2012 Lancia Thema belt

CAUTION!
 It is essential when replacing thecables on the battery that the
positive cable is attached to the
positive post and the negative
cable is attached to the negative
post. Battery posts are marked
positive (+) and negative (-) and
are identified on the battery case.
Cable clamps should be tight on
the terminal posts and free of cor-
rosion.
 If a “fast charger” is used while
the battery is in the vehicle, dis-
connect both vehicle battery
cables before connecting the char-
ger to the battery. Do not use a
“fast charger” to provide starting
voltage.
AIR CONDITIONER
MAINTENANCE
For best possible performance, your
air conditioner should be checked and
serviced by an authorized dealer at
the start of each warm season. This
service should include cleaning of the
condenser fins and a performance test. Drive belt tension should also be
checked at this time.
CAUTION!
Do not use chemical flushes in your
air conditioning system as the
chemicals can damage your air con-
ditioning components. Such damage
is not covered by the New Vehicle
Limited Warranty.WARNING!
 Use only refrigerants and com-
pressor lubricants approved by
the manufacturer for your air con-
ditioning system. Some unap-
proved refrigerants are flammable
and can explode, injuring you.
Other unapproved refrigerants or
lubricants can cause the system to
fail, requiring costly repairs.
 The air conditioning system con-
tains refrigerant under high pres-
sure. To avoid risk of personal in-
jury or damage to the system,
adding refrigerant or any repair
requiring lines to be disconnected
should be done by an experienced
technician. Refrigerant Recovery And
Recycling
R-134a Air Conditioning Refrigerant
is a hydrofluorocarbon (HFC) that is
endorsed by the Environmental Pro-
tection Agency and is an ozone-saving
product. However, the manufacturer
recommends that air conditioning
service be performed by authorized
dealers or other service facilities using
recovery and recycling equipment.
NOTE:
Use only manufacturer approved
A/C system sealers, stop leak prod-
ucts, seal conditioners, compres-
sor oil, and refrigerants.
A/C AIR FILTER
CAUTION!
Car maintenance should be done at
a LANCIA Dealership. For routine
and minor maintenance operations
you wish to carry out yourself, we do
recommend you have the proper
equipment, genuine LANCIA spare
parts and the necessary fluids; do
not however carry out these opera-
tions if you have no experience.
261

Seat Belt Maintenance
Do not bleach, dye, or clean the belts
with chemical solvents or abrasive
cleaners. This will weaken the fabric.
Sun damage can also weaken the fab-
ric.
If the belts need cleaning, use a mild
soap solution, or lukewarm water. Do
not remove the belts from the vehicle
to wash them.
Replace the belts if they appear frayed
or worn or if the buckles do not work
properly.
Cleaning The Center Console
Cupholders
Clean with a damp cloth or towel us-
ing a mild detergent with the cup-
holder in the center console.
NOTE:
The cupholder cannot be removed.FUSES
Integrated Power Module
The Integrated Power Module is lo-
cated in the engine compartment.
This module contains fuses and re-
lays.
CAUTION!
 When installing the integrated
power module cover, it is impor-
tant to ensure the cover is properly
positioned and fully latched. Fail-
ure to do so may allow water to get
into the integrated power module
and possibly result in an electrical
system failure.
 When replacing a blown fuse, it is
important to use only a fuse hav-
ing the correct amperage rating.
The use of a fuse with a rating
other than indicated may result in
a dangerous electrical system
overload. If a properly rated fuse
continues to blow, it indicates a
problem in the circuit that must
be corrected.
Integrated Power Module
274

Thousands Of Kilometers24 48 72 96 120 144 168 192
Months 12 24 36 48 60 72 84 96
Check tire condition/wear and adjust pressure, if neces-
sary.        
Check operation of lighting system (headlamps, direction
indicators, hazard warning lights, luggage compartment,
passenger compartment, glove compartment, instrument
panel warning lights, etc.).        
Check operation of windscreen washer system and adjust
jets if necessary.        
Check windshield/rear window wiper blade position/
wear.        
Check cleanliness of hood and tailgate locks and cleanli-
ness and lubrication of linkages.        
Visually inspect condition of: exterior bodywork, under-
body protection, pipes and hoses (exhaust - fuel system -
brakes), rubber elements (boots, sleeves, bushes, etc.).        
Check conditions and wear of front disc brake pads.        
Check conditions and wear of rear disc brake pads.        
Check and, if necessary, top up fluid levels (brakes, wind-
shield washer, battery, engine coolant, etc.).        
Visually inspect the condition of accessory drive belt/s. 
Adjust parking brake shoes as necessary. 
Check exhaust gas emissions.        
Check engine management system operation (via diag-
nostic socket).        
Change the automatic transmission fluid and filter (*) 
291

