towing equipment fitting ............................................................................ 3.31
towing hitch ................................................................. 5.8, 5.30
towing rings ............................................................ 1.37 – 1.38
towing weights ..................................................................... 6.5
traction control: ASR .............................................. 2.15 → 2.17
transporting children .......................... 1.34 – 1.35, 1.37 → 1.46
transporting objects in the luggage compartment ............................. 3.30 – 3.31
trims ..................................................................................... 5.9
trip computer and warning system .........................1.59 → 1.67
turning circle ............................................................... 6.6 – 6.7
tyre inflation kit ........................................................... 5.3 → 5.7
tyre pressure ...................................................................... 4.13
tyre pressures ............................................... 4.13, 5.12 → 5.14
tyres .............................................................. 4.13, 5.12 → 5.14
U
unlocking the doors ................................................ 1.11 – 1.12
V
variable power-assisted steering ....................................... 1.53
vehicle identification ............................................................ 6.2
vehicle identification plates ......................................... 6.2 – 6.3
ventilation ................................................................ 3.2 → 3.15