2011 VOLVO V60 fuel cap

Introduction
Volvo and the environment
* Option/accessory, for more information, see Introduction.13
the level of certain unhealthy gases such as
carbon monoxide then the air intake is closed.
Such a situation may arise in heavy traffic,
queues and tunnels for example.
The entry of nitrous oxides, ground-level ozone
and hydrocarbons is prevented by the carbon
filter.
Textile standardThe interior of a Volvo is designed to be plea-
sant and comfortable, even for people with
contact allergies and for asthma sufferers.
Extreme attention has been given to choosing
environmentally-compatible materials. This
means that they also fulfil the requirements in
the Oeko-Tex 100 standard
1, a major advance
towards a healthier passenger compartment
environment.
Oeko-Tex certification covers seatbelts, car-
pets and fabrics for example. The leather in the
upholstery undergoes chromium-free tanning
and fulfils the certification requirements.
Volvo workshops and the environmentRegular maintenance creates the conditions
for a long service life and low fuel consumption
for your car. In this way you contribute to a
cleaner environment. When Volvo's workshops
are entrusted with the service and mainte-
nance of your car it becomes part of our sys-tem. Volvo makes clear demands regarding the
way in which our workshops are designed in
order to prevent spills and discharges into the
environment. Our workshop staff have the
knowledge and the tools required to guarantee
good environmental care.
Reducing environmental impactYou can easily help reduce environmental
impact - here are a few tips:
•Avoid letting the engine idle - switch off the
engine when stationary for longer periods.
Pay attention to local regulations.
•Drive economically - think ahead.
•Perform service and maintenance in
accordance with the owner's manual's
instructions - follow the Service and War-
ranty Booklet's recommended intervals.
•If the car is equipped with an engine block
heater*, use it before starting from cold - it
improves starting capacity and reduces
wear in cold weather and the engine rea-
ches normal operating temperature more
quickly, which lowers consumption and
reduces emissions.
•High speed increases consumption con-
siderably due to increased wind resistance
- a doubling of speed increases wind resis-
tance 4 times.
•Always dispose of environmentally hazar-
dous waste, such as batteries and oils, in
an environmentally safe manner. Consult a
workshop in the event of uncertainty about
how this type of waste should be discarded
- an authorised Volvo workshop is recom-
mended.
Following this advice can save money, the
planet's resources are saved and the car's
durability is extended. For more information
and further advice, see the pages 266 and
355.
RecyclingAs a part of Volvo's environmental work, it is
important that the car is recycled in an envi-
ronmentally sound manner. Almost all of the
car can be recycled. The last owner of the car
is therefore requested to contact a dealer for
referral to a certified/approved recycling
facility.
The owner's manual and the
environment
The FSC symbol shows that the paper pulp in
this publication comes from FSC certified for-
ests or other controlled sources.
1More information on www.oekotex.com
ProCarManuals.com

06 During your journey
Refuelling
06
269 Refuelling
Opening/closing the fuel filler flap
Open the fuel filler flap using the button on the
lighting panel - the flap opens when the button
is released.
The filler flap is located on the right-hand rear
wing, as indicated by the information display's
arrow by the symbol
.
Close the fuel filler flap by pressing it in until a
click confirms that it is closed.
Opening the fuel filler flap manually
The fuel filler flap can be opened manually
when electric opening from the passenger
compartment is not possible.
1. Open/remove the side hatch in the cargo
area (same side as fuel filler flap).
2. Expand/open a perforated section in the
isolation and locate a green cord with han-
dle.
3. Pull the cord gently straight back until the
fuel filler flap folds out with a "click".
IMPORTANT
Pull the wire gently - minimal force is
required to disengage the hatch lock.
Opening/closing the fuel cap
The fuel filler cap can be attached onto the flap.
A certain overpressure may arise in the tank in
the event of high outside temperatures. Open
the cap slowly.
After refuelling, refit the cap and turn it until one
or more clicking sounds are heard.
Filling up with fuelDo not overfill the tank but fill until the pump
nozzle cuts out.
NOTE
Excess fuel in the tank can overflow in hot
weather.
ProCarManuals.com

