2011 Peugeot RCZ power steering
[x] Cancel search: power steeringPage 29 of 276
1/
INSTRUMENTS AND CONTROLS
Warning lamp
is on
Cause
Action/Observations
STOP
fi xed, alone
or associated
with another
warning lamp,
accompanied by
an audible signal
and a message
in the screen. Illumination of this warning
lamp is associated with a
serious braking system, power
steering, engine lubrication or
cooling system malfunction or a
punctured tyre. Stop as soon as it is safe to do so as there is a risk that the
engine will cut out while driving.
Park, switch off the ignition and contact a PEUGEOT
dealer or a qualifi ed workshop.
Maximum
coolant
temperature
fi xed with the
needle in the red
zone. The temperature of the cooling
system is too high. Stop as soon as it is safe to do so.
Wait until the engine has cooled down before topping up
the level, if necessary.
If the problem persists, contact a PEUGEOT dealer or a
qualifi ed workshop.
Braking
fi xed, associated
with the STOP
warning lamp. The braking system fl uid level is
too low. You must stop as soon as it is safe to do so.
Top up with brake fl uid recommended by PEUGEOT.
If the problem persists, have the system checked by a
PEUGEOT dealer or a qualifi ed workshop.
+
fi xed, associated
with the STOP
and ABS warning
lamp. The electronic brake force
distribution (EBFD) system has
a fault. You must stop as soon as it is safe to do so.
Have it checked by a PEUGEOT or a qualifi ed workshop.
Page 148 of 276
146
PETROL ENGINES
The various caps and covers allow access for checking the levels of the various fl uids and for replacing certain components.
1.
Power steering reservoir.
2.
Screenwash and headlamp wash reservoir.
3.
Coolant reservoir.
4.
Brake fl uid reservoir.
5.
Battery/Fuses.
6.
Fusebox.
7.
Air fi lter.
8.
Engine oil dipstick.
9.
Engine oil fi ller cap.
Page 149 of 276
7/
CHECKS
DIESEL ENGINE
The various caps and covers allow access for checking the levels of the various fl uids, for replacing certain components and for priming the fuel system.
1.
Power steering reservoir.
2.
Screenwash and headlamp wash reservoir.
3.
Coolant reservoir.
4.
Brake fl uid reservoir.
5.
Battery/Fuses.
6.
Fusebox.
7.
Air fi lter.
8.
Engine oil dipstick.
9.
Engine oil fi ller cap.
10.
Priming pump.
11 .
Bleed screw.
Page 151 of 276
7/
CHECKS
CHECKING LEVELS
Check all of these levels regularly and top them up if necessary, unless
otherwise indicated.
If a level drops signifi cantly, have the corresponding system checked by
a PEUGEOT dealer or a qualifi ed workshop.
OIL LEVEL
The check is carried out either when the ignition is switched
on using the oil level indicator on the instrument panel, or
using the dipstick.
This manual check will only be correct if the vehicle is on level ground
and the engine has been off for more than 30 minutes.
After topping up the oil, the check when switching on the ignition
with the oil level indicator in the instrument panel will only be valid
30 minutes after topping up.
It is normal to top up the oil level between services. PEUGEOT
recommends that you check the oil level and top up if necessary
every 3 000 miles (5 000 kilometres).
Engine oil change
Refer to the Warranty and Maintenance Record for details of the interval
for this operation.
In order to maintain the reliability of the engine and emission control
system, the use of additives in the engine oil is prohibited.
BRAKE FLUID LEVEL
The brake fl uid level should be close to the "MAX" mark. If it is
not, check the brake pad wear.
Changing the fluid
Refer to the Warranty and Maintenance Record for details of the interval
for this operation.
Fluid specification
The brake fl uid must conform to the manufacturer's recommendations
and meet the DOT4 standard.
POWER STEERING FLUID LEVEL
The power steering fl uid level should be close to the "MAX"
mark. Unscrew the cap, with the engine cold, to check the level.
When working under the bonnet, take care, as certain areas of the
engine may be extremely hot (risk of burns).
Oil specification
The oil must be the correct grade for your engine and conform to the
manufacturer's recommendations.
Page 181 of 276
8/
F10
F11
F13F14F12
F20
F19
F18
F17
F16
F15
F4
F8F2
F3F5 F7
F9
F6
F21 F1
PRACTICAL INFORMATION
ENGINE COMPARTMENT FUSES
The fusebox is placed in the engine compartment near the battery
(left-hand side).
Access to the fuses
)
Unclip the cover.
)
Change the fuse (see corresponding paragraph).
)
When you have fi nished, close the cover carefully to assure the
sealing of the fusebox.
Fuse table
Fuse N°
Rating
Functions
F1
20 A
Engine control unit supply, injection
pump and EGR electrovalves (Diesel),
injectors (Diesel).
F2
15 A
Horn.
F3
10 A
Front wash-wipe.
F4
20 A
Daytime running lamps.
F5
15 A
Air fl ow sensor, coolant pump, oil pump,
thermostat, blow-by heater (petrol),
by-pass and EGR electrovalves (Diesel),
diesel heater (Diesel).
F6
10 A
Steering wheel angle sensor, ABS/ESP
control unit, ESP control unit.
