2012 Citroen C5 oil filter

BLEEDING THE DIESEL FUEL
FILTER

Protective cover


Removing the cover


Bleeding water from the fuel
filter
Bleed regularly (at each oil change).
To bleed the water, slacken the bleed
screw or the water in diesel fuel sen-
sor, located at the base of the fi lter.
Continue until all the water has
fl owed out.
Then tighten the bleed screw or the
water detection sensor.

HDi 115, HDi 160 and V6 HDi 240
engines



)
Pull the protective cover upwards
to remove it.

HDi 140 engine



)
Remove the protective cover by
fi rst unclipping at 3
, then 1
and 4.

)
Unclip at 2
by pulling towards
you, then lift up.
Refi tting


)
Firstly clip in at 2
.

)
Lower and centre the cover.

)
Clip in at 3
and 4
, pushing verti-
cally and gently from the rear.

)
Clip in at 1
pushing vertically.


CHECKS
163
CHECKS

X!
168
CHECKS

HDi 160 - HDi 200 engines
(with particle emissions filter)



1.
Screenwash and headlamp wash
reservoir.

2.
Power steering and suspension
fl uid reservoir.

3.
Engine coolant header tank.

4.
Engine oil dipstick.

5.
Engine oil fi ller cap.

6.
Air fi lter.

7.
Brake fl uid reservoir.

8.
Battery.

As the Diesel fuel system ope-
rates under high pressure:


- All work on the fuel system is
prohibited.

- HDi engines make use of ad-
vanced technology.

All maintenance and repairs require
special qualifi cations which only a
CITROËN dealer can guarantee.


HDi 160


HDi 200

X!
169
CHECKS

V6 HDi 240 engine
(with particle emissions filter)


V6 HDi 240


1.
Screenwash and headlamp wash
reservoir.

2.
Power steering and suspension
fl uid reservoir.

3.
Engine coolant header tank.

4.
Engine oil dipstick.

5.
Engine oil fi ller cap.

6.
Air fi lter.

7.
Brake fl uid reservoir.

8.
"+" and "-" terminals for emergency
starting with a slave battery.

As the Diesel fuel system ope-
rates under high pressure:


- All work on the fuel system is
prohibited.

- HDi engines make use of ad-
vanced technology.

All maintenance and repairs require
special qualifi cations which only a
CITROËN dealer can guarantee.

X
!
171
CHECKS









Diesel additive level
(Diesel engine with particle
emission filter)

Topping up
This additive must be topped up by
a CITROËN dealer or a qualifi ed
workshop without delay.









Used products

Avoid prolonged contact of
used oil or fl uids with the skin.
Most of these fl uids are harmful to
health or indeed very corrosive.
Do not discard used oil or fl u-
ids into sewers or onto the
ground.
Take used oil to a CITROËN dealer
or a qualifi ed workshop (France) or
to an authorised waste disposal
site. The additive reservoir
low level is indicated
by fi xed illumination
of this warning lamp,
accompanied by an audible warning
and a message in the multifunction
screen.










Coolant level


The coolant level should be
close to the "MAX" mark but
should never exceed it.
When the engine is warm, the tem-
perature of the coolant is regulated
by the fan. This can operate with the
ignition off.

Changing the coolant
The coolant does not have to be
changed.

Fluid specifi cation
The coolant must conform to the
manufacturer's recommendations.






For vehicles fi tted with a particle
emissions fi lter, the cooling fan may
continue to run after stopping the
vehicle, even if the engine is cold.

In addition, as the cooling system is
pressurised, wait at least one hour
after switching off the engine before
carrying out any work.
To avoid any risk of scalding, unscrew
the cap by two turns to allow the pres-
sure to drop. When the pressure has
dropped, remove the cap and top up
the level.






















Screenwash and headlamp
wash fluid


In the case of vehicles fi tted
with headlamp washers, the
low fl uid level is indicated
by an audible signal and a
message in the screen.
Top up the reservoir when you next
stop the vehicle.

Fluid specifi cation
For optimum cleaning and to avoid
freezing, this fl uid must not be
topped up with or replaced with plain
water.



Reservoir capacity (depending on
version).


- screenwash fl uid: approximately
3.5 litres,

- screenwash and headlamp wash
fl uid: approximately 6.15 litres.

X
172
CHECKS






CHECKS












12 V battery

The battery does not re-
quire any maintenance.
However, check that the
terminals are clean and
correctly tightened, particu-
larly in summer and winter.
When carrying out work on the bat-
tery, refer to the "Practical information"
section for details of the precautions
to be taken before disconnecting the
battery and following its reconnection.










Particle filter system (Diesel)

Complementary to the catalytic con-
verter, this fi lter makes an active
contribution to the preservation of air
quality by trapping unburnt pollutant
particles. Black exhaust fumes are
thus no longer emitted.
After prolonged idling or driving at very
low speeds, you may occasionally no-
tice water vapour being emitted from
the exhaust when accelerating. This is
of no consequence to the running of
the vehicle or to the environment.
If there is risk of blockage, a mes-
sage appears in the instrument
panel screen, accompanied by an
audible signal and illumination of
the service warning lamp.
This alert tells you that the par-
ticle fi lter is approaching satura-
tion (in conditions of urban driving
of exceptionally long duration: low
speeds, traffi c jams etc.)
To regenerate the fi lter, it is advised
to drive as soon as possible, when
traffi c conditions permit, at a speed
of 40 mph (around 60 km/h) or
more for at least fi ve minutes (until
the alert message disappears).
If this alert persists, contact a CITROËN
dealer or a qualifi ed workshop.







The presence of this label, in particular
with the Stop & Start system, indicates
the use of a specifi c 12 V lead-acid bat-
tery with special technology and specifi -
cation. The involvement of a CITROËN
dealer or a qualifi ed workshop is essen-
tial when replacing or disconnecting the
battery.


Unless otherwise indicated, check
these components in accordance
with the servicing booklet and ac-
cording to your engine.
Otherwise, have them checked by
a CITROËN dealer or a qualifi ed
workshop.




















Air filter and passenger compartment filter


Refer to the servicing
booklet for details of the
replacement intervals for
these components.
Depending on the environ-
ment (e.g. dusty atmosphere) and
the use of the vehicle (e.g. city driv-
ing), replace them twice as often if
necessary
.
A clogged passenger compartment
fi lter may have an adverse effect on
the performance of the air condition-
ing system and generate undesirable
odours.

Replace the oil fi lter each
time the engine oil is
changed.













Oil filter

Refer to the servicing booklet for de-
tails of the replacement interval for
this component.