2012 PEUGEOT 107 brake

10
85 Checks
1. Coolant header tank2.Screenwash fluid reservoir 3.Brake fluid reservoir 4.Fusebox
5.Battery6. Air filter 7.Engine oil dipstick8.
Engine oil filler cap












Engine

86Checks






Checking levels
There are two marks on thedipstick:A= maximum
If you fill past this mark, contact a PEUGEOT dealer or a qualified workshop. B= minimum
Never allow the level to fallbelow this mark.
Dipstick
Brake fluid level

The brake fluid level should be close to the
"MA X" mark. If it is not, check the brake pad
w
ear. If a level drops si
gnificantly, have the corresponding system checked by a PEUGEOT dealer or a
qualified workshop.
Check all of these levels re
gularly and top them up if necessary, unless other wise indicated.
Take care when working under the bonnet, as certain areas of the engine may be extremely hot (risk of burns).
Oil level
The check is carried out either when the ignition is switched on using the oil level indicator on the instrument panel, or using the
dipstick.
This manual check will only be correct if the
vehicle is on level ground and the engine has
been off for more than 30 minutes.
It is normal to top up the oil level between two ser vices (or oil changes). PEUGEOT recommends that you checkthe level, and top up if necessary, every 3 000 miles (5 000 kms). After topping up the oil, the check whenswitching on the ignition with the oillevel indicator in the instrument panelis not valid during the 30 minutes after topping up.


Engine oil change

Refer to the servicing booklet for details of the
interval for this operation.
In order to maintain the reliabilit
y of the engine
and emission control system, the use of
additives in the engine oil is prohibited.

Oil specifi cation

The oil must be the correct grade for your engine and conform to the manufacturer'srecommendations.



Changing the fl uid

Refer to the servicing booklet for details of the
interval for this operation.

10
87 Checks
Screenwash fluid level
Top up the level when necessary.
Coolant level
Fluid specifi cation
For optimum cleaning and to avoid freezing,
this fluid must not be topped up or replaced
with plain water.



Fluid specifi cation

The brake fluid must conform to themanufacturer's recommendations and meet the
D
OT4 standard.


The coolant level should be close to the "MAX" mark but should never exceed it.
When the engine is warm, the temperature of
the coolant is regulated by the fan. This can
operate with the ignition off.
In addition, as the cooling system is pressurised, wait at least one hour after switching off the engine before carrying out anywork.
To avoid any risk of scalding, unscrew the cap by two turns to allow the pressure to drop.
When the pressure has dropped, remove thecap and top up the level.
Changing the coolant
The coolant does not have to be changed.
Fluid specifi cation
The coolant must conform to the
manufacturer's recommendations.









Used products
Avoid prolonged contact of used oil or fluids
with the skin.
M
ost of these fluids are harmful to health or indeed very corrosive.
Do not discard used oil or fluids intosewers or onto the ground.Take used oil to a PEUGEOT dealer or a qualified workshop (France) or to an authorised waste disposal site.

88Checks






Checks






2 Tronic gearbox















Brake pads
Unless other wise indicated, check thesecomponents in accordance with the servicingbooklet and according to your engine.
Other wise, have them checked by a PEUGEOT
dealer or a qualified workshop.
12 V battery
Oil filter
Manual gearbox
Only use products recommended byPEUGEOT or products of equivalent quality and specification.
In order to optimise the operation of units as impor tant as the brakingsystem, PEUGEOT selects and offers very specific products. To avoid damaging the electrical units, the use of a high pressure washer in the engine compar tment is strictlyprohibited.
Air filter and passenger compartment filter

Brake disc wear
Parkin
g brake
The battery does not require any maintenance.
However, check that the terminals are clean
and correctl
y tightened, particularly in summer and winter.
When carrying out work on the battery, refer to the "Practical information" section for details of the precautions
to be taken before disconnecting the battery and following its reconnection.