06 During your journey
Fuel
06
272* Option/accessory, for more information, see Introduction.
Diesel particle filter (DPF)Diesel cars are equipped with a particle filter,
which results in more efficient emission con-
trol. The particles in the exhaust gases are col-
lected in the filter during normal driving. So-
called "regeneration" is started in order to burn
away the particles and empty the filter. This
requires the engine to have reached normal
operating temperature.
Regeneration of the filter takes place automat-
ically at an interval of approximately
300-900 km depending on driving conditions.
Regeneration normally takes 10-20 minutes. It
may take a little longer at a low average speed.
Fuel consumption may increase slightly during
regeneration.
Regeneration in cold weatherIf the car is frequently driven short distances in
cold weather then the engine does not reach
normal operating temperature. This means that
regeneration of the diesel particle filter does
not take place and the filter is not emptied.
When the filter has become approximately
80% full of particles, a warning triangle on the
instrument panel illuminates, and the message
Soot filter full. See manual is shown on the
instrument panel display.
Start regeneration of the filter by driving the car
until the engine reaches normal operating tem-
perature, preferably on a main road or motor-way. The car should then be driven for approx-
imately 20 minutes more.
NOTE
A smaller reduction of engine power may be
noticed temporarily during regeneration.
When regeneration is complete the warning
text is cleared automatically.
Use the parking heater* in cold weather so that
the engine reaches normal operating tempera-
ture more quickly.
IMPORTANT
If the filter fills up with particles then it can
be difficult to start the engine and the filter
will be incapable of functioning. Then there
is a risk that the filter will have to be
replaced.
Fuel consumption and emissions of
carbon dioxide
Fuel consumption figures may change if the car
is equipped with extra equipment that affects
the car's weight. See information on weights
page 347 and table page 354.
The manner in which the car is driven, and
other non-technical factors can also affect fuel
consumption.Consumption is higher and power output lower
for fuel with an octane rating of 91 RON.
NOTE
Extreme weather conditions, driving with a
trailer or driving at high altitudes in combi-
nation with fuel grade are factors that could
affect the car's performance.
ProCarManuals.com

08 Maintenance and service
Engine compartment
08
308
When driving under adverse conditions, see
page 350.
IMPORTANT
In order to fulfil the requirements for the
engine's service intervals all engines are
filled with a specially adapted synthetic
engine oil at the factory. The choice of oil
has been made very carefully with regard to
service life, starting characteristics, fuel
consumption and environmental impact.
An approved engine oil must be used in
order that the recommended service inter-
vals can be applied. Only use a prescribed
grade of oil for both filling and oil change,
otherwise you will risk affecting service life,
starting characteristics, fuel consumption
and environmental impact.
Volvo Car Corporation disclaims all war-
ranty liability if engine oil of the prescribed
grade and viscosity is not used.
Volvo uses different systems for warning of
low/high oil level or low/high oil pressure. Cer-
tain variants have an oil pressure sensor, and
then the lamp for oil pressure is used. Other
variants have an oil level sensor, and then the
driver is informed via the warning symbol in the
centre of the instrument unit as well as by dis-play texts. Certain models have both variants.
Contact a Volvo dealer for more information.
Change the engine oil in accordance with the
intervals specified in the Service and Warranty
Booklet.
Using oil of a higher than specified grade is
permitted. If the car is driven in adverse con-
ditions, Volvo recommends using an oil of a
higher grade than that specified on the decal,
see page 351.
For capacities, see page 351 and onwards.
Engine with oil dipstick2
G021734
Dipstick and filler pipe.
Checking the oil level in a new car is especially
important before the first scheduled oil change.Volvo recommends checking the oil level every
2 500 km. The most accurate measurements
are made on a cold engine before starting. The
measurement will be inaccurate if taken imme-
diately after the engine is switched off. The
dipstick will indicate that the level is too low
because the oil has not had time to flow down
into the oil sump.
G021737
The oil level must be between the MIN and MAX
marks.
Measurement and filling if required1. Ensure that the car is level. After switching
off the engine it is important to wait
5 minutes to allow the oil time to run back
to the sump.
2. Pull up and wipe the dipstick.
2Only applies to petrol and 4-cyl. diesel.
ProCarManuals.com