Thousands Of Kilometers24 48 72 96 120 144 168 192
Months 12 24 36 48 60 72 84 96
Replace spark plugs. 
Replace air filter cartridge.    
Change engine oil and replace oil filter. Every 12.000 km or 12 months whichever comes first
Change brake fluid (or every 24 months). 
Replace pollen filter.        
(*) Change the automatic transmis-
sion fluid and filter(s) at 96 000 km
or 48 months if using your vehicle for
any of the following: city driving,
short (less than 7-8 km) and repeated
journeys, or frequent trailer or cara-
van towing.
Periodic Checks
Every 1 000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 windshield washer fluid level;
 tire inflation pressure and condi- tion;
 operation of lighting system (head- lights, direction indicators, hazard
warning lights, etc.);  operation of windshield washer/
wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3 000 km, check and top up, if
required, the engine oil level.
Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;
 short, repeated journeys (less than 7-8 km) at sub-zero outside tem-
peratures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness. You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi-
tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;
 visually inspect conditions of: en- gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
292

Thousands Of Kilometers20 40 60 80 100 120 140 160
Months 12 24 36 48 60 72 84 96
Check operation of windscreen washer system and adjust
jets if necessary.        
Check windshield/rear window wiper blade position/
wear.        
Check cleanliness of hood and tailgate locks and cleanli-
ness and lubrication of linkages.        
Visually inspect condition of: exterior bodywork, under-
body protection, pipes and hoses (exhaust - fuel system -
brakes), rubber elements (boots, sleeves, bushes, etc.).        
Check conditions and wear of front disc brake pads.        
Check conditions and wear of rear disc brake pads.        
Check and, if necessary, top up fluid levels (brakes,
windshield washer, battery, engine coolant, etc.).        
Visually inspect the condition of accessory drive belt/s. 
Adjust parking brake shoes as necessary. 
Check exhaust gas emissions.        
Check engine management system operation (via diag-
nostic socket).        
Change the automatic transmission fluid and filter (*). 
Replace fuel filter. 
Replace accessory drive belt/s. 
Replace air filter cartridge. 
Change engine oil and replace oil filter (**).
Change brake fluid (or every 24 months). 
Replace pollen filter.        
294

(*) Change the automatic transmis-
sion fluid and filter(s) at 100 000 km
or 60 months if using your vehicle for
any of the following: city driving,
short (less than 7-8 km) and repeated
journeys, or frequent trailer or cara-
van towing.
(**) The actual oil and oil filter re-
placement interval depends on the car
usage conditions and is indicated by a
warning light or message on the in-
strument panel, or in any case every
12 months.
Periodic Checks
Every1 000 km or before long jour-
neys, check and, if necessary, restore:
 engine coolant;
 brake fluid;
 windshield washer fluid level;
 tire inflation pressure and condi- tion;  operation of lighting system (head-
lights, direction indicators, hazard
warning lights, etc.);
 operation of windshield washer/ wiper system and positioning/wear
of windshield/rear window wiper
blades.
Every 3 000 km, check and top up, if
required, the engine oil level.
Heavy-Duty Use Of The Car
If the car is used mainly under one of
the following conditions:
 towing a trailer or caravan;
 dusty roads;
 short, repeated journeys (less than 7-8 km) at sub-zero outside tem-
peratures;
 engine often idling or driving long distances at low speeds or long pe-
riods of idleness. You should perform the following in-
spections more frequently than shown
on the Scheduled Servicing Plan:
 check front disc brake pad condi-
tions and wear;
 check cleanliness of hood and trunk locks, cleanliness and lubrication of
linkage;
 visually inspect conditions of: en- gine, transmission, pipes and hoses
(exhaust - fuel system - brakes) and
rubber elements (boots - sleeves -
bushes - etc.);
 check battery charge and battery fluid level (electrolyte);
 visually inspect condition of the ac- cessory drive belts;
 check and, if necessary, change en- gine oil and replace oil filter;
 check and, if necessary, replace pol- len filter;
 check and, if necessary, replace air cleaner filter.
295