Refer to the ser vicing booklet for
details of the replacement intervals
for these components.
Dependin
g on the environment (e.g.
dusty atmosphere) and the use of the vehicle (e.g. city driving), replace them twice as often if necessary.y A clogged passenger compar tment filter mayhave an adverse effect on the performance
of the air conditioning system and generate undesirable odours.
Replace the oil
filter each time theengine oil is changed.
Refer to the ser vicing booklet for
details of the replacement inter val for
this component.
The gearbox does not require any maintenance (no oil change).
Refer to the ser vicing booklet for the
details of the level checking intervalfor this component.
The
2 Tr o n i c gearbox does not require
any maintenance (no oil change).
Refer to the servicing booklet for
details of the checking inter val for
this unit.
Brake wear depends on the st
yle
of driving, par ticularly in the case
of vehicles used in town, over shor t
distances. It ma
y be necessary to
have the condition of the brakes checked
, even between vehicle services.
Unless there is a leak in the circuit, a drop in
the brake fluid level indicates that the brake pads are worn. For information on checkin
g brake
disc wear, contact a PEUGEOT
dealer or a qualified workshop.

I
f excessive travel or a loss of effectiveness of this system is
noticed, the parking brake must be checked, even between two services.
Checking this system must be done by a
PEUGEOT dealer or a qualified workshop.

128Visual search
Exterior


Keys, remote control, locating the vehicle 4, 26
Remote control battery 27
Starting 4, 42

Opening the bonnet 84


To w i ng 80-81


Tyres, pressures 65, 92


Parking brake 48, 88
ABS (EBFD-CSC) 49
ASR/ESP 50

Fuel tank, filler cap, filling with fuel 5, 30
Fuel gauge 23


Mirrors 37
Roof bars 81

Opening/closing, locking/unlocking doors 28


Front lamps, foglamps 44
Direction indicators 45 Changing bulbs 67- 68
Adjusting the headlamps 46


Boot 29, 41
Spare wheel, jack, changing, fitting 41, 6 5 - 6 7


Rear lamps, foglamp 44
Changing bulbs 69
Number plate lamps, 3rd brake lamp,side repeaters 70

LED daytime running lamps 45

130Visual search
Instruments and controls


Courtesy lamp 46


Rear view mirror 37


Electric windows 28


Front seats 38

Sun visors 40
Parking brake, handbrake 48


Audio system/Bluetooth 93-115
Vents, ventilation 33Heating, demist /defrost, air conditioning A/C 34-36Hazard warning lamps 48
Fittings, 12 volt socket 40


Mat 79


2 Tronic gearbox 42- 43
Manual gearbox 16
Seat belts 51-53

Audio system 11 6-127
Setting the time 25, 117Fitting audio equipment, speakers 79