08 Maintenance and service
Battery
08

* Option/accessory, for more information, see Introduction.323
WARNING
Connect and disconnect the positive and
negative cables in the correct sequence.
Detach the black negative cable
Detach the red positive cable
Detach the ventilation hose from the bat-
tery
Loosen the screw holding the battery
clamp.
Move the battery to the side and lift it up.
Installation
1. Lower the battery into the battery box.2. Move the battery inward and to the side
until it reaches the rear edge of the box.
3. Secure the battery using the battery clamp.
4. Connect the ventilation hose.
5. Connect the red positive cable.
6. Connect the black negative cable.
7. Press in the rear cover. (See Removal).
8. Reinstall the rubber moulding. (See
Removal).
9. Reinstall the front cover and secure it with
the clips. (See Removal).
Eco Start/Stop DRIVe*
The car is equipped with two 12 V batteries -
an extra heavy-duty battery for starting and a
support battery which assists the
Eco Start/Stop DRIVe function's starting
sequence.
BatteryStartSupport
Cold start
capacityA,
CCA (A)
760120
SizeB,
L×B×H (mm)278×175×19
0150×90×106
Capacity
(Ah)708
AIn accordance with the SAE standard.BLargest possible size.
NOTE
•The higher the current take-off in the car
(extra cooling/heating, etc.) the more
the batteries must be charged =
increased fuel consumption.
•When the capacity of the battery has
fallen below the lowest permissible level
then the Start/Stop function is disen-
gaged.
Temporarily reduced Start/Stop function due
to high current take-off means:
•The engine auto-starts1 without the driver
depressing the clutch pedal.
1Auto-start can only take place if the gear lever is in neutral position.
ProCarManuals.com

09 Specifications
Dimensions and weights09

347 Weights
Kerb weight includes the driver, the fuel tank
90% full and all fluids.
The weight of passengers and accessories,
and towball load (when a trailer is hitched, see
table page 348) influences the payload and is
not included in the kerb weight.
Permitted max. load = Gross vehicle weight -
Kerb weight.
NOTE
The documented kerb weight applies to
cars in the standard version - i.e. a car with-
out extra equipment or accessories. This
means that for every accessory added the
loading capacity of the car is reduced cor-
respondingly by the weight of the acces-
sory.
Examples of accessories that reduce load-
ing capacity are the Kinetic/Momentum/
Summum equipment levels, as well as other
accessories such as Towbar, Load carriers,
Space box, Audio system, Auxiliary lamps,
GPS, Fuel-driven heater, Safety grille, Car-
pets, Cargo cover, Power seats, etc.
Weighing the car is a certain way of ascer-
taining the kerb weight of your own partic-
ular car.
WARNING
The car's driving characteristics change
depending on how heavily it is loaded and
how the load is distributed.
For information on decal location, see page 344.
Max. gross vehicle weight
Max. train weight (car+trailer)
Max. front axle load
Max. rear axle load
Equipment level
Max. load: See registration document.
Max. roof load: 75 kg.
ProCarManuals.com

