2011 Ram 5500 Chassis Cab check engine

NOTE:
•The oil change indicator message will not monitor the
time since the last oil change. Change your vehicles oil
if it has been 6 months since your last oil change even
if the oil change indicator message is NOT illumi-
nated.
•Change your engine oil more often if you drive your
vehicle off-road for an extended period of time.
•Under no circumstances should oil change intervals
exceed 6,000 miles (10,000 km) or 6 months, whichever
comes first.
Your authorized dealer will reset the oil change indicator
message after completing the scheduled oil change. If a
scheduled oil change is performed by someone other
than your authorized dealer, the message can be reset by
referring to the steps described under “Electronic Vehicle
Information Center (EVIC)/Oil Change Due” in “Under-
standing Your Instrument Panel” or under “Instrument Cluster Description/Odometer/Trip Odometer” in “Un-
derstanding Your Instrument Panel” for further informa-
tion.
At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
8
M A I
N T
E
N A
N CE
S
C
H E
D
U L
E
SMAINTENANCE SCHEDULES 431

•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission and
add as needed.
•Check all lights and other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Inspect the brake hoses and lines.
•Lubricate outer tie rod ends.
CAUTION!
Failure to perform the required maintenance items
may result in damage to the vehicle.
Required Maintenance Intervals
Refer to the Maintenance Schedules on the following
pages for the required maintenance intervals.
8
M A I
N T
E
N A
N CE
S
C
H E
D
U L
E
S432 MAINTENANCE SCHEDULES

Fluid Level Check................ 405,406,407
Fluid Type ........................ 405,428
Shifting ............................. 270
Special Additives ...................... 408
Axle Fluid ....................... 404,405,428
Axle Lubrication (Axle Fluid) ............404,405
Battery ............................... 389
Keyless Transmitter Replacement (RKE) ....... 24
Saving Feature (Protection) ............... 143
Belts, Seat ............................ 38,74
Body Builders Guide ....................... 6
Body Mechanism Lubrication ............... 392
B-Pillar Location ........................ 303
Brake Fluid ......................... 402,428
Brake System ........................ 295,401
Anti-Lock (ABS) ....................... 295
Fluid Check .......................... 402
Master Cylinder ....................... 402 Parking
............................. 292
Warning Light ........................ 188
Brake/Transmission Interlock ............... 269
Bulb Replacement ....................... 420
Bulbs, Light .......................... 75,420
Cab Top Clearance Lights .................. 424
Calibration, Compass ..................... 204
Capacities, Antifreeze (Engine Coolant) ........ 426
Capacities, Fluid ........................ 426
Caps, Filler Oil (Engine) .......................... 387
Power Steering ........................ 292
Radiator (Coolant Pressure) ............... 399
Car Washes ............................ 409
Carbon Monoxide Warning ...............74,325
Cargo Light ............................ 142
Cellular Phone .......................... 87
Center High Mounted Stop Light ............ 423
10
INDEX 459

Center Lap Belts......................... 47
Center Seat Storage Compartment ............ 166
Certification Label ....................... 328
Chart, Tire Sizing ........................ 299
Check Engine Light
(Malfunction Indicator Light) .............190,383
Checking Your Vehicle For Safety ............. 73
Checks, Safety ........................... 73
Child Restraint ........................ 61,62
Child Restraint Tether Anchors .............64,68
Child Seat ............................ 62,66
Cigar Lighter ........................... 159
Cleaning Wheels ............................. 411
Climate Control ......................... 248
Clock ........................ 21 1,212,216,225
Compact Disc (CD) Maintenance ............. 247
Compass .............................. 202
Compass Calibration ..................... 204 Compass Variance
....................... 204
Computer, Trip/Travel .................... 201
Connector UCI ................................ 236
Universal Consumer Interface (UCI) ......... 236
Console, Overhead ....................... 154
Contract, Service ........................ 451
Coolant Pressure Cap (Radiator Cap) .......... 399
Cooling System ......................... 396
Adding Coolant (Antifreeze) .............. 398
Coolant Capacity ...................... 426
Coolant Level ...................... 396,400
Disposal of Used Coolant ................ 400
Drain, Flush, and Refill .................. 397
Inspection ........................... 400
Points to Remember .................... 400
Pressure Cap ......................... 399
Radiator Cap ......................... 399
Selection of Coolant (Antifreeze) .........397,427
460 INDEX