F7
10 A
Power steering control unit, automatic
gearbox, engine coolant level detector,
dual function brake switch.
F8
25 A
Starter motor control.
F9
10 A
Diagnostic socket, directional
headlamps, particle emission fi lter pump
(Diesel).
F10
30 A
Engine control unit actuators (petrol:
ignition coils, electrovalves, injectors,
fuel pump (Diesel: electrovalves,
heaters).
F11
40 A
Air conditioning blower.
Page 184 of 276
182
TOWING A VEHICLE
TOWING EYE
This is stored in the boot under the fl oor.
For access to it:
)
open the boot,
)
raise the fl oor using the strap,
)
secure it in the vertical position beyond the stops, located on the
sides of the boot,
)
remove the towing eye from the storage box.
GENERAL RECOMMENDATIONS
Observe the legislation in force in your country.
Ensure that the weight of the towing vehicle is higher than that of
the towed vehicle.
The driver must stay at the wheel of the towed vehicle.
Driving on motorways and fast roads is prohibited when towing.
When towing a vehicle with all four wheels on the ground, always
use an approved towing bar; rope and straps are prohibited.
When towing a vehicle with the engine off, there is no longer any
power assistance for braking or steering.
In the following cases, you must always call on a professional
recovery service:
- vehicle broken down on a motorway or fast road,
- when it is not possible to put the gearbox into neutral, unlock
the steering, or release the parking brake,
- towing with only two wheels on the ground,
- where there is no approved towing bar available...
Page 265 of 276
ALPHABETICAL INDEX
ALPHABETICAL INDEX
JACK socket ...................... 84, 250, 252
Jukebox (copy) ................................ 224
Jukebox (playing) ............................ 225J/
Menu, main ...................................... 246
Mini fuel level ................................... 143
Monochrome screen ................ 246, 256
Mountings for ISOFIX seats ............ 121
MP3 CD ........................................... 249
Multifunction screen (with audio
equipment) .......................... 42, 46, 48
Music media players ........................ 222M/Labels, identifi cation ........................ 194
Lamps, warning
and indicator ....................... 26, 30, 32
Lateral airbags .......................... 113, 115
Level, brake fl uid ............................. 149
Level, headlamp wash ............... 96, 149
Level, power steering fl uid ............... 149
Levels and checks ..... 146, 147, 149, 150
Lighting, guide-me home ............. 91, 92
Lighting, interior ........................... 77, 78
Lighting bulbs (replacement) ........... 168
Lighting on reminder .......................... 90
Lighting rheostat ................................ 38
Lighting stalk...................................... 88
Loading .............................................. 20
Load reduction mode ....................... 165
Locating your vehicle ......................... 52
Locking from the inside...................... 60
Locking the boot ................................ 62L/
Navigation........................................ 210
Number plate lamps ........................ 171N/
Main beam ......................... 88, 169, 170
Maintenance (advice) ...................... 186
Manual gearbox ............... 127, 128, 152
Manufacturer’s
identifi cation plates ....................... 194
Map reading lamps ............................ 77
Markings, identifi cation .................... 194
Mat..................................................... 85M/
Infl ating tyres ..................................... 20
Inputs
for audio system ..... 84, 226, 250, 252
Instrument
panel lighting ................................... 38
Instrument panels .................. 22, 24, 37
Instrument panel screen ............ 22, 128
Intelligent
Traction Control ............................ 103
Interior fi nish .................................... 186
Interior fi ttings .................................... 80
Interior lamp....................................... 77
Interior mood lighting ......................... 78
ISOFIX child seats .................... 121-123
ISOFIX mountings ........................... 121I/
Keeping
children safe ........... 112, 116, 119-123
Key in ignition warning..................... 124
Key with
remote control ............. 50, 51, 53, 124K/
Oil fi lter ............................................ 151
Oil level ...................................... 33, 149
Opening the bonnet ......................... 145
Opening the boot ......................... 50, 62
Opening the doors ................. 50, 59, 61
Opening the fuel fi ller fl ap ................ 143
Opening the retractable screen ......... 48
Operation indicator lamps............ 30, 32O/
Paint colour code ............................. 194
Paintwork, matt ................................ 186
Parking brake .......................... 125, 152P/
Page 271 of 276
VISUAL SEARCH
Running out of fuel, Diesel 148
Checking levels 149-150
- oil
- brake fl uid
- power steering fl uid
- coolant
- screenwash/headlamp wash fl uid
- additive (Diesel with particle emissions fi lter)
- used products
Changing bulbs 168-174
- front
- rear
Engine compartment fuses 175, 179-181
Petrol engines 189
Petrol weights 190
Diesel engines 191
Diesel weightsl 192
Dimensions 193
Identifi cation markings 194
Opening the bonnet 145
Under the bonnet, petrol 146
Under the bonnet, Diesel 147
Energy economy mode 165
Battery 166-167
TECHNICAL DATA - MAINTENANCE
Checking components 151-152
- battery
- air fi lter and passenger compartment fi lter
- oil fi lter
- particle emission fi lter (Diesel)
- gearboxes
- brake pads/discs
Cleaning and caring for your vehicle 186
- interior
- exterior