About Your Brakes . . . . . . . . . 206
ABS (Anti-Lock Brake
System) . . . . . . . . . . . . . . . . 208
Adaptive Cruise Control (ACC)
(Cruise Control) . . . . . . . . . . 117
Adding Engine Coolant
(Antifreeze) . . . . . . . . . . . . . . 266
Adding Fuel . . . . . . . . . . . . . 226
Adding Washer Fluid . . . . . . . 263
Additives, Fuel . . . . . . . . . . . 224
Adjustable Pedals . . . . . . . . . 114
Air Cleaner, Engine (Engine
Air Cleaner Filter) . . . . . . . . . 259Air Conditioner Maintenance
. . 261
Air Conditioning Filter . . . 185,261
Air Conditioning Refrigerant . . 261
Air Conditioning System
. . 184,261
Air Pressure, Tires . . . . . . . . . 214
Airbag . . . . . . . . . . . . . . . . 33,39
Airbag Deployment . . . . . . . . . 40
Airbag Light . . . . . . 38,41,52,156
Airbag Maintenance . . . . . . . . . 40
Airbag, Side . . . . . . . . . . 35,37,39
Airbag, Window
(Side Curtain) . . . . . . . . 35,37,39
Alarm Light . . . . . . . . . . . . . 158
Alarm System (Security Alarm)
. . 15
Alterations/Modifications,
Vehicle . . . . . . . . . . . . . . . . . . . 7 Anti-Lock Brake System
(ABS) . . . . . . . . . . . . . . 208,209
Anti-Lock Warning Light . . . . 158
Antifreeze
(Engine Coolant) . . . . . . . 266,283
Disposal . . . . . . . . . . . . . . 267
Appearance Care . . . . . . . . . . 271
Assist, Hill Start . . . . . . . . . . 211
Auto Down Power Windows . . . 23
Auto Unlock, Doors . . . . . . . . . 19
Auto Up Power Windows . . . . . 23
Automatic Dimming Mirror . . . 63
Automatic Door Locks . . . . . . . 19
Automatic Headlights . . . . . . . 105
Automatic Oil Change
Indicator . . . . . . . . . . . . . . . . 164
Automatic Temperature
Control (ATC) . . . . . . . . . . . . 184
Automatic Transaxle
Special Additives . . . . . . . . 270
Automatic
Transmission . . . 196,199,270,271 Adding Fluid . . . . . . . . 271,285
Autostick . . . . . . . . . . . . . . 202
Fluid and Filter Changes . . . 271
Fluid Change . . . . . . . . . . . 271
Fluid Level Check . . . . . . . 270
Fluid Type . . . . . . . . . . . . . 285
Special Additives . . . . . . . . 270 Automatic Transmission Limp
Home Mode . . . . . . . . . . . . . 198
Autostick . . . . . . . . . . . . . . . 202
Axle Fluid . . . . . . . . . . . . . . . 285
Axle Lubrication
(Axle Fluid) . . . . . . . . . . . . . 285
Battery . . . . . . . . . . . . . . . . . 260
Keyless Transmitter
Replacement (RKE) . . . . . . . 17
Location . . . . . . . . . . . . . . 260
Belts, Seat . . . . . . . . . . . . . 26,51
Body Mechanism
Lubrication . . . . . . . . . . . . . . 262
Brake Assist System . . . . . . . . 209
Brake Control System,
Electronic . . . . . . . . . . . . . . . 209
Brake Fluid . . . . . . . . . . . . . . 285
Brake System . . . . . . . . . . . . 268 Anti-Lock (ABS) . . . . . . . . 208
Fluid Check . . . . . . . . 269,285
Master Cylinder . . . . . . . . . 269
Parking . . . . . . . . . . . . . . . 206
Warning Light . . . . . . . . . . 157
Brake, Parking . . . . . . . . . . . 206
Brake/Transmission
Interlock . . . . . . . . . . . . . . . . 196
Brakes . . . . . . . . . . . . . . . . . 268
298

