2012 Ram 5500 Chassis Cab steering

Chassis
Component Fluid, Lubricant, or Genuine Part
Automatic Transmission (5.7L En-
gine Only)MOPARATF+4Automatic Transmission Fluid or equivalent licensed
ATF+4product.
Transfer Case MOPARATF+4Automatic Transmission Fluid or equivalent licensed
ATF+4product.
Front and Rear Axle Fluid (4500/
5500)GL-5 SAE 75W-90 Synthetic (MS-9763) or equivalent.
Brake Master Cylinder MOPARDOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MOPARPower Steering Fluid +4, MOPARATF+4Automatic Trans-
mission Fluid or equivalent licensed ATF+4product.
7
MAINTAINING YOUR VEHICLE 455

Once A Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
•Check all lights and other electrical items for correct
operation.At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S460 MAINTENANCE SCHEDULES

104,000 Miles (169,000 km) or
78 Months Maintenance
Service Schedule
❏Change the engine oil and engine oil
filter.
❏Rotate the tires, rotate at the first sign of
irregular wear, even if it occurs before
104,000 miles (169 000 km).
❏Lube the front drive shaft fitting (4x4
only).
❏Flush and replace engine coolant at
104,000 miles (169,00 km) or 60 months
(whichever occurs first).
❏Flush and replace power steering fluid.
Odometer Reading Date
Repair Order # Dealer Code
Signature, Authorized Service Center
112,000 Miles (182,000 km) or 84 Months Maintenance Service
Schedule
❏Change the engine oil and engine oil filter.
❏Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before
112,000 miles (182 000 km).
❏If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter; replace if necessary.
❏Lube the front drive shaft fitting (4x4 only).
❏Inspect the brake linings, replace if necessary.
❏Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for
damage, wear, improper looseness or end play; replace if necessary.
Odometer Reading Date
Repair Order # Dealer Code
Signature, Authorized Service Center
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
SMAINTENANCE SCHEDULES 469

Automatic Transmission
Adding Fluid....................... 433
Fluid and Filter Changes............... 434
Fluid Level Check.................432,433
FluidType ......................432,455
Shifting ........................... 284
Special Additives..................... 432
AxleFluid .......................430,431,455
Axle Lubrication (Axle Fluid)............430,431
B-Pillar Location........................ 320
Battery............................... 414
Keyless Transmitter Replacement (RKE)..... 25
Saving Feature (Protection).............. 152
Belts, Seat............................ 40,80
Body Builders Guide....................... 6
Body Mechanism Lubrication............... 417
Brake Fluid.........................428,455Brake System........................312,427
Anti-Lock (ABS)..................... 313
Fluid Check........................ 428
Master Cylinder..................... 428
Parking........................... 310
Warning Light....................... 198
Brake/Transmission Interlock............... 284
Bulb Replacement....................... 447
Bulbs,Light .......................... 82,446
Cab Top Clearance Lights.................. 451
Calibration, Compass..................... 216
Capacities, Antifreeze (Engine Coolant)........ 453
Capacities, Fluid........................ 453
Caps, Filler
Oil (Engine)........................ 412
Power Steering...................... 309
Radiator (Coolant Pressure)............. 424
Car Washes............................ 435
10
INDEX 487

Drain, Flush, and Refill................ 422
Inspection.......................... 425
Points to Remember.................. 426
Pressure Cap........................ 424
Radiator Cap....................... 424
Selection of Coolant (Antifreeze).......422,454
Cupholders............................ 172
Customer Assistance..................... 477
Data Recorder, Event...................... 64
Daytime Running Lights................... 153
Dealer Service.......................... 409
Defroster, Rear Window................... 180
Defroster, Windshield................ 80,265,271
Delay (Intermittent) Wipers................. 155
Differential, Limited-Slip.................. 304
Dipsticks
Automatic Transmission................ 433
Power Steering...................... 309Disabled Vehicle Towing................... 399
Disposal
Antifreeze (Engine Coolant)............. 425
Door Locks............................. 29
Door Locks, Automatic.................... 31
Driving
Through Flowing, Rising, or Shallow
Standing Water...................... 306
Dual Rear Wheels.....................340,388
Electric Rear Window Defrost............... 180
Electrical Power Outlets................... 165
Electronic Range Select (ERS)............... 290
Electronic Speed Control (Cruise Control)...... 160
Electronic Vehicle Information Center (EVIC).... 204
Electronically Shifted Transfer Case........... 298
Emergency Brake........................ 310
10
INDEX 489

