2011 Ram 3500 lock

CAUTION!
If the “Water In Fuel Indicator Light” remains on, DO
NOT START the engine before you drain water from
the fuel filter to avoid engine damage.
If the “Water In Fuel Indicator Light” comes on and a
single chime is heard while you are driving, or with the
ignition switch in the ON position, there may be a
problem with your water separator wiring or sensor. See
your authorized dealer for service.
Upon proper draining of the water from the fuel filter, the
“Water In Fuel Indicator Light” will remain illuminated
for approximately 10 seconds. If the water was drained
while the engine was running, the “Water In Fuel Indi-
cator Light” may remain on for approximately three
minutes. NOTE:
Care should be taken in disposing of used fluids
from your vehicle. Used fluids, indiscriminately dis-
carded, can present a problem to the environment. Con-
tact an authorized dealer, service station, or government
agency for advice on recycling programs and for where
used fluids and filters can be properly disposed of in
your area.
Drain the fuel/water separator filter when the “Water In
Fuel Indicator Light” is ON. Within 10 minutes of vehicle
shutdown, turn the drain valve (located on the side of the
filter) counterclockwise 1/4 turn, turn the ignition switch
to the ON position, and allow any accumulated water to
drain. Leave the drain valve open until all water and
contaminants have been removed. When clean fuel is
visible, close the drain valve by turning it clockwise, and
turn the ignition switch to OFF.
6
MAINTAINING YOUR VEHICLE 105

CAUTION! (Continued)
•Do not prefill the fuel filter when installing a new
fuel filter. There is a possibility debris could be
introduced into the fuel filter during this action. It
is best to install the filter dry and allow the in-tank
lift pump to prime the fuel system.
1. Ensure engine is turned off.
2. Place drain pan under the fuel filter drain hose.
3. Open the water drain valve 1/4 turn counterclockwise
and completely drain fuel and water into the approved
container.
4. Close the water drain valve.
5. Remove lid using a socket or strap wrench. Rotate
counterclockwise for removal. Remove used o-ring and
discard it. 6. Remove the used filter cartridge from the housing and
dispose of according to your local regulations.
7. Wipe clean the sealing surfaces of the lid and housing.
8. Install new o-ring back into ring groove on the filter
housing and lubricate with clean engine oil.
9. Remove new filter cartridge from plastic bag and
install into housing.
NOTE:
Do not remove cartridge from bag until you
reach this step in order to keep cartridge clean.
10. Push down on the cartridge to ensure it is properly
seated. Do not pre-fill the filter housing with fuel.
11. Install lid onto housing and tighten to 22.5 ft lbs
(30.5 N.m). Do not overtighten the lid.
12. Prime the engine using the procedure in “Priming If
The Engine Has Run Out Of Fuel.” Then start the engine
and confirm there are no leaks.
6
MAINTAINING YOUR VEHICLE 107

Adding Fuel............................ 83
Air Cleaner, Engine (Engine Air Cleaner
Filter) ............................. 102,126
Air Filter .............................. 102
Airbag Light ............................ 19
Antifreeze (Engine Coolant) .............. 114,115
Capacities ........................... 130
Disposal ............................ 117
Anti-Lock Warning Light ................... 19
Automatic Transmission .................... 68
Adding Fluid ......................... 122
Fluid Level Check ..................... 122
Fluid Type ........................ 122,133
Shifting .............................. 62
Axle Fluid ............................. 133
Battery ............................... 112
Blanket ........................... 51,113
Emergency Starting ..................... 90 Brake Fluid
............................ 133
Brake System ........................... 119
Fluid Check .......................... 119
Master Cylinder ....................... 119
Warning Light ......................... 14
Brake/Transmission Interlock ................ 61
Calibration, Compass ...................... 33
Capacities, Antifreeze (Engine Coolant) ........ 130
Capacities, Fluid ........................ 130
Caps, Filler Oil (Engine) .......................... 100
Radiator (Coolant Pressure) ............... 116
Charge Air Cooler ....................... 119
Check Engine Light (Malfunction Indicator
Light) ................................. 18
Compass .............................. 32
Compass Calibration ...................... 33
Compass Variance ........................ 33
162 INDEX