Introduction . . . . . . . . . . . . . . . 4
Jump Starting . . . . . . . . . . . . 246
Key-In Reminder . . . . . . . . . . . 13
Key, Programming . . . . . . . . . . 14
Key, Replacement . . . . . . . . . . 14
Key, Sentry (Immobilizer) . . . . 13
Keyless Enter-N-Go . . . . . . 20,191
Keyless Entry System . . . . . . . . 16
Keyless Go . . . . . . . . . . . . . . . 12
Keys . . . . . . . . . . . . . . . . . . . . 12
Kicker Sound System . . . . . . . 178
Knee Bolster . . . . . . . . . . . . . . 33
Lane Change and Turn
Signals . . . . . . . . . . . . . . . . . 107
Lane Change Assist . . . . . . . . 107
Lap/Shoulder Belts . . . . . . . . . 26
LATCH (Lower Anchors and
Tether for CHildren) . . . . . . 46,47
Latch Plate . . . . . . . . . . . . . . . 27
Latches . . . . . . . . . . . . . . . . . 53
Lead Free Gasoline . . . . . . . . 223
Leaks, Fluid . . . . . . . . . . . . . . 53
Life of Tires . . . . . . . . . . . . . 217
Light Bulbs . . . . . . . . . . . 53,280
Lights . . . . . . . . . . . . . . . 53,104Airbag . . . . . . . . . 38,41,52,156 Alarm . . . . . . . . . . . . . . . . 158
Anti-Lock . . . . . . . . . . . . . 158
Automatic Headlights . . . . . 105
Brake Assist Warning . . . . . 213
Brake Warning . . . . . . . . . . 157
Bulb Replacement . . . . 280,281
Dimmer Switch,
Headlight . . . . . . . . . . . . . 107
Electronic Stability Program
(ESP) Indicator . . . . . . . . . 213
Exterior . . . . . . . . . . . . . . . . 53
Fog . . . . . . . . . . . . . . . . . . 154
Hazard Warning Flasher . . . 240
Headlight Switch . . . . . . . . 104
Headlights . . . . . . . . . 104,281
Headlights On Reminder . . . 107
Headlights On With
Wipers . . . . . . . . . . . . 105,111
High Beam . . . . . . . . . . . . 107
High Beam Indicator . . . . . . 154
High Beam/Low Beam
Select . . . . . . . . . . . . . . . . 107
Illuminated Entry . . . . . . . . . 16
Instrument Cluster . . . . . . . 104
Intensity Control . . . . . . . . 109
Interior . . . . . . . . . . . . . . . 108
License . . . . . . . . . . . . . . . 283
Lights On Reminder . . . . . . 107
Low Fuel . . . . . . . . . . . . . . 162Malfunction Indicator
(Check Engine) . . . . . . . . . 156
Map Reading . . . . . . . . . . . 108
Parade Mode (Daytime
Brightness) . . . . . . . . . . . . 109
Passing . . . . . . . . . . . . . . . 108
Reading . . . . . . . . . . . 108,135
Seat Belt Reminder . . . . . . . 159
Security Alarm (Theft
Alarm) . . . . . . . . . . . . . . . 158
Service . . . . . . . . . . . . 280,281
Service Engine Soon
(Malfunction Indicator) . . . . 156
SmartBeams . . . . . . . . . . . 106
Theft Alarm (Security
Alarm) . . . . . . . . . . . . . . . 158
Tire Pressure Monitoring
(TPMS) . . . . . . . . . . . 155,219
Traction Control . . . . . . . . . 213
Turn Signal . . . . . . . . . . 53,107
Vanity Mirror . . . . . . . . . . . . 65
Wait to Start . . . . . . . . . . . 162
Warning (Instrument Cluster
Description) . . . . . . . . . . . . 154
Load Leveling System . . . . . . 147
Loading Vehicle . . . . . . . 227,228
Capacities . . . . . . . . . . . . . 228
Locks . . . . . . . . . . . . . . . . . . . 18 Auto Unlock . . . . . . . . . . . . 19
302