.
133 Alphabetical index
2 Tronic gearbox .............16, 19, 22, 24, 42, 43,77,88Backup starting .............................................76Battery...............................................76-78, 88Battery, charging ...........................................77Bluetooth (hands-free)................................104Bonnet...........................................................84Boot...............................................................41Brake discs....................................................88Brake lamps ..................................................69Brake pads ....................................................88Brakes ...........................................................88
Capacity, fuel tank........................................30CD changer..........................................r124-127CD MP3.................................................98-100Central locking..............................................26Changing a bulb ......................................67,68Changing a fuse ............................................71Changing a wheel .........................................65Changing the remotecontrol battery.............................................27Changingthe time...............................................25, 117Checking levels.......................................86,87Checking the engineoil level ........................................................86Checks ..........................................................88Child lock.......................................................28Children...................................................28, 63Child seats.......................................57,59, 60Child seats,conventional................................................59Coolant level .................................................87Courtesy mirror.............................................r40Cup holder.....................................................r40
B
C
Deactivatingthe passenger airbag..................................55Defrosting ......................................................33Demisting......................................................33Dimensions...................................................91Dipped beam.....................................44, 67, 68Dipstick..........................................................86Direction indicators...........................44, 67-69Display screen..............................................23Doors.............................................................28Driver''s seat belt notfastened warning lamp.........................22, 52Driving mode.................................................42
Easy mode(automatic mode) ........................................42Eco-driving...................................................17Eco-driving (advice)......................................17Economicaldriving ........................................................17Electronic engineimmobiliser..................................................27Electronic stability control (ESP)...........................................................50Engine...............................................85, 89,90Engine, petrol ................................................31Engine compartmentfusebox.......................................................71Engine oil ................................................85,86Engine oil levelindicator......................................................r86Engines.........................................................89Environment ..................................................17ESP ...............................................................50
E
ABS...............................................................49Accessories..............................................4, 82Access to rear seats(3-door) .......................................................38Adjusting headlamps....................................46Adjusting the steering wheel.........................37Airbag fault..............................................54, 55Airbags ..............................................21, 54, 55Airbags, curtain .......................................55,56Airbags, front.................................................56Airbags, lateral........................................55,56Airbag warning lamp.....................................54Air conditioning.......................................12, 17Air conditioning, manual.........................13, 35Air conditioning on/off...................................f35Air distribution adjustment......................34, 35Air filter..........................................................r88Air flow..............................................17,34, 35Air flow adjustment .................................34, 35Air vents..................................................33-35Anti-lock braking system (ABS)....................49Anti-theft........................................................26ASR...............................................................50Assistance, emergency braking...................49Audible warning............................................48Audio equipment(general).......................................25, 117,118Audio streaming(Bluetooth)................................................103Audio system (CD/CD changer)..........124-127Audio system (radio)................... 119,120,122Auxiliary socket ..............................40, 117,118
A
D

134Alphabetical index
Lamps, front......................................44,67,68Lamps, rear.......................................r44, 69,70LED daytime running lamps..........................45Level, brake fluid...........................................86Levels and checks...................................86,87Lighting....................................................44,68Lighting bulbs (replacement)..................67,68Lighting control stalk .....................................44Lighting on reminder.....................................r44Loading..........................................................17Locating your vehicle....................................26Locking/unlockinga door from the inside .................................28
Main beam........................................44, 67, 68Maintenance............................................17,85Manual mode................................................42Mat................................................................79Mini fuel level ..........................................23, 30Mirror, rear view............................................37Mirrors, door..................................................r37Mountings for ISOFIX seats .........................62MP3 CD .................................................99, 100
Number plate lamps......................................70
Oil filter..........................................................r88Oil level..........................................................86Opening the bonnet......................................84Opening the boot ..........................................29L
M
N
O
Filling with fuel ........................................30,31Fitting a wheel ...............................................65Flashing indicators .............................44, 67-70Folding/unfolding the door mirrors................37Force limiter..................................................r51Front foglamps........................................44, 68Front seats....................................................38Fuel..............................................17, 23,30,31Fuel consumption..............................17, 23, 30Fuel gauge ..............................................23, 30Fuel tank..................................................23, 30Fuses .............................................................71
Gearbox, manual..........................................88Gearbox, manual (reverse gear)...................16Gear lever......................................................17
Instrument panel fusebox.............................71Interior fittings...............................................40Interior lamp..................................................46ISOFIX.....................................................62, 64
ISOFIX child seats ..................................63, 64
ISOFIX mountings ...................................62, 64
Jack...............................................................65JACK socket..................................................40
Hands-free kit..............................................104Headlamp adjustment...................................44Headlamp flash .............................................44Headlamps ........................................ 44, 67, 68Head restraints, rear.....................................r39Heating ........................................12, 13, 17,34Keepin
g children safe.......................28,57, 63Key................................................................26
F
H
G
I
J
K
Identification..................................................92Identification plates .......................................92Inflating tyres ................................................17Instrument panel ...........................................19
G
Parcel shelf, rear...........................................r41Parking brake....................................20, 48,88Parking the vehicle........................................48Passengercompartment filter.......................r88Player, CD MP3.....................................99, 100Port, USB .............................................. 40, 101Power steering..............................................22Pre-tensioning seat belts..............................51Protecting children..................................57,63Puncture........................................................65
P