Fluid Leaks............................. 82
Fluid Level Checks
Automatic Transmission................ 433
Brake............................. 428
Power Steering...................... 309
Fluid, Brake........................... 455
Fluids, Lubricants and Genuine Parts.......... 454
Fog Lights.......................150,202,449
Four Wheel Drive....................... 294
Four-Way Hazard Flasher.................. 380
Freeing A Stuck Vehicle................... 396
Front Axle (Differential)................... 430
Fuel................................. 341
Adding........................... 346
Diesel............................. 454
Filler Cap (Gas Cap).................. 347
Filter ............................. 454
Gauge............................ 190
Light ............................. 197Octane Rating....................... 341
Requirements....................... 341
Tank Capacity....................... 453
Fuses................................ 440
Gas Cap (Fuel Filler Cap)...............347,406
Gasoline (Fuel)......................... 341
Gasoline, Reformulated................... 342
Gauges
Coolant Temperature.................. 190
Fuel.............................. 190
Oil Pressure........................ 193
Speedometer........................ 191
Tachometer......................... 190
Voltmeter.......................... 198
Gear Ranges........................... 285
Gear Select Lever Override................. 398
General Information.................. 18,25,124
Glass Cleaning.......................... 439
10
INDEX 491

Sliding Rear Window.................. 181
Steering........................308,309
Windows........................... 35
Power Steering Fluid..................... 455
Pregnant Women and Seat Belts.............. 53
Programmable Electronic Features............ 218
Programming Transmitters
(Remote Keyless Entry).................... 20
Radial Ply Tires......................... 330
Radiator Cap (Coolant Pressure Cap).......422,424
Radio Operation........................ 262
Radio, Satellite (Uconnect™ studios).......... 256
Rear Axle (Differential).................430,431
Rear Window Features.................... 180
Rear Window, Sliding..................... 181
Reclining Front Seats..................... 138
Recorder, Event Data...................... 64Recreational Towing...................... 368
Shifting into Transfer Case Neutral (N) . . 371,373
Shifting out of Transfer
Case Neutral (N)..................372,376
Reformulated Gasoline.................... 342
Refrigerant............................ 416
Reminder, Seat Belt....................... 52
Remote Control
Starting System....................... 26
Remote Keyless Entry (RKE)................. 20
Remote Sound System (Radio) Controls........ 260
Remote Starting System.................... 26
Replacement Keys........................ 17
Replacement Parts....................... 408
Replacement Tires....................... 334
Reporting Safety Defects................... 480
Resetting Oil Change Indicator...........196,212
Restraint, Head......................... 139
Restraints, Child....................... 65,71
10
INDEX 497

Settings, Personal........................ 218
Shift Lever Override...................... 398
Shifting ............................... 282
Automatic Transmission................ 284
Transfer Case....................... 296
Transfer Case, Shifting into Transfer
Case Neutral (N)..................371,373
Transfer Case, Shifting out of Transfer
Case Neutral (N)..................372,376
Shoulder Belt Upper Anchorage.............. 49
Shoulder Belts........................... 40
Signals, Turn...................... 82,153,190
Sliding Rear Window
Power............................ 181
Snow Chains (Tire Chains)................. 336
Snow Plow............................ 364
Snow Tires............................ 338
Spare Tire..........................331,332
Spark Plugs............................ 454Speed Control (Cruise Control).............. 160
Speedometer........................... 191
Starting............................. 26,279
Automatic Transmission................ 279
Cold Weather....................... 280
Engine Fails to Start.................. 280
Remote............................ 26
Starting Procedures (Gas Engines)............ 279
Steel Carcass Ply Tires.................... 327
Steering
Power..........................308,309
Wheel, Heated...................... 159
Wheel, Tilt......................... 157
Steering Wheel Audio Controls.............. 260
Steering Wheel Mounted Sound
System Controls......................... 260
Storage Compartment, Center Seat........... 176
Storage, Vehicle......................273,445
StoringYourVehicle ...................... 445
10
INDEX 499