Break-In Recommendations................ 72
Compartment Identification ............... 381
Coolant (Antifreeze) .................... 427
Exhaust Gas Caution .................. 74,325
Flooded, Starting ...................... 266
Jump Starting ......................... 370
Oil .............................. 386,427
Oil Filler Cap ......................... 387
Oil Selection .......................... 387
Oil Synthetic ......................... 388
Temperature Gauge .................... 180
Enhanced Accident Response Feature .......... 56
Exhaust Gas Caution ................74,325,394
Exhaust System ....................... 74,394
Exterior Lighting ........................ 139
Exterior Lights .......................... 75
Filters Air Cleaner .......................... 388 Engine Fuel
.......................... 427
Engine Oil ........................ 388,427
Engine Oil Disposal .................... 388
Flashers Turn Signal ...................... 75,144,180
Flat Tire Stowage ........................ 369
Flooded Engine Starting ................... 266
Fluid, Brake ........................... 428
Fluid Capacities ......................... 426
Fluid Leaks ............................. 76
Fluid Level Checks Automatic Transmission ................. 407
Brake .............................. 402
Power Steering ........................ 292
Fluids, Lubricants and Genuine Parts .......... 427
Fog Lights ....................... 140,191,422
Four Wheel Drive ....................... 277
Four-Way Hazard Flasher .................. 358
Freeing A Stuck Vehicle ................... 374
462 INDEX

Jack Location........................... 358
Jump Starting .......................... 370
Key, Programming ........................ 17
Key, Replacement ........................ 16
Key, Sentry (Immobilizer) ................... 15
Key-In Reminder ......................... 15
Keyless Entry System ...................... 20
Keys ................................. 12
Knee Bolster ............................ 51
Lane Change and Turn Signals .............. 144
Lane Change Assist ...................... 144
Lap Belts .............................. 47
Lap/Shoulder Belts ....................... 38
LATCH (Lower Anchors and Tether for
CHildren) .............................. 64
Latches ................................ 75
Leaks, Fluid ............................ 76 Life of Tires
............................ 314
Light Bulbs ............................. 75
Lights .............................. 75,138
Airbag ...................... 51,55,59,75,191
Alarm .............................. 183
Anti-Lock ........................... 191
Anti-Lock Warning ..................... 296
Automatic Headlights ................... 139
Brake Warning ........................ 188
Bulb Replacement ...................... 420
Cap Top Clearance ..................... 424
Cargo .............................. 142
Center Mounted Stop ................... 423
Check Engine (Malfunction Indicator) ........ 190
Courtesy/Reading ..................... 154
Daytime Running ...................... 143
Exterior .............................. 75
Fog .......................... 140,191,422
Four-Wheel Drive Indicator ............... 280
10
INDEX 465

Hazard Warning Flasher................. 358
Headlights ........................... 139
High Beam ........................ 145,187
High Beam Indicator .................... 187
High Beam/Low Beam Select ............. 145
Illuminated Entry ....................... 19
Instrument Cluster ..................... 180
Interior .......................... 141,154
Lights On Reminder .................... 143
Low Fuel ............................ 187
Oil Pressure .......................... 189
Passing ............................. 144
Seat Belt Reminder ..................... 193
Security Alarm (Theft Alarm) .............. 183
Service ............................. 420
Theft Alarm (Security Alarm) .............. 183
Transfer Case ......................... 280
Turn Signal ...................... 75,144,420
Warning (Instrument Cluster Description) ..... 180Limited-Slip Differential
................287,405
Loading Vehicle ......................... 328
Tires ............................... 303
Locks ................................. 28
Child Protection ........................ 32
Door ................................ 28
Power Door ........................... 29
Lower Anchors and Tether for CHildren
(LATCH) .............................. 64
Lubrication, Body ....................... 392
Lug Nuts ........................... 364,366
Maintenance Free Battery .................. 389
Maintenance Procedures ................... 385
Maintenance Schedule .................430,432
Maintenance Schedules .................... 430
Malfunction Indicator Light (Check Engine) ..... 383
Manual, Service ......................... 453
466 INDEX

Manual TransmissionFluid Level Check ..................... 405
Lubricant Selection ..................... 428
Memory Seat ........................... 132
Mini-Trip Computer ...................... 201
Mirrors ................................ 81
Automatic Dimming ..................... 82
Electric Powered ....................... 84
Heated .............................. 85
Memory ............................ 132
Outside .............................. 82
Rearview ............................. 81
Trailer Towing ......................... 86
Modifications/Alterations, Vehicle ............. 7
Mopar Parts ......................... 384,452
Multi-Function Control Lever ............... 143
New Vehicle Break-In Period ................ 72Occupant Restraints
................... 37,54,56
Occupant Restraints (Sedan) ................. 54
Octane Rating, Gasoline (Fuel) .............. 321
Odometer ............................. 183
Trip ................................ 183
Oil Change Indicator .................. 185,199
Oil Change Indicator, Reset ..............185,199
Oil, Engine ......................... 386,427
Capacity ............................ 426
Change Interval ....................... 386
Dipstick ............................. 386
Disposal ............................ 388
Filter ............................ 388,427
Filter Disposal ........................ 388
Identification Logo ..................... 387
Materials Added to ..................... 388
Pressure Gauge ....................... 183
Recommendation ...................... 387
Synthetic ............................ 388
10
INDEX 467