10 Alphabetical Index
10
379
Emergency equipment
warning triangle.................................. 296
Emergency puncture repair..................... 299
Emissions of carbon dioxide................... 272
Engine
overheating......................................... 278
starting................................................ 113
Engine block heater
fuel-driven........................................... 158
Engine compartment
coolant................................................ 310
oil........................................................ 307
overview.............................................. 307
power steering fluid............................ 312
Engine drag control ................................164
Engine oil.........................................307, 350
adverse driving conditions.................. 350
capacities........................................... 350
filter..................................................... 307
oil grade.............................................. 350
Engine specifications............................... 349
Environmental labelling, FSC, owner's
manual.......................................................13Error messages
Driver Alert Control............................. 196
Lane Departure Warning..................... 199
see Messages and symbols............... 179
Error messages in BLIS........................... 209
Error messages in Distance Alert............ 182
Error messages in the Adaptive cruise con-
trol............................................................ 179
ETC, electronic temperature control ....... 152
Expectant mothers, seatbelt...................... 19
External dimensions................................346
F
Fan........................................................... 153
Fault tracing for the camera sensor. 186, 192
First aid equipment.................................. 296
First aid kit .............................................. 296
Fluids, capacities..................................... 352
Fluids and oils.......................................... 352
Fog lamps
rear........................................................ 91
Foot brake............................................... 129
FOUR-C – Active chassis........................166FSC, environmental labelling..................... 13
Fuel.......................................................... 270
fuel consumption................................ 354
fuel economy...................................... 295
fuel filter.............................................. 271
Fuse box.................................................. 325
glovebox............................................. 330
Fuses.......................................................325
box in cargo area................................ 333
changing............................................. 325
cold zone............................................ 334
general................................................ 325
relay/fuse box in engine compart-
ment.................................................... 326
Start/Stop........................................... 334
Fuse table
fuses in engine compartment............. 327
G
Gearbox...................................................116
automatic............................................ 116
manual................................................ 116
Gear selector inhibitor.............................118
Gear selector inhibitor, mechanical disen-
gagement................................................. 119
ProCarManuals.com

10 Alphabetical Index
10
383
R
Radar sensor........................................... 171
limitations........................................... 177
Radio ...................................................... 225
AM/FM ............................................... 225
DAB ................................................... 229
Menu structure ..................................259
Rain sensor................................................ 98
Rear bulbs
location............................................... 316
Rearview and door mirrors
compass............................................. 106
door....................................................103
electrically retractable......................... 103
heating................................................ 104
interior................................................. 104
Rear window, defrosting.......................... 104
Recirculation............................................ 155
Recommendations during driving............ 266
Recommended child seats, table.............. 35
Recovery.................................................. 285
Refrigerant............................................... 148
Refuelling................................................. 269
fuel cap............................................... 269fuel filler flap, electrical opening......... 269
fuel filler flap, manual opening............ 269
refuelling............................................. 269
Relay/fuse box: see Fuses....................... 325
Remote control ....................................... 245
battery replacement ........................... 246
Remote control, HomeLink
Ÿ
programmable ................................... 134
Remote control key................................... 48
battery replacement.............................. 55
detachable key blade........................... 52
functions............................................... 49
range..................................................... 50
Remote control key system, type appro-
val............................................................361
Resetting the door mirrors.......................104
Resetting the power windows................. 102
Retractable power door mirrors............... 103
Reverse gear inhibitor.............................. 116
Rims
cleaning.............................................. 337
Roof load, max. weight ...........................347
Rustproofing............................................ 337
S
Safety grille.............................................. 276
Safety mode.............................................. 32
Safety net................................................. 275
Seat, see Seats.......................................... 83
Seatbelt
rear seat................................................ 20
seatbelt tensioner................................. 20
Seatbelt reminder...................................... 20
Seatbelts.................................................... 18
Seats.......................................................... 83
head restraints, rear.............................. 85
heating................................................ 153
lowering the front backrest................... 83
lowering the rear backrest.................... 86
power seats.......................................... 84
Securing loads (Loading)......................... 274
Service programme................................. 306
Set time interval....................................... 181
Side airbags............................................... 26
Signal input, external.......................218, 236
SIPS bags.................................................. 26
Soot filter................................................. 272
ProCarManuals.com