Computer, Trip/Travel..................... 30
Conserving Fuel ......................... 30
Coolant Pressure Cap (Radiator Cap) .......... 116
Cooling System ......................... 113
Adding Coolant (Antifreeze) .............. 115
Coolant Capacity ...................... 130
Coolant Level ...................... 1 13,117
Disposal of Used Coolant ................ 117
Drain, Flush, and Refill .................. 114
Inspection ........................... 117
Points to Remember .................... 118
Pressure Cap ......................... 116
Radiator Cap ......................... 116
Selection of Coolant (Antifreeze) ......... 114,131
Diesel Exhaust Brake ...................... 58
Diesel Fuel ............................. 81
Diesel Fuel Requirements ................... 81
Bulk Storage of ........................ 84 Diesel Fuel System, Re-Priming
.............. 108
Dipsticks .............................. 98
Disposal .............................. 102
Antifreeze (Engine Coolant) ............... 117
Engine Oil ........................... 102
Draining Fuel/Water Separator Filter .......... 104
Electronic Range Select (ERS) ..............62,68
Electronic Vehicle Information Center (EVIC) ..... 21
Emergency, In Case of Jump Starting ......................... 90
Engine ................................ 97
Air Cleaner .......................... 102
Block Heater ........................ 44,57
Break-In Recommendations ................. 6
Compartment ......................... 97
Coolant (Antifreeze) .................... 131
Identification .......................... 97
Idling ............................... 52
8
INDEX 163

Oil Pressure........................... 13
Speedometer .......................... 12
Tachometer ........................... 11
Voltmeter .......................... 14,49
Gear Ranges ........................ 64,69,75
Idle Up Feature .......................... 53
Information Center, Vehicle ................. 21
Instrument Cluster ...................... 10,11
Intervention Regeneration Strategy ........... 109
Jump Starting ........................... 90
Lights Airbag .............................. 19
Anti-Lock ............................ 19
Brake Warning ......................... 14
Check Engine (Malfunction Indicator) ........ 18
Electronic Stability Program (ESP) Indicator .... 20Fog ................................. 19
High Beam
........................... 14
High Beam Indicator .................... 14
Instrument Cluster ...................... 11
Seat Belt Reminder ...................... 20
Tire Pressure Monitoring (TPMS) ............ 16
Traction Control ........................ 20
Warning (Instrument Cluster Description) ...... 11
Locks Steering Wheel ......................... 6
Maintenance Procedures .................... 98
Maintenance Schedule .................... 136
Manual Transmission ...................... 74
Fluid Level Check ..................... 121
Lubricant Selection ..................... 133
Shift Speeds ........................... 75
Mini-Trip Computer ...................... 30
8
INDEX 165

Resetting Oil Change Indicator............... 27
Resetting Perform Service Indicator ........... 138
Seat Belts Reminder ............................ 20
Selection of Coolant (Antifreeze) .......... 114,131
Settings, Personal ........................ 34
Shifting ............................... 60
Automatic Transmission .................. 62
Manual Transmission .................... 74
Signals, Turn ............................ 11
Speedometer ............................ 12
Starting ............................... 44
Automatic Transmission .................. 44
Engine Block Heater ................... 44,57
Manual Transmission .................... 44
Starting Procedures ....................... 44
Starting Procedures (Diesel Engines) ........... 44Steering
Wheel Lock ............................ 6
Synthetic Engine Oil ...................... 102
Tachometer ............................. 11
Temperature Gauge, Engine Coolant ........... 11
Tip Start ............................... 44
Ti re s Pressure Warning Light .................. 16
Torque Converter Clutch .................67,73
Tow/Haul ............................. 66
Traction Control ......................... 121
Traction Control Light ..................... 20
Transfer Case Fluid ............................... 133
Transmission Automatic .......................... 62,68
Fluid ............................... 133
Manual ............................ 44,74
8
INDEX 167